1997 FORD L SERIES TSBs (33)
- Bulletin:
- BC0813961011
- Component:
- 180000 vehicle speed control
- Summary:
- Throttle position sensor &/or idle validation switch fails, in may generate ecm service codes or driveability concerns. a revised one piece sensor & switch is now available. *tt
- Bulletin:
- BC0465961115
- Component:
- 220000 seats
- Summary:
- Driver may experience a side to side movement or wobble of the seat. *tw
- Bulletin:
- BC0480961113
- Component:
- 022132 suspension:rear:springs:air suspension system:springs/bags
- Summary:
- Replacement leveling valve extention rod for hendrickson air-ride suspension. *tw
- Bulletin:
- BC0601961101
- Component:
- 102000 power train:manual transmission
- Summary:
- Many manual transmissions that are replaced/repaired under warranty and returned to the wprc show signs of improper/lack of maintenance or misdiagnosis. *tw
- Bulletin:
- BC0604961101
- Component:
- 073100 fuel system, gasoline:fuel injection system:fuel rail
- Summary:
- New fuel hose to replace the hose used in the low pressure fuel return system - the current hose may show sighn of deterioation or cracks. *tw
- Bulletin:
- BC0018961101
- Component:
- 220000 seats
- Summary:
- On l series equipped with cush-n-air seats, the driver may experience a side to side movement or wobble of the seat due to inadequate welds. *tw
- Bulletin:
- 96246
- Component:
- 114000 electrical system:wiring
- Summary:
- Wiring - electrical diode identification and service replacements. *tw
- Bulletin:
- 962217
- Component:
- 180000 vehicle speed control
- Summary:
- Engine - will not accelerate above idle speed - vehicles equipped with cummins m11, n14 or detroit diesel series 60 engine. *tw
- Bulletin:
- 962218
- Component:
- 113000 electrical system:starter assembly
- Summary:
- Starter - starter does not engage and/or starter may cycle (engage-disengage-engage) while cranking - vehicles equipped with an fd engine and an allison md3000 transmission built through 8/1/96, *tw
- Bulletin:
- BC0193970201
- Component:
- 061200 engine and engine cooling:engine:diesel
- Summary:
- Revised fan assemblies for premium diesel engines are now available. *jd
- Bulletin:
- 97115
- Component:
- 980000 unknown or other
- Summary:
- Service manual- powertrain control/emissions diagnosis (pc/ed) on-board diagnosis ii (obd ii)- cover page replacement to include 1997 vehicles with fd1060 or fd1460 engine. *jd
- Bulletin:
- 97117
- Component:
- 062100 engine and engine cooling:cooling system:radiator assembly
- Summary:
- Heater- lack of heat in passenger compartment- vehicles equipped with fd1060 engine- cooling system- engine does not reach operating temperature- vehicles equipped with fd1060 engine. *jd
- Bulletin:
- 97118
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Engine- fd1060 or fd1460- high vibration at low engine rpm- vibration- high- at low engine rpm- vehicles with fd1060 or fd1460 engine. *jd
- Bulletin:
- BC3505972301
- Component:
- 072100 fuel system, gasoline:delivery:fuel pump
- Summary:
- The fuel shutoff solenoid on the p-7100 pump. *jd
- Bulletin:
- BC1018797230
- Component:
- 072100 fuel system, gasoline:delivery:fuel pump
- Summary:
- Diagnose the fuel shutoff solenoid on the p-7100 pump. *jd
- Bulletin:
- 97315
- Component:
- 113000 electrical system:starter assembly
- Summary:
- No start- starter will not turn engine over- vehicles with fd1060 engine. *jd
- Bulletin:
- 97411
- Component:
- 061110 engine and engine cooling:engine:gasoline:belts and associated pulleys
- Summary:
- Fead belt- high wear and/or comes off of the drive pulley- vehicles built from 4/1/92 through 6/1/96 with fd1060 engine. *jd
- Bulletin:
- 97412
- Component:
- 062200 engine and engine cooling:cooling system:fan
- Summary:
- Cooling system- engine cooling fan cracks at center hub. *jd
- Bulletin:
- BC3201970214
- Component:
- 021230 suspension:front:springs:air suspension system
- Summary:
- Hendrickson air ride suspension with transverse mounted torque rods- the flat washers used on the rod to axle attatching bolt may deform. *tw
- Bulletin:
- BC3236970211
- Component:
- 113000 electrical system:starter assembly
- Summary:
- Fd 1060 engines - new design starter motor to alleviate hard start/no start concerns in cold ambients. *tw
- Bulletin:
- 97716
- Component:
- 061200 engine and engine cooling:engine:diesel
- Summary:
- Fuel injection pump- bosch- service information for fd1060/1460 diesel engines. *jd
- Bulletin:
- 97517
- Component:
- 061200 engine and engine cooling:engine:diesel
- Summary:
- Engine- diesel- fd1060 and fd1460- white smoke from exhaust- service tip. *jd
- Bulletin:
- 97630
- Component:
- 063140 engine and engine cooling:exhaust system:emission control:catalytic convertor
- Summary:
- Hard starting- possible plugged catalytic converter/muffler (ccm)- vehicles built after 11/29/93 equipped with 1994 emission level fd1060 or fd1460 diesel engine. *jd
- Bulletin:
- BC2312970501
- Component:
- 180000 vehicle speed control
- Summary:
- New throttle cable to reduce vibration atthe accelerator pedal. *tw
- Bulletin:
- 970902971817
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Some electronically controlled diesel engines can be modified to increase engine output by altering the original engine management system. *yc
- Bulletin:
- 9833
- Component:
- 162000 structure:body
- Summary:
- Service tips for surface defect removal without repainting. *yc
- Bulletin:
- 9852
- Component:
- 190000 tires
- Summary:
- Information on tire company telephone numbers for customer assistance. *yc
- Bulletin:
- 98214
- Component:
- 162800 structure:body:hood
- Summary:
- Concerns of air cleaner cover may rub a hole in the hood at the front edge of the air cleaner inlet " wagon wheel " on some vehicles. *yc
- Bulletin:
- 991413
- Component:
- 181000 vehicle speed control:accelerator pedal
- Summary:
- Vehicles equipped with fd1060 or fd1460 midrange diesel engines may experience a vibration or buzz through the throttle pedal. *tt
- Bulletin:
- 99205
- Component:
- 020000 suspension
- Summary:
- Subject regarding vehicle lean correction procedure. *tt
- Bulletin:
- 99196
- Component:
- 353600 equipment:air conditioner
- Summary:
- Information on identifying non-approved / alternate refrigerants which could cause safety, and performance concerns if installed in ford a/c systems. *tt
- Bulletin:
- 12116
- Component:
- 061100 engine and engine cooling:engine:gasoline
- Summary:
- Information on servicing the air cleaner element on all 1995- 1996-1997 l-series equipped with cat 3306 engines. *mjs
- Bulletin:
- 02169
- Component:
- 020000 suspension
- Summary:
- Subject regarding vehicle lean correction procedure developed for diagnosing and correcting vehicle lean. *tt
Home | Privacy