1998 FREIGHTLINER FLD Recalls (5)
- Campaign:
- 99V295000 on 10/28/1999
- Component:
- Suspension:front:hub
- Manufactured:
- 09/30/1998 - 10/17/1999
- Affected:
- 2,976
- Defect:
- Vehicle description: heavy duty trucks. the outboard bearing on the steering axle hubs can fail due to water intrusion through a hubcap vent.
- Consequence:
- This condition can result in a separation of the wheel.
- Correction:
- Dealers will remove the hubcap and inspect for water intrusion and corrosion. the hub and bearing assembly will be replaced if there is evidence of corrosion. a non-vented hubcap will be installed.
- Notes:
- Freightliner recall no. fl-246.owner notification began november 18, 1999. owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact freightliner at 1-800-547-0712. also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
- Campaign:
- 99V181002 on 01/11/2000
- Component:
- Electrical system:ignition:module
- Manufactured:
- 12/21/1998 - 07/15/1999
- Affected:
- 320
- Defect:
- Vehicle description: heavy duty trucks equipped with caterpillar engines and eaton autoshift transmissions. the engines can stall because of software problems.
- Consequence:
- Increased steering effort can occur.
- Correction:
- Caterpillar is conducting the owner notification and remedy of this recall. dealers will update these engines with software changes.
- Notes:
- Caterpillar is conducting the owner notification and remedy of this recall.owner notification is expected to begin during august 1999.owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact freightliner at 1-800-547-0712.also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
- Campaign:
- 00V232002 on 08/08/2000
- Component:
- Service brakes, air:antilock
- Manufactured:
- 02/12/1998 - 08/02/2000
- Affected:
- 35,405
- Defect:
- Vehicle description: heavy duty trucks and school bus chassis built with bendix air abs with an ec-17 1030r electronic control unit (ecu), there have been reports of unwanted abs activation at low speeds caused by 1) chafed abs wheel speed sensor wires on rotating parts or 2) a damaged component at the wheel end that generates a certain type of erratic sensor signal.
- Consequence:
- This condition could cause the abs ecu to exhaust the air at the air brake modulators for one or more of the wheels. this could result in extended braking distances and a possible crash.
- Correction:
- Dealers will replace the abs ecu.
- Notes:
- Owner notification began august 29, 2000, to school buses and emergency vehicle customers. owners of the remaining population were sent letters on september 9, 2000. owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact freightliner at 1-800-547-0712.also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
- Campaign:
- 02V077000 on 03/25/2002
- Component:
- Vehicle speed control
- Manufactured:
- 03/31/1997 - 02/27/1998
- Affected:
- 97
- Defect:
- Certain heavy duty trucks converted from sleepercabs to day cabs and equipped with a detroit diesel optimized idle system. the idle system was not completely disabled in the cab conversion process.
- Consequence:
- This can result in unintentional engine starting, increasing the risk of a crash.
- Correction:
- Dealers will completely disable the optimized idle system. owner notification began april 3, 2002. owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact freightliner at 1-800-547-0712.
- Notes:
- Also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
- Campaign:
- 03V112000 on 03/25/2003
- Component:
- Suspension:front:hub
- Manufactured:
- 07/31/1998 - 02/27/2001
- Affected:
- 5,716
- Defect:
- On certain trucks equipped with truck hub units manufactured by skf exclusively for use on arvinmeritor's ff98x series non-drive steer axles, the hub unit bearings can wear prematurely.
- Consequence:
- Seizure of the bearings can cause wheel separation or wheel end fire.
- Correction:
- Dealers will replace both front hubs. owner notification is expected to begin on or before september 20, 2003. owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact freightliner at 1-800-547-0712.
- Notes:
- Freightliner recall no. fl-407.customers can contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
1998 FREIGHTLINER FLD TSBs (2)
- Bulletin:
- 985481
- Component:
- 060000 engine and engine cooling
- Summary:
- Concerns with the high coolant temperature warning light illuminated. *tt
- Bulletin:
- SF174AB
- Component:
- 061110 engine and engine cooling:engine:gasoline:belts and associated pulleys
- Summary:
- Vehicles manufactured between may 1, 1998 and december 7, 1998 may have a quadramount tensioner incorrectly installed with a lockwasher instead of the proper flatwasher. *tt
Home | Privacy