1998 AUDI A6 Recalls (9)

Campaign:
97V160000 on 09/29/1997
Component:
Fuel system, gasoline:storage:tank assembly:filler pipe and cap
Manufactured:
06/30/1997 - 07/30/1997
Affected:
31
Defect:
Vehicle description: passenger vehicles. during pre-assembly of the fuel tanks, an incorrect filler neck was installed causing the filler neck to not "match" the fuel cap.
Consequence:
This condition could allow fuel to escape and if an ignition source was present, a fire could occur.
Correction:
Dealers will replace these filler necks.
Notes:
Owner notification began september 19, 1997.dealers have been issued a stop delivery and owners of vehicles already sold have been contacted by telephone.owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact volkswagen at 1-800-822-2834. also contact the national highway traffic safety administration's auto safety hotline at 1-800-424-9393.
Campaign:
98V134000 on 06/29/1998
Component:
Engine and engine cooling:cooling system
Manufactured:
01/31/1997 - 02/27/1998
Affected:
19,800
Defect:
Vehicle description: passenger vehicles. if the engine backfires during a cold-start, an air screen which is loosely seated in the air flow meter can become damaged.
Consequence:
Screen pieces could enter the intake air flow system and prevent the throttle plate from returning to its full idle position.
Correction:
Dealers will install a retaining ring to hold the air screen in place.
Notes:
Owner notification began during august 1998.owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact vwoa at 1-800-822-8987 or audi at 1-800-822-2834.also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
Campaign:
99V058000 on 03/24/1999
Component:
Fuel system, gasoline:storage:tank assembly:filler pipe and cap
Manufactured:
10/31/1997 - 03/21/1999
Affected:
27,964
Defect:
Vehicle description: passenger vehicles equipped with quattro drive system which employs a fuel and fuel vapor leak detection system. if the vehicle is refueled shortly after the engine is started, and is kept running while being refueled, the fuel vapor recovery system could produce sufficient back pressure to cause fuel to be ejected after a complete fill-up when the fuel pump nozzle is removed from the filler neck.
Consequence:
In the presence of an ignition source, fuel spray could result in fire or possible personal injury.
Correction:
Vw is providing a new page for the owner's manual and also requesting owners to make an appointment with their dealers to have a label containing important refueling instructions installed inside of the fuel filler door. dealers will also remove the tire pressure label and replace it with a new label affixed to the fender well at the right rear door.
Notes:
Owner notification began june 8, 1999.owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact audi at 1-800-822-2834. also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
Campaign:
99V248000 on 09/27/1999
Component:
Steering:linkages:rod:relay:connecting
Manufactured:
01/01/1998 - 07/30/1998
Affected:
51,900
Defect:
Vehicle description: passenger vehicles. the tie rods of the steering assembly are protected on each side by a seal to prevent moisture and dust particles from entering the swivel bearing mechanism. it is possible that some tie rod seals may not seal properly.
Consequence:
If moisture and/or dust particles enter the swivel bearing mechanism, the swivel bearing could wear over time diminishing the steering control of the vehicle.
Correction:
Dealers will replace the tie rods.
Notes:
Vw recall no. ul/audi recall no. kw. owner notification began october 5, 1999. owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact volkswagen at 1-800-822-8987 or audi at 1-800-822-2834.also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
Campaign:
99V131001 on 01/20/2000
Component:
Service brakes, hydraulic:power assist:vacuum:hoses, lines/piping, and fittings
Manufactured:
09/30/1997 - 02/27/1999
Affected:
88,121
Defect:
Vehicle description: passenger vehicles equipped with automatic transmissions. a control valve in the vacuum hose connecting the brake booster to the intake manifold may not open or close fully at temperatures below -4 f under certain driving conditions.
Consequence:
This condition could cause insufficient vacuum to be provided to the brake booster.
Correction:
Dealers will install a vacuum by-pass system into vehicles operated in these states which is designed to provide sufficient vacuum for full brake assist under all weather conditions.
Notes:
Owner notification began october 9, 1999.owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact vw at 1-800-822-8987 or audi at 1-800-822-2834.also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
Campaign:
01V157000 on 05/17/2001
Component:
Fuel system, gasoline:storage:tank assembly
Manufactured:
08/13/1997 - 11/14/2000
Affected:
70,000
Defect:
Vehicle description: passenger vehicles. sulfur in fuel interacts with certain additives found in widely available gasoline causing sulfur to become deposited on the contact points of three fuel sending units mounted inside the fuel tank. this could cause the fuel gauge to read full while the fuel tank may not in fact be full or could be empty.
Consequence:
Running out of fuel without warning while the fuel gauge indicates that there is sufficient fuel in the tank lead to safety problems.
Correction:
Dealers will remove the existing fuel level sending units and replace them with fuel level sending units using a new alloy composed of gold, silver, and a small amount of nickel, which will not chemically react with sulfur. vw/audi will also call back vehicles that were repaired under a previous recall last june in order to install the updated fuel sending units nhtsa 00v137/audi lb). owner notification began may 1, 2001. owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact audi at 1-866-892-2834.
Notes:
Also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
Campaign:
04V133000 on 03/21/2004
Component:
Electrical system
Manufactured:
08/13/1997 - 02/11/2004
Affected:
172,866
Defect:
On certain passenger vehicles, if a driver's knees push against the knee bolster (crash element) located under the dashboard, it can contact the headlight switch wiring harness, and an electrical short could occur.
Consequence:
A fire could originate in the left dashboard area.
Correction:
Dealers will install a protective covering on the knee bolster (crash element). in addition, the wiring harness as well as the felt protector on the left side of the dashboard carrier will be checked, and replaced if necessary. the recall began on july 26, 2004. owners should contact audi at 1-800-822-2834.
Notes:
Customers can also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
Campaign:
04V495000 on 10/18/2004
Component:
Vehicle speed control
Manufactured:
07/31/1997 - 07/30/1999
Affected:
28,300
Defect:
On certain passenger vehicles equipped with 2.8l, v6 5-valve engines, and automatic transmissions, while driving during extremely low ambient temperatures the throttle may freeze in an open position due to ice accumulating in the throttle body.
Consequence:
If this occurs, the vehicle may fail to reduce speed when the driver lifts his/her foot from the gas pedal. this loss of vehicle control could result in a crash without warning.
Correction:
Audi will install a replacement throttle body kit free of charge. the recall began on october 29, 2004. owners may contact audi at 1-800-822-2834. owners of vehicles which are not registered in the cold-weather states of alaska, colorado, connecticut, delaware, idaho, illinois, indiana, iowa, maine, maryland, massachusetts, michigan, minnesota, montana, nebraska, nevada, new hampshire, new jersey, new york, north dakota, ohio, oregon, pennsylvania, rhode island, south dakota, vermont, washington, wisconsin, and wyoming, will be notified of a service action, under which they will be provided the free remedy upon request.
Notes:
Vw/audi recall nos. jb/jg.customers can also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
Campaign:
06V198000 on 06/06/2006
Component:
Electrical system
Manufactured:
07/31/1997 - 05/30/2000
Affected:
70,512
Defect:
On certain passenger vehicles equipped with halogen low beam headlights, certain connector pins in the headlight switch connector come into contact with each other causing a short circuit. note: vehicles with xenon low beam headlights are not affected because the circuit in these vehicles contains a fuse, which precludes excessive current flow in the case of a short circuit. audi s6 and s6 avant vehicles are all equipped with xenon low beam headlights and, therefore, are not longer affected by this recall.
Consequence:
This condition could lead to overheating or fire.
Correction:
Dealers will reroute the wiring harness by installing a jumper wiring harness. the recall began on december 16, 2006. owners may contact audi at 1-800-822-2834.
Notes:
Volkswagen (audi) recall no. jn.customers may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov.

1998 AUDI A6 TSBs (66)

Bulletin:
970298
Component:
131000 visibility:windshield
Summary:
Condition with windshield water leak. *yc
Bulletin:
9802J
Component:
061000 engine and engine cooling:engine
Summary:
Repair manual updates / revisions on the camshaft position (cmp) sensor. *yc
Bulletin:
A9806
Component:
114000 electrical system:wiring
Summary:
Subject on electrical wiring diagrams, troubleshooting & component locations technical bulleting no. 3. *yc
Bulletin:
980491
Component:
353400 equipment:electrical:radio/tape deck/cd etc.
Summary:
Installation instructions on cellular telephone for vehicles without insulated glass. *yc
Bulletin:
980269
Component:
140000 air bags
Summary:
Deactivating and activating rear side airbags. *yc
Bulletin:
9803T
Component:
355200 equipment:other:owners/service/other manual
Summary:
Revisions on repair manual updates. *yc
Bulletin:
980598
Component:
140000 air bags
Summary:
Subject pertaining to airbag system with side airbags. *yc
Bulletin:
9809
Component:
353000 equipment:electrical
Summary:
Subject regarding cellular telephone installation instructions for vehicles without insulated glass and / or without fender mounted antenna. *tt
Bulletin:
9801
Component:
354300 equipment:mechanical:carrier/rack
Summary:
Subject on luggage cover handle, replacing. *yc
Bulletin:
9801
Component:
115000 electrical system:fuses and circuit breakers
Summary:
Subject on open condtion at fuse s14. *yc
Bulletin:
9802
Component:
021000 suspension:front
Summary:
Clunking or rattling noise from one or both sides of front suspension when driving over rough roads. *yc
Bulletin:
9803
Component:
132000 visibility:glass, side/rear
Summary:
Experiencing creaking / popping noises from rear window. *yc
Bulletin:
9801
Component:
980000 unknown or other
Summary:
Subject on floor mat fastener variations. *yc
Bulletin:
9808
Component:
980000 unknown or other
Summary:
Subject on central locking system, function options. *yc
Bulletin:
A9813
Component:
355200 equipment:other:owners/service/other manual
Summary:
Subject regarding repair manual booklet. *ak
Bulletin:
9903
Component:
133000 visibility:power window devices and controls
Summary:
A condition may exist where the front door window(s) binds or does not operate when opening or closing. *tt
Bulletin:
0001
Component:
090000 fuel system, other
Summary:
Subject regarding an incorrect fuel reading on fuel gauge (erratic, stuck on full or empty). *tt
Bulletin:
0002
Component:
090000 fuel system, other
Summary:
Revised information for vehicles exhibiting an incorrect fuel gauge reading. *tt
Bulletin:
0001
Component:
355100 equipment:other:labels
Summary:
Information on replacing damage fasteners when a condition exist where the rear license plate fasteners may be broken, loose or fallen behind the license plate holder / lens assembly.
Bulletin:
640001
Component:
133000 visibility:power window devices and controls
Summary:
A condition may exist where the front door window(s) bind or do not operate when opening or closing. *tt
Bulletin:
150102
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
A condition may exist where the engine cranks but will not start. *tt
Bulletin:
900102
Component:
114200 electrical system:wiring:interior/under dash
Summary:
Subject regarding instrument cluster, driver's information display fades. *jg
Bulletin:
900104
Component:
114200 electrical system:wiring:interior/under dash
Summary:
Subject regarding instrument cluster, driver's information display fades. *jg
Bulletin:
LQ
Component:
162200 structure:body:bumpers
Summary:
Service action campaign - installation of front bumper guides. *tt
Bulletin:
042804
Component:
021530 suspension:front:control arm:lower arm
Summary:
Service action to inspect lower control arm seals. *tt
Bulletin:
0408
Component:
090000 fuel system, other
Summary:
Long term fuel trim - system too rich. diagnostic trouble code p1123, p1125, p1137 and p1139. *tt
Bulletin:
JE
Component:
021530 suspension:front:control arm:lower arm
Summary:
Both front suspension lower control arms can exhibit wear, even though the damage to the rubber boots is not obvious. service action circular to check/replace front suspension lower control arms. *tt
Bulletin:
0402
Component:
061000 engine and engine cooling:engine
Summary:
Valve cover, diagnosing oil leakage from gaskets. *tt
Bulletin:
0403
Component:
180000 vehicle speed control
Summary:
Throttle body replacement kit installation. *tc
Bulletin:
0404
Component:
180000 vehicle speed control
Summary:
Throttle body replacement kit installation. *tc
Bulletin:
JE
Component:
021530 suspension:front:control arm:lower arm
Summary:
Check/replace replace front suspension lower control arms. *tc
Bulletin:
0406
Component:
062300 engine and engine cooling:cooling system:hose
Summary:
Coolant leak at oil cooler hoses. *tt
Bulletin:
480501
Component:
015000 steering:hydraulic power assist system
Summary:
Power steering, noisy. to include 2006 models. *tt
Bulletin:
11242004
Component:
021530 suspension:front:control arm:lower arm
Summary:
Service action je campaign-check/replace front suspension lower control arms. audi has found that in rare cases, one or both front suspension lower control arms on affected vehicles can exhibit wear, even though the damage to the rubber bo
Bulletin:
20056243
Component:
121000 exterior lighting:headlights
Summary:
Headlight aiming, using hella universal beamsetter. *kb
Bulletin:
0715
Component:
120000 exterior lighting
Summary:
Exterior lights, moisture accumulation. *nj
Bulletin:
2012749-2
Component:
121000 exterior lighting:headlights
Summary:
Exterior lights, mositure accumulation. *pe
Bulletin:
TSB-44-08-14
Component:
203000 wheels:lugs/nuts/bolts
Summary:
Audi: wheel bolts require torque adjustment. torque sticks and torque extension bars are not approved by audi of america, inc. and should not be used to apply torque to wheel bolts. all audi models included. *pe
Bulletin:
TSB-45-08-04
Component:
036000 service brakes, hydraulic:antilock
Summary:
Audi: abs activates during light brake application . control noises are heard from the abs unit at low speed without brake application. *pe
Bulletin:
TSB-94-07-15
Component:
120000 exterior lighting
Summary:
Audio: exterior lights, moisture accumulation. condensation is visible on the inside of headlights, taillights, fog lights, side marker lights, front turn signal or third brake light lens. damp air settles on the inside of a cold lens,
Bulletin:
TSB-24-11-66
Component:
061000 engine and engine cooling:engine
Summary:
Audi: in cold temperatures, ice can accumulate on the throttle body making the vehicle unable to return to idle.1998-1999 a6. *rm
Bulletin:
TSB-44-13-46
Component:
356000 equipment adaptive
Summary:
Audi: on certain vehicles, use calibrated torque wrench and not torque sticks, torque extension bars and impact guns/wrenches not approved for usage on wheel bolts by manufacturer, that can cause damage to brake, steering wheel, hub. mode
Bulletin:
SB-01-15-29
Component:
060000 engine (pws)
Summary:
Audi: engine, on some vehicles, would run irregularly or have malfunction indicator lamp (mil) on or possible filter element for camshaft adjustment valve can loosen and in oil circuit, there is no damage from loosened particles. model al
Bulletin:
A101511 2018288-
Component:
060000 engine and engine cooling
Summary:
Supersedes technical service bulletin group 10 number 13-10 dated september 5, 2013. prior to engine replacement, any debris lodged in transferred assemblies must be removed. if the engine experienced a serious mechanical problem, it is pos
Bulletin:
A171557 2010043-
Component:
060000 engine and engine cooling
Summary:
Supersedes technical service bulletin group 17 number 13-35 dated january 9, 2013. this bulletin lists engine oils that meet audi oil quality standards (vw 501 01, 502 00, 505 00, 505 01, and 504 00/507 00).
Bulletin:
A941565 2012749-
Component:
121000 exterior lighting:headlights
Summary:
Supersedes technical service bulletin group 94 number 12-92 dated october 24, 2012. condensation is visible on the inside of the headlight, taillight, fog light, side marker light, front turn signal, daytime running lights, or third brake l
Bulletin:
A011507 2028344-
Component:
060000 engine and engine cooling
Summary:
Supersedes technical service bulletin group 01 number 13-69 dated february 14, 2013. noises and inconsistent engine operation after cold start during the catalyst heating phase. the customer may misinterpret these symptoms as engine misfiri
Bulletin:
A101310 2018288-
Component:
060000 engine and engine cooling
Summary:
Supersedes technical service bulletin group 10 number 10-02 dated september 14, 2010. prior to engine replacement, any debris lodged in transferred assemblies must be removed. if the vehicle's engine experienced a serious mechanical problem
Bulletin:
A901341 2010353-
Component:
356000 equipment adaptive
Summary:
Supersedes technical service bulletin group 90 number 10-14 dated august 10, 2010. cigarette lighter element will not lock into the lighter socket -u1- to begin the heating process, or the lighter element will not automatically release once
Bulletin:
A441346 2010334-
Component:
200000 wheels
Summary:
Supersedes technical service bulletin group 44 number 12-32 dated august 2, 2012. wheel bolt requires torque adjustment. torque sticks, torque extension bars, and impact guns/wrenches are not approved by audi of america, inc., and should no
Bulletin:
A191450 2025303-
Component:
060000 engine and engine cooling
Summary:
Supersedes technical service bulletin group 19 number 13-41 dated june 20, 2013. discontinuation and mixing of audi-approved engine coolants. g11, g12, and g12+ coolants have been replaced by an improved version. g12++ coolant (for service
Bulletin:
A001467 2002047-
Component:
355200 equipment:other:owners/service/other manual
Summary:
Supersedes technical service bulletin group 00 number 14-61 dated may 1, 2014. technician preparation when calling the audi technical assistance center (tac).
Bulletin:
A941292 2012749-
Component:
120000 exterior lighting
Summary:
Supersedes technical service bulletin group 94 number 11-52 dated october 11, 2011. condensation is visible on the inside of the headlight, taillight, fog light, side marker light, front turn signal, daytime running lights, or third brake
Bulletin:
A191341 2025303-
Component:
060000 engine and engine cooling
Summary:
Supersedes technical service bulletin group 19 number 13-35 dated march 25, 2013. discontinuation and mixing of audi-approved engine coolants. g11, g12, and g12+ coolants have been replaced by an improved version. g12++ coolant (for service
Bulletin:
A451510 2042048-
Component:
103100 power train:automatic transmission:control module (tcm, pcm)
Summary:
Vehicle will not communicate with diagnostic scan tool or emissions test equipment. customers may have issues with vehicle passing state im emissions test programs because the scan tool cannot communicate with the vehicle. abs and/or brake
Bulletin:
A191562 2025303-
Component:
060000 engine and engine cooling
Summary:
Supersedes technical service bulletin group 19 number 15-61 dated july 7, 2015. discontinuation and mixing of audi-approved engine coolants. g11, g12, and g12+ coolants have been replaced by an improved version. g12++ coolant (for service a
Bulletin:
A191335 2025303-
Component:
060000 engine and engine cooling
Summary:
Supersedes technical service bulletin group 19 number 11-19 dated february 10, 2011. discontinuation and mixing of audi-approved engine coolants. g11, g12, and g12+ coolants have been replaced by an improved version. g12++ coolant (for serv
Bulletin:
A001348 2002047-
Component:
355200 equipment:other:owners/service/other manual
Summary:
Supersedes technical service bulletin group 00 number 11-19 dated april 8, 2011. this tsb contains information on technician preparation when calling the audi technical assistance center
Bulletin:
2013_06_ATU Audi
Component:
355200 equipment:other:owners/service/other manual
Summary:
This document contains information on the audi side assist update.
Bulletin:
A441455 2010334-
Component:
200000 wheels
Summary:
Supersedes technical service bulletin group 44 number 13-46 dated december 9, 2013. wheel bolt requires torque adjustment.
Bulletin:
Accessories Oper
Component:
350000 equipment
Summary:
This is an advance notice for audi of america employees. this notice contains information for the accessories operations technical bulletin.
Bulletin:
A941791 2012749-
Component:
120000 exterior lighting
Summary:
This informational bulletin contains technical information for when there is condensation visible on the inside of the headlight, taillight, fog light, side marker light, front turn signal, daytime running lights, and/or third brake light l
Bulletin:
A441662 2010334-
Component:
200000 wheels
Summary:
This information tsb provides information regarding the correct way to torque adjust a wheel bolt.
Bulletin:
ATE-17-05
Component:
350000 equipment
Summary:
Due to increasing requests for high voltage personal protective equipment (hve ppe) for dealer technicians working with high voltage vehicles (hybrid, plugin hybrid, electric vehicle), the volkswagen tools and equipment team has identified
Bulletin:
A171782 2010043-
Component:
060000 engine (pws)
Summary:
This informational bulletin contains all the the audi oil quality standards that should be used when doing an oil change.
Bulletin:
A1915612025303-5
Component:
060000 engine and engine cooling
Summary:
Supersedes technical service bulletin group 19 number 14-50 dated june 20, 2014. discontinuation and mixing of audi-approved engine coolants. g11, g12, and g12+ coolants have been replaced by an improved version. g12++ coolant (for service

Home | Privacy