1998 LINCOLN TOWN CAR Recalls (8)

Campaign:
98V028000 on 02/24/1998
Component:
Exterior lighting:headlights
Manufactured:
10/12/1997 - 11/22/1997
Affected:
571,800
Defect:
Vehicle description: passenger vehicles. the text and/or graphics for the vehicle headlamp aiming instructions provided in the owner guides are not sufficiently clear. this does not meet the requirements of fmvss no. 108, "lamps, reflective devices, and associated equipment."
Consequence:
If the headlamp assemblies are replaced, customers may be confused by the aiming instructions provided in the owner guides causing the headlamps to be improperly aimed.
Correction:
Owner guides containing revised aiming instructions will be mailed to owners of these vehicles.
Notes:
Owner notification is expected to begin march 23, 1998. owners who do not receive the free owner guide within a reasonable time should contact ford at 1-800-392-3673.also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
Campaign:
98V322000 on 12/17/1998
Component:
Suspension:front:control arm:lower ball joint
Manufactured:
03/14/1996 - 12/17/1998
Affected:
175,000
Defect:
Vehicle description: certain 1996-1999 ford crown victoria police, fleet, natural gas, and 1996-1999 lincoln town car limousine vehicles that were produced with a lower control arm ball joint containing a one piece bearing; and 1990-1996 ford crown victoria police, fleet, and ngv vehicles and 1990-1996 lincoln town car limousine vehicles that have been serviced with either a ball joint containing the one-piece bearing or a front lower control arm containing a ball joint with a one-piece bearing. the one-piece bearing within the lower control arm ball joint can weaken slowly during use and eventually crack. this could result in separation of the ball and cap of the joint, allowing the control arm to drop to the ground.
Consequence:
If this occurs while the vehicle is moving, reduced steering control could occur, increasing the risk of a crash.
Correction:
Dealers will replace the lower control arm ball joints (2).
Notes:
Owner notification is expected to begin january 18, 1999.owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact ford at 1-800-392-3673.also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
Campaign:
00V157002 on 06/15/2000
Component:
Seat belts:front:anchorage
Affected:
1,129
Defect:
Vehicle description: passenger vehicles using aftermarket front passenger side seat belt assemblies that were sold by ford parts departments from january 1, through june 13, 2000. these seat belt assemblies fail to comply with the requirements of fmvss no. 209, "seat belt assemblies." the equipment involved is service stock seat belt assemblies, model nos. h 9977, h 9979, t 9063, and t 9217, built by trw vehicle safety systems, inc. (trw) manufactured from june 1, 1998 through may 21, 2000. some of these seat belt assemblies may have been installed as service replacement equipment on the vehicles involved in the recall.
Consequence:
In the event of a collision, these seat belts may not restrain an occupant increasing the risk of injury.
Correction:
Dealers will inspect these vehicles and replace the service seat belt assemblies that were installed in these vehicles from january 1 through june 13, 2000.
Notes:
Owner notification began september 28, 2000. owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact ford at 1-800-392-3673.also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
Campaign:
00V157001 on 06/15/2000
Component:
Seat belts:front:anchorage
Affected:
1,167
Defect:
Vehicle description: passenger vehicles using aftermarket driver's seat belt assemblies that were sold by ford parts departments from january 1, through june 13, 2000. these seat belt assemblies fail to comply with the requirements of fmvss no. 209, "seat belt assemblies." the equipment involved is service stock seat belt assemblies, model nos. h 9977, h 9979, t 9063, and t 9217, built by trw vehicle safety systems, inc. (trw) manufactured from june 1, 1998 through may 21, 2000. some of these seat belt assemblies may have been installed as service replacement equipment on the vehicles involved in the recall.
Consequence:
In the event of a collision, these seat belts may not restrain an occupant increasing the risk of injury.
Correction:
Dealers will inspect these vehicles and replace the service seat belt assemblies that were installed in these vehicles from january 1 through june 13, 2000.
Notes:
Owner notification began september 28, 2000. owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact ford at 1-800-392-3673.also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
Campaign:
00V200000 on 07/19/2000
Component:
Equipment:mechanical:jacks
Manufactured:
06/09/1997 - 06/13/2000
Affected:
875,000
Defect:
Vehicle description: passenger vehicles. these vehicles have jacking instructions which, if followed, could cause the vehicle operator to place the jack on a frame weld when attempting to raise a rear wheel. if the vehicle is jacked up with the jack placed on the frame weld and if the vehicle is free to roll (wheels not blocked or chocked), the jack could yield and the vehicle may drop suddenly.
Consequence:
If this occurs and any portion of the operator's body is under the vehicle, the potential for personal injury exists.
Correction:
Owners will be provided with a revised jack instruction and stowage card and jack warning label, as well as a supplement to the owner guide.
Notes:
Owner notification began august 3, 2000.owners who do not receive the free instructions and label within a reasonable time should contact ford at 1-800-392-3673.also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
Campaign:
00V356000 on 12/14/2000
Component:
Tires
Manufactured:
09/18/1997 - 09/25/2000
Affected:
10,000
Defect:
Vehicle description: certain limousines stretched over 60 inches fail to comply with the requirements of fmvss no. 109, "new pneumatic tires," and no. 110, "tire selection and rims."
Consequence:
The vehicle weight could exceed the maximum load rating for the tire, increasing the risk of premature tire wear or blowout.
Correction:
Dealers will replace all 5 tires (including the spare tire) with michelin tires (225/70r16 107t reinforced white sidewall) with a sufficiently higher load rating. owner notification began january 10, 2001. owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact ford at 1-800-248-0186.
Notes:
Also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
Campaign:
07V336000 on 08/02/2007
Component:
Vehicle speed control
Manufactured:
11/04/1991 - 02/27/1998
Affected:
3,600,000
Defect:
On certain pickup trucks, passenger vehicles, sport utility vehicles, and motor homes chassis, the speed control deactivation switch may, under certain conditions, leak internally and then overheat, smoke, or burn.
Consequence:
This could result in an underhood fire.
Correction:
Dealers will install a fused wiring harness. owners of the passenger cars included in this campaign will be instructed to return their vehicles to their dealers to have the speed control deactivation switch disconnected as an interim repair. as soon as repair parts are available (expected october 2007), owners will be instructed to return to the dealers for installation of a fused wiring harness. the recall began on august 13, 2007, and mailing completed by september 19, 2007. owners may contact ford at 1-888-222-2751.
Notes:
Ford recall no. 05s28.customers may also contact the national highway traffic safety administration;s vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov.
Campaign:
15E082000 on 10/05/2015
Component:
Steering
Affected:
1,767
Defect:
Dorman products, inc. (dorman) is recalling certain model dorman steering shafts, part number 425-359, solutions steering shafts, part number 7-0359, and oe solutions steering shafts, part number 425-359, manufactured april 17, 2014, to september 28, 2015. these aftermarket replacement steering shafts are sold for use in 1995-2002 ford crown victoria, mercury grand marquis, and lincoln town car vehicles. these steering shafts may separate during operation if the integral fastener is loose or missing and if the interfacing vehicle shaft is compressed in length.
Consequence:
If the shafts separate during vehicle operation, a loss of steering control would result, increasing the risk of a vehicle crash.
Correction:
Dorman will notify owners, and dealers will replace the steering shaft, free of charge. the recall began on october 28, 2015. owners may contact dorman customer service at 1-800-523-2492, option 5.
Notes:
Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.

1998 LINCOLN TOWN CAR TSBs (194)

Bulletin:
97090297183
Component:
103100 power train:automatic transmission:control module (tcm, pcm)
Summary:
Experiencing difficulties with the malfunction indicator lamp (mil). *yc
Bulletin:
9831
Component:
162000 structure:body
Summary:
Repairs to vinyl covered surfaces. *yc
Bulletin:
9833
Component:
162000 structure:body
Summary:
Service tips for surface defect removal without repainting. *yc
Bulletin:
985A5
Component:
034530 service brakes, hydraulic:foundation components:disc:rotor
Summary:
Hub-mount brake rotor machining equipment from rotunda is now approved for warranty and service use. *yc
Bulletin:
9888
Component:
103000 power train:automatic transmission
Summary:
Information on a new transmission fluid usage chart. *yc
Bulletin:
9844
Component:
162000 structure:body
Summary:
Some difficulty in matching the texture of the oem anti-chip stone abrasion material to rpair materials when servicing. *yc
Bulletin:
9845
Component:
045300 service brakes, air:disc:rotor
Summary:
Availability of hub-mount brake rotor machining equipment. *yc
Bulletin:
98412
Component:
103000 power train:automatic transmission
Summary:
The 4r70w transmission installed in some vehicles will have an orange
Bulletin:
9852
Component:
190000 tires
Summary:
Information on tire company telephone numbers for customer assistance. *yc
Bulletin:
9864
Component:
063000 engine and engine cooling:exhaust system
Summary:
Information on a buzzing or rattle noise from the exhaust system. *tt
Bulletin:
9873
Component:
353400 equipment:electrical:radio/tape deck/cd etc.
Summary:
Experiencing a whining / buzzing noise in the speakers of the entertainment radio or two-way radio. *tt
Bulletin:
9874
Component:
061000 engine and engine cooling:engine
Summary:
A new silicone gasket and sealant. *yc
Bulletin:
982522
Component:
162300 structure:body:door
Summary:
Concerns of broken blend doors on some vehicles. *yc
Bulletin:
982543
Component:
036000 service brakes, hydraulic:antilock
Summary:
Some vehicles with anti lock brakes may exhibit customer concerns of a momentary buzz type noise from the left side of the engine compartment. this could be caused by abs brake system self testing. *ak
Bulletin:
982547
Component:
134000 visibility:sun roof assembly
Summary:
Some vehicles with the sun roof options may experience loose headliner attachments. *yc
Bulletin:
982676
Component:
063000 engine and engine cooling:exhaust system
Summary:
Some vehicles may exhibit a customer concern of loud ping / crackle from exhaust system during cool down. *yc
Bulletin:
982743
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Some vehicles may exhibit an intermittent stall at stops. *yc
Bulletin:
98258
Component:
010000 steering
Summary:
A vibration / noise felt in steering wheel on right turns.
Bulletin:
98259
Component:
980000 unknown or other
Summary:
Some vinyl covered items such as dash panels, door trim panels, consoles, etc., may exhibit a small dent, scuff, abrasion and/ or discoloration resulting from assembly, transit, dealer prep and/or customer usage. *yc
Bulletin:
98219
Component:
022140 suspension:rear:springs:leaf spring assembly
Summary:
The rear air springs may dislodge limousine vehicles. *yc
Bulletin:
98203
Component:
162000 structure:body
Summary:
Concerns with adhensives not recommended for body panel repairs. *yc
Bulletin:
982010
Component:
063000 engine and engine cooling:exhaust system
Summary:
Experiencing a " buzzing " or " rattling " noise from the exhaust system. *yc
Bulletin:
982310
Component:
063100 engine and engine cooling:exhaust system:emission control
Summary:
Mass air flow (maf)- sensor contamination- service tip. *ak
Bulletin:
982312
Component:
103000 power train:automatic transmission
Summary:
Issues regareding diagnostic trouble codes ( dtcs ) p0705, p0708, p1704, and / or p1705 may be stored in memory. *yc
Bulletin:
982323
Component:
162000 structure:body
Summary:
Information regarding replacement and / or repairs on any lock component. *yc
Bulletin:
98241
Component:
012200 steering:column locking:anti-theft device
Summary:
Diagnostic service tips on passive anti theft system ( pats ). *yc
Bulletin:
98203
Component:
160000 structure
Summary:
Concerns with the potential effects of adhesives used for body panel repairs. *tt
Bulletin:
98219
Component:
022132 suspension:rear:springs:air suspension system:springs/bags
Summary:
Dislodgment of rear air spring from axle spring seat during acceleration or full suspension travel conditions on some limousine vehicles that are operated at or near maximum loads. *ak
Bulletin:
9943
Component:
100000 power train
Summary:
Information regarding reprogramming powertrain control modules (pcms). *tt
Bulletin:
9947
Component:
061000 engine and engine cooling:engine
Summary:
Engine experiencing roughness at idle due to exhaust system resonance. *tt
Bulletin:
5896
Component:
114200 electrical system:wiring:interior/under dash
Summary:
Information pertaining to cluster concerns. *tt
Bulletin:
12579
Component:
133000 visibility:power window devices and controls
Summary:
Information regarding drivers door modules (ddm) incorrectly replaced when diagnosing passive anti-theft system (pats) / battery related no start conditions. *tt
Bulletin:
12609
Component:
110000 electrical system
Summary:
Information regarding pinpint test / 4wabs diagnostic trouble code b1676 (battery voltage) - update. *tt
Bulletin:
12615
Component:
071100 fuel system, gasoline:storage:tank assembly
Summary:
Subject regarding fuel tank clunk. *tt
Bulletin:
9814
Component:
034530 service brakes, hydraulic:foundation components:disc:rotor
Summary:
Subject regarding the availability of hub-mount brake rotor machining equipment. *tt
Bulletin:
9818
Component:
072100 fuel system, gasoline:delivery:fuel pump
Summary:
Fuel pump replacement procedure - service tip. *tt
Bulletin:
98110
Component:
116300 electrical system:ignition:anti-theft controller
Summary:
Subject regarding passive anti theft system (pats) diagnostic service tips. *tt
Bulletin:
976011
Component:
070000 fuel system, gasoline
Summary:
Experiencing difficulty diagnosing vehicles with evaporative fuel system diagnostic trouble codes. *tt
Bulletin:
976011
Component:
133000 visibility:power window devices and controls
Summary:
Subject regarding function test changes on service bay diagnostic system (sbds). *tt
Bulletin:
99B09
Component:
022000 suspension:rear
Summary:
Vehicles may develop cosmetic cracks in the frame of the rear upper control arm access opening. *tt
Bulletin:
99816
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Ford motor company now recommends sae 5w-30 viscosity grade for servicing any ford gasoline-powered vehicle regardless of model year. *tt
Bulletin:
9996
Component:
103000 power train:automatic transmission
Summary:
Experiencing a delayed or no 2-3 upshift, primarily when the transmission is cold on vehicles with ford qality remanufactured (fqr) 4r70w transmission exchange units with julian build between 062-97 and 040-99. *tt
Bulletin:
99129
Component:
353400 equipment:electrical:radio/tape deck/cd etc.
Summary:
Experiencing a whine / buzz type noise in the speakers of the entertainment radio or two-way radio on vehicles with an in-tank electric fuel pump. *tt
Bulletin:
99139
Component:
125000 exterior lighting:brake lights
Summary:
Conditions with the brake lamps inadvertently disabling the brake shift interlock. *tt
Bulletin:
6400
Component:
353600 equipment:air conditioner
Summary:
Vehicles may dispense hot air from side demister ducts in all climate control operating modes. *tt
Bulletin:
996078
Component:
162700 structure:body:trunk lid
Summary:
Subject pertaining to inoperative trunk release. *tt
Bulletin:
98-4828
Component:
353400 equipment:electrical:radio/tape deck/cd etc.
Summary:
Subject pertaining to the service manual not having a pinpoint test for "degraded am reception or continuous seek in am" in the diagnosis and testing portion of the audio chapter. *tt
Bulletin:
983083
Component:
353400 equipment:electrical:radio/tape deck/cd etc.
Summary:
Information pertaining to the 6 disc magazine for the cd player. *tt
Bulletin:
983210
Component:
138000 visibility:defroster/defogger system
Summary:
Information regarding defog/defrost ehnahcements. *tt
Bulletin:
983291
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Experiencing a high pitched whistle noise from the engine compartment at idle. *tt
Bulletin:
983566
Component:
116300 electrical system:ignition:anti-theft controller
Summary:
Information regarding programming / diagnosing passive anti-theft system (pats) related issues. *tt
Bulletin:
9811334
Component:
355100 equipment:other:labels
Summary:
Information pertaining to the premium fuel recommended label. *tt
Bulletin:
9811351
Component:
103000 power train:automatic transmission
Summary:
Some vehicles with 4r70w transmission may have a harsh reverse engagement. *tt
Bulletin:
983566
Component:
116300 electrical system:ignition:anti-theft controller
Summary:
Information on programming / diagnosing any passive anti-theft system (pats) related issues. *tt
Bulletin:
9811256
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Experiencing a high pitched whistle noise from engine compartmant at idle. *tt
Bulletin:
996748
Component:
980000 unknown or other
Summary:
Some vehicles may exhibit the following concerns immediately after starting the vehicle: the speedometer will not display vehicle speed, the odometer display is all dashes, the message center display for distance to empty or average spe
Bulletin:
996785
Component:
353000 equipment:electrical
Summary:
Vehicles equipped with a cellular phone may exhibit a condition in which the cellular phone does not ring when receiving incoming calls. *tt
Bulletin:
996799
Component:
353600 equipment:air conditioner
Summary:
Concerns with vehicles built from job #1 through 4/1/1999 exhibiting poor a/c performance and / or a pop / click noise in mas a/c. *tt
Bulletin:
99219
Component:
017000 steering:linkages
Summary:
This bulletin mentions that the workshop manuals do not contain a procedure for inspecting the pitman arm ball joint for wear. *tt
Bulletin:
992110
Component:
162300 structure:body:door
Summary:
Information on both front doors not staying open. *tt
Bulletin:
99222
Component:
114000 electrical system:wiring
Summary:
Subject on a wire harness terminal repair kit available for repairing electrical wiring harnesses. *tt
Bulletin:
99185
Component:
980000 unknown or other
Summary:
Vehicles built between 3/15/1997 and 12/31/1998 and with 4r70w transmissions may experience delayed or no 2-3 upshift, transmission control indicator lamp illuminated with diagnostic trouble code p0782 stored in memory. *tt
Bulletin:
99194
Component:
034000 service brakes, hydraulic:foundation components
Summary:
Information for servicing and diagnosing brake vibration, brake inspection, and brake friction material replacement. *tt
Bulletin:
99195
Component:
353600 equipment:air conditioner
Summary:
Service information for musty and mildew type odors coming from the air conditioning / heating system. *tt
Bulletin:
99196
Component:
353600 equipment:air conditioner
Summary:
Information on identifying non-approved / alternate refrigerants which could cause safety, and performance concerns if installed in ford a/c systems. *tt
Bulletin:
99234
Component:
980000 unknown or other
Summary:
Information on diagnosing a vehicle with malfunction indicator lamp illuminated and diagnostic trouble codes p0442 and p0455 stored in continuous memory. *tt
Bulletin:
992310
Component:
353600 equipment:air conditioner
Summary:
Vehicles built through 4/16/1998 may exhibit improper, erratic, or no temperature control or poor a/c performance and / or a popping / clicking noise in max a/c on vehicles built thorugh 4/1/1999. *tt
Bulletin:
99242
Component:
162300 structure:body:door
Summary:
Information on replacing and / or repairing malfunctioning (door, ignition and decklid) locks. *tt
Bulletin:
99247
Component:
134000 visibility:sun roof assembly
Summary:
Some vehicles equipped with factory moonroofs and built through 9/20/1999 may experience a booming noise while driving with the moonroof open. *tt
Bulletin:
7249
Component:
353600 equipment:air conditioner
Summary:
Information on using peanut style a/c fittings. *tt
Bulletin:
98163
Component:
162300 structure:body:door
Summary:
Locks failed. yd
Bulletin:
7307
Component:
034000 service brakes, hydraulic:foundation components
Summary:
A condition may exist of a squeal / squeak from the front brakes. *tt
Bulletin:
7312
Component:
134000 visibility:sun roof assembly
Summary:
Some vehicles equipped with factory installed moonroof may exhibit a booming or buffeting noise while traveling at speeds greater than 40 mph when the moonroof is open. *tt
Bulletin:
13330
Component:
353600 equipment:air conditioner
Summary:
Subject regarding hot air from side demister ducts. *tt
Bulletin:
98164
Component:
162000 structure:body
Summary:
A transeal coating is on the front and rear bumpers. this coating must be removed before delivery to the customer. yd
Bulletin:
13025
Component:
063000 engine and engine cooling:exhaust system
Summary:
Some vehicles may exhibit a bang popping noise heard from the exhaust system during cool-down. *tt
Bulletin:
0031
Component:
353600 equipment:air conditioner
Summary:
Vehicles may experience the a/c blower motor inoperative. *mjs
Bulletin:
8136
Component:
138200 visibility:defroster/defogger system:rear window
Summary:
Subject pertaining to heated backglass repair processes. *tt
Bulletin:
13868
Component:
138200 visibility:defroster/defogger system:rear window
Summary:
Information regarding heated backglass repair processes. *tt
Bulletin:
986001
Component:
353400 equipment:electrical:radio/tape deck/cd etc.
Summary:
Information regarding publication cd update. *ak
Bulletin:
8269
Component:
116300 electrical system:ignition:anti-theft controller
Summary:
Subject regarding passive anti-theft system (pats) installation caution: wires may break. *tt
Bulletin:
8300
Component:
063000 engine and engine cooling:exhaust system
Summary:
Some vehicles may exibit a bang popping noise heard from the exhaust system during cool-down. *tt
Bulletin:
8382
Component:
116000 electrical system:ignition
Summary:
Some vehicles may exhibit a miss, buck / jerk, surge in the ignition coil / spark plug boot. *tt
Bulletin:
0062
Component:
103100 power train:automatic transmission:control module (tcm, pcm)
Summary:
Some vehicles may exhibit idle di[ after a tip-in/tip-out maneuver, spark knock/detonation on acceleration or light load. *mjs
Bulletin:
13942
Component:
116300 electrical system:ignition:anti-theft controller
Summary:
Concerns that the passive anti-theft system (pats) transceiver wiring may be broken due to improper wire routing and / or a misplacement of the connector near the base of the steering column. *tt
Bulletin:
12068
Component:
116300 electrical system:ignition:anti-theft controller
Summary:
Vehicles will not start with a programmed passive anti-theft (pats) key for 20 seconds after an attempt to start with a non-programmed pats key. *mjs
Bulletin:
985017
Component:
021000 suspension:front
Summary:
Experiencing a grunt or squeak noise from the front suspension when turning the steering to full lock, to the left or the right. *tt
Bulletin:
985021
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Some vehicles with calibrations of 8-18j and 8-18e (all r levels) may exhibit a concern of spark knock / ping / detonation under acceleratioin at low engine speeds when the engine is at normal operating temperature. *tt
Bulletin:
12072
Component:
022130 suspension:rear:springs:air suspension system
Summary:
Vehicle may appear to sit high in the rear when the ignition is first turned on during the first 200 miles (320 km) of vehicle operation. *mjs
Bulletin:
12083
Component:
100000 power train
Summary:
Some 4.6l vehicles equipped with a 4r70w transmission, may experience a harsh reverse engagement. *mjs
Bulletin:
12120
Component:
100000 power train
Summary:
Some vehicles with 4r70w transmissions built from 4/16/98 through 10/30/98 may exhibit a leak from the vent area of the transmission. *mjs
Bulletin:
12154
Component:
116300 electrical system:ignition:anti-theft controller
Summary:
Some vehicles equipped with pats (securilock) except certain models now have availability of fleet keys through rotunda. *mjs
Bulletin:
5078
Component:
103000 power train:automatic transmission
Summary:
Some vehicles equipped with a 4r70w transmissions may experience harsh reverse engagement. *tt
Bulletin:
985090
Component:
063000 engine and engine cooling:exhaust system
Summary:
Some vehicles may exhibit a customer concern of loud ping / crackle from exhaust system during cool down. *tt
Bulletin:
12174
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Some vehicles may exhibit a hard start/long crank, cold start stall, cold rough idle concern. *mjs
Bulletin:
12178
Component:
100000 power train
Summary:
Information regarding tsb 98-5a-12 (transaxle/transmission/transfer case-vehicles towed behind recreational vehicles-recommended guidelines) does not list towing information for certain model vehicles. *mjs
Bulletin:
985096
Component:
020000 suspension
Summary:
Some vehicles may appear to sit high in the rear when the ignition is first turned on during the first 200 miles (320 km) of vehicle operation. *tt
Bulletin:
985099
Component:
090000 fuel system, other
Summary:
On some vehicles, the fuel gauges may stick at full or approximately 3/4 full. *tt
Bulletin:
985107
Component:
116300 electrical system:ignition:anti-theft controller
Summary:
Certain vehicles will not start with a programmed passive anti-theft (pats) key for 20 seconds after an attempt to start with a non-programmed pats key. *tt
Bulletin:
985143
Component:
102000 power train:manual transmission
Summary:
Some vehicles with 4r70w transmissions built from 4/16/98 through the end of the 1998 model year may exhibit a leak from the vent area of the transmission. *tt
Bulletin:
9811480
Component:
353600 equipment:air conditioner
Summary:
Climate control is investigating concerns of broken blend doors on some vehicles. *tt
Bulletin:
11482
Component:
103000 power train:automatic transmission
Summary:
For certain model vehicles, the 4r70w transmission solenoid molded leadframe must be replaced when removed. *tt
Bulletin:
8269
Component:
012200 steering:column locking:anti-theft device
Summary:
Information regarding passive anti-theft system (pats) transceiver wiring may be broken due to improper wire routing and / or a misplacement of the connector near the base of the steering column. **mr
Bulletin:
8300
Component:
063000 engine and engine cooling:exhaust system
Summary:
Some vehicles may exhibit a bang / popping noise heard from the exhaust system during cool-down. **mr
Bulletin:
11530
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
When diagnosing crank / no start on certain vehicles equipped with passive anti-theft (pats) check the customers key ring for any magnetic objects like the mobile speedpass key which may affect the signal transmission between the pats key a
Bulletin:
14181
Component:
071100 fuel system, gasoline:storage:tank assembly
Summary:
Concerns with fuel tank thump. *tt
Bulletin:
99-6193
Component:
116300 electrical system:ignition:anti-theft controller
Summary:
Information on resetting the passive anti-theft system (pats). *tt
Bulletin:
6218
Component:
022000 suspension:rear
Summary:
Conditions with cosmetic cracks in the frame at the rear upper control arm access opening. *tt
Bulletin:
6329
Component:
138000 visibility:defroster/defogger system
Summary:
This bulletin addresses two design changes made to enhance the windshield and side window defog / defrost performance. *tt
Bulletin:
12743
Component:
980000 unknown or other
Summary:
Exhibiting malfunction indicator lamp (mil) with diagnostic trouble codes (dtc(s) po351 and / or p0356 (coil primary circuit malfunction). *tt
Bulletin:
6728
Component:
063000 engine and engine cooling:exhaust system
Summary:
Some vehicles may exhibit a bang popping noise heard from the exhaust system during cool-down. *tt
Bulletin:
6035
Component:
036000 service brakes, hydraulic:antilock
Summary:
Some vehicles equipped with teves four wheel anti-lock brakes (4wabs) may exhibit a yellow anti-lock brake lamp illuminated with no diagnostic trouble codes in memory. *tt
Bulletin:
12704
Component:
103100 power train:automatic transmission:control module (tcm, pcm)
Summary:
Subject regarding all vehicles requires a parameter reset to be performed on the passive anti-theft system module (pats / vic / hec) when the powertrain control module (pcm) is replaced. *tt
Bulletin:
12714
Component:
161000 structure:frame and members
Summary:
Some vehicles may develop cosmetic cracks in the frame at the rear upper control arm access opening when operated under severe duty conditions. *tt
Bulletin:
12557
Component:
114200 electrical system:wiring:interior/under dash
Summary:
Some vehicles may exhibit various cluster concerns such as illumination of the check traction assist lamp, speedometer reads o; digital odometer reads all dashes; message center display for dte / gte reads for loss of speed single to the he
Bulletin:
13031
Component:
103100 power train:automatic transmission:control module (tcm, pcm)
Summary:
Subject regarding junt-in-time pcm reprogram. *tt
Bulletin:
13057
Component:
353000 equipment:electrical
Summary:
Concerns with cellular phones not ringing when receiving calls. *tt
Bulletin:
13065
Component:
353600 equipment:air conditioner
Summary:
Some vehicles may exhibit poor a/c performance and / or a pop / click noise in max a/c. *tt
Bulletin:
12816
Component:
353600 equipment:air conditioner
Summary:
Concerns with hot air from side demister ducts. *tt
Bulletin:
7194
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Subject regarding ford quality renewal (fqr) assembly launch of 4.6l 2v engine. *tt
Bulletin:
13355
Component:
353600 equipment:air conditioner
Summary:
Information regarding a/c peanut o-ring color. *tt
Bulletin:
13382
Component:
034000 service brakes, hydraulic:foundation components
Summary:
Some vehicles may exhibit a squeal / squeak from the front brakes during light brake applications. *tt
Bulletin:
13400
Component:
134000 visibility:sun roof assembly
Summary:
Some cars equipped with factory installed moonroof may exhibit a booming or buffeting noise while traveling at speeds greater than 40 mph when the moonroof is open. *tt
Bulletin:
4619
Component:
980000 unknown or other
Summary:
Some vehicles may exhibit malfunction indicator light on with evaporative diagnostic trouble codes p0442, p0455 set. *tt
Bulletin:
4656
Component:
063000 engine and engine cooling:exhaust system
Summary:
Some vehicles may exhibit a rattle noise from exhaust system nvh damper on the left hand damper only. *tt
Bulletin:
99-8-15
Component:
162300 structure:body:door
Summary:
Subject regarding door trim panel replacement - service tip. *tt
Bulletin:
99111
Component:
980000 unknown or other
Summary:
Information designed to aid in the diagnosis, testing and repair of noise, vibration and harshness (nvh) concerns. *tt
Bulletin:
991210
Component:
980000 unknown or other
Summary:
Ford motor company has released a private labeled material to be used for iron particle / acid rain service repairs. *tt
Bulletin:
99152
Component:
103000 power train:automatic transmission
Summary:
Information on the new flush and fill tool available through rotunda. *tt
Bulletin:
4708
Component:
114200 electrical system:wiring:interior/under dash
Summary:
Some vehicles may have a concern of intermittent instrument cluster gauges inoperative. *tt
Bulletin:
4715
Component:
063000 engine and engine cooling:exhaust system
Summary:
Some vehicles may exhibit a customer concern of loud ping / crackle from the exhaust system during cool down. *tt
Bulletin:
11754
Component:
980000 unknown or other
Summary:
Information correcting the workshop manual volume ii, which is in error for auto lamp concerns. *tt
Bulletin:
11774
Component:
063000 engine and engine cooling:exhaust system
Summary:
Some vehicles may exhibit a rattle noise from the exhaust system nvh damper on the left hand damper only. *tt
Bulletin:
11816
Component:
980000 unknown or other
Summary:
Some vehicles may have a concern of intermittent instrument cluster gauges inoperative. *tt
Bulletin:
5107
Component:
980000 unknown or other
Summary:
Some vehicles will not start with a programmed passive anti-theft (pats) key for 20 seconds after an attempt to start with a non-programmed pats key. the pats will not recognize a programmed pats key until the system resets. *t
Bulletin:
5203
Component:
185000 vehicle speed control:cruise control
Summary:
Some vehicles may exhibit a hard start / long crank, cold start stall, cold rough idle concern. *tt
Bulletin:
12219
Component:
120000 exterior lighting
Summary:
For all vehicles with lighting control module concerns that require a module replacement, the technican must call for approval before removing and / or replacing the module. *tt
Bulletin:
12223
Component:
162300 structure:body:door
Summary:
For all vehicles with drivers door module concerns that require a module replacement, the technician must call for approval before removing and / or replacing. *tt
Bulletin:
12224
Component:
221600 seats:front assembly:power adjust
Summary:
For all vehicles with drivers seat module concerns that require a module replacement, the technician must call for approval before removing and / or replacing the module. *tt
Bulletin:
12226
Component:
980000 unknown or other
Summary:
For all vehicles with remote keyless entry concerns that require a module and / or transmitter (keyfob) replacement, the technician must call for approval before removing and / or replacing the module or keyfob. *tt
Bulletin:
12230
Component:
036000 service brakes, hydraulic:antilock
Summary:
All vehicles with antilock brake module concerns that require a module replacement, the technician must call for approval before removing and / or replacing the module. *tt
Bulletin:
12232
Component:
133000 visibility:power window devices and controls
Summary:
Information used when servicing power door lock or power window issues. *tt
Bulletin:
12298
Component:
103000 power train:automatic transmission
Summary:
Some vehicles equipped with 4r70w transmissions may exhibit delayed or no 2-3 upshift, primarily when the transmission is cold. transmission control indicator light (tcil) may also flash with diagnostic trouble code p0782. *tt
Bulletin:
090308
Component:
980000 unknown or other
Summary:
Mil light on with evaporative dtc p0442, p0455
Bulletin:
002310
Component:
103600 power train:automatic transmission:cooling unit and lines
Summary:
Subject regarding contamination from prior transmission concerns or excess wear may be trapped in the transmission fluid cooling system. *tt
Bulletin:
00E11
Component:
350000 equipment
Summary:
Service action bulletin regarding on-board diagnostic system upgrade. *tt
Bulletin:
00B60
Component:
020000 suspension
Summary:
On some vehicles the rear suspension upper control arm brackets on the frame may develop minor cracks when subjected to severe duty service. *jb
Bulletin:
99B09
Component:
020000 suspension
Summary:
Subject pertaining to cosmetic cracks in frame at the rear upper control arm access opening when subjected to severe duty operating conditions. *jb
Bulletin:
0111
Component:
061000 engine and engine cooling:engine
Summary:
On some vehicles, the engine mounts may not exhibit satisfactory durability under severe operating conditions that may be encountered by police, taxi or limo / livery vehicles such as extended idling at high ambient temperatures. *
Bulletin:
00213
Component:
353600 equipment:air conditioner
Summary:
Subject regarding climate control - eatc - blower motor control service tips. *jb
Bulletin:
00214
Component:
061000 engine and engine cooling:engine
Summary:
Information regarding revised engine mounts for severe duty vehicles. *jb
Bulletin:
00E11
Component:
103100 power train:automatic transmission:control module (tcm, pcm)
Summary:
Service action 00e11, supplement #1 - update information regarding on-board diagnostic system upgrade. *tt
Bulletin:
99B09
Component:
161000 structure:frame and members
Summary:
Owner notification program 99b09 supplement #2 for certain commercial vehicle frame service. *tt
Bulletin:
0162
Component:
116300 electrical system:ignition:anti-theft controller
Summary:
Vehicles equipped with passive anti-theft system (pats) may not start or crank. *tt
Bulletin:
14862
Component:
071100 fuel system, gasoline:storage:tank assembly
Summary:
Information on replacing fuel tank strap bolts. *tt
Bulletin:
14821
Component:
061000 engine and engine cooling:engine
Summary:
Some vehicles equipped with 4.6l romeo engine may exhibit an oil leak from the cylinder head gasket area. *tt
Bulletin:
14844
Component:
110000 electrical system
Summary:
Some vehicles may exhibit various intermittent / constant electrical system conditions. *tt
Bulletin:
14864
Component:
061000 engine and engine cooling:engine
Summary:
Subject regarding certain vehicles with 4.6l romeo engines exhibiting an oil leak from the cylinder head gasket area. *tt
Bulletin:
0147
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Subject regarding engine oil recommendations for use in 2001 vehicles - sae 5w-20 motor oil. *tt
Bulletin:
01M02
Component:
075000 fuel system, gasoline:carburetor system
Summary:
Owner notification program regarding additional coverage on certain 4.6l sohc intake manifolds. some of the composite intake manifolds may develop fatigue cracks at the coolant crossover duct. *tt
Bulletin:
01M02
Component:
075000 fuel system, gasoline:carburetor system
Summary:
Some of the composite intake manifolds used on 4.6l sohc engines may develop fatigue cracks at the coolant crossover duct. this condition could result in engine coolant leakage which, if not serviced, may cause engine overheating. compl
Bulletin:
14918
Component:
103100 power train:automatic transmission:control module (tcm, pcm)
Summary:
This bulletin states that on some vehicles (including 2002 blackwood) a battery disconnect or parameter reset is required during powertrain control module (pcm) or instrument cluster (vic / hec / icm) replacement. *tt
Bulletin:
14181
Component:
061000 engine and engine cooling:engine
Summary:
Vehicles built up to december of 1999 may exhibit a clunk noise from the rear of the vehicle when driving over speed bumps. this may be caused by the fill-limiting valve inside the fuel tank. *tt
Bulletin:
01156
Component:
138120 visibility:defroster/defogger system:windshield:heater core
Summary:
Some vehicles may exhibit heater core leaks. *slc
Bulletin:
01157
Component:
980000 unknown or other
Summary:
Information regarding transmission fluid usage charts. *slc
Bulletin:
15158
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Some vehicles may exhibit a fead belt jump-off toss. *yh
Bulletin:
01181
Component:
103800 power train:automatic transmission:park/neutral start switch
Summary:
Brake shift interlock.*jb
Bulletin:
012110
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Some vehicles equipped with the romeo built 4.6l 2v engine may exhibit an engine oil leak or oil weepage from the cylinder head gasket at the right hand rear or the left hand front of the engine. *tt
Bulletin:
012113
Component:
116100 electrical system:ignition:switch
Summary:
Some ignition switch lock cylinder assemblies may exhibit rougness and / or excess effort in turning, key does not fully return from start, a malfunction indicator lamp may illuminate with p0500, p1502 and u1039 stored in powertrian control
Bulletin:
012114
Component:
071100 fuel system, gasoline:storage:tank assembly
Summary:
Parts and procedure to reduce the potential of fuel tank punctures during rare and extremely high-speed rear impacts. *tt
Bulletin:
01205
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Some vehicles may exhibit vacuum or air leaks in the intake manifold and / or engine system causing diagnostic trouble codes p0171 and or p0174. *tt
Bulletin:
0214
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Some engine assemblies with aluminum cylinder heads repaired in-vehile have been found to leak coolant and/or oil from the cylinder head gasket area. *tt
Bulletin:
12120
Component:
100000 power train
Summary:
Some vehicles with 4r700 transmissions built from 4/16/98 through the end of the 1998 model year may exhibit a leak from the vent area of the transmission. *tt
Bulletin:
01246
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Engine oil system priming procedures, service tips for reports of premature engine failure. *tt
Bulletin:
0222
Component:
060000 engine and engine cooling
Summary:
Some vehicles may exhibit an intake manifold crossover (first runner) coolant seepage condition. *tt
Bulletin:
02136
Component:
103800 power train:automatic transmission:park/neutral start switch
Summary:
On some vehicles, the brake shift interlock may be inoperative, now allowing the operator to move the shift lever from the park position. stop lamp operation may also be affected. *tt
Bulletin:
0245
Component:
111000 electrical system:battery
Summary:
Information regarding discharged battery charging service tips and guidelines. *tt
Bulletin:
15889
Component:
353600 equipment:air conditioner
Summary:
Some vehicles equipped with the electronic automatic temperature control (eatc) will not cycle the ai conditioner compressor when the floor mode is selected. *tt
Bulletin:
0398
Component:
090000 fuel system, other
Summary:
Malfunction indicator lamp (mil) illumination with diagnostic trouble codes p0442, p0455, p0456, p0457, p1442 or check fuel cap lamp illuminated with diagnostic trouble code p0457. *tt
Bulletin:
03181
Component:
110000 electrical system
Summary:
Remote keyless entry (rke) - service tips. *tt
Bulletin:
03203
Component:
110000 electrical system
Summary:
Malfunction indicator lamp illuminated with diagnostic trouble codes (dtcs) p0442, p0455, p0456, p0457 or p1442 or a check fuel cap lamp illuminated with dtc p0457 for the evaporative emission system. *tt
Bulletin:
17730
Component:
110000 electrical system
Summary:
Dashes displayed instead of an odometer reading - no communication with the anti-lock brake system (abs) module. *tt
Bulletin:
17871
Component:
116000 electrical system:ignition
Summary:
Multiple driveability concerns under acceleration caused by ignition coil. *tt
Bulletin:
03261
Component:
103000 power train:automatic transmission
Summary:
New service part - number 5 needle bearing and race kit - 4r70w transmission - service tip. *tt
Bulletin:
17810
Component:
103000 power train:automatic transmission
Summary:
Transmission failure where there is a large amount of metal or debris in the pan. *tt
Bulletin:
17828
Component:
110000 electrical system
Summary:
Various intermittent/constant electrical concerns. *tt
Bulletin:
02208
Component:
353600 equipment:air conditioner
Summary:
Climate control a/c service tech tips. *eh
Bulletin:
04217
Component:
103100 power train:automatic transmission:control module (tcm, pcm)
Summary:
General power train control module (pcm) programming procedures. *tt
Bulletin:
042107
Component:
103100 power train:automatic transmission:control module (tcm, pcm)
Summary:
General (pcm) power train control module programming procedures. *tt
Bulletin:
0531
Component:
162000 structure:body
Summary:
Customer satisfaction program 05b31 - information only. a possibility that during a high speed / high energy rear collision, certain components have an increased risk of puncturing the fuel tank on vehicles with limo prep package limo pack
Bulletin:
041601
Component:
060000 engine and engine cooling
Summary:
Wds cop kit diagnostic tip - coil on plug (cop) ignition systems - engine misfire or rough running. *tt
Bulletin:
05N04
Component:
063200 engine and engine cooling:exhaust system:manifold/header/muffler/tail pipe
Summary:
Extended coverage program 05n04 - extended coverage for composite intake manifold. this program is being provided as a settlement to a class action lawsuit. the terms of the settlement extend the coverage of the all-composite intake manif
Bulletin:
07212
Component:
061000 engine and engine cooling:engine
Summary:
Some 1997-2008 vehicles equipped with a 4.6l 2v, 5.4l 2v, or 6.8l 2v engine--spark plug thread repair procedure--not covered under new vehicle limited warranty. *nj this includes f-53 motorhome chassis. updated 2/23/10. *pe
Bulletin:
CSP 08B04
Component:
071100 fuel system, gasoline:storage:tank assembly
Summary:
Ford/lincoln mercury: certain 1992-2001 model year crown victoria, grand marquis, and town car vehicles registered in the states of wisconsin and connecticut upgrade modifications for high speed rear impacts. *pe

Home | Privacy