1997 PONTIAC TRANS SPORT Recalls (6)

Campaign:
98V072000 on 04/08/1998
Component:
Visibility:windshield wiper/washer:linkages
Manufactured:
03/31/1996 - 08/29/1997
Affected:
55,154
Defect:
Vehicle description: passenger mini vans equipped with traction control systems. the windshield wiper linkage arm can contact a brake line which is connected to the traction control system modulator valve. this contact can chafe the brake line resulting in a brake fluid leak.
Consequence:
Brake fluid leakage can cause reduced brake effectiveness and increased stopping distances.
Correction:
Dealers will install a brake line clip to ensure proper clearance. also the brake lines will be inspected to any damage caused by this condition and will replace any damaged lines.
Notes:
Owner notification is expected to begin during april 1998. owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact chevrolet at 1-800-222-1020, pontiac at 1-800-762-2737, or oldsmobile at 1-800-442-6537.also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
Campaign:
01V067000 on 03/07/2001
Component:
Latches/locks/linkages:doors:latch
Manufactured:
05/31/1996 - 08/30/1997
Affected:
477,011
Defect:
Vehicle description: minivans equipped with passenger side power sliding doors. the door closes but may not be latched. if this happens, the power sliding door can open while the vehicle is in motion, particularly when the vehicle ascends a hill, makes a turn, or travels over a rough road surface.
Consequence:
An unrestrained occupant could fall out of the van and be injured.
Correction:
Dealers will install a new un-latch actuator assembly to the power sliding door. this recall has been continued under safety recall 01v-264. owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact chevrolet at 1-800-222-1020, pontiac at 1-800-762-2737, or oldsmobile at 1-800-442-6537.
Notes:
Also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
Campaign:
01V264000 on 08/26/2001
Component:
Latches/locks/linkages:doors:latch
Affected:
248,737
Defect:
Vehicle description: 1997-2001 chevrolet venture, pontiac montana/transport, and oldsmobile silhouette mini vans equipped with passenger side power sliding doors that were serviced in campaign 01013 (01v-067) from april to august 2001. also 2001 chevrolet venture, pontiac montana, and oldsmobile silhouette mini vans equipped with passenger side power sliding doors assembled in january through april 2001. these vehicles have inadequate front welds. if a front weld fails, the actuator can jam in the unlatched position and, when the sliding door closes, it will not be latched.
Consequence:
If this happens, the power sliding door can open while the vehicle is in motion, particularly when the vehicle ascends a hill, makes a turn, or travels over a rough road surface. an unrestrained occupant could fall out of the van and be injured.
Correction:
Dealers will inspect and, if required, install a new power sliding door unlatch actuator assembly. owner notification began on october 22, 2001. owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact chevrolet at 1-800-222-1020, pontiac at 1-800-762-2737, or oldsmobile at 1-800-442-6537.
Notes:
Also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
Campaign:
02V286000 on 11/05/2002
Component:
Steering:rack and pinion
Manufactured:
03/31/1996 - 08/30/1997
Affected:
1,159,156
Defect:
Certain passenger vehicles and mini vans have lower pinion bearings in the power rack and pinion assembly in which the retainer tabs were not crimped properly. these and some other retainers used in vehicles assembled between january 1, 1996 and october 31, 1997, could fail and permit the ball bearings to escape.
Consequence:
If this occurs, the pinion shaft can be forced upward during left turns and back down as the steering wheel is moved back and to the right. if the pinion shaft moves further, the driver will need to exert more effort to turn the steering wheel, similar to a vehicle without power assisted steering. if the pinion shaft moves even further, the driver will require much higher effort to turn left and may not be able to turn the wheel as much as intended. with the maximum pinion shaft movement, which requires internal gear component damage, the driver can encounter high resistance to turning left, followed by unintended power assist to the right. in any of these conditions, a crash could occur.
Correction:
Dealers will install a new lower pinion bearing unless inspect of the existing bearing indicates that replacement of the gear assembly is necessary. owner notification began january 24, 2003. owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact chevrolet at 1-800-222-1020, pontiac at 1-800-762-2737, or oldsmobile at 1-800-442-6537.
Notes:
Gm recall no. 02049.also, customers can contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
Campaign:
04V597000 on 12/21/2004
Component:
Latches/locks/linkages:doors:latch
Affected:
717,302
Defect:
On certain minivans equipped with second-row bucket seats or captain's chairs and a power sliding door on the passenger side of the vehicle, a passenger using the interior handle to open the power sliding door could be injured.
Consequence:
If a passenger uses the interior handle to open the power sliding door and holds onto the handle while it is being opened by the motor, the passenger's arm may be pushed into the seat back or armrest and a wrist or lower arm injury may result.
Correction:
Dealers will replace the power sliding door interior handle on the passenger-side. if the vehicle is equipped with a power or manual sliding door on the driver-side, the interior handle will also be replaced for appearance reasons. note: before the vehicle is serviced, gm advises owners to not use the interior door handle to open the door. the driver can open and close the door from switches at the driver's position or by using the remote key fob. the driver should tell passengers to use the switch located in front of the door to open or close it. the driver should use the override switch to prevent operation of the power door by children or by others who are not familiar with its use. the owner notification letter mailing will be conducted in phases with the first phase beginning on may 31, 2005. the second phase mailing began on july 18, 2005. the recall began on may 31, 2005. phase 2 began on july 18, 2005. phase 3 (final phase) began on august 24, 2005, to all remaining customers. owners should contact chevrolet at 1-800-630-2438; pontiac at 1-800-620-7668; or oldsmobile at 1-800-630-6537.
Notes:
Gm recall no. 04110.customers can also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
Campaign:
07E021000 on 03/11/2007
Component:
Fuel system, other:storage:tank assembly:pressure relief devices
Affected:
742
Defect:
Certain delphi fuel pressure regulators, p/nos. fp10020-11b1, fp10026-11b1, and fp10027-11b1, sold after january 9, 2007, as aftermarket equipment for various passenger vehicles listed above. the universal pressure regulators (upr) were produced without an o'ring and retainer.
Consequence:
Fuel may leak, possibly resulting in a fire.
Correction:
Delphi will notify owners and replace the upr free of charge. the recall began on april 23, 2007. owners can contact delphi at 877-411-8770.
Notes:
This recall only pertains to aftermarket delphi fuel pressure regulators and has no relation to any original equipment installed by general motors.customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov.

1997 PONTIAC TRANS SPORT TSBs (68)

Bulletin:
631518
Component:
162500 structure:body:tailgate
Summary:
Rattle at rear of vehicle over road bump or upon closing rear lift gate. *tw
Bulletin:
577106A
Component:
103000 power train:automatic transmission
Summary:
Cold start rattle noise. *tw
Bulletin:
676004
Component:
183000 vehicle speed control:cables
Summary:
Engine noise in passenger compartment (remove accelerator cable retaining clips). *tw
Bulletin:
677164
Component:
103000 power train:automatic transmission
Summary:
Intermittent neutral or loss of drive at highway speeds or from fourth gear (replace control valve body assembly). *tw
Bulletin:
733402
Component:
022140 suspension:rear:springs:leaf spring assembly
Summary:
Thud/clunk noise from rear suspension (check/replace rear springs). *tw
Bulletin:
577106A
Component:
105300 power train:driveline:driveshaft
Summary:
Cold start rattle noise (diagnosis/service procedure). *tw
Bulletin:
731053
Component:
131000 visibility:windshield
Summary:
Crack at center top of windshield (replace windshield). *tw
Bulletin:
739009
Component:
980000 unknown or other
Summary:
Remote keyless entry (rke) range is shorter than expected. *tw
Bulletin:
735010
Component:
051120 parking brake:conventional:mechanical:linkage and cable
Summary:
Clicking and/or squealing noise coming from the rear brakes (adjust park brake cable). *tw
Bulletin:
731103
Component:
138000 visibility:defroster/defogger system
Summary:
Air temperature from hvac outlets does not change or blows cold (replace temperature valve door). *tw
Bulletin:
736212
Component:
062000 engine and engine cooling:cooling system
Summary:
Engine coolant weeping from coolant recovery reservoir cap. *tw
Bulletin:
735011
Component:
036100 service brakes, hydraulic:antilock:control unit/module
Summary:
Squealing and/or grinding (scraping) noise from front brakes (bend abs speed sensor bracket away from rotor). *tw
Bulletin:
549001A
Component:
353400 equipment:electrical:radio/tape deck/cd etc.
Summary:
Cln indicator appears on radio display and does not turn off (reset cln indicator with the eject button on tape). *tw
Bulletin:
731102
Component:
138000 visibility:defroster/defogger system
Summary:
Loss of hvac modes (route vacuum line insidethe frame rail). *tw
Bulletin:
970801731057
Component:
162300 structure:body:door
Summary:
Hotline information regarding procedures for sliding door body and rear quarter window itch. *yc
Bulletin:
970901739017
Component:
133000 visibility:power window devices and controls
Summary:
Loss of owner customization settings.
Bulletin:
970901731062
Component:
162300 structure:body:door
Summary:
Various power sliding side door conditions. *yc
Bulletin:
970901731612
Component:
162000 structure:body
Summary:
A metal stud may puncture the carpeting near the brake assembly. *yc
Bulletin:
970801735026
Component:
036000 service brakes, hydraulic:antilock
Summary:
Comment that the abs light is on with diagnostic trouble codes (dtc's) 46 and 86 set as current or history. *yc
Bulletin:
970801738138
Component:
130000 visibility
Summary:
Subject on power window "auto-down" feature inoperative. *yc
Bulletin:
731104
Component:
138000 visibility:defroster/defogger system
Summary:
Insufficient heater performance in extreme cold weather. *yc
Bulletin:
98839601
Component:
353400 equipment:electrical:radio/tape deck/cd etc.
Summary:
Experiencing am band radio interference when windshield wipers are operating or secondary ignition system noise with engine running. *yc
Bulletin:
98776304A
Component:
073200 fuel system, gasoline:fuel injection system:injectors
Summary:
Some vehicles may experience a driveability symptom of long or hard starts, chuggle, rough idle and light or intermittent misfire. *yc
Bulletin:
838205
Component:
136000 visibility:windshield wiper/washer
Summary:
Comments that the windshield wiper blade(s) chatter on the windshield. *yc
Bulletin:
98776514A
Component:
980000 unknown or other
Summary:
Some vehicles may experience a mil (malfunction indicator lamp) light illuminated on the vehicle's instrument panel. *yc
Bulletin:
98576124A
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Comments on a ticking type noise that begins shortly after cold engine start-up and gradually diminishes as the engine warms up. *yc
Bulletin:
831704
Component:
162000 structure:body
Summary:
Concerns of door handles on white painted vehicles truning yellow. *yc
Bulletin:
98108
Component:
034200 service brakes, hydraulic:foundation components:hoses, lines/piping, and fittings
Summary:
A condition in which the windshield wiper linkage arm contacts a brake line connected to the traction control system (tcs) modulator valve while the wiper linkage arm is in motion. *tt
Bulletin:
990604005
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Some owners may experience a driveability symptom of long or hard starts, chuggle, rough idle and light or intermittent misfire. *tt
Bulletin:
9959
Component:
030000 service brakes, hydraulic
Summary:
Conditions with ice accumulating on the rear brake pipes. *tt
Bulletin:
990864017
Component:
162300 structure:body:door
Summary:
Some customers may comment that their sliding side door rattles at the top. *tt
Bulletin:
990730030
Component:
106000 power train:axle assembly
Summary:
Some vehicles equipped with hydra-matic 3t40, 4t60 or 4t60-e transxales may comment on a grinding and / or growling noise that is noticeable when in park on incline. *tt
Bulletin:
831220
Component:
353600 equipment:air conditioner
Summary:
A/c compressor clutch is engaged. this condition is most noticeable when engine is around the 1000-2000 rpm range. the noise may be lodest when the engine is under light acceleration through this rpm range. the moan noise may be created
Bulletin:
000940001
Component:
150000 seat belts
Summary:
Excessive lateral movement (side to side) when using certain aftermarket child seats. this condition occurs in vehicles equipped with second and third row bucket seats. *tt
Bulletin:
000864007
Component:
133000 visibility:power window devices and controls
Summary:
Some customers may comment that the front door glass is slow or noisy when moving up or down or the window is inoperative. *tt
Bulletin:
836316
Component:
071100 fuel system, gasoline:storage:tank assembly
Summary:
Some vehicles built prior to vin breakpoint wd100162 may exhibit fuel tank thud / clunk type noise audible when accelerating from a stop or during a braking maneuver when the fuel tank is filled between 5/8 and full. *tt
Bulletin:
000138011
Component:
138000 visibility:defroster/defogger system
Summary:
Some customers may comment on poor heat in the vehicle passenger compartment at low engine rpm. this condition is most prevalent at outside temperatures below 0 degrees c (32 degrees f). *tt
Bulletin:
990604005A
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Some owners may comment on driveability symptons of long or hard starts, chuggle, rough idle and light or intermittent misfire due to clogged fuel injectors. *tt
Bulletin:
990730030A
Component:
106000 power train:axle assembly
Summary:
Owners of some vehicles equipped with hydra-matic 3t40, 4t60, 4t60-e or 4t65-e transaxles may comment on a grinding and / or growling noise that is noticeable when standing in park on a hill or slope with the engine running and the parking
Bulletin:
010523006
Component:
034510 service brakes, hydraulic:foundation components:disc:caliper
Summary:
Subject regarding revised fastener requirements for front and rear brake caliper bracket. *tt
Bulletin:
010523006A
Component:
034510 service brakes, hydraulic:foundation components:disc:caliper
Summary:
This bulletin is being issued to revise the fastener requirements for the front and rear brake caliper bracket replacement procedures in the disc-brake sub-section of brakes in the appropriate service manual. *tt
Bulletin:
010851004
Component:
162800 structure:body:hood
Summary:
Information regarding premature aluminum hood corrosion. *yh
Bulletin:
010857006
Component:
162000 structure:body
Summary:
This bulletin contains information on various waterleak conditions. *tt
Bulletin:
020858003
Component:
162000 structure:body
Summary:
Some customers may comment that road noise can be heard coming from the area behind the front seats. *tt
Bulletin:
020867006
Component:
162000 structure:body
Summary:
Some customers may comment that there is rust forming around the front or rear portion of the roof. *tt
Bulletin:
020864011
Component:
162300 structure:body:door
Summary:
Some customers may comment that the power sliding door will reverse on closing or the door will appear closed, but the alarm will come on when the transmission is moved out of park. *tt
Bulletin:
020858005
Component:
131000 visibility:windshield
Summary:
Concerns with wind noise at the base of the windshield. *tt
Bulletin:
020601014
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Subject regarding revised lower intake manifold installation. *tt
Bulletin:
000138011B
Component:
138000 visibility:defroster/defogger system
Summary:
Subject regarding poor heat with cold outside temperatures at low engine rpm. *tt
Bulletin:
000138011A
Component:
138000 visibility:defroster/defogger system
Summary:
Subject regarding poor heat with cold outside temperatures at low engine rpm. *tt
Bulletin:
020864006A
Component:
162900 structure:body:roof and pillars
Summary:
Roof perforation. *tt
Bulletin:
020867006B
Component:
162900 structure:body:roof and pillars
Summary:
Roof perforation. *tt
Bulletin:
030601010
Component:
060000 engine and engine cooling
Summary:
Engine oil or coolant leak. *tt
Bulletin:
000940001B
Component:
500000 child seat
Summary:
Excessive lateral movement (side to side) when using certain aftermarket child seats. this condition occurs in vehicles equipped with second and third row bucket seats. including the 1997 - 1999 opel sintra. *tt
Bulletin:
030232049
Component:
017500 steering:linkages:tie rod assembly
Summary:
Release of new outer tie rod ends for service. *tt
Bulletin:
03-06-01-010
Component:
061000 engine and engine cooling:engine
Summary:
Engine oil or coolant leak. *tt gm reminder. *tt install new lower intake manifold gasket. updated 7/18/08 *pe
Bulletin:
01880
Component:
100000 power train
Summary:
No tcc apply, malfunction indicator lamp (mil) on, tcc surge, possible p0740, p1870, or 39 after installation of a reman (srta) 4t60/4t60e. *tt
Bulletin:
3042
Component:
110000 electrical system
Summary:
Battery drain on vehicles equipped with power sliding doors. *tt
Bulletin:
010844005A
Component:
355200 equipment:other:owners/service/other manual
Summary:
Information on error codes on radio display their cause and corrective action. *eh
Bulletin:
16NA260
Component:
353400 equipment:electrical:radio/tape deck/cd etc.
Summary:
This technical bulletin provides a procedure to reprogram the media disc player with the latest calibrations to correct a condition of the rear entertainment system not operating as intended in colder ambient temperature areas due to calibr
Bulletin:
PIP4723B
Component:
118000 electrical system: software
Summary:
This preliminary information communicates to the dealer the process for downloading or updating operating software for the tire pressure monitor, active fuel injector tester, multi media tester, pico scope, gr8 starting/charging tester and
Bulletin:
PIC4696A
Component:
353100 equipment:electrical:anti-theft devices
Summary:
This preliminary information communication provides information to the technician on how to unlock radios that are delco theftlock. technician will use the radio to get the scrambled code. technician will need to contact the radio unlock ce
Bulletin:
PIC4696B
Component:
353100 equipment:electrical:anti-theft devices
Summary:
This preliminary information communication provides information to the technician on how to unlock radios that are delco theftlock. technician will use the radio to get the scrambled code. technician will need to contact the radio unlock ce
Bulletin:
17-NA-016
Component:
200000 wheels
Summary:
This informational bulletin provides information on wheel bearing p/n 13582664 being received new with visible rust and no action is needed as this does not affect the part performance.
Bulletin:
17-NA-016
Component:
200000 wheels
Summary:
This informational bulletin provides information on wheel bearing p/n 13582664 being received new with visible rust and no action is needed as this does not affect the part performance.
Bulletin:
05-06-04-035D
Component:
070000 fuel system, gasoline
Summary:
This informational bulletin provides the technician with information on what e85 fuel may due to a non e85 vehicle.
Bulletin:
17-NA-073
Component:
355200 equipment:other:owners/service/other manual
Summary:
This warranty administration bulletin provides policy information with the field action courtesy transportation policy.
Bulletin:
PIC4696C
Component:
150000 seat belts
Summary:
This preliminary information communication provides information to the technician on how to unlock radios that are delco theftlock. technician will use the radio to get the scrambled code. technician will need to contact the radio unlock ce

Home | Privacy