1997 ORION VI Recalls (6)
- Campaign:
- 97V129000 on 08/28/1997
- Component:
- Steering:linkages
- Manufactured:
- 11/30/1996 - 02/27/1997
- Affected:
- 20
- Defect:
- Vehicle description: low floor transit buses. due to machining and casting variances, two of the steering relay arms on these vehicles can fracture.
- Consequence:
- Failure of the steering arm leaves the bus with no steering control increasing the risk of a vehicle crash.
- Correction:
- Dealers will replace these steering arms.
- Notes:
- Owners were notified august 1, 1997, to remove these buses from service until the remedy was performed.a second ownernotificationis expected to begin september 2, 1997.owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact orion bus at 1-315-768-8101.also contact the national highway traffic safety administration's auto safety hotline at 1-800-424-9393.
- Campaign:
- 98V166000 on 07/21/1998
- Component:
- Suspension:front
- Manufactured:
- 01/07/1996 - 06/21/1998
- Affected:
- 31
- Defect:
- Vehicle description: transit buses built with zf front axles equipped with lucas disc brakes. the brake lever connecting the brake chamber pushrod to the disc brake actuator can contact the air bag support gusset during application of the brakes and become jammed and will not release the brake when the driver removes their foot from the brake pedal.
- Consequence:
- Since this is a steering axle, unwanted application of the brake can cause the vehicle to turn in the direction of the locked wheel increasing the risk of a vehicle crash.
- Correction:
- Dealers will rework the brake levers on the subject buses.
- Notes:
- Zf is handling the owner notification and remedy for this recall.
- Campaign:
- 98V210000 on 09/24/1998
- Component:
- Unknown or other
- Manufactured:
- 01/01/1997 - 08/31/1998
- Affected:
- 723
- Defect:
- Vehicle description: transit buses equipped with wheel chair barriers. the wheel chair barriers are attached to the floor structure with a bolt threaded into the floor structure. in the case of a frontal crash, with the wheel chair position occupied, the bolt threads could strip allowing movement of the wheel chair barrier.
- Consequence:
- This condition could allow movement of the wheel chair which could cause personal injury, or death, to the wheel chair occupant.
- Correction:
- Dealers will replace the existing wheel chair barrier leg mounting bolts with new bolts, nuts and washers.
- Notes:
- Owner notification is expected to begin during october 1998. owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact orion at 1-905-403-1111.also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
- Campaign:
- 98V331000 on 12/22/1998
- Component:
- Steering:linkages:knuckle:spindle:arm
- Manufactured:
- 11/30/1996 - 06/29/1997
- Affected:
- 20
- Defect:
- Vehicle description: low-floor transit buses equipped with a cast steel steering relay arm. the steering arms can fail without warning.
- Consequence:
- This condition can leave the bus with no steering control, increasing the risk of a crash.
- Correction:
- Dealers will replace these steering arms.
- Notes:
- Owner notification began december 22, 1998. owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact orion at 1-905-403-1111.also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
- Campaign:
- 03V120000 on 03/31/2003
- Component:
- Visibility:glass, side/rear
- Manufactured:
- 12/31/1994 - 12/30/2002
- Affected:
- 4,191
- Defect:
- Certain transit buses fail to comply with the requirements of federal motor vehicle safety standard no. 217, "bus emergency exits and window retention and release." the handle pull force exceeds the 89n force to release the emergency window. additional force is required to release the window.
- Consequence:
- in the event of a crash, an occupant may have difficulty opening the emergency exit window, increasing the risk of personal injury or death.
- Correction:
- Dealers will repair these windows. owner notification began june 1, 2003. owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact orion at 1-800-492-2116.
- Notes:
- Customers can also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
- Campaign:
- 10V538000 on 11/02/2010
- Component:
- Equipment adaptive
- Manufactured:
- 12/31/1995 - 12/29/2000
- Affected:
- 217
- Defect:
- Daimler bus is recalling certain model year 1995 through 2000 transit buses manufactured from january 1996 through december 2000. these buses are configured with a tapped fitting for the hydraulic wheelchair ramp. in the engine compartment connected to the hydraulic pump is a fitting with an adapter for the wheelchair ramp operation. the fitting can crack and cause hydraulic fluid to leak into the engine compartment.
- Consequence:
- Hydraulic fluids leaking into the engine compartment can be ignited by the hot turbocharger and cause an engine fire.
- Correction:
- Bus owners will be instructed on how to repair the buses free of charge. the safety recall began on 3, december 2010. owners may contact daimler buses at 1-800-716-7566.
- Notes:
- Owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to <a href=http://www.safercar.gov>http://www.safercar.gov</a> .
Home | Privacy