1999 FORD CROWN VICTORIA Recalls (8)

Campaign:
98V322000 on 12/17/1998
Component:
Suspension:front:control arm:lower ball joint
Manufactured:
03/14/1996 - 12/13/1998
Affected:
175,000
Defect:
Vehicle description: certain 1996-1999 ford crown victoria police, fleet, natural gas, and 1996-1999 lincoln town car limousine vehicles that were produced with a lower control arm ball joint containing a one piece bearing; and 1990-1996 ford crown victoria police, fleet, and ngv vehicles and 1990-1996 lincoln town car limousine vehicles that have been serviced with either a ball joint containing the one-piece bearing or a front lower control arm containing a ball joint with a one-piece bearing. the one-piece bearing within the lower control arm ball joint can weaken slowly during use and eventually crack. this could result in separation of the ball and cap of the joint, allowing the control arm to drop to the ground.
Consequence:
If this occurs while the vehicle is moving, reduced steering control could occur, increasing the risk of a crash.
Correction:
Dealers will replace the lower control arm ball joints (2).
Notes:
Owner notification is expected to begin january 18, 1999.owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact ford at 1-800-392-3673.also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
Campaign:
00V157002 on 06/15/2000
Component:
Seat belts:front:anchorage
Affected:
1,129
Defect:
Vehicle description: passenger vehicles using aftermarket front passenger side seat belt assemblies that were sold by ford parts departments from january 1, through june 13, 2000. these seat belt assemblies fail to comply with the requirements of fmvss no. 209, "seat belt assemblies." the equipment involved is service stock seat belt assemblies, model nos. h 9977, h 9979, t 9063, and t 9217, built by trw vehicle safety systems, inc. (trw) manufactured from june 1, 1998 through may 21, 2000. some of these seat belt assemblies may have been installed as service replacement equipment on the vehicles involved in the recall.
Consequence:
In the event of a collision, these seat belts may not restrain an occupant increasing the risk of injury.
Correction:
Dealers will inspect these vehicles and replace the service seat belt assemblies that were installed in these vehicles from january 1 through june 13, 2000.
Notes:
Owner notification began september 28, 2000. owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact ford at 1-800-392-3673.also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
Campaign:
00V157001 on 06/15/2000
Component:
Seat belts:front:anchorage
Affected:
1,167
Defect:
Vehicle description: passenger vehicles using aftermarket driver's seat belt assemblies that were sold by ford parts departments from january 1, through june 13, 2000. these seat belt assemblies fail to comply with the requirements of fmvss no. 209, "seat belt assemblies." the equipment involved is service stock seat belt assemblies, model nos. h 9977, h 9979, t 9063, and t 9217, built by trw vehicle safety systems, inc. (trw) manufactured from june 1, 1998 through may 21, 2000. some of these seat belt assemblies may have been installed as service replacement equipment on the vehicles involved in the recall.
Consequence:
In the event of a collision, these seat belts may not restrain an occupant increasing the risk of injury.
Correction:
Dealers will inspect these vehicles and replace the service seat belt assemblies that were installed in these vehicles from january 1 through june 13, 2000.
Notes:
Owner notification began september 28, 2000. owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact ford at 1-800-392-3673.also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
Campaign:
00V200000 on 07/19/2000
Component:
Equipment:mechanical:jacks
Manufactured:
06/17/1997 - 06/14/2000
Affected:
875,000
Defect:
Vehicle description: passenger vehicles. these vehicles have jacking instructions which, if followed, could cause the vehicle operator to place the jack on a frame weld when attempting to raise a rear wheel. if the vehicle is jacked up with the jack placed on the frame weld and if the vehicle is free to roll (wheels not blocked or chocked), the jack could yield and the vehicle may drop suddenly.
Consequence:
If this occurs and any portion of the operator's body is under the vehicle, the potential for personal injury exists.
Correction:
Owners will be provided with a revised jack instruction and stowage card and jack warning label, as well as a supplement to the owner guide.
Notes:
Owner notification began august 3, 2000.owners who do not receive the free instructions and label within a reasonable time should contact ford at 1-800-392-3673.also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
Campaign:
02I003000 on 11/20/2002
Component:
Fuel system, gasoline:storage:tank assembly
Manufactured:
06/30/1992 - 10/20/2002
Affected:
350,000
Defect:
In order to enhance police office safety, model year 1992-2003 crown victoria police interceptor (cvpi) vehicles will be equipped with shields designed to help protect the fuel tank in high-speed rear-impact crashes. ford also will be offering an optional trunk package designed to improve the safe transport of sharp-edged, heavy equipment in these vehicles.
Consequence:
Some high-speed rear-impact crashes have resulted in fuel tank punctures and fires in cvpi vehicles.
Correction:
Ford has advised us that shield kits have been available since late october and will be installed on police interceptor vehicles at no cost. the optional trank package will be available by the end of 2002. ford has established a new web site at www.cvpi.com to answer additional questions about the safe use of cpvi vehicles.
Notes:
Customers can also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
Campaign:
03V472000 on 11/18/2003
Component:
Fuel system, other:storage:tank assembly
Affected:
4,218
Defect:
On certain natural gas vehicles, if a flame from a vehicle interior fire becomes locally directed at the natural gas fuel tank located immediately behind the rear seat, the flame could damage the fiberglass wrap on the tank weakening the tank.
Consequence:
If the strength of the tank is significantly compromised, it could rupture, increasing the risk of a fire.
Correction:
Dealers will install an insulator behind the current seat back. owner notification began on january 7, 2004. owners should contact ford at 1-800-392-3673.
Notes:
Ford recall no. 03s08.customers can also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
Campaign:
06E056000 on 06/22/2006
Component:
Fuel system, gasoline
Affected:
58,640
Defect:
Certain aftermarket fuel filters sold under the purolator brand name, p/n f65277, shipped from january 16 through june 2, 2006, for use on the above listed passenger vehicles. due to incorrect design, the quick connectors may not fully seat with the tube interface, even though the person making the connection may believe that the quick connector is fully attached.
Consequence:
Failure of this connection could lead to fuel spillage and, in the presence of an ignition source, a fire could occur.
Correction:
Ufi will notify owners and replace the filters free of charge. the recall began on august 4, 2006. owners may contact ufi filters usa at 800-230-5876.
Notes:
This recall only pertains to ufi filters usa (purolator) aftermarket fuel filters and has no relation to any original equipment installed on the listed passenger vehicles.customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov.
Campaign:
15E082000 on 10/05/2015
Component:
Steering
Affected:
1,767
Defect:
Dorman products, inc. (dorman) is recalling certain model dorman steering shafts, part number 425-359, solutions steering shafts, part number 7-0359, and oe solutions steering shafts, part number 425-359, manufactured april 17, 2014, to september 28, 2015. these aftermarket replacement steering shafts are sold for use in 1995-2002 ford crown victoria, mercury grand marquis, and lincoln town car vehicles. these steering shafts may separate during operation if the integral fastener is loose or missing and if the interfacing vehicle shaft is compressed in length.
Consequence:
If the shafts separate during vehicle operation, a loss of steering control would result, increasing the risk of a vehicle crash.
Correction:
Dorman will notify owners, and dealers will replace the steering shaft, free of charge. the recall began on october 28, 2015. owners may contact dorman customer service at 1-800-523-2492, option 5.
Notes:
Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.

1999 FORD CROWN VICTORIA TSBs (196)

Bulletin:
9873
Component:
353400 equipment:electrical:radio/tape deck/cd etc.
Summary:
Experiencing a whining / buzzing noise in the speakers of the entertainment radio or two-way radio. *tt
Bulletin:
98259
Component:
980000 unknown or other
Summary:
Some vinyl covered items such as dash panels, door trim panels, consoles, etc., may exhibit a small dent, scuff, abrasion and/ or discoloration resulting from assembly, transit, dealer prep and/or customer usage. *yc
Bulletin:
982010
Component:
063000 engine and engine cooling:exhaust system
Summary:
Experiencing a " buzzing " or " rattling " noise from the exhaust system. *yc
Bulletin:
982310
Component:
063100 engine and engine cooling:exhaust system:emission control
Summary:
Mass air flow (maf)- sensor contamination- service tip. *ak
Bulletin:
98246
Component:
110000 electrical system
Summary:
Ford motor company has released a new electrical grease ( f8az - 19g208-aa ) to reduce the possibility of moisture corrosion at the terminals. *yc
Bulletin:
9943
Component:
100000 power train
Summary:
Information regarding reprogramming powertrain control modules (pcms). *tt
Bulletin:
9947
Component:
061000 engine and engine cooling:engine
Summary:
Engine experiencing roughness at idle due to exhaust system resonance. *tt
Bulletin:
99B04
Component:
105300 power train:driveline:driveshaft
Summary:
Some police interceptors may exhibit a driveshaft vibration or boom during high speed operation. *tt
Bulletin:
99B03
Component:
072200 fuel system, gasoline:delivery:hoses, lines/piping, and fittings
Summary:
Subject regarding inadvertent activation of the inertia switch. *tt
Bulletin:
5789
Component:
034530 service brakes, hydraulic:foundation components:disc:rotor
Summary:
Replacing front brake rotors. *tt
Bulletin:
12549
Component:
353400 equipment:electrical:radio/tape deck/cd etc.
Summary:
Customer may complain that cd / dj my be inoperative. *tt
Bulletin:
12609
Component:
110000 electrical system
Summary:
Information regarding pinpint test / 4wabs diagnostic trouble code b1676 (battery voltage) - update. *tt
Bulletin:
12615
Component:
071100 fuel system, gasoline:storage:tank assembly
Summary:
Subject regarding fuel tank clunk. *tt
Bulletin:
99B03S1
Component:
072200 fuel system, gasoline:delivery:hoses, lines/piping, and fittings
Summary:
Information regarding the inertia switch. *tt
Bulletin:
99B09
Component:
022000 suspension:rear
Summary:
Vehicles may develop cosmetic cracks in the frame of the rear upper control arm access opening. *tt
Bulletin:
99816
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Ford motor company now recommends sae 5w-30 viscosity grade for servicing any ford gasoline-powered vehicle regardless of model year. *tt
Bulletin:
99910
Component:
036400 service brakes, hydraulic:antilock:abs warning light
Summary:
Addressing concerns with the brake lamp inadvertently disabling the brake shift interlock on police vehicles. *tt
Bulletin:
99129
Component:
353400 equipment:electrical:radio/tape deck/cd etc.
Summary:
Experiencing a whine / buzz type noise in the speakers of the entertainment radio or two-way radio on vehicles with an in-tank electric fuel pump. *tt
Bulletin:
99139
Component:
125000 exterior lighting:brake lights
Summary:
Conditions with the brake lamps inadvertently disabling the brake shift interlock. *tt
Bulletin:
991312
Component:
162300 structure:body:door
Summary:
Information published to help identify correct replacement 1999 model door sealing weatherstrip. *tt
Bulletin:
6312
Component:
133000 visibility:power window devices and controls
Summary:
Some vehicles may experience a condition where all the keyless entry functions are inoperative (i.e., key fobs, power door locks, express down window, and remote trunk release). *tt
Bulletin:
6330
Component:
980000 unknown or other
Summary:
Experiencing a popping / snapping noise from the instrument panel. *tt
Bulletin:
6399
Component:
131000 visibility:windshield
Summary:
Some customers may report concerns about a smear / streak / haze in the front windshield. *tt
Bulletin:
6459
Component:
020000 suspension
Summary:
Experiencing a sagging rear suspension when vehicle is loaded with equipment. *tt
Bulletin:
12815
Component:
131000 visibility:windshield
Summary:
Subject regarding windshield smear. *tt
Bulletin:
12890
Component:
071100 fuel system, gasoline:storage:tank assembly
Summary:
Brief information on removing the fuel tank solenoid valve thread. *tt
Bulletin:
12893
Component:
063000 engine and engine cooling:exhaust system
Summary:
Some vehicle may exhibit an exhaust moan hear on slight acceleration. *tt
Bulletin:
6159
Component:
162200 structure:body:bumpers
Summary:
Subject regarding front bumper cover attachment. *tt
Bulletin:
996166
Component:
034000 service brakes, hydraulic:foundation components
Summary:
Information regarding the heavy duty brake booster. *tt
Bulletin:
98-4828
Component:
353400 equipment:electrical:radio/tape deck/cd etc.
Summary:
Subject pertaining to the service manual not having a pinpoint test for "degraded am reception or continuous seek in am" in the diagnosis and testing portion of the audio chapter. *tt
Bulletin:
99147
Component:
103100 power train:automatic transmission:control module (tcm, pcm)
Summary:
Information on using the service bay technical system (sbts) and new generation star (ngs) tester, and to update the powertrain control module (pcm) information charts. *tt
Bulletin:
99155
Component:
182000 vehicle speed control:linkages
Summary:
Some vehicles may experience a light spark knock / detonation occurring while accelerating in ambient temperatures greater than 32 degrees c (90 degrees f). *tt
Bulletin:
9913125
Component:
103000 power train:automatic transmission
Summary:
Sone police vehicles and other vehicles with 4r70w may exhibit a vibration and / or transmission extension housing bushing damage from sustained high speed operation. *tt
Bulletin:
9913134
Component:
204000 wheels:cap/cover/hub
Summary:
Subject regarding policy vehicles equipped with full size wheel covers exhibiting a concern with the wheel covers becoming loose after being removed and replaced several times. *tt
Bulletin:
99E03
Component:
091100 fuel system, other:storage:tank assembly
Summary:
Emission recall for vehicles that were built with a fuel filler-valve which could leak while the vehicle is being operated which can exceed evaporative emissions standards. *tt
Bulletin:
99208
Component:
330000 interior lighting
Summary:
On some vehicles, the interior dome lamp may not be adhered to the roof. *tt
Bulletin:
99219
Component:
017000 steering:linkages
Summary:
This bulletin mentions that the workshop manuals do not contain a procedure for inspecting the pitman arm ball joint for wear. *tt
Bulletin:
99222
Component:
114000 electrical system:wiring
Summary:
Subject on a wire harness terminal repair kit available for repairing electrical wiring harnesses. *tt
Bulletin:
99181
Component:
106100 power train:axle assembly:banjo housing
Summary:
Some police vehicles may exhibit a vibration and / or transmission fluid leak from the extension housing seal area. *tt
Bulletin:
99185
Component:
980000 unknown or other
Summary:
Vehicles built between 3/15/1997 and 12/31/1998 and with 4r70w transmissions may experience delayed or no 2-3 upshift, transmission control indicator lamp illuminated with diagnostic trouble code p0782 stored in memory. *tt
Bulletin:
99186
Component:
980000 unknown or other
Summary:
Some vehicles may exhibit an intermittent transmission control indicator lamp or malfunction indicator lamp illumination. *tt
Bulletin:
99194
Component:
034000 service brakes, hydraulic:foundation components
Summary:
Information for servicing and diagnosing brake vibration, brake inspection, and brake friction material replacement. *tt
Bulletin:
99196
Component:
353600 equipment:air conditioner
Summary:
Information on identifying non-approved / alternate refrigerants which could cause safety, and performance concerns if installed in ford a/c systems. *tt
Bulletin:
99197
Component:
980000 unknown or other
Summary:
Subject regarding intermittent transmission control indicator lamp or malfunction indicator lamp illumination. *tt
Bulletin:
99234
Component:
980000 unknown or other
Summary:
Information on diagnosing a vehicle with malfunction indicator lamp illuminated and diagnostic trouble codes p0442 and p0455 stored in continuous memory. *tt
Bulletin:
99242
Component:
162300 structure:body:door
Summary:
Information on replacing and / or repairing malfunctioning (door, ignition and decklid) locks. *tt
Bulletin:
6903
Component:
204000 wheels:cap/cover/hub
Summary:
Some police vehicles, equipped with full size wheel covers, may exhibit a concern with the wheel covers becoming loose after being removed and replaced several times. *tt
Bulletin:
13259
Component:
162200 structure:body:bumpers
Summary:
Some vehicles built after january 1999 may exhibit a front bumper cover that appears to be loose or have excessive movement. *tt
Bulletin:
7137
Component:
162200 structure:body:bumpers
Summary:
Some vehicles built after january 1999 may exhibit a front bumper cover that appears to be loose or have excessive movement. *tt
Bulletin:
7207
Component:
353400 equipment:electrical:radio/tape deck/cd etc.
Summary:
Some vehicles may exhibit a cd changer with a cd magazine that jams / will not eject. *tt
Bulletin:
7249
Component:
353600 equipment:air conditioner
Summary:
Information on using peanut style a/c fittings. *tt
Bulletin:
6505
Component:
071100 fuel system, gasoline:storage:tank assembly
Summary:
Brief information on removing the fuel tank solenoid valve on natural gas vehicles. *tt
Bulletin:
6506
Component:
063000 engine and engine cooling:exhaust system
Summary:
Some vehicles may exhibit an exhaust moan / roar heard on slight acceleration and at speeds near 42 mph for single exhaust and near 62 mph on dual exhaust cars. *tt
Bulletin:
6614
Component:
133000 visibility:power window devices and controls
Summary:
Some vehicles built in june 1999, may exhibit the autolock feature inoperative or the radio button illumination / dimming feature inoperative. *tt
Bulletin:
6617
Component:
133000 visibility:power window devices and controls
Summary:
Exhibiting an intermittent concern where the window one touch down feature will operate from window switch locations other than the driver's door. *tt
Bulletin:
12950
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Some vehicle engines may crank without starting. *tt
Bulletin:
13025
Component:
063000 engine and engine cooling:exhaust system
Summary:
Some vehicles may exhibit a bang popping noise heard from the exhaust system during cool-down. *tt
Bulletin:
7424
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Information on vehicles exhibiting engine oil that has a milky appearance at predelivery inspection. *tt
Bulletin:
13573
Component:
116200 electrical system:ignition:module
Summary:
Subject regarding reprogramming the pcm for police interceptors exhibiting a low maximum speed condition. *tt
Bulletin:
8038
Component:
353600 equipment:air conditioner
Summary:
Experiencing a thump noise from the air conditioner system approximately 5-10 seconds after initial air conditioner compressor engagement. *tt
Bulletin:
7874
Component:
112000 electrical system:alternator/generator/regulator
Summary:
The vehicle may exhibit detonation/spark knock.
Bulletin:
8060
Component:
021000 suspension:front
Summary:
Some vehicles may exhibit a slight steering drift / wander condition, usually noted during highway driving. *tt
Bulletin:
8243
Component:
103000 power train:automatic transmission
Summary:
Some police vehicles may exhibit shifting concerns due to engine driveability issues. *tt
Bulletin:
8246
Component:
204000 wheels:cap/cover/hub
Summary:
Some police vehicles, equipped with full size wheel covers, may exhibit a concern with the wheel covers becoming loose after being removed and replaced several times. *tt
Bulletin:
8024
Component:
133000 visibility:power window devices and controls
Summary:
Some vehicles equipped with a keyless entry system, may exhibit a condition where all the keyless entry functions are inoperative, includes remote key fob's , power door locks, express down window and remote trunk release, vehicles built be
Bulletin:
8382
Component:
116000 electrical system:ignition
Summary:
Some vehicles may exhibit a miss, buck / jerk, surge in the ignition coil / spark plug boot. *tt
Bulletin:
13808
Component:
162300 structure:body:door
Summary:
Some vehicles built before january 1, 1999 and equipped with a keyless entry system, may exhibit a condition where all the keyless entry functions are inoperative. *mjs
Bulletin:
13814
Component:
353600 equipment:air conditioner
Summary:
Some vehicles may exhibit a thump noise from the a/c system approximately 5-10 seconds after initial a/c compressor engagement. *mjs
Bulletin:
13925
Component:
103000 power train:automatic transmission
Summary:
Some police vehicles may exhibit shift concerns due to engine driveability issues. *tt
Bulletin:
13928
Component:
204000 wheels:cap/cover/hub
Summary:
Some police vehicles, equipped with full size wheel covers, may exhibit a concern with the wheel covers becoming loose after being removed and replaced several times. *tt
Bulletin:
985017
Component:
021000 suspension:front
Summary:
Experiencing a grunt or squeak noise from the front suspension when turning the steering to full lock, to the left or the right. *tt
Bulletin:
985034
Component:
220000 seats
Summary:
Police vehicles with bucket seats may have customer concern for leaning seats. *tt
Bulletin:
12092
Component:
022000 suspension:rear
Summary:
Some police vehicles may exhibit a sagging rear suspension when vehicle is loaded with equipment. *mjs
Bulletin:
12111
Component:
103000 power train:automatic transmission
Summary:
Some vehices may exhibit a popping/ticking noise when the car is shifted from reverse to forward gear. *mjs
Bulletin:
12118
Component:
180000 vehicle speed control
Summary:
Some vehicles may exhibit a hesitation on hard acceleration or lacks power on acceleration. *mjs
Bulletin:
12120
Component:
100000 power train
Summary:
Some vehicles with 4r70w transmissions built from 4/16/98 through 10/30/98 may exhibit a leak from the vent area of the transmission. *mjs
Bulletin:
12147
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Some crown victoria police vehicles engine may stall during braking over rumble strips, these vibrations may open the inertia fuel switch. *mjs
Bulletin:
12154
Component:
116300 electrical system:ignition:anti-theft controller
Summary:
Some vehicles equipped with pats (securilock) except certain models now have availability of fleet keys through rotunda. *mjs
Bulletin:
12168
Component:
015000 steering:hydraulic power assist system
Summary:
Some vehicles may exhibit a power steering noise when turning and reduced power steering assist at low speeds. *mjs
Bulletin:
985079
Component:
022000 suspension:rear
Summary:
Some police vehicles may exhibit a sagging rear suspension when vehicle is loaded with equipment. *tt
Bulletin:
12174
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Some vehicles may exhibit a hard start/long crank, cold start stall, cold rough idle concern. *mjs
Bulletin:
985149
Component:
072200 fuel system, gasoline:delivery:hoses, lines/piping, and fittings
Summary:
Some police vehicles may stall during braking over rumble strips. these vibrations may open the inertia fuel switch. engineering is investigating concern. *tt
Bulletin:
5156
Component:
180000 vehicle speed control
Summary:
Some vehicles may exhibit a hesitation on hard acceleration or lacks power on acceleration. *tt
Bulletin:
985166
Component:
105300 power train:driveline:driveshaft
Summary:
Some vehicles may exhibit a popping / ticking noise when the car is shifted from reverse to forward gear. *tt
Bulletin:
0081
Component:
185000 vehicle speed control:cruise control
Summary:
Information regarding rough idle approximately 20 seconds after cold engine start-up may occur on some vehicles. **mr
Bulletin:
8243
Component:
102000 power train:manual transmission
Summary:
Some police vehicles may exhibit shift concerns due to engine drivability issues. **mr
Bulletin:
8300
Component:
063000 engine and engine cooling:exhaust system
Summary:
Some vehicles may exhibit a bang / popping noise heard from the exhaust system during cool-down. **mr
Bulletin:
8576
Component:
204000 wheels:cap/cover/hub
Summary:
Some vehicles with full size luxury wheels covers may exhibit a clicking noise while driving. **mr
Bulletin:
14081
Component:
980000 unknown or other
Summary:
Some vehicles may exhibit an inoperative keyless entry pad. **mr
Bulletin:
14080
Component:
204000 wheels:cap/cover/hub
Summary:
Some vehicles with full size luxury wheel covers may exhibit a clicking noise while driving. **mr
Bulletin:
14181
Component:
071100 fuel system, gasoline:storage:tank assembly
Summary:
Concerns with fuel tank thump. *tt
Bulletin:
99-6190
Component:
354100 equipment:mechanical:jacks
Summary:
Brief information on tire jack location. *tt
Bulletin:
99-6193
Component:
116300 electrical system:ignition:anti-theft controller
Summary:
Information on resetting the passive anti-theft system (pats). *tt
Bulletin:
6218
Component:
022000 suspension:rear
Summary:
Conditions with cosmetic cracks in the frame at the rear upper control arm access opening. *tt
Bulletin:
6242
Component:
106100 power train:axle assembly:banjo housing
Summary:
Experiencing a vibration and / or transmission extension housing bushing damage. *tt
Bulletin:
12700
Component:
354100 equipment:mechanical:jacks
Summary:
Information on the revised jack assembly stowage location. *tt
Bulletin:
12743
Component:
980000 unknown or other
Summary:
Exhibiting malfunction indicator lamp (mil) with diagnostic trouble codes (dtc(s) po351 and / or p0356 (coil primary circuit malfunction). *tt
Bulletin:
12763
Component:
980000 unknown or other
Summary:
Exhibiting a condition where the keyless entry functions are inoperative. *tt
Bulletin:
6035
Component:
036000 service brakes, hydraulic:antilock
Summary:
Some vehicles equipped with teves four wheel anti-lock brakes (4wabs) may exhibit a yellow anti-lock brake lamp illuminated with no diagnostic trouble codes in memory. *tt
Bulletin:
12704
Component:
103100 power train:automatic transmission:control module (tcm, pcm)
Summary:
Subject regarding all vehicles requires a parameter reset to be performed on the passive anti-theft system module (pats / vic / hec) when the powertrain control module (pcm) is replaced. *tt
Bulletin:
12714
Component:
161000 structure:frame and members
Summary:
Some vehicles may develop cosmetic cracks in the frame at the rear upper control arm access opening when operated under severe duty conditions. *tt
Bulletin:
12725
Component:
106100 power train:axle assembly:banjo housing
Summary:
Some vehicles may exhibit a vibration and / or transmission extension housing bushing damage from sustained high speed operation. *tt
Bulletin:
12868
Component:
022000 suspension:rear
Summary:
Some police vehicles may exhibit a sagging rear suspension when vehicle is loaded with equipment. *tt
Bulletin:
13290
Component:
353400 equipment:electrical:radio/tape deck/cd etc.
Summary:
Some vehicles may exhibit a cd changer with a cd magazine that jams / will not eject. *tt
Bulletin:
13355
Component:
353600 equipment:air conditioner
Summary:
Information regarding a/c peanut o-ring color. *tt
Bulletin:
13448
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Some vehicles may exhibit engine oil that has a milky appearance at predelivery inspection due to condensation in the crankcase. *tt
Bulletin:
4656
Component:
063000 engine and engine cooling:exhaust system
Summary:
Some vehicles may exhibit a rattle noise from exhaust system nvh damper on the left hand damper only. *tt
Bulletin:
99-8-15
Component:
162300 structure:body:door
Summary:
Subject regarding door trim panel replacement - service tip. *tt
Bulletin:
99111
Component:
980000 unknown or other
Summary:
Information designed to aid in the diagnosis, testing and repair of noise, vibration and harshness (nvh) concerns. *tt
Bulletin:
991210
Component:
980000 unknown or other
Summary:
Ford motor company has released a private labeled material to be used for iron particle / acid rain service repairs. *tt
Bulletin:
12794
Component:
980000 unknown or other
Summary:
Concerns with an intermittent pop / snap noise from the instrument panel. *tt
Bulletin:
99152
Component:
103000 power train:automatic transmission
Summary:
Information on the new flush and fill tool available through rotunda. *tt
Bulletin:
4699
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
On some vehicles, the engine may be overfilled with oil. this may be caused by misinterpretation of the oil level indicator (dipstick) markings. *tt
Bulletin:
11774
Component:
063000 engine and engine cooling:exhaust system
Summary:
Some vehicles may exhibit a rattle noise from the exhaust system nvh damper on the left hand damper only. *tt
Bulletin:
5203
Component:
185000 vehicle speed control:cruise control
Summary:
Some vehicles may exhibit a hard start / long crank, cold start stall, cold rough idle concern. *tt
Bulletin:
5204
Component:
015000 steering:hydraulic power assist system
Summary:
Power steering noise when turning and reduced power steering assist at low speeds. *tt
Bulletin:
12223
Component:
162300 structure:body:door
Summary:
For all vehicles with drivers door module concerns that require a module replacement, the technician must call for approval before removing and / or replacing. *tt
Bulletin:
12230
Component:
036000 service brakes, hydraulic:antilock
Summary:
All vehicles with antilock brake module concerns that require a module replacement, the technician must call for approval before removing and / or replacing the module. *tt
Bulletin:
002310
Component:
103600 power train:automatic transmission:cooling unit and lines
Summary:
Subject regarding contamination from prior transmission concerns or excess wear may be trapped in the transmission fluid cooling system. *tt
Bulletin:
00B60
Component:
020000 suspension
Summary:
On some vehicles the rear suspension upper control arm brackets on the frame may develop minor cracks when subjected to severe duty service. *jb
Bulletin:
99B09
Component:
020000 suspension
Summary:
Subject pertaining to cosmetic cracks in frame at the rear upper control arm access opening when subjected to severe duty operating conditions. *jb
Bulletin:
0111
Component:
061000 engine and engine cooling:engine
Summary:
On some vehicles, the engine mounts may not exhibit satisfactory durability under severe operating conditions that may be encountered by police, taxi or limo / livery vehicles such as extended idling at high ambient temperatures. *
Bulletin:
01114
Component:
020000 suspension
Summary:
Some vehicles may exhibit vibrations felt at speeds above 72 km/h (45 mph). *tt
Bulletin:
00213
Component:
353600 equipment:air conditioner
Summary:
Subject regarding climate control - eatc - blower motor control service tips. *jb
Bulletin:
00214
Component:
061000 engine and engine cooling:engine
Summary:
Information regarding revised engine mounts for severe duty vehicles. *jb
Bulletin:
99B09
Component:
161000 structure:frame and members
Summary:
Owner notification program 99b09 supplement #2 for certain commercial vehicle frame service. *tt
Bulletin:
0162
Component:
116300 electrical system:ignition:anti-theft controller
Summary:
Vehicles equipped with passive anti-theft system (pats) may not start or crank. *tt
Bulletin:
14862
Component:
071100 fuel system, gasoline:storage:tank assembly
Summary:
Information on replacing fuel tank strap bolts. *tt
Bulletin:
14821
Component:
061000 engine and engine cooling:engine
Summary:
Some vehicles equipped with 4.6l romeo engine may exhibit an oil leak from the cylinder head gasket area. *tt
Bulletin:
14864
Component:
061000 engine and engine cooling:engine
Summary:
Subject regarding certain vehicles with 4.6l romeo engines exhibiting an oil leak from the cylinder head gasket area. *tt
Bulletin:
0147
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Subject regarding engine oil recommendations for use in 2001 vehicles - sae 5w-20 motor oil. *tt
Bulletin:
01M02
Component:
075000 fuel system, gasoline:carburetor system
Summary:
Owner notification program regarding additional coverage on certain 4.6l sohc intake manifolds. some of the composite intake manifolds may develop fatigue cracks at the coolant crossover duct. *tt
Bulletin:
01M02
Component:
075000 fuel system, gasoline:carburetor system
Summary:
Some of the composite intake manifolds used on 4.6l sohc engines may develop fatigue cracks at the coolant crossover duct. this condition could result in engine coolant leakage which, if not serviced, may cause engine overheating. compl
Bulletin:
14907
Component:
980000 unknown or other
Summary:
Concerns with vehicles exhibiting the oil pressure gauge registering low or no oil pressure usually on initial start-up after several hours of cold soak. *tt
Bulletin:
14181
Component:
061000 engine and engine cooling:engine
Summary:
Vehicles built up to december of 1999 may exhibit a clunk noise from the rear of the vehicle when driving over speed bumps. this may be caused by the fill-limiting valve inside the fuel tank. *tt
Bulletin:
14310
Component:
980000 unknown or other
Summary:
Some vehicles may exhibit an incorrect p1729 (4x4 low switch) diagnostic trouble code (dtc) in continues memory. *tt
Bulletin:
01137
Component:
103000 power train:automatic transmission
Summary:
Some vehicles equipped with a 4r70w automatic transmission may exhibit a clunk noise during the 2-1 downshift event. *tt
Bulletin:
15061
Component:
133000 visibility:power window devices and controls
Summary:
Some vehicles built 04/15/2000 or earlier equipped with a keyless entry system may exhibit an inoperative door-mounted keypad, interior and exterior lamps that self-activate and a weak or discharged vehicle battery. *tt
Bulletin:
15078
Component:
105300 power train:driveline:driveshaft
Summary:
Some police and taxi vehicles may exhibit either underbody sheetmetal cracking in the driveshaft tunnel at the rear seat kickup and / or driveshaft contact with the underbody. *tt
Bulletin:
15026
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Some vehicles may exhibit a stall at idle after start-up condition. *tt
Bulletin:
01156
Component:
138120 visibility:defroster/defogger system:windshield:heater core
Summary:
Some vehicles may exhibit heater core leaks. *slc
Bulletin:
01157
Component:
980000 unknown or other
Summary:
Information regarding transmission fluid usage charts. *slc
Bulletin:
15171
Component:
131000 visibility:windshield
Summary:
Information regarding police option-rear window disable-tamper resistance. *yd
Bulletin:
15158
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Some vehicles may exhibit a fead belt jump-off toss. *yh
Bulletin:
15113
Component:
091100 fuel system, other:storage:tank assembly
Summary:
Some vehicles may exhibit a fuel fill valve sealing condition. *yd
Bulletin:
01181
Component:
103800 power train:automatic transmission:park/neutral start switch
Summary:
Brake shift interlock.*jb
Bulletin:
15271
Component:
091110 fuel system, other:storage:tank assembly:filling/charging
Summary:
Dedicated cng regulator bowl kit available. *jg
Bulletin:
01194
Component:
110000 electrical system
Summary:
This aritlce is to provide information on replacement of old style hood lamp switch to the rvised mechanical hood lamp switch. *tt
Bulletin:
01213
Component:
126000 exterior lighting:turn signal
Summary:
Vehicles may exhibit an intermittent rapid flashing of the turn signals. *tt
Bulletin:
012110
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Some vehicles equipped with the romeo built 4.6l 2v engine may exhibit an engine oil leak or oil weepage from the cylinder head gasket at the right hand rear or the left hand front of the engine. *tt
Bulletin:
012113
Component:
116100 electrical system:ignition:switch
Summary:
Some ignition switch lock cylinder assemblies may exhibit rougness and / or excess effort in turning, key does not fully return from start, a malfunction indicator lamp may illuminate with p0500, p1502 and u1039 stored in powertrian control
Bulletin:
012114
Component:
071100 fuel system, gasoline:storage:tank assembly
Summary:
Parts and procedure to reduce the potential of fuel tank punctures during rare and extremely high-speed rear impacts. *tt
Bulletin:
01205
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Some vehicles may exhibit vacuum or air leaks in the intake manifold and / or engine system causing diagnostic trouble codes p0171 and or p0174. *tt
Bulletin:
0214
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Some engine assemblies with aluminum cylinder heads repaired in-vehile have been found to leak coolant and/or oil from the cylinder head gasket area. *tt
Bulletin:
01221
Component:
070000 fuel system, gasoline
Summary:
Some dedicated compressed natural gas (cng) vehicles may exhibit a rough idle, or no start in cold conditions. *tt
Bulletin:
01246
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Engine oil system priming procedures, service tips for reports of premature engine failure. *tt
Bulletin:
0222
Component:
060000 engine and engine cooling
Summary:
Some vehicles may exhibit an intake manifold crossover (first runner) coolant seepage condition. *tt
Bulletin:
02136
Component:
103800 power train:automatic transmission:park/neutral start switch
Summary:
On some vehicles, the brake shift interlock may be inoperative, now allowing the operator to move the shift lever from the park position. stop lamp operation may also be affected. *tt
Bulletin:
0253
Component:
091100 fuel system, other:storage:tank assembly
Summary:
Subject regarding alternative fuel vehicle compressed natural gas tank inspection. *tt
Bulletin:
0245
Component:
111000 electrical system:battery
Summary:
Information regarding discharged battery charging service tips and guidelines. *tt
Bulletin:
02107
Component:
136200 visibility:windshield wiper/washer:motor
Summary:
Transfer service tips for the front wiper motor mount bracket and depressed park output arm. *tt
Bulletin:
0297
Component:
126000 exterior lighting:turn signal
Summary:
Some vehicles produced before 3/5/2002 may exhibit an intermittent rapid flashing of the turn signals. *tt
Bulletin:
15761
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Some dedicated cng vehicles may exhibit driveability conditions of hard start / no start / rough running. *tt
Bulletin:
020503
Component:
071100 fuel system, gasoline:storage:tank assembly
Summary:
Guidance for cng tank inspection for vehicles produced after december 2, 1996. *tt update. *tt
Bulletin:
15808
Component:
133000 visibility:power window devices and controls
Summary:
Some vehicles equipped with a one-touch down module or a drivers door moudle may exhibit a condition where the drivers window moves down when one of the other windows is operated. *tt
Bulletin:
15812
Component:
350000 equipment
Summary:
Overspeed warning chime activation when travelling above 70 m ph / 110 kph. *tt
Bulletin:
02B02
Component:
350000 equipment
Summary:
Installation of optional police interceptor package upgrade kit. *tt update part 2. expiration date removed. *tt
Bulletin:
0349
Component:
090000 fuel system, other
Summary:
A possible fuel leak may occur at the fuel fill valve on some cng (compressed natural gas) vehicles. *tt *jb
Bulletin:
0326
Component:
062200 engine and engine cooling:cooling system:fan
Summary:
Revised cooling fan motor available. *tt
Bulletin:
030409
Component:
090000 fuel system, other
Summary:
Possible fuel leak at fill valve - fill valve service part revisions - cng vehicles only. *tt
Bulletin:
0398
Component:
090000 fuel system, other
Summary:
Malfunction indicator lamp (mil) illumination with diagnostic trouble codes p0442, p0455, p0456, p0457, p1442 or check fuel cap lamp illuminated with diagnostic trouble code p0457. *tt
Bulletin:
03144
Component:
061000 engine and engine cooling:engine
Summary:
Engine misfire or rough running condition with coil on plug (cop) ignition systems may be more accurately diagnosed using the optional worldwide diagnostic system (wds) coil on plug (cop) kit. 2003 super duty f series included. *tt
Bulletin:
16996
Component:
110000 electrical system
Summary:
Police interceptor may exhibit low charging system voltage at idle. *tt
Bulletin:
03181
Component:
110000 electrical system
Summary:
Remote keyless entry (rke) - service tips. *tt
Bulletin:
03183
Component:
180000 vehicle speed control
Summary:
Dedicated compressed natural gas (cng) rough idle or no start when cold vehicles equipped with dedicated 4.6l or 5.4l cng engine only. *tt
Bulletin:
03193
Component:
121000 exterior lighting:headlights
Summary:
Excessive moisture in the headlamp assembly. *tt
Bulletin:
03206
Component:
061000 engine and engine cooling:engine
Summary:
Some dedicated cng vehicles may exhibit various driveability conditions due to a loss of injector performance, resulting from fuel quality. loss of power at heavy load, diagnostic trouble codes (dtcs) for lean fuel, rough idle, hard start,
Bulletin:
17757
Component:
126000 exterior lighting:turn signal
Summary:
Intermittent rapid flashing of the turn signals. *tt
Bulletin:
17871
Component:
116000 electrical system:ignition
Summary:
Multiple driveability concerns under acceleration caused by ignition coil. *tt
Bulletin:
03261
Component:
103000 power train:automatic transmission
Summary:
New service part - number 5 needle bearing and race kit - 4r70w transmission - service tip. *tt
Bulletin:
16378
Component:
061000 engine and engine cooling:engine
Summary:
Idle miss or surge at highway speeds. premature ignition coil-on-plug (cop) replacement / under investigation (qsf). *tt
Bulletin:
16380
Component:
061000 engine and engine cooling:engine
Summary:
Service cylinder head gasket for 4.6l applications. *tt
Bulletin:
0441
Component:
020000 suspension
Summary:
Cracks in the rear of the frame side member between the upper and lower trailing arm brackets. *tt
Bulletin:
17810
Component:
103000 power train:automatic transmission
Summary:
Transmission failure where there is a large amount of metal or debris in the pan. *tt
Bulletin:
02176
Component:
032100 service brakes, hydraulic:switches:brake light
Summary:
Lamp-brake-invadvertent disabling of brake shift interlock. *mj
Bulletin:
031501
Component:
138130 visibility:defroster/defogger system:windshield:controls/wiring
Summary:
Inoperative electric rear window defroster (heated backlite) grid lines, integral antenna concerns. *tt
Bulletin:
031404
Component:
061000 engine and engine cooling:engine
Summary:
Engine misfire or running - coil on plug (cop) ignition systems - wds cop kit diagnostic tips. to include various 2005 models. * ar this article 04161 supersedes tsb 03-14-04.
Bulletin:
02208
Component:
353600 equipment:air conditioner
Summary:
Climate control a/c service tech tips. *eh
Bulletin:
04189
Component:
138200 visibility:defroster/defogger system:rear window
Summary:
Rear window defroster grid/integral antenna diagnosis and repair - terminal tab repair. *tt
Bulletin:
042107
Component:
103100 power train:automatic transmission:control module (tcm, pcm)
Summary:
General (pcm) power train control module programming procedures. *tt
Bulletin:
18351
Component:
060000 engine and engine cooling
Summary:
Charging system limitations. *eh
Bulletin:
041601
Component:
060000 engine and engine cooling
Summary:
Wds cop kit diagnostic tip - coil on plug (cop) ignition systems - engine misfire or rough running. *tt
Bulletin:
05N04
Component:
063200 engine and engine cooling:exhaust system:manifold/header/muffler/tail pipe
Summary:
Extended coverage program 05n04 - extended coverage for composite intake manifold. this program is being provided as a settlement to a class action lawsuit. the terms of the settlement extend the coverage of the all-composite intake manif
Bulletin:
07212
Component:
061000 engine and engine cooling:engine
Summary:
Some 1997-2008 vehicles equipped with a 4.6l 2v, 5.4l 2v, or 6.8l 2v engine--spark plug thread repair procedure--not covered under new vehicle limited warranty. *nj this includes f-53 motorhome chassis. updated 2/23/10. *pe
Bulletin:
CSP-08B01
Component:
063140 engine and engine cooling:exhaust system:emission control:catalytic convertor
Summary:
Ford: certain 1999-2001 model year vehicles up to 6000 lb gvwr registered in new york and certain 2001 vehicles up to 6000 lb gvwr registered in the state of maine, certified for sale in california-federal emission warranty refund. *pe
Bulletin:
CSP 08B04
Component:
071100 fuel system, gasoline:storage:tank assembly
Summary:
Ford/lincoln mercury: certain 1992-2001 model year crown victoria, grand marquis, and town car vehicles registered in the states of wisconsin and connecticut upgrade modifications for high speed rear impacts. *pe

Home | Privacy