1997 FORD F-250 Recalls (14)
- Campaign:
- 96V161000 on 09/02/1996
- Component:
- Equipment:other:labels
- Manufactured:
- 12/14/1995 - 03/10/1996
- Affected:
- 134,770
- Defect:
- The certification labels on the involved vehicles has incorrect rear tire inflation pressure designations. this does not comply with fmvss no. 120, "tire selection and rims for motor vehicles other than passenger cars."
- Consequence:
- Incorrect inflation pressures could cause premature wear of the rear tires. .
- Correction:
- Owners will be provided with correct certification labels and instructions for installing these labels. dealers can install this label if the owner so desires.
- Notes:
- Owner notification:owner notification is expected to begin october 18, 1996. note:owners who do not receive the correct label within a reasonable time free of charge should contact ford at 1-800-392-3673.also contact the national highway traffic safety administration's auto safety hotline at 1-800-424-9393.
- Campaign:
- 96V184000 on 09/30/1996
- Component:
- Service brakes, hydraulic:foundation components:master cylinder
- Manufactured:
- 08/18/1996 - 08/22/1996
- Affected:
- 1,200
- Defect:
- The retainer clip that holds the master cylinder push rod to the brake pedal arm is missing.
- Consequence:
- A loss of service braking can occur increasing the risk of a vehicle accident.
- Correction:
- Dealers will inspect to verify that the retainer clips are installed and if clips are missing will install clips.
- Notes:
- Owner notification:owner notification occurred september 30, 1996.note:owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact ford at 1-800-392-3673.also contact the national highway traffic safety administration's auto safety hotline at 1-800-424-9393.
- Campaign:
- 97V171000 on 10/09/1997
- Component:
- Power train:automatic transmission:gear position indication (prndl)
- Manufactured:
- 07/21/1996 - 08/21/1997
- Affected:
- 866,000
- Defect:
- Vehicle description: light duty pickup trucks and multi-purpose passenger vehicles. if the automatic transmission shift cable assembly was not fully attached to the steering column bracket, the shift cable assembly can come out of the bracket. the vehicle operator would then not be able to shift the transmission from one of the drive gear positions into the park position even though the gear shift selector would indicate "park."
- Consequence:
- The condition would not allow a disengagement of the transmission from the park position or affect proper neutral start switch operation. unintended vehicle movement could occur if the parking brake was not set.
- Correction:
- Dealers will make the proper attachment of the transmission shift control cable to the steering column bracket and add a tie strap to that connection.
- Notes:
- Owner notification is expected to begin october 20, 1997.owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact ford at 1-800-392-3673.also contact the national highway traffic safety administration's auto safety hotline at 1-800-424-9393.
- Campaign:
- 97V187000 on 10/29/1997
- Component:
- Tires:bead
- Manufactured:
- 08/31/1996 - 07/16/1997
- Affected:
- 31,600
- Defect:
- Vehicle description: light duty pickup trucks and chassis. the tires on these vehicles were damaged during mounting onto the wheels. only trucks produced at the cuautitlan, mexico plant between september 1, 1996, and july 17, 1997, were affected by the defect.
- Consequence:
- The bead area of the tire was cut which could result in air loss. sudden air loss could occur resulting in a loss of vehicle control.
- Correction:
- Due to the age of the vehicles and this recall affecting original equipment tires only, ford will no longer accept claims for this campaign.
- Notes:
- Ford recall no. 97s90.owner notification began december 1, 1997.owners who take their vehicles to a firestone dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact firestone at 1-800-457-6281.also contact the national highway traffic safety administration's auto safety hotline at 1-800-424-9393.
- Campaign:
- 98V095000 on 05/12/1998
- Component:
- Wheels:lugs/nuts/bolts
- Manufactured:
- 11/30/1995 - 04/13/1998
- Affected:
- 1,520,000
- Defect:
- Vehicle description: multi-purpose vehicles and light duty pickup trucks. the lug nuts on these vehicles may not create sufficient clamp load allowing wheel movement in relation to the hub/rotor mounting surface.
- Consequence:
- This can result in the loosening of lug nuts, stud fatigue failure, and the potential for a wheel separation from the vehicle, increasing the risk of a vehicle crash.
- Correction:
- Owners of these vehicles will be receiving two notifications. the first notification, which began in may 1998, will provide an interim repair procedure until parts become available. this interim procedure can be completed by owners or their dealers. it specifies that the lug nut torque must be verified to be 100 lbs. then the lug nuts need to be tightened an additional 1/8 to 1/4 turn more. there will be a second owner notification, which is expected to begin july 20, 1998, under which dealers will inspect the wheel studs and replace the wheel lug nuts.
- Notes:
- Owners will be receiving two notifications.the first notification, which began in may 1998, will provide an interim repair procedure. there will be a second owner notification, which is expected to begin july 20, 1998.owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact ford at 1-800-392-3673.also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
- Campaign:
- 00V231000 on 08/22/2000
- Component:
- Fuel system, gasoline:delivery:hoses, lines/piping, and fittings
- Manufactured:
- 10/31/1995 - 08/30/1997
- Affected:
- 670,509
- Defect:
- Vehicle description: light duty pickup trucks manufactured at the kansas city or norfolk assembly plants. the front fuel line assembly could have a hole rubbed through in one of two locations. the first location is below the fuel rail connection where the flexible hose is crimped to the steel tube. the bracket that attaches the front fuel line to the transmission could have been bent during assembly. the second location is at the rear steel tube section forward of the rear bracket. during installation the rear steel tubes of the front fuel line assembly could have been bent downward. in vehicles equipped with a manual 4xz4 transfer case shifter, the shifter linkage may contact the steel tubes as it is being shifted between 4h, 4l, 2l and neutral.
- Consequence:
- This condition could result in fuel leakage. fuel leakage in the presence of an ignition source could result in a fire.
- Correction:
- Dealers will inspect these lines and replace the front fuel line assembly if necessary. owner notification began october 27, 2000. owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact ford at 1-800-392-3673.
- Notes:
- Also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
- Campaign:
- 01X001000 on 05/21/2001
- Component:
- Tires:tread/belt
- Affected:
- 13,000,000
- Defect:
- This is not a safety recall in accordance with the safety act. however, it is deemed a safety improvement campaign by the agency. equipment description: ford is replacing all firestone wilderness at 15, 16, and 17 inch tires mounted on ford trucks and suvs. ford reports tread separation can occur due to a combination of the sensitivity of the tire design to stress, aging, and manufacturing differences between plants. ford is replacing these tires to prevent possible premature tire failure. vehicle description: the vehicles listed below may have been originally equipped with firestone wilderness at tires or may have had wilderness at tires installed during the firestone recall launched in august 2000. certain 1991 throught 2002 ford explorer certain 2001 throught 2002 explorer sport, and sport trac certain 1997 through 2002 mercury mountaineer certain 1991 through 2001 ranger certain 1999 through 2001 expedition certain 1991 through 1994, and 1997 model year f-series certain 1991 through 1994 bronco note: both original equipment and replacement tires are affected.
- Consequence:
- Should the tread separate at highway speeds, a vehicle crash could occur, possibly resulting in personal injury or death.
- Correction:
- The replacement/reimbursement program for this campaign expired on march 31, 2002. however, customers can contact ford at 1-877-917-3673 or go on-line to www.ford.com for possible assistance.
- Campaign:
- 03V196000 on 06/02/2003
- Component:
- Steering:gear box:shaft sector
- Manufactured:
- 02/29/1996 - 09/29/1996
- Affected:
- 171,446
- Defect:
- On certain pickup trucks and sport utility vehicles, if the intermediate shaft yoke separates from the steering gear input shaft, the steering system becomes disconnected.
- Consequence:
- This could result in loss of steering control, potentially resulting in a vehicle crash without warning.
- Correction:
- Dealers will inspect the steering intermediate shaft yoke to determine if the yoke is fully seated on the steering gear input shaft. if the yoke is fully seated no service is required. if the yoke is not fully seated and bolt groove and spline is visible, the intermediate shaft and bolt will be replaced as well as the bolt at the steering column connection. owner notification began on may 30, 2003. owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact ford at 1-800-392-3673.
- Notes:
- Ford recall no. 03s02.customers can also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
- Campaign:
- 05V388000 on 09/06/2005
- Component:
- Vehicle speed control
- Affected:
- 4,500,000
- Defect:
- On certain pickup trucks and sport utility vehicles equipped with speed control, the speed control deactivation switch may overheat, smoke, or burn.
- Consequence:
- A fire at the switch could occur.
- Correction:
- By letter dated september 12, 2005, owners were instructed to return their vehicles to their dealers to have the speed control deactivation switch disconnected. owners who have had their speed control deactivated are being notified that parts will be available and advised to make an appointment to reconnect the speed control beginning in february 2006. owners who did not have their speed control deactivated are being notified to have their system remedied beginning in february 2006. owners are urged to avail themselves of the free disconnect service as soon as possible because of the significant risk of fire. owners may contact ford at 1-800-392-3673. (note: also see recalls 05v017 and 06v286)
- Notes:
- Ford recall no. 05s28.customers may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov.
- Campaign:
- 06E052000 on 06/11/2006
- Component:
- Exterior lighting:headlights
- Affected:
- 14,616
- Defect:
- Certain eagle eyes headlamps, p/nos. fr208-b101r, fr208-b101l, fr208-b001r, and fr208-b001l, sold for use as replacement equipment for the passenger vehicles listed above. these headlamps fail to conform to the photometric requirements of federal motor vehicle safety standard no. 108, lamps, reflective devices, and associated equipment.
- Consequence:
- Decreased lighting visibility may result in a vehicle crash.
- Correction:
- Sabry lee will notify owners and offer full credit for any noncompliant headlamp. the recall is expected to begin on june 14, 2006. owners may contact sabry lee account executive at 1-866-467-2279.
- Notes:
- This recall only pertains to aftermarket replacement equipment and has no relation to any original equipment installed on vehicles manufactured by the ford motor company.customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov.
- Campaign:
- 06E067000 on 07/31/2006
- Component:
- Exterior lighting:headlights
- Affected:
- 19,413
- Defect:
- Certain maxzone headlight assemblies, depo brand, p/nos. 331-1129l-asn and 331-1129r-asn, sold for use as aftermarket equipment for the above listed passenger vehicles. these headlamps fail to conform to the photometric requirements of federal motor vehicle safety standard no. 108, lamps, reflective devices, and associated equipment.
- Consequence:
- Decreased lighting visibility may result in a vehicle crash.
- Correction:
- Maxzone will notify owners and offer reimbursement for any noncompliant headlights. the recall began on july 28, 2006. owners may contact maxzone at 909-822-3288.
- Notes:
- This recall only pertains to aftermarket replacement equipment and has no relation to any original equipment installed on vehicles manufactured by ford motor company.customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov.
- Campaign:
- 06V286000 on 08/01/2006
- Component:
- Vehicle speed control
- Affected:
- 1,200,000
- Defect:
- On certain trucks equipped with speed control, gasoline or natural gas engines, the speed control deactivation switch may overheat.
- Consequence:
- Overheating could result in smoke or burn and an underhood fire.
- Correction:
- Dealers will install a fused wiring harness into the speed control system free of charge. the recall began on august 7, 2006. owners may contact ford at 1-866-436-7332. (note: also see recalls 05v017 and 05v388)
- Notes:
- Ford recall no. 05s28.customers may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov.
- Campaign:
- 07E066000 on 08/28/2007
- Component:
- Equipment:electrical
- Affected:
- 175
- Defect:
- Certain cequent 90 degree 7-way right angle adaptors sold by distributors in tow packages for aftermarket sales to tow 5th wheel rv travel trailers. due to incorrect wiring of the harness, the trailer lights may not operate properly.
- Consequence:
- If the trailer lights are not working properly, a vehicle crash can occur.
- Correction:
- All of the defective tow packages are still at the distributor level and have not been sold to any consumers.
- Notes:
- This recall only pertains to aftermarket cequent tow packages and has no relation to any original equipment installed on daimlerchrysler, gmc, or ford vehicles.customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov.
- Campaign:
- 11V385000 on 07/31/2011
- Component:
- Fuel system, gasoline:storage:tank assembly:mounting
- Manufactured:
- 06/19/1995 - 08/03/2004
- Affected:
- 1,100,000
- Defect:
- Ford is recalling certain 1997 through 2003 model year ford f-150, 2004 model year ford f-150 heritage, 1997 through 1999 model year f-250 less than 8,500 lbs. gross vehicle weight rating (gvwr), and 2002 and 2003 lincoln blackwood vehicles manufactured from june 20, 1995, through august 4, 2004, originally sold, or currently registered in, connecticut, delaware, illinois, indiana, iowa, kentucky, maine, maryland, massachusetts, michigan, minnesota, missouri, new hampshire, new jersey, new york, ohio, pennsylvania, rhode island, vermont, west virginia, wisconsin, and the district of columbia. prolonged exposure to road deicing chemicals may cause severe corrosion of the fuel tank straps which secure the tank to the vehicle.
- Consequence:
- As a result of the corrosion, one or both straps may fail allowing the fuel lines to separate from the tank, or in some cases, causing the tank to contact the ground. either scenario may result in a fuel leak presenting a fire hazard.
- Correction:
- Ford will notify owners and instruct them to take their vehicles to a ford or lincoln dealer to have the fuel tank straps replaced with straps that have increased corrosion protection. early in this campaign, if replacement straps are not available, dealers may install a cable support under the strap as an interim repair or a steel reinforcement over the existing strap as a permanent repair. any repairs will be performed free of charge. the safety recall began on september 16, 2011. owners may contact ford motor company customer relationship center at 1-866-436-7332. ford's recall campaign number is 11s21
- Notes:
- Ford's recall campaign number is 11s21.owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to <a href=http://www.safercar.gov>http://www.safercar.gov</a> .
1997 FORD F-250 TSBs (314)
- Bulletin:
- BC0676961025
- Component:
- 036000 service brakes, hydraulic:antilock
- Summary:
- Information when electronic/hydraulic control unit (ehcu) malfunctions. *tt
- Bulletin:
- BC0693961023
- Component:
- 185000 vehicle speed control:cruise control
- Summary:
- Investigating 7.3l irregular idle. *tt
- Bulletin:
- BC0694961023
- Component:
- 102000 power train:manual transmission
- Summary:
- Information for recreational towing (all wheels on the ground). *tt
- Bulletin:
- BC0696961023
- Component:
- 116000 electrical system:ignition
- Summary:
- Concerns of check engine light (mil) w/ codes p0300 thru p0308 & eng runes rough/misses. *tt
- Bulletin:
- BC0697961023
- Component:
- 162300 structure:body:door
- Summary:
- Windnoise concerns in the right door a-pillar area of the supercab. *tt
- Bulletin:
- BC0750961017
- Component:
- 072100 fuel system, gasoline:delivery:fuel pump
- Summary:
- Spade terminal between sender & fuel pump has been changed to a eyelet terminal. *tt
- Bulletin:
- BC0753961017
- Component:
- 102000 power train:manual transmission
- Summary:
- 4x4 vehicles may exhibit a grinding noise while shifting into 4l. *tt
- Bulletin:
- BC0782961014
- Component:
- 061100 engine and engine cooling:engine:gasoline
- Summary:
- Concerns of check engine light 'on'. *tt
- Bulletin:
- BC0823961010
- Component:
- 103400 power train:automatic transmission:lever and linkage:column shift
- Summary:
- Concern of water entry into the transfer case. *tt
- Bulletin:
- BC0841961008
- Component:
- 136000 visibility:windshield wiper/washer
- Summary:
- Concerns of windshield wiper not cleaning, streaking or smearing. *tt
- Bulletin:
- BC0844961008
- Component:
- 102000 power train:manual transmission
- Summary:
- E4od trans may emit a tick/rattle noise when driving at light loads in 1st gear at 1100 to 1800 rpm rpm. *tt
- Bulletin:
- BC0854961007
- Component:
- 138120 visibility:defroster/defogger system:windshield:heater core
- Summary:
- Reattachment of heater hose fittings for concern of no heat, overheat, or coolant loss may occur due to heater hoses not properly connected at their quick-connect fittings. *tt
- Bulletin:
- BC0883961004
- Component:
- 063200 engine and engine cooling:exhaust system:manifold/header/muffler/tail pipe
- Summary:
- Vehicles may exhibit an exhaust leak &/or noise due to warped exhaust manifolds. *tt
- Bulletin:
- BC0884961004
- Component:
- 073200 fuel system, gasoline:fuel injection system:injectors
- Summary:
- For misfire concerns on 4.2l/4.6l/5.4l/6.8l engines. *tt
- Bulletin:
- BC5168961001
- Component:
- 103400 power train:automatic transmission:lever and linkage:column shift
- Summary:
- Procedure for resolving the concern of water entry into the transfer case. *tt
- Bulletin:
- BC5195961001
- Component:
- 190000 tires
- Summary:
- Firestone p235 tires may exhibit a high frequency vibration at 65-75 mph. *tt
- Bulletin:
- BC5197961001
- Component:
- 106000 power train:axle assembly
- Summary:
- Some vehicles equipped w/ an ax4s transaxle may have been shipped w/ a low transaxle fluid level. *tt
- Bulletin:
- BC5201961001
- Component:
- 185000 vehicle speed control:cruise control
- Summary:
- Investigating 7.3l irregular idle. *tt
- Bulletin:
- BC0315961101
- Component:
- 061110 engine and engine cooling:engine:gasoline:belts and associated pulleys
- Summary:
- Fead belt squeal, cold only. *tw
- Bulletin:
- BC0321961101
- Component:
- 021000 suspension:front
- Summary:
- Pop/clunk from steering linkage over bumps. *tw
- Bulletin:
- BC0340961127
- Component:
- 116200 electrical system:ignition:module
- Summary:
- Certain 1997 vehciles may have been built with the 240 second misfire delay. *tw
- Bulletin:
- 96246
- Component:
- 114000 electrical system:wiring
- Summary:
- Wiring - electrical diode identification and service replacements. *tw
- Bulletin:
- 96249
- Component:
- 103700 power train:automatic transmission:torque converter
- Summary:
- Torque converter - leak test procedure - service tip. *tw
- Bulletin:
- 962410
- Component:
- 103000 power train:automatic transmission
- Summary:
- Transmission - e40d - 4r70w - 4r44e - 5r55e - new digital transmission range sensor - diagnosis service tip. *tw
- Bulletin:
- 962412
- Component:
- 051120 parking brake:conventional:mechanical:linkage and cable
- Summary:
- Brakes - rear parking brake cable binds - vehicles built before 8/20/96 - all chassis cab vehicles are excluded. *tw
- Bulletin:
- 962418
- Component:
- 103000 power train:automatic transmission
- Summary:
- Transmission - e40d - revised design forward planet thrust washer - service tip. *tw
- Bulletin:
- 96221
- Component:
- 131000 visibility:windshield
- Summary:
- Windshield and interior glass - fog/film. *tw
- Bulletin:
- 96222
- Component:
- 034000 service brakes, hydraulic:foundation components
- Summary:
- Brakes - elimination of sanding rotors and drums - service tip. *tw
- Bulletin:
- 96226
- Component:
- 353600 equipment:air conditioner
- Summary:
- Air conditioning - compressor failure - insufficient amount of refrigerant oil. *tw
- Bulletin:
- 962213
- Component:
- 063200 engine and engine cooling:exhaust system:manifold/header/muffler/tail pipe
- Summary:
- Exhaust - exhaust leak at exhaust manifolds - vehicles equipped with 7.0l or 7.5l engine. *tw
- Bulletin:
- 96252
- Component:
- 171100 latches/locks/linkages:doors:latch
- Summary:
- Locks - replace and/or repair any lock component - service tip. *tw
- Bulletin:
- 962511
- Component:
- 116200 electrical system:ignition:module
- Summary:
- Powertrain control module -reprogram powertrain control module (pcm) - service procedures - service tip. *tw
- Bulletin:
- 962518
- Component:
- 980000 unknown or other
- Summary:
- Door - power point access door breaks - vehicles built through 8/31/96. *tw
- Bulletin:
- 962521
- Component:
- 011000 steering:wheel and handle bar
- Summary:
- Steering - clunk noise from steering column on accelerating and braking. *tw
- Bulletin:
- 962525
- Component:
- 980000 unknown or other
- Summary:
- Noise - rattle - summary of concerns - service tips. *tw
- Bulletin:
- 962612
- Component:
- 103700 power train:automatic transmission:torque converter
- Summary:
- Transaxle - torque converter replacement guidelines and torque converter/transaxle cooling system cleaning procedures - service tip. *tw
- Bulletin:
- BC0053970201
- Component:
- 103000 power train:automatic transmission
- Summary:
- Some 1995 and all 1996 and 1997 vehicles with e40d transmissions have been built with a reusable elastomeric transmission fluid pan gasket. *jd
- Bulletin:
- BC0120970201
- Component:
- 131000 visibility:windshield
- Summary:
- Diagnosis windnoise at the inner belt, raise door glass to full up position. *jd
- Bulletin:
- BC0121970201
- Component:
- 104000 power train:transfer case (4-wheel drive)
- Summary:
- Driveline rattle over bumps. *jd
- Bulletin:
- BC0124970201
- Component:
- 071000 fuel system, gasoline:storage
- Summary:
- For customer concerns of stall, rough idle, lacks power, poor fuel economy, backfire, surge under heavy acceleration, loss in fuel pressure under acceleration of excessive fuel pressure. *jd
- Bulletin:
- BC0256970201
- Component:
- 061100 engine and engine cooling:engine:gasoline
- Summary:
- A running change for the 7.3l to allow better definition on cylinder contribution tests in process. *jd
- Bulletin:
- BC0315970201
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Fead belt squeal, cold only. revised belt released. *jd
- Bulletin:
- BC0321970201
- Component:
- 017500 steering:linkages:tie rod assembly
- Summary:
- Pop/clunk from steering linkage over bumps. *jd
- Bulletin:
- BC0345970201
- Component:
- 980000 unknown or other
- Summary:
- Driveline clunk, 4.2l backfire, 4.6l lack of power, 4.6l misfire/mil light issues, and windnoise. *jd
- Bulletin:
- BC1012897020
- Component:
- 131000 visibility:windshield
- Summary:
- Wind noise at the inner belt, raise door glass to full up position. *jd
- Bulletin:
- BC1012997020
- Component:
- 104000 power train:transfer case (4-wheel drive)
- Summary:
- Driveline rattle over bumps. *jd
- Bulletin:
- BC1013297020
- Component:
- 071000 fuel system, gasoline:storage
- Summary:
- Stall, rough idle, lacks power, poor fuel economy, backfire, surge under heavy acceleration, loss in fuel pressure under acceleration or excessive fuel pressure and/or mil activation with dtcs. *jd
- Bulletin:
- BC1015397020
- Component:
- 103000 power train:automatic transmission
- Summary:
- Vehicles with e4od transmissions have been built with a reusable elastomeric transmission fluid pan gasket. *jd
- Bulletin:
- 97113
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- An engine vibration and/or "moaning" noise at 2600-3000 rpm may occur on some vehicles. *jd
- Bulletin:
- 97214
- Component:
- 980000 unknown or other
- Summary:
- Engine - 7.3l dit - glow plug start-up on-time during cold temperature - service tip. *tw
- Bulletin:
- 97215
- Component:
- 980000 unknown or other
- Summary:
- Diagnostic guides for out-of-warranty vehicles to be used as a master copy - diagnostic guides no longer available from adistra. *tw
- Bulletin:
- 97216
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Leak - oil leakat engine valley pan and/or high pressure oil pump - vehicles equipped with 7.3l diesel engine. *tw
- Bulletin:
- BC0053972301
- Component:
- 104000 power train:transfer case (4-wheel drive)
- Summary:
- Some 1995 and all 1996 and 1997 vehicles with e4od transmissions have been built with a reusable elastomeric transmission fluid pan gasket. *jd
- Bulletin:
- BC0056972301
- Component:
- 061110 engine and engine cooling:engine:gasoline:belts and associated pulleys
- Summary:
- Some vehicles with air conditioning can exhibit a cold start accessory drive belt noise (chirp) concern. *jd
- Bulletin:
- BC0321972301
- Component:
- 017100 steering:linkages:link:drag:connection
- Summary:
- Pop/clunk from steering linkage over bumps. *jd
- Bulletin:
- BC0325972301
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Some 5.4l front end serpetntine belts may make some noise between temperatures fo 30 f-50 f. *jd
- Bulletin:
- BC3363972301
- Component:
- 116200 electrical system:ignition:module
- Summary:
- The ngs displays incorrect date for the ing gem pid on the vehicles. *jd
- Bulletin:
- BC3440972301
- Component:
- 980000 unknown or other
- Summary:
- Availablity of the sbds "red disc" with improvements to 7.3l/e40d 2-3 shift quality and enhanced apcm functioning has been delayed. *jd
- Bulletin:
- BC3443972301
- Component:
- 980000 unknown or other
- Summary:
- Second printing of the 1997 owners guide states that the vehicles long wheelbase may have a snowplow installed- this is incorrect. *jd
- Bulletin:
- BC3510972301
- Component:
- 063130 engine and engine cooling:exhaust system:emission control:gas recirculation valve (egr valve)
- Summary:
- Check engine light on with dtc p0455 in continuous memory on 1997 5.4l vehicle applications. *jd
- Bulletin:
- BC1020097230
- Component:
- 980000 unknown or other
- Summary:
- The second printing of the 1997 owners guide states that the vehicles 4x4 long wheelbase may have a snowplow installed- this is incorrect. *jd
- Bulletin:
- BC1020897230
- Component:
- 980000 unknown or other
- Summary:
- Availablity of the sbds "red disc" with improvments to 7.3l/e40d 2-3 shift quality and enhanced apcm funtioning has been delayed to late february form the original january 1997 date. *jd
- Bulletin:
- BC1022797230
- Component:
- 116200 electrical system:ignition:module
- Summary:
- The ngs displays incorrect data for the ign gem pid on the vehicles. *jd
- Bulletin:
- 9735
- Component:
- 353600 equipment:air conditioner
- Summary:
- Air conditioning- r-134a tracer dye installed in a/c system and three o-ring spring lock couplers- service tip. *jd
- Bulletin:
- 9747
- Component:
- 160000 structure
- Summary:
- Frame- rivet replacement with bolts- service tips. *jd
- Bulletin:
- BC3090970225
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Vehicles with a rough running/miss symptom with a misfire dtc on a particular cylinder where normal diagnosis does not pinpoint a cause - check for damage to camshaft. *tw
- Bulletin:
- 97410
- Component:
- 103600 power train:automatic transmission:cooling unit and lines
- Summary:
- Transmission- e4od- cooler bypass valve service during transmission overhaul- service tip. *jd
- Bulletin:
- BC3101970224
- Component:
- 034000 service brakes, hydraulic:foundation components
- Summary:
- Soft brake pedal. *tw
- Bulletin:
- BC3130970221
- Component:
- 061200 engine and engine cooling:engine:diesel
- Summary:
- Diesel exhaust smell in passenger cabin may be due to poor connection at the inlet or outlet to/from the turbo. *tw
- Bulletin:
- BC3153970219
- Component:
- 180000 vehicle speed control
- Summary:
- Inoperative or erratic cruise control operation along with harsh transmission shifts. *tw
- Bulletin:
- BC3171970217
- Component:
- 131000 visibility:windshield
- Summary:
- Unexplained glass breakage of the left front door. *tw
- Bulletin:
- BC3212970213
- Component:
- 980000 unknown or other
- Summary:
- Camshaft position sensor information . *tw
- Bulletin:
- BC3241970210
- Component:
- 063200 engine and engine cooling:exhaust system:manifold/header/muffler/tail pipe
- Summary:
- Exhaust leaks or noise at the joint between the y-pipe and the exhaust manifold. *tw
- Bulletin:
- BC3242970210
- Component:
- 105000 power train:driveline
- Summary:
- Driveline clunking or grunting noise. *tw
- Bulletin:
- BC3279970207
- Component:
- 126200 exterior lighting:turn signal:switch
- Summary:
- Concerns with the multi-function switch. *tw
- Bulletin:
- BC3287970206
- Component:
- 101100 power train:clutch assembly:pedal/linkage
- Summary:
- The clutch may be hard to depress due to dust/contamination entering the slave cylinder. *tw
- Bulletin:
- 9778
- Component:
- 121000 exterior lighting:headlights
- Summary:
- Headlamp- headlamp housing melts- ambulance and emergency vehicles only. *jd
- Bulletin:
- 9779
- Component:
- 114100 electrical system:wiring:front underhood
- Summary:
- Wiring- aftermarket wiring alterations- service tip. *jd
- Bulletin:
- 97713
- Component:
- 021230 suspension:front:springs:air suspension system
- Summary:
- Noise- "buzzing"- underhood when air suspension is in operation. *jd
- Bulletin:
- 9751
- Component:
- 220000 seats
- Summary:
- Interior- leather seat cleaning procedure- service tip. *jd
- Bulletin:
- 97511
- Component:
- 103000 power train:automatic transmission
- Summary:
- Fluid- transmission fluid usage charts. *jd
- Bulletin:
- 9768
- Component:
- 980000 unknown or other
- Summary:
- Fuel economy- customer expectations versus vehicle usage. *jd
- Bulletin:
- 97618
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Low rpm- 7.3l dit engine fails to start- code 340 stored in memory and/or engine fails to achieve rated speed for 2-3 minutes after extended cold soak- f-series built through 2/9/96 and all econolines. *jd
- Bulletin:
- 97627
- Component:
- 021700 suspension:front:hub
- Summary:
- Noise- "ratcheting"- front axle- 4x4- self-engagement of automatic hub locks- f-250 and f-350 over 8500# gvw. *jd
- Bulletin:
- 97629
- Component:
- 061200 engine and engine cooling:engine:diesel
- Summary:
- Transmission- e4od- harsh/delayed 2-3 upshifts- vehicles with 7.3l diesel and 49-state calibration- f-series built through 2/3/97 and all 1996 e-350. *jd
- Bulletin:
- BC2297970501
- Component:
- 075000 fuel system, gasoline:carburetor system
- Summary:
- When the air cleaner is being replaced, the drain mechanism on the bottom of the air cleaner case is to be cleaned of obstructions. *tw
- Bulletin:
- BC2301970501
- Component:
- 102000 power train:manual transmission
- Summary:
- New clutch slave cylinder with a redesigned lip seal. *tw
- Bulletin:
- BC2360970501
- Component:
- 021000 suspension:front
- Summary:
- For concerns of noisy/squeaky steering and diagnosis is for the pitman arm, recommended service is to replace the pitman arm. *tw
- Bulletin:
- BC2363970501
- Component:
- 980000 unknown or other
- Summary:
- The only authorized repair for a front frame bumper mounting bracket needing replacement is to replace the frame. *tw
- Bulletin:
- BC2391970501
- Component:
- 135200 visibility:rearview mirrors/devices:exterior
- Summary:
- Engineering is addressing the issue of intermittent/unable to adjust mirror concerns. *tw
- Bulletin:
- BC105849705
- Component:
- 353400 equipment:electrical:radio/tape deck/cd etc.
- Summary:
- Vehicles with premium radios will be equipped with volume control/on-off switch. *tw
- Bulletin:
- 97111097238
- Component:
- 030000 service brakes, hydraulic
- Summary:
- Subject on rear vibration/shudder when applying brakes. *yc
- Bulletin:
- 9831
- Component:
- 162000 structure:body
- Summary:
- Repairs to vinyl covered surfaces. *yc
- Bulletin:
- 9833
- Component:
- 162000 structure:body
- Summary:
- Service tips for surface defect removal without repainting. *yc
- Bulletin:
- 985A5
- Component:
- 034530 service brakes, hydraulic:foundation components:disc:rotor
- Summary:
- Hub-mount brake rotor machining equipment from rotunda is now approved for warranty and service use. *yc
- Bulletin:
- 985A11
- Component:
- 034000 service brakes, hydraulic:foundation components
- Summary:
- Service tip information regarding elimination of sanding rotors and drums. *yc
- Bulletin:
- 985A25
- Component:
- 034000 service brakes, hydraulic:foundation components
- Summary:
- A vibration or shudder may be felt during braking on some vehicles. *yc
- Bulletin:
- 985A35
- Component:
- 051120 parking brake:conventional:mechanical:linkage and cable
- Summary:
- The rear parking brake cables may bind and not allow the rear brake shoes to return fully to the anchor pins after the parking brake is applied. *yc
- Bulletin:
- 9888
- Component:
- 103000 power train:automatic transmission
- Summary:
- Information on a new transmission fluid usage chart. *yc
- Bulletin:
- 9845
- Component:
- 045300 service brakes, air:disc:rotor
- Summary:
- Availability of hub-mount brake rotor machining equipment. *yc
- Bulletin:
- 98413
- Component:
- 034000 service brakes, hydraulic:foundation components
- Summary:
- A grabbing condition and / or squeal noise from the rear brakes during first few brake applications after rainfall and / or while brakes are cold. *tt
- Bulletin:
- 98419
- Component:
- 980000 unknown or other
- Summary:
- Some vehicles may exhibit a flashing transmission control indicator lamp (tcil) and diagnostic trouble codes (dtcs) 62,628, and/or 1728. *yc
- Bulletin:
- 9852
- Component:
- 190000 tires
- Summary:
- Information on tire company telephone numbers for customer assistance. *yc
- Bulletin:
- 9858
- Component:
- 980000 unknown or other
- Summary:
- The malfunction indicator lamp (mil) may illuminate and diagnostic trouble code (dtc) p0503 may be stored in memory. *yc
- Bulletin:
- 9864
- Component:
- 063000 engine and engine cooling:exhaust system
- Summary:
- Information on a buzzing or rattle noise from the exhaust system. *tt
- Bulletin:
- 9869
- Component:
- 185000 vehicle speed control:cruise control
- Summary:
- Concerns with hesitation, stumble, surge, miss, rough idle, stall at idle. *tt
- Bulletin:
- 98611
- Component:
- 061100 engine and engine cooling:engine:gasoline
- Summary:
- Concerns with reduced power, stalling, hesitation, and surge. *yc
- Bulletin:
- 98613
- Component:
- 138000 visibility:defroster/defogger system
- Summary:
- Subject regarding cold air felt on the floor while in heat mode. *yc
- Bulletin:
- 980298
- Component:
- 980000 unknown or other
- Summary:
- Information regarding the hotline survey. *yc
- Bulletin:
- 980310
- Component:
- 020000 suspension
- Summary:
- Experiencing vibration at cruise over 50 mph. *yc
- Bulletin:
- 980317
- Component:
- 061100 engine and engine cooling:engine:gasoline
- Summary:
- Symptoms regarding p0300-p0308 misfire dtcs with 4.6l engines. *yc
- Bulletin:
- 980323
- Component:
- 061100 engine and engine cooling:engine:gasoline
- Summary:
- Concerns with external oil leaks. *yc
- Bulletin:
- 982548
- Component:
- 980000 unknown or other
- Summary:
- Brief information giving the correct part number for tsb 98-3-12. *yc
- Bulletin:
- 982673
- Component:
- 202000 wheels:center section
- Summary:
- If you encounter a vehicle with a missing wheel hub o-ring, do not install a new o-ring. *yc
- Bulletin:
- 982740
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Concerns with high pressure oil pumps are not serviceable. *yc
- Bulletin:
- 9810569
- Component:
- 017000 steering:linkages
- Summary:
- Concerns of squeaky / noisy pitman arm. *yc
- Bulletin:
- 98259
- Component:
- 980000 unknown or other
- Summary:
- Some vinyl covered items such as dash panels, door trim panels, consoles, etc., may exhibit a small dent, scuff, abrasion and/ or discoloration resulting from assembly, transit, dealer prep and/or customer usage. *yc
- Bulletin:
- 982512
- Component:
- 061100 engine and engine cooling:engine:gasoline
- Summary:
- Some vehicles with higher odometer readings may experience a hesitation on acceleration just off idle and misfire complaints with malfunction indicator lalmp ( mil ) on. *yc
- Bulletin:
- 982110
- Component:
- 061100 engine and engine cooling:engine:gasoline
- Summary:
- During high idle speeds throttle sticks after steady state driving in cold ambient temperatures. *yc
- Bulletin:
- 982117
- Component:
- 050000 parking brake
- Summary:
- A new parking brake control rubber bumper stop is now available for service. *yc
- Bulletin:
- 982010
- Component:
- 063000 engine and engine cooling:exhaust system
- Summary:
- Experiencing a " buzzing " or " rattling " noise from the exhaust system. *yc
- Bulletin:
- 98231
- Component:
- 114200 electrical system:wiring:interior/under dash
- Summary:
- Condition with water intrusion into the generic electronic module ( gem ) may occur on some vehicles. *yc
- Bulletin:
- 982310
- Component:
- 063100 engine and engine cooling:exhaust system:emission control
- Summary:
- Mass air flow (maf)- sensor contamination- service tip. *ak
- Bulletin:
- 982312
- Component:
- 103000 power train:automatic transmission
- Summary:
- Issues regareding diagnostic trouble codes ( dtcs ) p0705, p0708, p1704, and / or p1705 may be stored in memory. *yc
- Bulletin:
- 982313
- Component:
- 061100 engine and engine cooling:engine:gasoline
- Summary:
- Some vehicles with a 7.3l direct injection (di) turbo diesel engine, one or more of the following concerns may be present: rough idle, stalling, hesitation/ stumble, loss / lack of power, poor fuel economy, and excessive oil consumption.
- Bulletin:
- 982314
- Component:
- 061110 engine and engine cooling:engine:gasoline:belts and associated pulleys
- Summary:
- Premature wear of the belt tensioner may occur on some vehicles. *yc
- Bulletin:
- 982323
- Component:
- 162000 structure:body
- Summary:
- Information regarding replacement and / or repairs on any lock component. *yc
- Bulletin:
- 98246
- Component:
- 110000 electrical system
- Summary:
- Ford motor company has released a new electrical grease ( f8az - 19g208-aa ) to reduce the possibility of moisture corrosion at the terminals. *yc
- Bulletin:
- 9943
- Component:
- 100000 power train
- Summary:
- Information regarding reprogramming powertrain control modules (pcms). *tt
- Bulletin:
- 99411
- Component:
- 030000 service brakes, hydraulic
- Summary:
- Vehicles experiencing increased brake pedal effort and / or false abs cycling at low speeds, or abs lamp illumination. *tt
- Bulletin:
- 9946
- Component:
- 103000 power train:automatic transmission
- Summary:
- Concerns with transmission fluid leaking at radiator. *tt
- Bulletin:
- 5955
- Component:
- 105500 power train:driveline:differential unit
- Summary:
- Subject regarding front differential noise investigation. *tt
- Bulletin:
- 12601
- Component:
- 162000 structure:body
- Summary:
- Experiencing whistling noise coming from the front of the vehicle at highway speeds. *tt
- Bulletin:
- 98113
- Component:
- 160000 structure
- Summary:
- Subject pertaining to red rust stains on the edges of the bumper center vent and fog lamp openings. *tt
- Bulletin:
- 976007
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Brief information regarding cylinder head temperature (cht) and fail safe cooling. *tt
- Bulletin:
- 976011
- Component:
- 061100 engine and engine cooling:engine:gasoline
- Summary:
- Customer may complain of intermittent stall / bucks / jerks while driving. *tt
- Bulletin:
- BPI9905
- Component:
- 031100 service brakes, electric
- Summary:
- Customer may complain that the raybestos electronic brake controller does not work, works incorrectly, works intermittently, pulses the 4-way flashers, and / or interfers with antilock brakes operation. *tt
- Bulletin:
- 99816
- Component:
- 061100 engine and engine cooling:engine:gasoline
- Summary:
- Ford motor company now recommends sae 5w-30 viscosity grade for servicing any ford gasoline-powered vehicle regardless of model year. *tt
- Bulletin:
- 9996
- Component:
- 103000 power train:automatic transmission
- Summary:
- Experiencing a delayed or no 2-3 upshift, primarily when the transmission is cold on vehicles with ford qality remanufactured (fqr) 4r70w transmission exchange units with julian build between 062-97 and 040-99. *tt
- Bulletin:
- 99128
- Component:
- 353600 equipment:air conditioner
- Summary:
- Some vehicles may exhibit a whistling noise while driving with a/c in the off position at speeds above 64 km/h (40 mph). *tt
- Bulletin:
- 99129
- Component:
- 353400 equipment:electrical:radio/tape deck/cd etc.
- Summary:
- Experiencing a whine / buzz type noise in the speakers of the entertainment radio or two-way radio on vehicles with an in-tank electric fuel pump. *tt
- Bulletin:
- 99139
- Component:
- 125000 exterior lighting:brake lights
- Summary:
- Conditions with the brake lamps inadvertently disabling the brake shift interlock. *tt
- Bulletin:
- 991313
- Component:
- 036000 service brakes, hydraulic:antilock
- Summary:
- Subject regarding anti-lock brake lamp illumination, increased break pedal effort and / or false anti-lock brake system (abs) cycling at low speeds. *tt
- Bulletin:
- 9946
- Component:
- 103600 power train:automatic transmission:cooling unit and lines
- Summary:
- Concerns with transmission fluid leaking at the radiator. *tt
- Bulletin:
- 6477
- Component:
- 022141 suspension:rear:springs:leaf spring assembly:leaf
- Summary:
- Subject regarding rear spring rattle. *tt
- Bulletin:
- 12905
- Component:
- 106000 power train:axle assembly
- Summary:
- Some vehicles may experience axle wind up and / or clunking, popping, ratcheting type noises when making cornering maneuvers on vehicles equipped with a four wheel drive hi or low range mode. *tt
- Bulletin:
- 996034
- Component:
- 061100 engine and engine cooling:engine:gasoline
- Summary:
- Experiencing a engine knock at cold start-up. *tt
- Bulletin:
- 996042
- Component:
- 135000 visibility:rearview mirrors/devices
- Summary:
- Information on using 1999 procedures manual for side mirror replacement. *tt
- Bulletin:
- 996113
- Component:
- 105000 power train:driveline
- Summary:
- Experiencing front differential noise. *tt
- Bulletin:
- 996128
- Component:
- 034000 service brakes, hydraulic:foundation components
- Summary:
- Subject regarding right rear brake concerns under investigation. *tt
- Bulletin:
- 996139
- Component:
- 105000 power train:driveline
- Summary:
- Concerns with front differential noise. *tt
- Bulletin:
- 983070
- Component:
- 103400 power train:automatic transmission:lever and linkage:column shift
- Summary:
- Somve vehicles may exhibit a buzz / low growl noise coming from the area of the transfer case manual shift lever. *tt
- Bulletin:
- 983074
- Component:
- 106000 power train:axle assembly
- Summary:
- Concerns with axle wind-up and / or clunking, popping, ratcheting type noises when making cornering maneuvers. *tt
- Bulletin:
- 983301
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- This bulletin provides procedures on neutralizing the exhaust, transmission and engine mounts. *tt
- Bulletin:
- 983302
- Component:
- 200000 wheels
- Summary:
- This bulletin mentions how some hub o-rings may be cut during the installation of the wheels. *tt
- Bulletin:
- 9811335
- Component:
- 061100 engine and engine cooling:engine:gasoline
- Summary:
- Exhibiting a vibration, noise or ground out condition when turning or under load. *tt
- Bulletin:
- 9811342
- Component:
- 353400 equipment:electrical:radio/tape deck/cd etc.
- Summary:
- Information on removing the radio chassis from some vehicles. *tt
- Bulletin:
- 9811344
- Component:
- 200000 wheels
- Summary:
- Some vehicles may exhibit loose lugnuts and / or broken wheel studs. *tt
- Bulletin:
- 9811346
- Component:
- 061100 engine and engine cooling:engine:gasoline
- Summary:
- Some vehicles may experience an intermittent stall condition after a long deceleration when using the m1 or m2 gear on the e40d or when using a lower gear with the m50d for engine braking. *tt
- Bulletin:
- 99164
- Component:
- 116000 electrical system:ignition
- Summary:
- Concerns with a hard to turn ignition key and / or a hard to remove key from ignition cylinder. *tt
- Bulletin:
- 983564
- Component:
- 030000 service brakes, hydraulic
- Summary:
- Experiencing a squealing noise from the front brakes when applying the brakes on some vehicles. *tt
- Bulletin:
- 983570
- Component:
- 061100 engine and engine cooling:engine:gasoline
- Summary:
- Some engines may exhibit oil leakage. *tt
- Bulletin:
- 99143
- Component:
- 105500 power train:driveline:differential unit
- Summary:
- Some 4x4 vehicles built with center disconnect front axles may exhibit a moaning noise from the front differential while operating in 4x2 mode. *tt
- Bulletin:
- 996754
- Component:
- 162300 structure:body:door
- Summary:
- This online bulletin addresses concerns with cracks in the door sheet metal at the lower rear of the window opening near the belt molding. *tt
- Bulletin:
- 996780
- Component:
- 133000 visibility:power window devices and controls
- Summary:
- This online service bulletin involves vehicles exhibiting windnoise at the top of the door glass seal / weatherstrip molding area. *tt
- Bulletin:
- 996876
- Component:
- 162200 structure:body:bumpers
- Summary:
- Information pertaining to conditions with red staining (spots) on the front bumper wing ends. *tt
- Bulletin:
- 99222
- Component:
- 114000 electrical system:wiring
- Summary:
- Subject on a wire harness terminal repair kit available for repairing electrical wiring harnesses. *tt
- Bulletin:
- 99185
- Component:
- 980000 unknown or other
- Summary:
- Vehicles built between 3/15/1997 and 12/31/1998 and with 4r70w transmissions may experience delayed or no 2-3 upshift, transmission control indicator lamp illuminated with diagnostic trouble code p0782 stored in memory. *tt
- Bulletin:
- 99194
- Component:
- 034000 service brakes, hydraulic:foundation components
- Summary:
- Information for servicing and diagnosing brake vibration, brake inspection, and brake friction material replacement. *tt
- Bulletin:
- 99196
- Component:
- 353600 equipment:air conditioner
- Summary:
- Information on identifying non-approved / alternate refrigerants which could cause safety, and performance concerns if installed in ford a/c systems. *tt
- Bulletin:
- 99234
- Component:
- 980000 unknown or other
- Summary:
- Information on diagnosing a vehicle with malfunction indicator lamp illuminated and diagnostic trouble codes p0442 and p0455 stored in continuous memory. *tt
- Bulletin:
- 99242
- Component:
- 162300 structure:body:door
- Summary:
- Information on replacing and / or repairing malfunctioning (door, ignition and decklid) locks. *tt
- Bulletin:
- 7022
- Component:
- 162000 structure:body
- Summary:
- Information regarding outward dents in pickup box wheel wells. *mjs
- Bulletin:
- 13203
- Component:
- 162000 structure:body
- Summary:
- Information regarding outward dents in pickup box wheel wells. *mjs
- Bulletin:
- 13238
- Component:
- 162300 structure:body:door
- Summary:
- Information regarding vehicles that exhibit cracks in the door sheet metal. *mjs
- Bulletin:
- 98163
- Component:
- 162300 structure:body:door
- Summary:
- Locks failed. yd
- Bulletin:
- 98151
- Component:
- 120000 exterior lighting
- Summary:
- Malfunction indicator lamp failed. yd
- Bulletin:
- 98158
- Component:
- 021000 suspension:front
- Summary:
- Front end shimmy may occur at various driving speeds and is usually induced when hitting bumps, such as large potholes or rough railroad crossings. shimmy is not always verified during road test. *ak
- Bulletin:
- 981512
- Component:
- 063100 engine and engine cooling:exhaust system:emission control
- Summary:
- A direct replacement part for the evaporative emission canister and bracket assembly. ak
- Bulletin:
- 981517
- Component:
- 500000 child seat
- Summary:
- Install a revised child seat tether kit.
- Bulletin:
- 13412
- Component:
- 103000 power train:automatic transmission
- Summary:
- Some vehicles may exhibit a condition of no 4x4 low range engagement or a stuck in 4x4 low range, with no (dtc) diagnostic trouble code stored in the gem. *tt
- Bulletin:
- 98168
- Component:
- 103000 power train:automatic transmission
- Summary:
- Transmission- e40d/4r100-1989-99-main controls, separator plates and separator plate gaskets usage chart. yd
- Bulletin:
- 98169
- Component:
- 011000 steering:wheel and handle bar
- Summary:
- Steering -alignment-toe set procedure service tip. yd
- Bulletin:
- 981610
- Component:
- 221200 seats:front assembly:recliner
- Summary:
- The seat back may not latch/ lock in the desired position and remain folded forward over the seat cushion. yd
- Bulletin:
- 981612
- Component:
- 073000 fuel system, gasoline:fuel injection system
- Summary:
- Fuel may leak from the spring lock couplings. yd
- Bulletin:
- 981613
- Component:
- 103600 power train:automatic transmission:cooling unit and lines
- Summary:
- Transmission fluid leaks at radiator. yd
- Bulletin:
- 981617
- Component:
- 980000 unknown or other
- Summary:
- Floor mat installation procedure service tip. yd
- Bulletin:
- 98168
- Component:
- 980000 unknown or other
- Summary:
- Installation of vinyl floor mats service tip. ak
- Bulletin:
- 7353
- Component:
- 103000 power train:automatic transmission
- Summary:
- Some vehicles may exhibit a condition of no 4x4 low range engagement or a stuck in 4x4 low range, with no diagnostic trouble codes stored in the gem module. *tt
- Bulletin:
- 13479
- Component:
- 162300 structure:body:door
- Summary:
- Some vehicles may exhibit cracks in the door sheet metal at the lower rear of the window opening near the belt molding. *tt
- Bulletin:
- 13550
- Component:
- 162000 structure:body
- Summary:
- Some vehicles may exhibit dents on the wheel well sheet metal of the pcik-up box area when used in off-road applications. *tt
- Bulletin:
- 0014
- Component:
- 161000 structure:frame and members
- Summary:
- Vehicles may experience inner fender well- dented or dinged from stones being thrown into wheelwell. *mjs
- Bulletin:
- 0015
- Component:
- 103000 power train:automatic transmission
- Summary:
- Information regarding the new transmission cooler flusher- service tip. *mjs
- Bulletin:
- 7821
- Component:
- 162700 structure:body:trunk lid
- Summary:
- Cracks in the door sheet metal at the lower rear of the window opening near the belt molding.
- Bulletin:
- 0017
- Component:
- 980000 unknown or other
- Summary:
- Subject on the malfunction indicator lamp (mil) may illuminate and diagnostic trouble codes may appear. *mjs
- Bulletin:
- 0038
- Component:
- 103600 power train:automatic transmission:cooling unit and lines
- Summary:
- Vehicles may experience solid particle contaminants from prior transmission concerns or excess wear, may be trapped in the transmission fluid cooling system is not properly flushed, fluid in-line filter kit. *mjs
- Bulletin:
- 13838
- Component:
- 131000 visibility:windshield
- Summary:
- Concerns with vehicles exhibiting a windshield creak / squeak. *tt
- Bulletin:
- 13745
- Component:
- 100000 power train
- Summary:
- Some vehicles may experience a condition of no 4 x 4 low range engagement or a stuck in 4 x 4 low range. *mjs
- Bulletin:
- 00611
- Component:
- 103100 power train:automatic transmission:control module (tcm, pcm)
- Summary:
- Some bi-fuel vehicles may require powertrain control module (pcm) replacement during service and may not run on cng or lpg., recalibration of the pcm/replacement. *mjs
- Bulletin:
- 12071
- Component:
- 162300 structure:body:door
- Summary:
- Some vehicles may exhibit cracks in the door sheet metal at the lower rear of the window opening near the belt molding. *mjs
- Bulletin:
- 985028
- Component:
- 110000 electrical system
- Summary:
- Information regarding a new service part released for the license plate light circuit which will reduce the cose of repairs. *tt
- Bulletin:
- 985042
- Component:
- 061100 engine and engine cooling:engine:gasoline
- Summary:
- Repeat message regarding vehicles exhibiting rough idle / miss condition. *tt
- Bulletin:
- 12113
- Component:
- 103100 power train:automatic transmission:control module (tcm, pcm)
- Summary:
- Some vehicles with e40d and california calibration 7-90p-r10/11 may stall during long decel conditions while in mkanual 1 or 2 gear. *mjs
- Bulletin:
- 5046
- Component:
- 061100 engine and engine cooling:engine:gasoline
- Summary:
- Repeat message regarding vehicles exhibiting a lack of power. *tt
- Bulletin:
- 5047
- Component:
- 061100 engine and engine cooling:engine:gasoline
- Summary:
- Repeat message regarding a hard start / no start condition. *tt
- Bulletin:
- 12139
- Component:
- 061100 engine and engine cooling:engine:gasoline
- Summary:
- Some vehicles equipped with 4.6l or 6.8l engines may exhibit a cold start engine noise until warmed up. *mjs
- Bulletin:
- 12154
- Component:
- 116300 electrical system:ignition:anti-theft controller
- Summary:
- Some vehicles equipped with pats (securilock) except certain models now have availability of fleet keys through rotunda. *mjs
- Bulletin:
- 985058
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Subject regarding external oil leaks - repeat message. *tt
- Bulletin:
- 985059
- Component:
- 061100 engine and engine cooling:engine:gasoline
- Summary:
- Experiencing cold engine knock (repeat / revised message). *tt
- Bulletin:
- 985062
- Component:
- 061100 engine and engine cooling:engine:gasoline
- Summary:
- Subject regarding idle vibration (repeat message). *tt
- Bulletin:
- 985063
- Component:
- 180000 vehicle speed control
- Summary:
- Subject regarding vehicles exhibiting vibration at cruise over 50 mph. (repeat message). *tt
- Bulletin:
- 9803000
- Component:
- 980000 unknown or other
- Summary:
- Hotline contact id number on oasis. a nine digit contact number is attached to the oasis information when a vin and symptom code is entered into oasis. *yc
- Bulletin:
- 980312
- Component:
- 061100 engine and engine cooling:engine:gasoline
- Summary:
- Excessive white smoke. verify glow plug operation by performing glow plug system operation check on the hard start/no start diagnostic sheet. *tt
- Bulletin:
- 980325
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Cold engine upper knock/tick. *yc
- Bulletin:
- 985029
- Component:
- 162300 structure:body:door
- Summary:
- Some vehicles may exhibit cracks in the door sheet metal at the lower rear of the window opening near the belt molding. *tt
- Bulletin:
- 98-4717
- Component:
- 162300 structure:body:door
- Summary:
- Vehicles exhibit cracks in door sheet metal at lower rear of the window opening near belt molding. *ak
- Bulletin:
- 98-4722
- Component:
- 185000 vehicle speed control:cruise control
- Summary:
- Repeat message, no change- rough idle/miss. *ak
- Bulletin:
- 98-4725
- Component:
- 105300 power train:driveline:driveshaft
- Summary:
- Vibration at cruise over 50 mph. *ak
- Bulletin:
- 98-4726
- Component:
- 061100 engine and engine cooling:engine:gasoline
- Summary:
- Repeat message, no change: hard start/ no start. *ak
- Bulletin:
- 98-4734
- Component:
- 061120 engine and engine cooling:engine:gasoline:turbo-charger
- Summary:
- Lack of power due to failure of engine turbo boost
- Bulletin:
- 6232
- Component:
- 062000 engine and engine cooling:cooling system
- Summary:
- Some vehicles may develop a coolant leak at the worm gear clamp located at the joint between the metal intake coolant tube and the coil resulting in engine misfire with diagnostic trouble code p0304 and / or rough idle. *tt
- Bulletin:
- 6287
- Component:
- 185000 vehicle speed control:cruise control
- Summary:
- Some vehicles may experience an idle vibration. *tt
- Bulletin:
- 98-4738
- Component:
- 061100 engine and engine cooling:engine:gasoline
- Summary:
- Cold engine knock 5.4l action. *ak
- Bulletin:
- 98-4742
- Component:
- 116000 electrical system:ignition
- Summary:
- Vehicle stalls upon acceleration. *ak
- Bulletin:
- 12720
- Component:
- 062000 engine and engine cooling:cooling system
- Summary:
- Some vehicles may develop a coolant leak at the worm gear clamp located at the joint between the metal intake coolant tube and the flexible rubber coolant hose. *tt
- Bulletin:
- 12738
- Component:
- 161000 structure:frame and members
- Summary:
- Some vehicles may exhibit a idle vibration.
- Bulletin:
- 12590
- Component:
- 105500 power train:driveline:differential unit
- Summary:
- Some 4x4 vehicles may exhibit a moan noise from the front differential when the vehicle is operating in 4x2 mode and goes away when operating in 4x4 mode. *tt
- Bulletin:
- 13054
- Component:
- 131000 visibility:windshield
- Summary:
- Experiencing windnoise at the top of the door glass seal / weatherstrip molding area. *tt
- Bulletin:
- 13106
- Component:
- 162200 structure:body:bumpers
- Summary:
- On some vehicles the front bumpers may exhibit red staining (spots) on the bumer wing ends. *tt
- Bulletin:
- 6489
- Component:
- 022140 suspension:rear:springs:leaf spring assembly
- Summary:
- Some vehicles built with 3-leaf or 4-leaf rear springs may exhibit a rear spring rattle. *tt
- Bulletin:
- 12879
- Component:
- 022140 suspension:rear:springs:leaf spring assembly
- Summary:
- Subject regarding rear spring clip kits for vehicles exhibiting a rear spring rattle. *tt
- Bulletin:
- 12882
- Component:
- 022140 suspension:rear:springs:leaf spring assembly
- Summary:
- Subject regarding the availability of rear spring clip kits for vehicles exhibiting rear spring rattle. *tt
- Bulletin:
- 13505
- Component:
- 103400 power train:automatic transmission:lever and linkage:column shift
- Summary:
- All 4x4 vehicles with electronic shift onthe fly transfer cases will display contact plate pids opposite of the 1999 or earlier workshop manual indicates when using ngs with 15.0 level or later software. *tt
- Bulletin:
- 985A23
- Component:
- 034000 service brakes, hydraulic:foundation components
- Summary:
- A comprehensive pull and drift diagnostic procedure has been developed to assist technicians in helping to resolve pull or drift conditions. *tt
- Bulletin:
- 4614
- Component:
- 185000 vehicle speed control:cruise control
- Summary:
- Information on vehicles exhibiting rough idle / miss. *tt
- Bulletin:
- 4616
- Component:
- 061100 engine and engine cooling:engine:gasoline
- Summary:
- Brief information vehicles exhibiting hard start / no start condition. *tt
- Bulletin:
- 4617
- Component:
- 061100 engine and engine cooling:engine:gasoline
- Summary:
- Brief information on vehicles exhibiting lack of power condition. *tt
- Bulletin:
- 4625
- Component:
- 061100 engine and engine cooling:engine:gasoline
- Summary:
- Brief information on vehicles exhibiting a stall on deceleration condition. *tt
- Bulletin:
- 4628
- Component:
- 106000 power train:axle assembly
- Summary:
- Some vehicles may exhibit rear axle noise. *tt
- Bulletin:
- 4629
- Component:
- 061100 engine and engine cooling:engine:gasoline
- Summary:
- Brief information concern vehicles exhbiting external oil leaks. *tt
- Bulletin:
- 4631
- Component:
- 100000 power train
- Summary:
- Brief information on vehicles exhibit vibration at cruise over 50 mph. *tt
- Bulletin:
- 4633
- Component:
- 034000 service brakes, hydraulic:foundation components
- Summary:
- Rear brake drag or excessive wear on rear brakes. *tt
- Bulletin:
- 4638
- Component:
- 061100 engine and engine cooling:engine:gasoline
- Summary:
- Malfunction indicator lamp on, with p0300 - p0308 misfire diagnostic trouble codes with a 4.6l engine. *tt
- Bulletin:
- 99-8-15
- Component:
- 162300 structure:body:door
- Summary:
- Subject regarding door trim panel replacement - service tip. *tt
- Bulletin:
- 99111
- Component:
- 980000 unknown or other
- Summary:
- Information designed to aid in the diagnosis, testing and repair of noise, vibration and harshness (nvh) concerns. *tt
- Bulletin:
- 991210
- Component:
- 980000 unknown or other
- Summary:
- Ford motor company has released a private labeled material to be used for iron particle / acid rain service repairs. *tt
- Bulletin:
- 99152
- Component:
- 103000 power train:automatic transmission
- Summary:
- Information on the new flush and fill tool available through rotunda. *tt
- Bulletin:
- 4682
- Component:
- 160000 structure
- Summary:
- Some super cab vehicles may exhibit a moan / droan in the cab at 1500 - 1600 rpm or a cab vibration at 1800 - 1900 rpm. *tt
- Bulletin:
- 4683
- Component:
- 010000 steering
- Summary:
- Some vehicles may exhibit a rubbing or squeak noise as the steering wheel is turned. *tt
- Bulletin:
- 4703
- Component:
- 200000 wheels
- Summary:
- Some trucks built with 16 inch chrome styled steel wheels and trucks built with 16 inch steel wheels may exhibit signs of rust around the edges of the wheels. *tt
- Bulletin:
- 11794
- Component:
- 011000 steering:wheel and handle bar
- Summary:
- Experiencing a rubbing or squeak noise as the steering wheel is turned. *tt
- Bulletin:
- 11799
- Component:
- 160000 structure
- Summary:
- Some supercab vehicles may exhibit a moan / droan in the cab at 1500 - 1600 rpm or a cab vibration at 1800 - 1900 rpm. *tt
- Bulletin:
- 11811
- Component:
- 200000 wheels
- Summary:
- Some vehicles built with 16 inch chrome styled steel wheels and with 16 inch steel wheels may exhibit signs of rust around the edges of the wheels. *tt
- Bulletin:
- 11814
- Component:
- 160000 structure
- Summary:
- Some vehicles may exhibit cracks in the door sheet metal at the lower rear of the window opening near the belt molding. *tt
- Bulletin:
- 4981
- Component:
- 061100 engine and engine cooling:engine:gasoline
- Summary:
- Some vehicles equipped with 5.4l engines may exhibit a cold start engine knock concern until warmed up. *tt
- Bulletin:
- 5250
- Component:
- 185000 vehicle speed control:cruise control
- Summary:
- Information on super duty models with 7.3l diesel engines exhibiting rough idle / miss condition. *tt
- Bulletin:
- 5251
- Component:
- 103400 power train:automatic transmission:lever and linkage:column shift
- Summary:
- Some super duty vehicles with 7.3l dit diesel engines may exhibit 4x4 lights on, 4x4 inoperative and / or multiple gem codes. *tt
- Bulletin:
- 5254
- Component:
- 061100 engine and engine cooling:engine:gasoline
- Summary:
- Information on super duty 7.3 dit diesel engine vehicles exhibiti lack of power. *tt
- Bulletin:
- 5257
- Component:
- 061100 engine and engine cooling:engine:gasoline
- Summary:
- Information on vehicles exhibiting cold engine knock. *tt
- Bulletin:
- 5258
- Component:
- 180000 vehicle speed control
- Summary:
- Information on vehicles exhibiting vibration at cruise over 50 mph. *tt
- Bulletin:
- 5262
- Component:
- 136000 visibility:windshield wiper/washer
- Summary:
- Information on diagnosticing erratic windshield wiper operation. *tt
- Bulletin:
- 5262
- Component:
- 180000 vehicle speed control
- Summary:
- Service information for vehicles exhibiting stall on deceleration condition. *tt
- Bulletin:
- 5267
- Component:
- 061100 engine and engine cooling:engine:gasoline
- Summary:
- Subject regarding misfire codes on all engines. *tt
- Bulletin:
- 5316
- Component:
- 103000 power train:automatic transmission
- Summary:
- Some super duty 7.3l e4od and 7.3l 4r100 vehicles may exhibit various transmission concerns, including stall on transmission engagement and / or a buzz noise on engagement. *tt
- Bulletin:
- 12208
- Component:
- 110000 electrical system
- Summary:
- Some texas department of transportation (dot) trucks may encounter a radio frequency interference (rfi) condition when using hand held two-way radios in the range of 47.18 mhz. *tt
- Bulletin:
- 12248
- Component:
- 103000 power train:automatic transmission
- Summary:
- Some heavy duty and super duty vehicles may exhibit various transmission concerns, including stall on transmission engagement and / or a buzz noise on engagement. *tt
- Bulletin:
- 985185
- Component:
- 061100 engine and engine cooling:engine:gasoline
- Summary:
- Cold start engine noise
- Bulletin:
- 980307
- Component:
- 061100 engine and engine cooling:engine:gasoline
- Summary:
- Vehicle stalls/quits while driving. *ak
- Bulletin:
- 4635
- Component:
- 061100 engine and engine cooling:engine:gasoline
- Summary:
- Cold engine knock. *tt
- Bulletin:
- 980323
- Component:
- 073000 fuel system, gasoline:fuel injection system
- Summary:
- Dtc's p1211/1212 icp pressure higher/lower than expected.
- Bulletin:
- 98S14
- Component:
- 203000 wheels:lugs/nuts/bolts
- Summary:
- Safety recall update to replace locking lug nuts. *tt
- Bulletin:
- 00238
- Component:
- 061100 engine and engine cooling:engine:gasoline
- Summary:
- Some vehicles may exhibit a no crank / no start condition in temperatures below 12 degrees c (10 degrees f). *tt
- Bulletin:
- 00239
- Component:
- 110000 electrical system
- Summary:
- A condition may exist with possible electronc damage occuring to the compuvalve from voltage spikes between the compuvalve connections when connecting or disconnecting the main compuvalve harness c4025. *tt
- Bulletin:
- 14455
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Oil leak from the front or rear cylinder head oil supply rail end plugs. *tt
- Bulletin:
- 002310
- Component:
- 103600 power train:automatic transmission:cooling unit and lines
- Summary:
- Subject regarding contamination from prior transmission concerns or excess wear may be trapped in the transmission fluid cooling system. *tt
- Bulletin:
- 00254
- Component:
- 180000 vehicle speed control
- Summary:
- Some vehicles may exhibit an engine buck, surge, or jerk (also known as hitching / hesitation) while the speed control is active through all engine temperatures. *tt
- Bulletin:
- 00261
- Component:
- 185000 vehicle speed control:cruise control
- Summary:
- Some vehicles equipped with a 4.6l, 5.4l, or 6.8l engine may exhibit a rough idle / miss after start-up in cold ambient temperatures. *tt
- Bulletin:
- 01111
- Component:
- 160000 structure
- Summary:
- Some vehicles may exhibit a water leak around the rear (sliding) window. *tt
- Bulletin:
- 14365
- Component:
- 061110 engine and engine cooling:engine:gasoline:belts and associated pulleys
- Summary:
- This bulletin addresses concerns a noise at intial engine startup when cold from the accessory drive belt. *jb
- Bulletin:
- 0147
- Component:
- 061100 engine and engine cooling:engine:gasoline
- Summary:
- Subject regarding engine oil recommendations for use in 2001 vehicles - sae 5w-20 motor oil. *tt
- Bulletin:
- 0193
- Component:
- 106100 power train:axle assembly:banjo housing
- Summary:
- A condition may exist where a driveline vibration and / or a transmission fluid leak from the extension housing seal area may occur on some vehicles. this may be caused by the extension housing bushing or seal walking / spinning out due t
- Bulletin:
- 01166
- Component:
- 103400 power train:automatic transmission:lever and linkage:column shift
- Summary:
- Some vehicles may exhibit water in the transfer case, this could cause low range 4x4 lamp to illuminate, short of transfer case switch, or windshield wipers to be erratic or inoperative. *slc
- Bulletin:
- 15113
- Component:
- 091100 fuel system, other:storage:tank assembly
- Summary:
- Some vehicles may exhibit a fuel fill valve sealing condition. *yd
- Bulletin:
- 01182
- Component:
- 162300 structure:body:door
- Summary:
- Some vehicles may experience a cosmetic crack in the outer door panel at the lower rear corner of window opening.*jb
- Bulletin:
- 01181
- Component:
- 103800 power train:automatic transmission:park/neutral start switch
- Summary:
- Brake shift interlock.*jb
- Bulletin:
- 15260
- Component:
- 113000 electrical system:starter assembly
- Summary:
- Concerns with corroded positive starter cable. *tt
- Bulletin:
- 01215
- Component:
- 180000 vehicle speed control
- Summary:
- A condition may exist, where throttle sticking may occur on a few vehicles in very cold ambient temperatures after operating at steady speed or extended idle for a period of time. *tt
- Bulletin:
- 01205
- Component:
- 061100 engine and engine cooling:engine:gasoline
- Summary:
- Some vehicles may exhibit vacuum or air leaks in the intake manifold and / or engine system causing diagnostic trouble codes p0171 and or p0174. *tt
- Bulletin:
- 15570
- Component:
- 061100 engine and engine cooling:engine:gasoline
- Summary:
- Some vehicles may exhibit various driveability conditions including lacks power, hesitates, hard to start, and/or malfunction indicator lamp (mil) illuminated and produce possible diagnostic trouble codes p0103, p0172 and p0175. *tt
- Bulletin:
- 01246
- Component:
- 061100 engine and engine cooling:engine:gasoline
- Summary:
- Engine oil system priming procedures, service tips for reports of premature engine failure. *tt
- Bulletin:
- 02E17
- Component:
- 072200 fuel system, gasoline:delivery:hoses, lines/piping, and fittings
- Summary:
- Subject regarding heater hose to fuel rail flex line inspection. *jg
- Bulletin:
- 0342
- Component:
- 090000 fuel system, other
- Summary:
- Possible fuel leak may occur at the fuel fill valve, on some dedicated cng vehicles. *tt *jb
- Bulletin:
- 030402
- Component:
- 090000 fuel system, other
- Summary:
- On some dedicated cng vehicles, a possible fuel leak may occur at the fuel fill valve. revised service parts. *tt
- Bulletin:
- 03103
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Vehicles without the coolant lock-off may exhibit a no start condition. *tt
- Bulletin:
- 0398
- Component:
- 090000 fuel system, other
- Summary:
- Malfunction indicator lamp (mil) illumination with diagnostic trouble codes p0442, p0455, p0456, p0457, p1442 or check fuel cap lamp illuminated with diagnostic trouble code p0457. *tt
- Bulletin:
- 03148
- Component:
- 103600 power train:automatic transmission:cooling unit and lines
- Summary:
- New transmission cooler flusher - service tips. 2003 escort and super duty f series included. *tt
- Bulletin:
- 03213
- Component:
- 061120 engine and engine cooling:engine:gasoline:turbo-charger
- Summary:
- A no-start or reduced power condition may occur intermittently. *tt
- Bulletin:
- 032119
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- An engine vibration and/or moaning noise at 2600-3000 rpm. *tt
- Bulletin:
- 032120
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- 7.3l dit glow plug start-up on-time during cold temperature - service tip. *tt
- Bulletin:
- 032121
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- A high number of high pressure rexroth pumps and injection pressure regulators (ipr) are being replaced due to oil leaking, when all that is required is a new gasket or seal on either the pump or ipr. *tt
- Bulletin:
- 032123
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Low rpm, no start, runs poorly, stall. 7.3l dit engine. *tt
- Bulletin:
- 032125
- Component:
- 114000 electrical system:wiring
- Summary:
- Aftermarket wiring alterations - service tip. *tt
- Bulletin:
- 032140
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Engine buck, surge or jerk (also known as hitching/hesitation) while the speed control is active through all engine temperatures. *tt
- Bulletin:
- 16515
- Component:
- 010000 steering
- Summary:
- Oil leak at high pressure pump fittings and/or plug. this includes super duty f-series. oasis. *tt
- Bulletin:
- 17571
- Component:
- 110000 electrical system
- Summary:
- Malfunction indicator lamp (mil) on with diagnostic trouble codes p0603 (powertrain control module keep alive memory error) or p0605 ( powertrain control module read only memory error). *tt
- Bulletin:
- 02176
- Component:
- 032100 service brakes, hydraulic:switches:brake light
- Summary:
- Lamp-brake-invadvertent disabling of brake shift interlock. *mj
- Bulletin:
- 02193
- Component:
- 073000 fuel system, gasoline:fuel injection system
- Summary:
- Driveability-idle-high idle speeds-throttle sticks after steady state driving in extreme cold ambient temperatures-vehicles built through 12/31/01 equipped with 4.6l engine. *mj
- Bulletin:
- 04L19
- Component:
- 017500 steering:linkages:tie rod assembly
- Summary:
- Customer maintenance reminder - literature program 04l19 - tie rod inspection procedure. *tt
- Bulletin:
- 04217
- Component:
- 103100 power train:automatic transmission:control module (tcm, pcm)
- Summary:
- General power train control module (pcm) programming procedures. *tt
- Bulletin:
- 042107
- Component:
- 103100 power train:automatic transmission:control module (tcm, pcm)
- Summary:
- General (pcm) power train control module programming procedures. *tt
- Bulletin:
- 05417
- Component:
- 063130 engine and engine cooling:exhaust system:emission control:gas recirculation valve (egr valve)
- Summary:
- Intermittent rough idle - non-commanded egr (exhaust gas recirculation valve) flow. *tt
- Bulletin:
- 07212
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Some 1997-2008 vehicles equipped with a 4.6l 2v, 5.4l 2v, or 6.8l 2v engine--spark plug thread repair procedure--not covered under new vehicle limited warranty. *nj this includes f-53 motorhome chassis. updated 2/23/10. *pe
- Bulletin:
- TSB-14-0147
- Component:
- 071100 fuel system, gasoline:storage:tank assembly
- Summary:
- Ford/lincoln: safety recall issued due to one or both fuel tank straps fracturing due to being in high corrosion areas for an extended period and dislodging fuel tank. model 1997-99 f250, 1997-03 f150, 2004 f150 heritage, 2002-2003 blackw
- Bulletin:
- TSB-14-0164
- Component:
- 071100 fuel system, gasoline:storage:tank assembly
- Summary:
- Ford/lincoln: safety recall regarding high corrosion areas for operating, for an extended time, vehicles where both or one strap of fuel tank can fracture, after contacting ground. model 1997-99 f250 ld, 1997-03 f150, 2004 f150 heritage,
Home | Privacy