1999 CHRYSLER SEBRING Recalls (9)

Campaign:: 99I004000 on 02/16/2000
Component:: Structure:body:roof and pillars
Affected:: 175,000
Defect:: This is not a safety recall in accordance with the safety act. however, it is deemed a safety improvement campaign by the agency. vehicle description: passenger vehicles. if the convertible top cover is not installed correctly, it can separate unexpectedly from the vehicle while driving.
Consequence:: If the cover separates while driving, it could distract the driver increasing the risk of a crash.
Correction:: Owners will receive an improved convertible top cover instruction label and installation instructions.
Notes:: Daimlerchrysler has decided to conduct a customer satisfaction notification to send instruction labels to owners.owners can contact daimlerchrysler at 1-800-992-1997.
Campaign:: 00V421002 on 03/11/2001
Component:: Suspension:front:control arm:lower ball joint
Manufactured:: 06/30/1994 - 02/27/2000
Affected:: 393,796
Defect:: Vehicle description: passenger vehicles. if the rubber boots on the lower lateral arm ball joints of the front suspension were damaged during assembly, dirt and water can intrude. also, mmc has added the potential of leaking moisture, which can cause the ball stud to corrode.
Consequence:: This condition could cause the lower lateral arm ball joint to separate, increasing the risk of a vehicle crash. this campaign supercedes mmc's previous safety recall campaign, see 99v-066.
Correction:: Dealers will inspect the lower lateral arm ball joint for wear. ball joints that exhibit wear beyond the established tolerance will be replaced with newly designed lateral arm ball joints. ball joints that are within the established tolerance will be cleaned and a special sealant will be applied to prevent intrusion of moisture.
Notes:: Owner notification began may 21, 2001.owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact daimlerchrysler at 1-800-853-1403. also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
Campaign:: 01I012000 on 01/06/2002
Component:: Steering:wheel and handle bar
Affected:: 9,800
Defect:: This is not a safety recall in accordance with the safety act. however, it is deemed a safety improvement campaign by the agency. vehicle description: 1998-1999 chrysler sebring jxi limited convertibles. the steering column intermediate shaft coupler pinch bolt retaining pin could snag and/or fray the edge of the driver's side floor mat.
Consequence:: This could interfere with the steering control of the vehicle.
Correction:: Dealer will replace the steering column intermediate shaft coupler pinch bolt and retaining pin. in addition, the front floor mats will be replaced.
Notes:: Daimlerchrysler has decided to conduct a customer satisfaction campaign to replace the steering column intermediate shaft coupler pinch bolt,retaining pin, e-clip and the front floor mats.owners can contact daimlerchrysler at 1-800-853-1403, concerning this program.
Campaign:: 06E064000 on 07/16/2006
Component:: Exterior lighting
Affected:: 4,029
Defect:: Certain tradesonic combination lamps sold as replacement lamps for use on the above listed passenger vehicles. combination lamps not equipped with amber side reflectors fail to conform with the requirements of federal motor vehicle safety standard no. 108, lamps, reflective devices, and associated equipment.
Consequence:: Lack of amber side reflectors in the lamps will decrease lighting visibility to other drivers and may possibly result in a vehicle crash.
Correction:: Tradesonic will notify owners and replace the lamps free of charge. the recall is expected to begin during july 2006. owners may contact tradesonic at 626-934-8884.
Notes:: This recall only pertains to tradesonic aftermarket lamps and has no relation to any original equipment installed on the listed passenger vehicles.for more information on the lamp model numbers, click on document search and view document titled "lamp model numbers."customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov.
Campaign:: 06E088000 on 10/25/2006
Component:: Fuel system, gasoline:delivery:fuel pump
Affected:: 39,243
Defect:: Certain tigas fuel pump modules manufactured between june 1 and september 24, 2006, sold under various brand names and p/nos. these fuel pump modules are sold as aftermarket for use in certain daimlerchrysler vehicles listed above. silicone material used in manufacture of the flapper valve was out-of-specification, leading to excess swell of the flapper valve restricting the flow of fuel to the fuel pump module.
Consequence:: Fuel restriction could result in loss of power and/or engine stall, possibly resulting in a vehicle crash.
Correction:: Ti automotive will notify owners and replace the defective fuel pump modules free of charge. the recall began on october 6, 2006. owners may contact ti automotive toll-free at 1-877-461-1834.
Notes:: This recall only pertains to aftermarket fuel pump modules and has no relation to any original equipment installed on vehicles by daimlerchrysler.customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov.
Campaign:: 06E091000 on 11/01/2006
Component:: Fuel system, gasoline:delivery:fuel pump
Affected:: 24,358
Defect:: Certain airtex fuel pump modules, p/nos. e7089m, e7094m, e7113m, and e7129m, manufactured between june 1 and september 24, 2006. these fuel pump modules were sold as aftermarket for use in certain daimlerchrysler vehicles listed above. silicone material used in manufacture of the flapper valve was out-of-specification, leading to excess swell of the flapper valve restricting the flow of fuel to the fuel pump module.
Consequence:: Fuel restriction could result in loss of power and/or engine stall, possibly resulting in a vehicle crash.
Correction:: Airtex will notify owners and replace the defective fuel pump modules free of charge. the recall began on october 18, 2006. owners may contact airtex toll-free at 1-866-867-3759.
Notes:: This recall only pertains to aftermarket fuel pump modules and has no relation to any original equipment installed on vehicles by daimlerchrysler.customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov.
Campaign:: 07E055000 on 07/25/2007
Component:: Fuel system, gasoline:delivery:fuel pump
Affected:: 222
Defect:: Certain airtex fuel pump module assemblies, p/n e7081h, sold for use as replacement equipment for the vehicles listed above. the wall of the flared fitting of the fuel pump is not thick enough to prevent the mating threaded fittings from bottoming out before an adequate seal is achieved. this condition may result in leakage of fuel at the connection of the vehicle fuel line and the fuel pump module assembly.
Consequence:: In the presence of an ignition source, a fuel leak could result in a fire.
Correction:: Airtex will notify owners and replace the fuel pumps free of charge. the recall is expected to begin during july 2007. owners can contact airtex automotive at 800-880-3056.
Notes:: Airtex recall no. fp072007-1.this recall only pertains to aftermarket replacement equipment and has no relation to any original equipment installed on vehicles manufactured by daimlerchrysler or mitsubishi.customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov.
Campaign:: 09E012000 on 04/06/2009
Component:: Exterior lighting
Affected:: 16,270
Defect:: Sabersport is recalling 16,270 combination corner and bumper lamp assemblies of various part numbers sold for use as aftermarket equipment for various passenger vehicles. these headlamps fail to conform to the requirements of federal motor vehicle safety standard no. 108, "lamps, reflective devices, and associated equipment." these lamps do not contain the required amber side reflectors.
Consequence:: Decreased lighting visibility may result in a vehicle crash.
Correction:: Sabersport will notify owners and offer a full refund for the noncompliant combination lamps. the safety recall began on may 11, 2009. owners may contact sabersport at 1-909-598-7589.
Notes:: This recall only pertains to aftermarket replacement equipment and has no relation to any original equipment installed on vehicles produced by the vehicle manufacturer.in order to determine if your aftermarket lamp assembly is affected by this noncompliance, please review the list of model numbers provided to us by sabersport.the list can be found under "document search" located at the bottom of your screen.owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to <a href=http://www.safercar.gov>http://www.safercar.gov</a> .
Campaign:: 09E043000 on 07/08/2009
Component:: Equipment
Affected:: 30,351
Defect:: Import products is recalling 30,351 fuel filters sold to and branded by the affinia group as carquest p/n 86523, napa p/n 3523, and wix p/n 33523 for use as replacement equipment on the vehicles listed above. these filters may develop a leak in the hose assembly and/or connectors due to improperly adhered line connectors.
Consequence:: This condition may result in a vehicle fire.
Correction:: The affinia group will notify owners and the filters will be replaced free of charge. the safety recall began on august 1, 2009. owners may contact wix filter return center at 1-704-869-7411 or import products at 1-508-279-8207.
Notes:: This recall only pertains to affinia group aftermarket fuel filters and has no relation to any original equipment installed on the listed passenger vehicles.owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to <a href=http://www.safercar.gov>http://www.safercar.gov</a> .

1999 CHRYSLER SEBRING TSBs (61)

Bulletin:: 235798
Component:: 162000 structure:body
Summary:: Information regarding headlining sagging above rear window due to hook and loop fastenerseparating from rear window curtain. *ak *yc
Bulletin:: 241598
Component:: 353600 equipment:air conditioner
Summary:: Information on a/c system performance complaints and /0r a/c compressor failure in high ambient temperatures (90+f). *ak
Bulletin:: #9864
Component:: 162000 structure:body
Summary:: Subject on front fascia protector removal. *yc
Bulletin:: 250298
Component:: 063000 engine and engine cooling:exhaust system
Summary:: Subject regarding i/m ( inspection maintenance ) testing - obd ii "carb" readiness monitor information. *yc
Bulletin:: 234598
Component:: 980000 unknown or other
Summary:: Approval of using of in- transit protective film. on all vehicles at all assembly plants. *ak
Bulletin:: 190698
Component:: 015300 steering:hydraulic power assist:power steering fluid
Summary:: A new power steering fluid. *yc
Bulletin:: 090598
Component:: 061000 engine and engine cooling:engine
Summary:: A new multi-layer steel ( mls ) head gasket has been developed and is being implemented into production vehicles. *yc
Bulletin:: 050898
Component:: 034500 service brakes, hydraulic:foundation components:disc
Summary:: Exhibitting a conditon where the steering wheel shakes or the brake pedal pulsates due to premature wear of front brake rotors and pads. *ak
Bulletin:: 081798
Component:: 145000 air bags:on-off switch assembly
Summary:: Subject regarding airbag on - off switches. *yc
Bulletin:: 236098
Component:: 134000 visibility:sun roof assembly
Summary:: Some vehicles may exhibit a condition where the sunshade fabric delaminates from the substrate along the edeges of the sunshade. *yc
Bulletin:: #9850
Component:: 162000 structure:body
Summary:: Conditions regarding paint splatter, belvidere rail head storage yard. *yc
Bulletin:: 190199
Component:: 015100 steering:hydraulic power assist:pump
Summary:: Procedures on aligning the power steering belt. *tt
Bulletin:: 210499
Component:: 103000 power train:automatic transmission
Summary:: Service and parts information on 1999 running changes to transmission range sensor (trs) *tt
Bulletin:: 210599
Component:: 103000 power train:automatic transmission
Summary:: Subject regarding reusable automatic transmission oil pan gasket. *tt
Bulletin:: 020299
Component:: 020000 suspension
Summary:: Vehicles exhibiting front coil spring creaking, popping, or squeaking. *tt
Bulletin:: 210699
Component:: 180000 vehicle speed control
Summary:: Conditions with intermittent loss of speed control. *tt
Bulletin:: 9920
Component:: 106000 power train:axle assembly
Summary:: Information on fast feedback fleet - installation of 2000 model year 41te transaxles. *tt
Bulletin:: 9917
Component:: 020000 suspension
Summary:: Customer may complain of harsh ride, vehicle lead or pull and perceived brake shudder. *tt
Bulletin:: 9913
Component:: 103100 power train:automatic transmission:control module (tcm, pcm)
Summary:: Vehicles may experience faults related to the transmission range sensor (trs). *tt
Bulletin:: 020799
Component:: 022400 suspension:rear:shock absorber
Summary:: Conditions with light knocking noise from the rear shock area. *tt
Bulletin:: 181299
Component:: 103100 power train:automatic transmission:control module (tcm, pcm)
Summary:: This bulletin explains the operation and application of the leak detection pump (ldp) monitor test. *tt
Bulletin:: 090799
Component:: 061000 engine and engine cooling:engine
Summary:: Information regarding 2.5l v-6 head gasket application. *tt
Bulletin:: 090899
Component:: 061000 engine and engine cooling:engine
Summary:: Technical service bulletin regarding multi-layer steel (mls) head gasket installation procedures. *tt
Bulletin:: 210599A
Component:: 103000 power train:automatic transmission
Summary:: This bulletin announces the availability and installation of a resuable automatic transmission oil pan gasket. *tt
Bulletin:: 233599
Component:: 220000 seats
Summary:: Information on child seat tether anchors. *tt
Bulletin:: 081698
Component:: 353400 equipment:electrical:radio/tape deck/cd etc.
Summary:: Information on installation of radio transmitting equipment. *ak
Bulletin:: 083298
Component:: 061000 engine and engine cooling:engine
Summary:: New vehicle prep procedures - compass calibration / hvac operation. *yc
Bulletin:: 090798
Component:: 061000 engine and engine cooling:engine
Summary:: Subject regarding oil seepage at cam position sensor / misinterpreted head gasket leak. *yc
Bulletin:: 183298
Component:: 162000 structure:body
Summary:: Subject on flash programming failure recovery. *yc
Bulletin:: 233199
Component:: 151100 seat belts:front:anchorage
Summary:: Subject regarding twisted seat belts. *tt
Bulletin:: 083799
Component:: 145000 air bags:on-off switch assembly
Summary:: Daimlerchrysler corporation is now offerinb airbag on / off switches for selected vehicles. *tt
Bulletin:: 180100
Component:: 061000 engine and engine cooling:engine
Summary:: Subject regarding misdiagnosed leak detection pump systems with diagnostic trouble codes p1494, p0442 p0455, or p0456. *tt
Bulletin:: 182699
Component:: 063000 engine and engine cooling:exhaust system
Summary:: Some vehicles may experience nox emission failure when performing an asm type inspection / maintenance (i/m) emission test. *tt
Bulletin:: 080600
Component:: 114000 electrical system:wiring
Summary:: This bulletin provides a revised wire splice procedure and related parts. *tt
Bulletin:: 235699
Component:: 162300 structure:body:door
Summary:: Some vehicles may exhibit a condition where the butyl used for holding the door weather shield in place drips from the lower door edge. *tt
Bulletin:: 230800
Component:: 220000 seats
Summary:: Subject regarding child seat tether anchors. *tt
Bulletin:: 211599
Component:: 106000 power train:axle assembly
Summary:: Subject on transaxle seepage mis-diagnosis- case porosity. *mjs
Bulletin:: 233599REVA
Component:: 162000 structure:body
Summary:: Subject on the child seat tether anchors. *mjs
Bulletin:: 234099
Component:: 162000 structure:body
Summary:: Subject on vehicles experiencing door cladding loose or falling off. *mjs
Bulletin:: 082700
Component:: 140000 air bags
Summary:: Subject regarding non-deployed airbag handling procedures. *tt
Bulletin:: 2300800B
Component:: 220000 seats
Summary:: Subject regarding child seat tether anchors. *tt
Bulletin:: 0804000
Component:: 221600 seats:front assembly:power adjust
Summary:: Information on new components and a repair procedure developed to replace failed seat slide motors. *tt
Bulletin:: 0800600REV
Component:: 110000 electrical system
Summary:: Subject regarding wire splice repairs. *sb
Bulletin:: 884
Component:: 162300 structure:body:door
Summary:: On certain coupe vehicles, the door garnish moldings may move forward on the door and contact the rear edge of the front fender when the door is opened. *tt
Bulletin:: 0801001
Component:: 110000 electrical system
Summary:: Subject regarding airbag / clock spring service for various models including 2002 model year jeep liberty. *tt
Bulletin:: 1801201
Component:: 350000 equipment
Summary:: Subject regarding generic scan tool (gst), publication no. 81-170-00008 provided with this technical service bulletin to provide reference information when using generic scan tool on obdii vehicles. *tt
Bulletin:: 2100601
Component:: 103000 power train:automatic transmission
Summary:: Automatic transmission fluid usage atf+4. *tt *mj
Bulletin:: 1802001
Component:: 061100 engine and engine cooling:engine:gasoline
Summary:: Exhibiting rough idle, hard start and start & stall.*cls
Bulletin:: 1802002
Component:: 980000 unknown or other
Summary:: Flash programming failure recovery. *slc
Bulletin:: 2500102A
Component:: 063100 engine and engine cooling:exhaust system:emission control
Summary:: Malfunction indicator lamp (mil) illumination, diagnostic trouble code (dtc) p0442, p0455, or p0456 - leak detection pump (ldp), leak detected. this bulletin supersedes 25-001-02 dated feb 11, 2002. *tt
Bulletin:: 9003623
Component:: 355200 equipment:other:owners/service/other manual
Summary:: Wiper if mopar oe wipers are unavailable, the below alternatives can be offered instead. 05066964a$ = wbrw0011a$ 05066973a$ = wb000019a$ or wbf00019a$ 05096134a$ = wb000027a$ or wbf00028a$ 55154762a$ = wb000013a$ 68001330a$ = wb000019
Bulletin:: 20616
Component:: 110000 electrical system
Summary:: P/n cbszr068aa: inspect & return: module kit - occupant restraint you have been identified as either having stock, or have stock in transit to your dealership. please return part number cbszr068aa as per the qir attached. replacement par
Bulletin:: 22892
Component:: 355200 equipment:other:owners/service/other manual
Summary:: Return: lamp assy - chmsl& cargo light you have been identified as either having stock, or have stock in transit to your dealership. please return all stock of follow ing part numbers:55372082ae, 55372082ad, 55372082ac, 55372082ab, 553720
Bulletin:: 22867
Component:: 110000 electrical system
Summary:: Inspect and return: solenoid module - transmission you have been identified as either having stock, or have stock in transit to your dealership. please return suspect stock of follow ing part numbers:52120000aa, 52119435af, 05078709ab. s
Bulletin:: 22958
Component:: 117000 digital instrument panel
Summary:: 1nt30xdvac - inspect and return: panel - instrument panel you have been identified as either having stock, or have stock in transit to your dealership. please return suspect stock of part number 1n t30xdvac. see attachments for identifyin
Bulletin:: 20244
Component:: 350000 equipment
Summary:: Cbxdp361aa return: spacer kit - visor you have been identified as either having stock, or have stock in transit to your dealership. please return stock of part number cbxdp361aa. replacement part number is cbxdp361ab w hich is in stock a
Bulletin:: Volume 2, Issue
Component:: 355200 equipment:other:owners/service/other manual
Summary:: Warranty operations newsletter updates from warranty operations
Bulletin:: Volume 2, Issue
Component:: 355200 equipment:other:owners/service/other manual
Summary:: Warranty operations newsletter updates from warranty operations
Bulletin:: 23137
Component:: 350000 equipment
Summary:: Inspect and return: trim cover assy - a-pillar rt/lt you have been identified as either having stock, or have stock in transit to your dealership. please return suspect stock of part numbers: 1za04dx9ae, 1za05dx9ae. see attachments for id
Bulletin:: 23104
Component:: 120000 lighting (pws)
Summary:: 05182535ad - lamp assy ?tail light lt you have been identified as either having stock, or have stock in transit to your dealership. please return suspect stock of part number 05182535ad . see attachments for identifying suspect stock. pl
Bulletin:: 23027
Component:: 114000 electrical system:wiring
Summary:: Return: wiring assy - engine you have been identified as either having stock, or have stock in transit to your dealership. please return stock packaged before 2016/07/31 (31 july, 2016)of follow ing part numbers:68176457af, 68176459af. p

Home | Privacy