1998 CHEVROLET LUMINA Recalls (5)

Campaign:
03V527000 on 12/17/2003
Component:
Steering:rack and pinion
Manufactured:
03/31/1997 - 10/30/1997
Affected:
750,283
Defect:
Certain passenger vehicles have lower pinion bearings in the power rack and pinion assembly in which the retainer tabs were not crimped properly. these retainers could fail and permit the ball bearings to escape.
Consequence:
If this occurs, the pinion shaft can be forced upward during left turns and back down as the steering wheel is moved back and to the right. if the pinion shaft moves further, the driver will need to exert more effort to turn the steering wheel, similar to a vehicle without power assisted steering. if the pinion shaft moves even further, the driver will require much higher effort to turn left and may not be able to turn the wheel as much as intended. with the maximum pinion shaft movement, which requires internal gear component damage, the driver can encounter high resistance to turning left, followed by unintended power assist to the right. in any of these conditions, a crash could occur.
Correction:
Dealers will install a new lower pinion bearing unless inspect of the existing bearing indicates that replacement of the gear assembly is necessary. owner notification began on february 5, 2004. owners should contact buick at 1-866-608-8080; chevrolet at 1-800-630-2438; oldsmobile at 1-800-630-6537; or pontiac at 1-800-620-7668.
Notes:
Gm recall no. 03062.customers can also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
Campaign:
07E021000 on 03/11/2007
Component:
Fuel system, other:storage:tank assembly:pressure relief devices
Affected:
742
Defect:
Certain delphi fuel pressure regulators, p/nos. fp10020-11b1, fp10026-11b1, and fp10027-11b1, sold after january 9, 2007, as aftermarket equipment for various passenger vehicles listed above. the universal pressure regulators (upr) were produced without an o'ring and retainer.
Consequence:
Fuel may leak, possibly resulting in a fire.
Correction:
Delphi will notify owners and replace the upr free of charge. the recall began on april 23, 2007. owners can contact delphi at 877-411-8770.
Notes:
This recall only pertains to aftermarket delphi fuel pressure regulators and has no relation to any original equipment installed by general motors.customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov.
Campaign:
09V116000 on 04/07/2009
Component:
Engine and engine cooling
Affected:
1,497,516
Defect:
General motors is recalling 1,497,516 my 1997-2003 buick regal, my 1998-2003 chevrolet lumina, monte carlo and impala, my 1998-1999 oldsmobile intrigue, my 1997-2003 pontiac grand prix vehicles equipped with a 3.8l v6 naturally aspirated engine. some of these vehicles have a condition in which drops of engine oil may be deposited on the exhaust manifold through hard braking.
Consequence:
If the manifold is hot enough and the oil runs below the heat shield, it may ignite into a small flame and may spread to the plastic spark plug wire channel and beyond increasing the risk of an engine compartment fire.
Correction:
Dealers will replace the engine's front valve cover and front-valve-cover gasket with new parts of an improved design and remove the engine's plastic cover and plastic oil-fill-tube extension, free of charge. the recall is expected to begin during may 2016. owners may contact chevrolet at 1-800-630-2438, oldsmobile at 1-800-630-6537, and pontiac at 1-800-620-7668 or http://www.pontiac.com or http:www.gmownercenter.com.
Notes:
Gm recall no. 09047.owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to <a href=http://www.safercar.gov>http://www.safercar.gov</a> .
Campaign:
15V701000 on 10/25/2015
Component:
Engine and engine cooling:engine
Manufactured:
05/21/1997 - 04/07/1999
Affected:
1,003,556
Defect:
General motors llc (gm) is recalling certain model year 1998-1999 chevrolet lumina and oldsmobile intrigue, 1997-2004 buick regal and pontiac grand prix, 2000-2004 chevrolet impala, and 1998-2004 chevrolet monte carlo vehicles. the affected vehicles were previously repaired under recalls 08v-118, 09v-116, and 15v-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence:
Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Correction:
The remedy applied under recalls 08v-118, 09v-116, and 15v-201 did not adequately remove the safety risk. under the improved remedy, dealers will replace the engine's front valve cover and gasket. vehicles that are covered by recalls 08v-118, 09v-116, or 15v-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. the recall began on february 19, 2016. owners may contact chevrolet customer service at 1-800-222-1020, buick customer service at 1-800-521-7300, oldsmobile customer service at 1-800-442-6537 and pontiac customer service at 1-800-458-8006. gm's number for this recall is 15757. note: until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
Notes:
Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.
Campaign:
15V701000 on 10/25/2015
Component:
Engine and engine cooling:exhaust system:manifold/header/muffler/tail pipe
Manufactured:
05/21/1997 - 04/07/1999
Affected:
1,003,556
Defect:
General motors llc (gm) is recalling certain model year 1998-1999 chevrolet lumina and oldsmobile intrigue, 1997-2004 buick regal and pontiac grand prix, 2000-2004 chevrolet impala, and 1998-2004 chevrolet monte carlo vehicles. the affected vehicles were previously repaired under recalls 08v-118, 09v-116, and 15v-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence:
Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Correction:
The remedy applied under recalls 08v-118, 09v-116, and 15v-201 did not adequately remove the safety risk. under the improved remedy, dealers will replace the engine's front valve cover and gasket. vehicles that are covered by recalls 08v-118, 09v-116, or 15v-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. the recall began on february 19, 2016. owners may contact chevrolet customer service at 1-800-222-1020, buick customer service at 1-800-521-7300, oldsmobile customer service at 1-800-442-6537 and pontiac customer service at 1-800-458-8006. gm's number for this recall is 15757. note: until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
Notes:
Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.

1998 CHEVROLET LUMINA TSBs (46)

Bulletin:
98839010
Component:
140000 air bags
Summary:
Some customers may comment that the air bag warning light comes on intermittently or stays on. *yc
Bulletin:
98067
Component:
355100 equipment:other:labels
Summary:
Product emission campaign information regarding emission label error. *tt
Bulletin:
98067
Component:
355100 equipment:other:labels
Summary:
Product emission campaign regarding emission label error. *tt
Bulletin:
990603007
Component:
090000 fuel system, other
Summary:
Some customers may comment that the fuel gauge reads incorrectly / fluctuates, and the low fuel chime sounds prematurely. *tt
Bulletin:
990604037
Component:
116200 electrical system:ignition:module
Summary:
Subject on on-board diagnostic (obd) system improvements. *mjs
Bulletin:
98067
Component:
355100 equipment:other:labels
Summary:
Subject on 98067-product emission campaign emission label error. *mjs
Bulletin:
990603007A
Component:
090000 fuel system, other
Summary:
Conditions with inaccurate fuel gauge / fluctuates, premature low fuel chime. *tt
Bulletin:
990730030
Component:
106000 power train:axle assembly
Summary:
Some vehicles equipped with hydra-matic 3t40, 4t60 or 4t60-e transxales may comment on a grinding and / or growling noise that is noticeable when in park on incline. *tt
Bulletin:
990603007B
Component:
090000 fuel system, other
Summary:
Some customers may comment on the following conditions: 1) the fuel gauge reading incorrectly. 2) low fuel chime sounds prematurely. 3) fuel gauge may fluctuate from full to empty. *tt
Bulletin:
000851001
Component:
135200 visibility:rearview mirrors/devices:exterior
Summary:
Some customers may comment that the black plastic housing around the outside rear view mirror turns chalky or is dull in color. *tt
Bulletin:
876002A
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Some v6 engines may, on a very infrequent basis, have an oil odor condition that is generally encountered after the engine's oil has been changed.typically the odor lasts approximately 1000 miles after the change of oil and then does not re
Bulletin:
533307B
Component:
020000 suspension
Summary:
Some vehicles may exhibit front suspension scrunch / popping type noise coming from the front of vehicle that is apparent during low speed turning maneuvers. *tt
Bulletin:
836317
Component:
070000 fuel system, gasoline
Summary:
Some operators of vehicles equipped with land mobile communcation systems, such as those utilized by law enforcement agencies, may comment on fuel pump related radio frequency interference during vehicle operation. *tt
Bulletin:
010601007
Component:
062000 engine and engine cooling:cooling system
Summary:
Engine coolant consumption or coolant leak (inspect for material degradation/replace intake manifolds) *tt updated 11/02/07 *nj
Bulletin:
010601008
Component:
061000 engine and engine cooling:engine
Summary:
Some owners may comment on a repeat engine oil pan leak. *tt
Bulletin:
990604005A
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Some owners may comment on driveability symptons of long or hard starts, chuggle, rough idle and light or intermittent misfire due to clogged fuel injectors. *tt
Bulletin:
990603007C
Component:
090000 fuel system, other
Summary:
A condition may exist in which the fuel gauge reads incorrectly / fluctuates, low fuel chime sounds prematurely. *tt
Bulletin:
990730030A
Component:
106000 power train:axle assembly
Summary:
Owners of some vehicles equipped with hydra-matic 3t40, 4t60, 4t60-e or 4t65-e transaxles may comment on a grinding and / or growling noise that is noticeable when standing in park on a hill or slope with the engine running and the parking
Bulletin:
010601010A
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Subject regarding polymer service pistons. *tt
Bulletin:
010601007A
Component:
062000 engine and engine cooling:cooling system
Summary:
Experiencing excessive engine coolant consumption, or an engine coolant leak near or under the throttle body area of the upper intake manifold. *tt
Bulletin:
32
Component:
980000 unknown or other
Summary:
Information regarding extra clips in the 4t65e transmission. *slc
Bulletin:
010730032B
Component:
103000 power train:automatic transmission
Summary:
Some owners may comment on a transmission oil leak. *tt updated *eh
Bulletin:
020601014
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Subject regarding revised lower intake manifold installation. *tt
Bulletin:
010601008A
Component:
061000 engine and engine cooling:engine
Summary:
Some owners may comment on a repeat engine oil pan leak. *tt
Bulletin:
000730002B
Component:
102000 power train:manual transmission
Summary:
Concerns with slips, harsh upshift or garage shifts, launch shudders, flares, erratic shifts and intermittent concerns, diagnostic trouble code p1811 or p0748 set. *tt
Bulletin:
020730014
Component:
980000 unknown or other
Summary:
Information on servicing 4t65e transaxle spacer plate and gaskets. *tt
Bulletin:
020730014A
Component:
980000 unknown or other
Summary:
Information on servicing 4t65-e transaxle spacer plate and gaskets for various models from 1997 through 2002. *tt
Bulletin:
010601002A
Component:
061000 engine and engine cooling:engine
Summary:
Revised piston pin removal / installation procedure. *tt
Bulletin:
01880
Component:
100000 power train
Summary:
No tcc apply, malfunction indicator lamp (mil) on, tcc surge, possible p0740, p1870, or 39 after installation of a reman (srta) 4t60/4t60e. *tt
Bulletin:
040601017
Component:
063200 engine and engine cooling:exhaust system:manifold/header/muffler/tail pipe
Summary:
New upper intake manifold and gasket kits. *tt
Bulletin:
3115
Component:
063200 engine and engine cooling:exhaust system:manifold/header/muffler/tail pipe
Summary:
Engine intake manifold coolant leak. *sc
Bulletin:
040601021
Component:
061000 engine and engine cooling:engine
Summary:
New rear main seal and special tool for installation. *tt
Bulletin:
01292004
Component:
015000 steering:hydraulic power assist system
Summary:
Power steering gear lower pinion bearing, safety recall 03062. *tt
Bulletin:
57
Component:
114000 electrical system:wiring
Summary:
Wire harness may be stretched, or the pcs may not be oriented in the same position, after installing a service replacement valve body assembly. gm tech link. *tt
Bulletin:
050525006
Component:
046300 service brakes, air:antilock:wheel speed sensor
Summary:
Revised front wheel speed sensor replacement procedure. *tt
Bulletin:
050604058
Component:
180000 vehicle speed control
Summary:
Intermittent chuggle or fishbite on light acceleration or a highway speeds with no diagnostic trouble codes (dtcs). *tt
Bulletin:
4615
Component:
040000 service brakes, air
Summary:
Abs pump running when not needed. *nj
Bulletin:
16NA260
Component:
353400 equipment:electrical:radio/tape deck/cd etc.
Summary:
This technical bulletin provides a procedure to reprogram the media disc player with the latest calibrations to correct a condition of the rear entertainment system not operating as intended in colder ambient temperature areas due to calibr
Bulletin:
PIC5913
Component:
110000 electrical system
Summary:
This preliminary information communication provides information to the technician about vehicles that have a supplemental inflatable restraint lamp, service vehicle soon lamp on and/or radio locked, possibly after module replacement. techni
Bulletin:
PIP4723B
Component:
118000 electrical system: software
Summary:
This preliminary information communicates to the dealer the process for downloading or updating operating software for the tire pressure monitor, active fuel injector tester, multi media tester, pico scope, gr8 starting/charging tester and
Bulletin:
PIC4696A
Component:
353100 equipment:electrical:anti-theft devices
Summary:
This preliminary information communication provides information to the technician on how to unlock radios that are delco theftlock. technician will use the radio to get the scrambled code. technician will need to contact the radio unlock ce
Bulletin:
PIC4696B
Component:
353100 equipment:electrical:anti-theft devices
Summary:
This preliminary information communication provides information to the technician on how to unlock radios that are delco theftlock. technician will use the radio to get the scrambled code. technician will need to contact the radio unlock ce
Bulletin:
PI1217
Component:
100000 power train
Summary:
This preliminary bulletin provides a way to aid the technician in diagnosing transmission fluid leaking from the trans breather vent.
Bulletin:
05-06-04-035D
Component:
070000 fuel system, gasoline
Summary:
This informational bulletin provides the technician with information on what e85 fuel may due to a non e85 vehicle.
Bulletin:
17-NA-073
Component:
355200 equipment:other:owners/service/other manual
Summary:
This warranty administration bulletin provides policy information with the field action courtesy transportation policy.
Bulletin:
PIC4696C
Component:
150000 seat belts
Summary:
This preliminary information communication provides information to the technician on how to unlock radios that are delco theftlock. technician will use the radio to get the scrambled code. technician will need to contact the radio unlock ce

Home | Privacy