1998 JEEP WRANGLER Recalls (6)
- Campaign:
- 98V023000 on 02/09/1998
- Component:
- Service brakes, hydraulic:power assist:vacuum
- Manufactured:
- 10/24/1997 - 11/09/1997
- Affected:
- 8,900
- Defect:
- Vehicle description: multi-purpose passenger vehicles. the power brake booster vacuum reservoir diaphragm can split or tear.
- Consequence:
- This can cause an increase in engine idle speed and a loss of power assist during brake application without prior warning.
- Correction:
- Dealers will inspect the brake booster date code and any boosters with the suspect manufacturing date range will be replaced.
- Notes:
- Owner notification began march 25, 1998. owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact chrysler at 1-800-992-1997.also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
- Campaign:
- 98V048000 on 03/18/1998
- Component:
- Seat belts:front:anchorage
- Manufactured:
- 01/11/1998 - 01/15/1998
- Affected:
- 2,427
- Defect:
- Vehicle description: multi-purpose passenger vehicle. the front seat belt shoulder turning loop anchors were not properly heat treated and are not properly hardened.
- Consequence:
- In the event of a vehicle crash, the front seat occupant may not be properly restrained increasing the risk of serious injury.
- Correction:
- Dealers will replace the front seat shoulder belt turning loop on these vehicles.
- Notes:
- Owner notification began april 6, 1998. owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact chrysler at 1-800-992-1997.also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
- Campaign:
- 04E041000 on 06/07/2004
- Component:
- Equipment
- Affected:
- 80
- Defect:
- Bestop aftermarket rear shell roof racks,manufactured between april 27 and may 20, 2004, designed for use with the bestop hardtop made for the 1986-1995 and 1997-2003 jeep wrangler. the cockpit cover may not stay latched to the roof rack because the latch bracket mispositions the rotary latch to the cockpit cover. as a result, the cockpit cover may not stay latched to the roof rack and could separate from the roof rack. this recall only pertains to aftermarket rear shell roof racks and has no relation to any original equipment installed on jeep wrangler vehicles by daimlerchrysler.
- Consequence:
- Should this occur, the cockpit could cause injury by striking persons outside the vehicle or could become a distraction or an obstacle to other drivers, possibly resulting in a vehicle crash.
- Correction:
- Bestop will notify its customers and provide a repair kit and installation instructions free of charge. owner notification began june 16, 2004. owners who do not receive the free remedy within a reasonable time should contact bestop customer service department at (800) 845-3567.
- Notes:
- Also, customers can contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
- Campaign:
- 06E011000 on 01/31/2006
- Component:
- Fuel system, gasoline:delivery:fuel pump
- Affected:
- 7,291
- Defect:
- Certain aftermarket airtex electric fuel pumps installed for use as replacement equipment for certain 1997-2004 jeep wrangler; 1997-2001 jeep cherokee; 1997-2004 jeep grand cherokee; and 2000-2003 dodge dakota vehicles. the plastic electrical grommet connectors at the top of the fuel pump module are not compatible with automotive fuels and may degrade causing a potential leak path for fuel.
- Consequence:
- In the presence of an ignition source, a fuel leak could result in a fire.
- Correction:
- Airtex will notify its customers and will replace the affected fuel pumps free of charge. the recall began on january 25, 2006. owners may contact airtex customer service department at 1-800-880-3056.
- Notes:
- This recall only pertains to aftermarket airtex electric fuel pumps and has no relation to any original equipment installed on jeep grand cherokee, cherokee, wrangler, or dodge dakota vehicles manufactured by daimlerchrysler.customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov.
- Campaign:
- 06E022000 on 03/12/2006
- Component:
- Service brakes, hydraulic
- Affected:
- 7,440
- Defect:
- Certain aftermarket brake hydraulic master cylinders sold as replacement brake cylinders for certain ford, daimlerchrysler, and jeep passenger vehicles. these brake cylinders were sold under the brand names of napa, raybestos, aimco, ac delco, carquest, bendix, and wagner. only products that were manufactured from july 27, 2005 through january 17, 2006 (date codes 0529 through 0602) are subject to this recall. when subject to very cold temperatures, an internal seal in the master cylinder could lose flexibility and may cause brake fluid to leak.
- Consequence:
- Loss of brake fluid can lead to a decrease in brake line pressure and an increase in stopping distance, which can result in a vehicle crash.
- Correction:
- Affinia (brake parts, inc.) will replace the subject brake hydraulic master cylinders free of charge. the recall began on march 20, 2006. owners can contact affina group customer service at 1-800-323-0354.
- Notes:
- This recall only pertains to aftermarket napa, raybestos, ac delco, aimco, carquest, and bendix brake hydraulic master cylinders and has no relation to any original equipment installed on daimlerchrysler or ford vehicles.customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov.
- Campaign:
- 06E026000 on 03/22/2006
- Component:
- Exterior lighting
- Affected:
- 61,944
- Defect:
- Certain pro-a motors corner lamps, turn signals, and headlights sold as replacement lamps for use on certain passenger vehicles listed above. some combination lamps that are not equipped with amber side reflectors fail to conform to federal motor vehicle safety standard no. 108, lamps, reflective devices, and associated equipment.
- Consequence:
- Without the amber reflectors, the vehicle will be poorly illuminated, possibly resulting in a vehicle crash without warning.
- Correction:
- Pro-a motors will notify owners and offer to repurchase the lamps. the recall began on april 3, 2006. owners may contact pro-a motors at 323-838-2988.
- Notes:
- This recall only pertains to pro-a motors aftermarket lamps and has no relation to any original equipment installed on the listed passenger vehicles.for more information on the lamp model numbers, click on document search and view document titled "lamp model numbers."customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov.
1998 JEEP WRANGLER TSBs (63)
- Bulletin:
- 980130183197
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Subject pertaining to obd ii misfire monitor. *yc
- Bulletin:
- 970919083297
- Component:
- 140000 air bags
- Summary:
- Authorized airbag deactivation for medical necessity. *yc
- Bulletin:
- 9807
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Some vehicles have incorrect dipstick installation. *yc
- Bulletin:
- 240398
- Component:
- 034530 service brakes, hydraulic:foundation components:disc:rotor
- Summary:
- A squeaking noise may be present when the system mode is changed from floor to panel heating.*ak
- Bulletin:
- 980320240398
- Component:
- 138000 visibility:defroster/defogger system
- Summary:
- A squeaking noise may be heard when the system mode is changed from floor to panel or defrost. *yc
- Bulletin:
- 230998
- Component:
- 022000 suspension:rear
- Summary:
- A rattling or knocking noise may be present when driving over rough roads, noise was coming from rear of vehicle. *ak
- Bulletin:
- 182298
- Component:
- 120000 exterior lighting
- Summary:
- Information on the obd ii misfire montior. *yc
- Bulletin:
- 182198
- Component:
- 116200 electrical system:ignition:module
- Summary:
- Service caution on powertrain control module ( pcm ). *yc
- Bulletin:
- 232198
- Component:
- 220000 seats
- Summary:
- A squeaking noise heard in the front seat. *yc
- Bulletin:
- 08298
- Component:
- 114200 electrical system:wiring:interior/under dash
- Summary:
- Erratic instrument panel cluster operation / intermittent air bag warning light. *yc
- Bulletin:
- 050398
- Component:
- 034530 service brakes, hydraulic:foundation components:disc:rotor
- Summary:
- Exhibiting minor brake pedal pulstion which may be caused by rough disc rotors. *ak
- Bulletin:
- 182898
- Component:
- 063000 engine and engine cooling:exhaust system
- Summary:
- Erroneous mil with dtc $71(po441) -evap purge flow monitor failure due to inappropriate fuel level readings during the test sequence. *ak
- Bulletin:
- 233698
- Component:
- 162000 structure:body
- Summary:
- Information to assist in identifying water leak entry points by highlighting areas where leaks are likely to occur based on the experience gained during the development of the vehicle. *yc
- Bulletin:
- 083398
- Component:
- 145000 air bags:on-off switch assembly
- Summary:
- Information on passenger's air bag on/off switch which is located on forward end of floor console, and allows passenger's side air bag on/off switch to be disabled when certain child restraint devices are used in the passenger's seatin
- Bulletin:
- 030598
- Component:
- 105100 power train:driveline:universal joint
- Summary:
- A clicking noise may be present when changing from a forward gear to reverse due to poor fitting universal joint retaining straps. *ak
- Bulletin:
- 110798
- Component:
- 063000 engine and engine cooling:exhaust system
- Summary:
- The outer exhaust manifold studs may fatigue and break. *yc
- Bulletin:
- 233198
- Component:
- 162800 structure:body:hood
- Summary:
- A squeak or buzz coming from the hood of the vehicle. *yc
- Bulletin:
- 210998
- Component:
- 103400 power train:automatic transmission:lever and linkage:column shift
- Summary:
- A thumping or creaking noise may be heard coming from the transmission tunnel area on acceleration or while driving over bumpy roads. *yc
- Bulletin:
- 190498
- Component:
- 011000 steering:wheel and handle bar
- Summary:
- A squawking or scrapping noise coming from the steering column which may be confused with clock spring or steering column bearing noise. *yc
- Bulletin:
- 250298
- Component:
- 063000 engine and engine cooling:exhaust system
- Summary:
- Subject regarding i/m ( inspection maintenance ) testing - obd ii "carb" readiness monitor information. *yc
- Bulletin:
- 110798
- Component:
- 063200 engine and engine cooling:exhaust system:manifold/header/muffler/tail pipe
- Summary:
- Outer exhaust manifold studs may fatigue/break. *ak
- Bulletin:
- 081798
- Component:
- 145000 air bags:on-off switch assembly
- Summary:
- Subject regarding airbag on - off switches. *yc
- Bulletin:
- 180399
- Component:
- 980000 unknown or other
- Summary:
- Subject regarding erroneous malfunction indicator lamp illumination with diagnostic trouble code $24 (po107). *tt
- Bulletin:
- 230999
- Component:
- 162000 structure:body
- Summary:
- Subject on water leak diagnostic / repair procedures. *tt
- Bulletin:
- 080799
- Component:
- 110000 electrical system
- Summary:
- Information regarding power distribution center (pdc) service. *tt
- Bulletin:
- 180799
- Component:
- 980000 unknown or other
- Summary:
- Exhibiting erroneous malfunction indicator lamp illumination with diagnostic trouble code $a8 (p1763) governor pressure sensor volts too high. *tt
- Bulletin:
- 210899
- Component:
- 103000 power train:automatic transmission
- Summary:
- Vehicles exhibiting buzz, whining, or moaning like noise from cold transmission when reverse gear is selected. *tt
- Bulletin:
- 081599
- Component:
- 110000 electrical system
- Summary:
- Some vehicles may exhibit an erratic, intermittent cluster operation / intermittent air bag warning light. *tt
- Bulletin:
- 081499
- Component:
- 061100 engine and engine cooling:engine:gasoline
- Summary:
- Conditions with vehicle start and stall or vehicle no-start. *tt
- Bulletin:
- 181299
- Component:
- 103100 power train:automatic transmission:control module (tcm, pcm)
- Summary:
- This bulletin explains the operation and application of the leak detection pump (ldp) monitor test. *tt
- Bulletin:
- 021299
- Component:
- 021000 suspension:front
- Summary:
- This bulletin pertains to front end alignment - adjustable / offset ball joints. *tt
- Bulletin:
- 081698
- Component:
- 353400 equipment:electrical:radio/tape deck/cd etc.
- Summary:
- Information on installation of radio transmitting equipment. *ak
- Bulletin:
- 183298
- Component:
- 162000 structure:body
- Summary:
- Subject on flash programming failure recovery. *yc
- Bulletin:
- 0832097
- Component:
- 110000 electrical system
- Summary:
- Information regarding nhtsa authorized airbag deactivation for medical necessity. *nlm
- Bulletin:
- 140897
- Component:
- 070000 fuel system, gasoline
- Summary:
- Information on poor drivability with high di (drivability index) fuel. *nlm
- Bulletin:
- 241397
- Component:
- 353600 equipment:air conditioner
- Summary:
- Information on a/c refrigerant leaks. *nlm
- Bulletin:
- 183197
- Component:
- 114200 electrical system:wiring:interior/under dash
- Summary:
- Conditions on obd ii misfire monitor. *nlm
- Bulletin:
- 183697
- Component:
- 114200 electrical system:wiring:interior/under dash
- Summary:
- Concerns on incorrect fault mature time - dtc $b7 leak detection pump solenoid circuit. *nlm
- Bulletin:
- 241197
- Component:
- 353600 equipment:air conditioner
- Summary:
- Concerns with a/c evaporator odor. *nlm
- Bulletin:
- 083799
- Component:
- 145000 air bags:on-off switch assembly
- Summary:
- Daimlerchrysler corporation is now offerinb airbag on / off switches for selected vehicles. *tt
- Bulletin:
- 180100
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Subject regarding misdiagnosed leak detection pump systems with diagnostic trouble codes p1494, p0442 p0455, or p0456. *tt
- Bulletin:
- 080600
- Component:
- 114000 electrical system:wiring
- Summary:
- This bulletin provides a revised wire splice procedure and related parts. *tt
- Bulletin:
- 234199
- Component:
- 162000 structure:body
- Summary:
- Information regarding the improved door weather strip. *mjs
- Bulletin:
- 242199
- Component:
- 138000 visibility:defroster/defogger system
- Summary:
- Vehicles may experience water dripping from the bottom of the evaporator drain tube and enter the passenger compartment causing wet carpet or water on the passenger compartment floor. *mjs
- Bulletin:
- 082700
- Component:
- 140000 air bags
- Summary:
- Subject regarding non-deployed airbag handling procedures. *tt
- Bulletin:
- 0800600REV
- Component:
- 110000 electrical system
- Summary:
- Subject regarding wire splice repairs. *sb
- Bulletin:
- 0801001
- Component:
- 110000 electrical system
- Summary:
- Subject regarding airbag / clock spring service for various models including 2002 model year jeep liberty. *tt
- Bulletin:
- 1801201
- Component:
- 350000 equipment
- Summary:
- Subject regarding generic scan tool (gst), publication no. 81-170-00008 provided with this technical service bulletin to provide reference information when using generic scan tool on obdii vehicles. *tt
- Bulletin:
- 2500401
- Component:
- 063000 engine and engine cooling:exhaust system
- Summary:
- Subject regarding additional diagnostic for diagnostic trouble codes caused by an evaporative system leak. *tt
- Bulletin:
- 2100601
- Component:
- 103000 power train:automatic transmission
- Summary:
- Automatic transmission fluid usage atf+4. *tt *mj
- Bulletin:
- 2401201
- Component:
- 138000 visibility:defroster/defogger system
- Summary:
- Customers may complain that the hvac drain water leaks under passenger side carpet. *tt
- Bulletin:
- 2302501
- Component:
- 162000 structure:body
- Summary:
- Soft top zipper cleaner and lubricant - for difficult to operate window zippers. *tt
- Bulletin:
- 1802002
- Component:
- 980000 unknown or other
- Summary:
- Flash programming failure recovery. *slc
- Bulletin:
- 2100903
- Component:
- 103000 power train:automatic transmission
- Summary:
- Automatic transmission diagnostic teardown procedure. various models including the 2004 ram truck, durango, sebring convertible, cherokee, vision, neon, and voyager. *tt *sc
- Bulletin:
- 2400703
- Component:
- 353600 equipment:air conditioner
- Summary:
- Hvac drive water leaks under passenger side front carpet. *tt
- Bulletin:
- 0901004
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Dirt and debris accumulation at rear main seal. *tt
- Bulletin:
- 2300504
- Component:
- 162000 structure:body
- Summary:
- Soft top zipper cleaner and lubricant - for difficult to operate window zippers. *tt
- Bulletin:
- 0801505
- Component:
- 103100 power train:automatic transmission:control module (tcm, pcm)
- Summary:
- Powertrain control module initialization. *sc
- Bulletin:
- 2401305
- Component:
- 353600 equipment:air conditioner
- Summary:
- Air conditioning (a/c) cooling coil odor. *tt
- Bulletin:
- 2301006
- Component:
- 162000 structure:body
- Summary:
- Primary door weatherstrip water leak at a-pillar belt line. *tt
- Bulletin:
- 1900306
- Component:
- 010000 steering
- Summary:
- Steering shimmy. *tt
- Bulletin:
- 22
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Reprogram pcm and inspect catalytic converter. *kb
- Bulletin:
- 9002849
- Component:
- 160000 structure
- Summary:
- Part description: insulator on lever assy manual valve - valve body - rwd transmission issue description: the manual valve insulator, attaching rivet and instruction sheet are now available as a kit. if the insulator requires replacement
Home | Privacy