1998 MITSUBISHI GALANT Recalls (2)

Campaign:
00V421001 on 12/17/2000
Component:
Suspension:front:control arm:lower ball joint
Manufactured:
01/31/1993 - 06/29/1999
Affected:
567,432
Defect:
Vehicle description: passenger vehicles. if the rubber boots on the lower lateral arm ball joints of the front suspension were damaged during assembly, dirt and water can intrude. also, mmc has added the potential of leaking moisture, which can cause the ball stud to corrode.
Consequence:
This condition could cause the lower lateral arm ball joint to separate, increasing the risk of a vehicle crash. this campaign supercedes mmc's previous safety recall campaign, see 99v-066.
Correction:
Dealers will inspect the lower lateral arm ball joint for wear. ball joints that exhibit wear beyond the established tolerance will be replaced with newly designed lateral arm ball joints. ball joints that are within the established tolerance will be cleaned and a special sealant will be applied to prevent intrusion of moisture.
Notes:
Owner notification will be conducted in phases.the first phase began april 2, 2001, and the final phase will be completed on september 3, 2001. owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact mitsubishi america at 1-888-mitsu-2001 (1-888-648-7820).also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
Campaign:
07E055000 on 07/25/2007
Component:
Fuel system, gasoline:delivery:fuel pump
Affected:
222
Defect:
Certain airtex fuel pump module assemblies, p/n e7081h, sold for use as replacement equipment for the vehicles listed above. the wall of the flared fitting of the fuel pump is not thick enough to prevent the mating threaded fittings from bottoming out before an adequate seal is achieved. this condition may result in leakage of fuel at the connection of the vehicle fuel line and the fuel pump module assembly.
Consequence:
In the presence of an ignition source, a fuel leak could result in a fire.
Correction:
Airtex will notify owners and replace the fuel pumps free of charge. the recall is expected to begin during july 2007. owners can contact airtex automotive at 800-880-3056.
Notes:
Airtex recall no. fp072007-1.this recall only pertains to aftermarket replacement equipment and has no relation to any original equipment installed on vehicles manufactured by daimlerchrysler or mitsubishi.customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov.

1998 MITSUBISHI GALANT TSBs (21)

Bulletin:
971101971101
Component:
061000 engine and engine cooling:engine
Summary:
Service manual revision on corrected crankshaft bearing procedures. *yc
Bulletin:
97110116010
Component:
061000 engine and engine cooling:engine
Summary:
Repair information for correcting a cold start generator drive belt noise condition on some vehicles. *yc
Bulletin:
97110142A013
Component:
162000 structure:body
Summary:
Vehicles may exhibit a condition where the driver's side sunroof side decoration cover comes loose. *yc
Bulletin:
97100155002
Component:
980000 unknown or other
Summary:
Preventing dust from entering the interior. *yc
Bulletin:
TSB9723015
Component:
101100 power train:clutch assembly:pedal/linkage
Summary:
Information about improved automatic transaxle end clutch. *tt
Bulletin:
TSB9754015
Component:
133000 visibility:power window devices and controls
Summary:
Repair procedures for audio failure on various model years. *yc
Bulletin:
TSB9813007
Component:
072100 fuel system, gasoline:delivery:fuel pump
Summary:
Procedures on fule pump operation check. *yc
Bulletin:
TSB9813005
Component:
180000 vehicle speed control
Summary:
Vehicles may experience long cold start times, sag during warm-up, and stalling. *tt
Bulletin:
TSB9823007
Component:
103000 power train:automatic transmission
Summary:
The park/neutral position switch continuity check table is incorrectly printed in the affected service manual pages. *yc
Bulletin:
TSB9823014
Component:
103000 power train:automatic transmission
Summary:
Experiencing a/t harsh 3-2 downshifts. *tt
Bulletin:
TSB9816003
Component:
116000 electrical system:ignition
Summary:
Information concerning a change in spark plug. *yc
Bulletin:
TSB9931002
Component:
190000 tires
Summary:
This bulletin contains snow tire recommendations for certain cars and sport-utility vehicles. *tt
Bulletin:
48
Component:
185000 vehicle speed control:cruise control
Summary:
Exhibiting rough idle after warm-up. *tt
Bulletin:
9922003
Component:
102000 power train:manual transmission
Summary:
This bulletin contains recommended manual transmission / transaxle maintenance information. *tt
Bulletin:
9923010
Component:
103000 power train:automatic transmission
Summary:
This bulletin contains recommended automatic transmission / transaxle maintenance information. *tt
Bulletin:
0013005
Component:
350000 equipment
Summary:
This bulletin contains obd-ii drive cycle procedures and warranty claim information for obd-ii drive cycle on affected vehicles. *tt
Bulletin:
67
Component:
015000 steering:hydraulic power assist system
Summary:
Subject regarding power steering pump replacement. *jb
Bulletin:
0255002
Component:
353600 equipment:air conditioner
Summary:
Subject regarding corrected air conditioner magnetic clutch service procedures. *jg
Bulletin:
TSB0211002
Component:
061000 engine and engine cooling:engine
Summary:
Information on crankshaft identification marks - service manual revision. *tt
Bulletin:
0313005
Component:
350000 equipment
Summary:
Obd-ii drive cycle. *tt
Bulletin:
TT237
Component:
355200 equipment:other:owners/service/other manual
Summary:
This is a service newsletter (tech talk) that was sent out to dealers.

Home | Privacy