1997 OLDSMOBILE ACHIEVA Recalls (4)

Campaign:
97V059000 on 04/24/1997
Component:
Electrical system:wiring:front underhood
Manufactured:
11/30/1996 - 01/29/1997
Affected:
3,464
Defect:
The protective cover for the underhood fuse center was omitted. without this cover, the positive terminal bolt on the fuse block is exposed and can contact the insulated negative battery cable. if the insulation on the negative cable becomes sufficiently worn, an electrical short circuit can occur between the positive terminal and negative cable resulting in extremely high current flow.
Consequence:
This high current flow can cause arcing and result in an underhood fire.
Correction:
Dealers will inspect these vehicles for the presence of the protective cover and, if necessary, install a protective cover to the underhood fuse center.
Notes:
Owner notification:owner notification began during april 1997. note:owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact buick at 1-800-521-7300, oldsmobile at 1-800-442-6537, or pontiac at 1-800-762-2737.also contact the national highway traffic safety administration's auto safety hotline at 1-800-424-9393.
Campaign:
02V070000 on 03/24/2002
Component:
Electrical system:ignition:switch
Manufactured:
05/31/1996 - 07/30/1997
Affected:
1,589,948
Defect:
On certain passenger vehicles. if the engine fails to start and the driver holds the key in the "start" position for an extended period, high current flows through the ignition switch, and sometimes produces enough heat to melt internal switch parts.
Consequence:
If the switch is damaged, a fire could occur in the steering column, even with the engine off and the key removed.
Correction:
Dealers will install a relay kit in these vehicles to prevent high current from flowing through the ignition switch. owner notification began march 27, 2002. owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact chevrolet at 1-800-222-1020, pontiac at 1-800-762-2737, buick at 1-800-521-7300, or oldsmobile at 1-800-442-6537.
Notes:
Customers can also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
Campaign:
07E015000 on 02/25/2007
Component:
Fuel system, gasoline:delivery:fuel pump
Affected:
3,124
Defect:
Certain delphi aftermarket fuel pump modules / module reservoir assemblies (mra) that were sold for use on the above listed vehicles. during production the mras vent and fuel return tubes were reversed. this condition can result in the vehicle not running correctly (idle rough and/or stall) due to an overly rich fuel blend or the vehicle's evaporative emission carbon canister may leak fuel.
Consequence:
A stalled vehicle can increase the risk of a vehicle crash. a fuel leak can result in a fire.
Correction:
Delphi will notify owners and replace the defective mras free of charge. the recall began on march 20, 2007. owners can contact delphi at 1-877-335-7443.
Notes:
This recall only pertains to aftermarket delphi fuel pump modules and has no relation to any original equipment installed on vehicles manufactured by general motors corporation.customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov.
Campaign:
07E021000 on 03/11/2007
Component:
Fuel system, other:storage:tank assembly:pressure relief devices
Affected:
742
Defect:
Certain delphi fuel pressure regulators, p/nos. fp10020-11b1, fp10026-11b1, and fp10027-11b1, sold after january 9, 2007, as aftermarket equipment for various passenger vehicles listed above. the universal pressure regulators (upr) were produced without an o'ring and retainer.
Consequence:
Fuel may leak, possibly resulting in a fire.
Correction:
Delphi will notify owners and replace the upr free of charge. the recall began on april 23, 2007. owners can contact delphi at 877-411-8770.
Notes:
This recall only pertains to aftermarket delphi fuel pressure regulators and has no relation to any original equipment installed by general motors.customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov.

1997 OLDSMOBILE ACHIEVA TSBs (50)

Bulletin:
676204
Component:
062100 engine and engine cooling:cooling system:radiator assembly
Summary:
Coolant loss, visible coolant leakage, low coolant lamp on or coolant odor caused by coolant leakage. *tw
Bulletin:
676528
Component:
063100 engine and engine cooling:exhaust system:emission control
Summary:
Intermittent diagnostic trouble code p0107 map sensor circuit low voltage (pcm flash calibration) *tw
Bulletin:
577106A
Component:
103000 power train:automatic transmission
Summary:
Cold start rattle noise. *tw
Bulletin:
631109
Component:
138000 visibility:defroster/defogger system
Summary:
Air coming from i/p vent while in heater modes or a delay occurs when changing to a new mode setting (diagnose/modify/replace). *tw
Bulletin:
677164
Component:
103000 power train:automatic transmission
Summary:
Intermittent neutral or loss of drive at highway speeds or from fourth gear (replace control valve body assembly). *tw
Bulletin:
577106A
Component:
105300 power train:driveline:driveshaft
Summary:
Cold start rattle noise (diagnosis/service procedure). *tw
Bulletin:
733301
Component:
021000 suspension:front
Summary:
Squawk noise coming from front suspension or engine compartment area (install ultra high molecular tape). *tw
Bulletin:
676305
Component:
183000 vehicle speed control:cables
Summary:
Difficult to depress accelerator pedal and/or accelerator cable separation (install accelerator cable and clip). *tw
Bulletin:
776109
Component:
061000 engine and engine cooling:engine
Summary:
Engine stall at cold start, rough idle, oil filter expansion, high oil pressure and engine misfire dtc's (replace oil pump with improved press relief valve bore). *tw
Bulletin:
549001A
Component:
353400 equipment:electrical:radio/tape deck/cd etc.
Summary:
Cln indicator appears on radio display and does not turn off (reset cln indicator with the eject button on tape). *tw
Bulletin:
970501776109
Component:
061000 engine and engine cooling:engine
Summary:
Exhibiting diagnostic trouble codes p0300, p0301, p0302, p0303, and p0304 indicating engine misfire conditions. *yc
Bulletin:
971101731616
Component:
220000 seats
Summary:
Comments that the seat belt latch slides to the seat belt anchor sleeve. *yc
Bulletin:
971101631041
Component:
162300 structure:body:door
Summary:
Comments on inoperative power door locks (front and/or rear doors).
Bulletin:
971101776304
Component:
073000 fuel system, gasoline:fuel injection system
Summary:
Subject pertaining to driveability symptoms due to fuel injector deposits. *yc
Bulletin:
971101733209
Component:
011000 steering:wheel and handle bar
Summary:
Experiencing a squeak/squawk noise coming from the bottom of the steering column. *yc
Bulletin:
9709015015A
Component:
036000 service brakes, hydraulic:antilock
Summary:
Complaints that the abs indicator lamp is "on". *yc
Bulletin:
970801676305
Component:
180000 vehicle speed control
Summary:
Some vehicles experience difficulties to depress accelerator pedal and/or an accelerator cable separation. *yc
Bulletin:
970801735026
Component:
036000 service brakes, hydraulic:antilock
Summary:
Comment that the abs light is on with diagnostic trouble codes (dtc's) 46 and 86 set as current or history. *yc
Bulletin:
98776304A
Component:
073200 fuel system, gasoline:fuel injection system:injectors
Summary:
Some vehicles may experience a driveability symptom of long or hard starts, chuggle, rough idle and light or intermittent misfire. *yc
Bulletin:
98731616A
Component:
220000 seats
Summary:
Seat belt latch slides to seat belt anchor sleeve. *yc
Bulletin:
98776514A
Component:
980000 unknown or other
Summary:
Some vehicles may experience a mil (malfunction indicator lamp) light illuminated on the vehicle's instrument panel. *yc
Bulletin:
98836416
Component:
111000 electrical system:battery
Summary:
Conditions regarding weak or discharged battery, slow starting, gen or mil lamp on, various driveability symptoms. *yc
Bulletin:
98576124A
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Comments on a ticking type noise that begins shortly after cold engine start-up and gradually diminishes as the engine warms up. *yc
Bulletin:
833208
Component:
010000 steering
Summary:
Some customers may comment about a squeak/ squawk type noise coming from the steering column area when turning the steering wheel. *yc
Bulletin:
831704
Component:
162000 structure:body
Summary:
Concerns of door handles on white painted vehicles truning yellow. *yc
Bulletin:
990604005
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Some owners may experience a driveability symptom of long or hard starts, chuggle, rough idle and light or intermittent misfire. *tt
Bulletin:
990730030
Component:
106000 power train:axle assembly
Summary:
Some vehicles equipped with hydra-matic 3t40, 4t60 or 4t60-e transxales may comment on a grinding and / or growling noise that is noticeable when in park on incline. *tt
Bulletin:
000524001
Component:
034000 service brakes, hydraulic:foundation components
Summary:
Information regarding snow intrusion into rear drum brake assemblies. **mr
Bulletin:
876002A
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Some v6 engines may, on a very infrequent basis, have an oil odor condition that is generally encountered after the engine's oil has been changed.typically the odor lasts approximately 1000 miles after the change of oil and then does not re
Bulletin:
990604005A
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Some owners may comment on driveability symptons of long or hard starts, chuggle, rough idle and light or intermittent misfire due to clogged fuel injectors. *tt
Bulletin:
990730030A
Component:
106000 power train:axle assembly
Summary:
Owners of some vehicles equipped with hydra-matic 3t40, 4t60, 4t60-e or 4t65-e transaxles may comment on a grinding and / or growling noise that is noticeable when standing in park on a hill or slope with the engine running and the parking
Bulletin:
010601010A
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Subject regarding polymer service pistons. *tt
Bulletin:
000089008A
Component:
980000 unknown or other
Summary:
Some customers may want to tow their vehicle behind another vehicle with all four tires ont he ground. this bulletin provides information regarding recreational (dinghy) towing for certain vehicles including the 1996 through 2000 toyota c
Bulletin:
010602012
Component:
062000 engine and engine cooling:cooling system
Summary:
Some owners may comment on leakage of a few drops of coolant after parking their vehicle. *tt
Bulletin:
010849020
Component:
116000 electrical system:ignition
Summary:
Subject regarding revised ignition lock cylinder or ignition switch assembly replacement. *slc
Bulletin:
020601014
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Subject regarding revised lower intake manifold installation. *tt
Bulletin:
010601002A
Component:
061000 engine and engine cooling:engine
Summary:
Revised piston pin removal / installation procedure. *tt
Bulletin:
000089008B
Component:
980000 unknown or other
Summary:
Some customers may want to tow their vehicle behind another vehicle with all four tires ont he ground. this bulletin provides information regarding recreational (dinghy) towing for certain vehicles including 1988-2004 chevrolet and gmc li
Bulletin:
000089008E
Component:
980000 unknown or other
Summary:
Some customers may want to tow their vehicle behind another vehicle with all four tires ont he ground. this bulletin provides information regarding recreational (dinghy) towing for certain vehicles including 1988-2004 chevrolet and gmc li
Bulletin:
00966B
Component:
046300 service brakes, air:antilock:wheel speed sensor
Summary:
Abs front wheel speed codes - jumper harness. *tt
Bulletin:
00966
Component:
046300 service brakes, air:antilock:wheel speed sensor
Summary:
Anti-lock braking system (abs) front wheel speed codes - jumper harness. *tt
Bulletin:
04152004
Component:
046300 service brakes, air:antilock:wheel speed sensor
Summary:
Vehicles may set anyone or a combination of front-wheel speed sensor anti-lock brake system codes as intermittent or hard failures. gm voicemail express. *tt
Bulletin:
3447
Component:
100000 power train
Summary:
4t40e or 4t45e will not shift no diagnostic trouble codes. *tt
Bulletin:
4615
Component:
040000 service brakes, air
Summary:
Abs pump running when not needed. *nj
Bulletin:
16NA260
Component:
353400 equipment:electrical:radio/tape deck/cd etc.
Summary:
This technical bulletin provides a procedure to reprogram the media disc player with the latest calibrations to correct a condition of the rear entertainment system not operating as intended in colder ambient temperature areas due to calibr
Bulletin:
PIP4723B
Component:
118000 electrical system: software
Summary:
This preliminary information communicates to the dealer the process for downloading or updating operating software for the tire pressure monitor, active fuel injector tester, multi media tester, pico scope, gr8 starting/charging tester and
Bulletin:
PIC4696A
Component:
353100 equipment:electrical:anti-theft devices
Summary:
This preliminary information communication provides information to the technician on how to unlock radios that are delco theftlock. technician will use the radio to get the scrambled code. technician will need to contact the radio unlock ce
Bulletin:
PIC4696B
Component:
353100 equipment:electrical:anti-theft devices
Summary:
This preliminary information communication provides information to the technician on how to unlock radios that are delco theftlock. technician will use the radio to get the scrambled code. technician will need to contact the radio unlock ce
Bulletin:
05-06-04-035D
Component:
070000 fuel system, gasoline
Summary:
This informational bulletin provides the technician with information on what e85 fuel may due to a non e85 vehicle.
Bulletin:
PIC4696C
Component:
150000 seat belts
Summary:
This preliminary information communication provides information to the technician on how to unlock radios that are delco theftlock. technician will use the radio to get the scrambled code. technician will need to contact the radio unlock ce

Home | Privacy