1997 FORD EXPLORER Recalls (12)
- Campaign:
- 97V074000 on 04/30/1997
- Component:
- Vehicle speed control
- Manufactured:
- 02/01/1996 - 02/16/1997
- Affected:
- 23,000
- Defect:
- Vehicle description: multi-purpose passenger vehicles equipped with 5.0l engines originally sold or currently registered in the states of alaska, idaho, iowa, maine, michigan (upper peninsula only), minnesota, montana, nebraska, new hampshire, new york, north dakota, south dakota, vermont, wisconsin, and wyoming. these vehicles, when operated for extended periods of time at highway speeds and temperatures below -20 degrees farenheit, do not return to idle due to ice in the throttle body.
- Consequence:
- Although the vehicle can be controlled by either applying the service brakes or shifting the transmission to neutral, increased brake pedal efforts or some increase in stopping distance can result.
- Correction:
- Dealers will install a revised pcv system with water heated vacuum source.
- Notes:
- Owner notification:owner notification is expected to begin may 19, 1997.note:owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact ford at 1-800-392-3673.also contact the national highway traffic safety administration's auto safety hotline at 1-800-424-9393.
- Campaign:
- 98V060000 on 03/26/1998
- Component:
- Fuel system, gasoline:delivery:hoses, lines/piping, and fittings
- Manufactured:
- 07/31/1996 - 01/31/1998
- Affected:
- 320,000
- Defect:
- Vehicle description: multi-purpose passenger vehicles equipped with 4.0l single overhead cam engines. the engine fuel lines can be damaged if the vehicle is jump started and the ground cable is attached to the fuel line bracket that is located near the battery. since the bracket is not grounded, the stainless steel fuel line braid could act as a ground potentially overheating the ptfe inner liner of the fuel line resulting in damage to the fuel line.
- Consequence:
- The fuel lines can leak, and in the presence of an ignition source, a fire could potentially result.
- Correction:
- Dealers will install a warning label on the fuel line bracket advising owners not to use it for a jump start ground. also a revised bolt will be installed in the alternator bracket to provide a convenient jump start ground location.
- Notes:
- Owner notification is expected to begin april 20, 1998.owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact ford at 1-800-392-3673.also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
- Campaign:
- 99V062001 on 03/30/1999
- Component:
- Vehicle speed control
- Manufactured:
- 05/28/1996 - 03/03/1999
- Affected:
- 898,739
- Defect:
- Vehicle description: certain 1997-1999 rhd explorer equipped with 4.0l ohv/sohc engines and cruise control built from may 29, 1996 through march 4, 1999; 1998-1999 explorer/mountaineers equipped with 4.0l ohv/sohc or 5.0l engines or 1998-1999 rangers equipped with 2.5l, 3.0l ffv/efi or 4.0l engines and cruise control built from january 5, 1998 through march 4, 1999; 1998-1999 mustangs equipped with 3.8l, 4.6l 2-valve or 4-valve engines and cruise control built from march 2, 1998 through march 4, 1999; 1999 f250/f350/f450/f550 (over 8,500 lbs.) trucks equipped with 5.4l or 6.8l engines and cruise control built from march 2, 1998 through march 4, 1999; and 1999 f-53 stripped chassis equipped with 5.4l or 6.8l engines and cruise control built from march 2, 1998 through march 4, 1999. a cruise control cable can interfere with the speed control servo pulley and not allow the throttle to return to idle when disengaging the cruise control.
- Consequence:
- If the cruise control is used and this condition is present, a stuck throttle could result, which could potentially result in a crash.
- Correction:
- Dealers will replace the cruise control cables. at the present time, the replacement cables are not available. customers are being advised not to use the cruise control system until a replacement can be made.
- Notes:
- A pre-release warning letter that identified an interim fix until the parts for the permanent fix became available was mailed to owners beginning march 27, 1999.a second owner notification, identifying the permanent fix was mailed to owners beginning may 24, 1999.owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact ford at 1-800-392-3673.also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
- Campaign:
- 00V168000 on 06/28/2000
- Component:
- Exterior lighting
- Affected:
- 20,637
- Defect:
- Vehicle description: mini vans, light pickup trucks, and sport utility vehicles. off lease canadian vehicles equipped with daytime running lights which meet canadian requirements and not the photometric requirements of fmvss 108, "lamps, reflective devices, and associated equipment." according to ford, the vehicles were imported into the u.s. erroneously.
- Consequence:
- The light given off from the daytime running lights is brighter than allowed by u.s. standards.
- Correction:
- Dealers will be advised to deactivate the running light function and to complete any outstanding safety recalls on these vehicles.
- Notes:
- Owner notification began july 19, 2000. owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact ford at 1-800-392-3673.also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
- Campaign:
- 00T005000 on 08/09/2000
- Component:
- Tires:tread/belt
- Affected:
- 14,400,000
- Defect:
- Tire description: firestone wilderness at, size p235/75r15, produced at the decatur, illinois tire plant and all firestone radial atx and radial atx ii tires, size p235/75r15. operation of these tires at low inflation pressures, high speed, and in hot weather, can contribute to separation of the tire tread.
- Consequence:
- If the tread separates from the tire, the driver can lose control of the vehicle, possibly resulting in a crash causing injury or death.
- Correction:
- The replacement/reimbursement program for this campaign expired on august 29, 2001. however, customers should contact firestone customer service at 1-800-465-1904 for possible assistance.
- Campaign:
- 00V402000 on 11/28/2000
- Component:
- Suspension
- Manufactured:
- 08/10/1994 - 10/30/1996
- Affected:
- 810,000
- Defect:
- Vehicle description: sport utility vehicles. under certain conditions, a front sway bar link can fracture.
- Consequence:
- Vehicle handling could be affected, increasing the risk of a crash.
- Correction:
- Dealers will replace both the left and right front sway bar links.
- Notes:
- Owner notification began december 15, 2000. owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact ford at 1-800-392-3673.also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
- Campaign:
- 00V422000 on 12/27/2000
- Component:
- Vehicle speed control
- Manufactured:
- 05/28/1996 - 10/19/1998
- Affected:
- 220,000
- Defect:
- Vehicle description: sport utility vehicles equipped with 4.0l sohc engines and still retain the original throttle body (part numbers 97jf-9e926ab or 97jf-9e926-ac). some of the original throttle bodies installed allowed a gap between the plate and bore to be built too narrow. this reduced clearance allowed the engine deposits normally present in the throttle body to contact or bridge the gap. if the engine deposits bridged the gap between the throttle plate and bore and then hardened, on the initial application of the accelerator pedal after the engine has cooled, the operator would need to apply additional force to the accelerator pedal to break the bridge.
- Consequence:
- This could result in engine surge when the accelerator pedal breaks free.
- Correction:
- Dealers will replace the original throttle bodies.
- Notes:
- Owner notification began march 5, 2001.owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact ford at 1-800-392-3673.also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
- Campaign:
- 01X001000 on 05/21/2001
- Component:
- Tires:tread/belt
- Affected:
- 13,000,000
- Defect:
- This is not a safety recall in accordance with the safety act. however, it is deemed a safety improvement campaign by the agency. equipment description: ford is replacing all firestone wilderness at 15, 16, and 17 inch tires mounted on ford trucks and suvs. ford reports tread separation can occur due to a combination of the sensitivity of the tire design to stress, aging, and manufacturing differences between plants. ford is replacing these tires to prevent possible premature tire failure. vehicle description: the vehicles listed below may have been originally equipped with firestone wilderness at tires or may have had wilderness at tires installed during the firestone recall launched in august 2000. certain 1991 throught 2002 ford explorer certain 2001 throught 2002 explorer sport, and sport trac certain 1997 through 2002 mercury mountaineer certain 1991 through 2001 ranger certain 1999 through 2001 expedition certain 1991 through 1994, and 1997 model year f-series certain 1991 through 1994 bronco note: both original equipment and replacement tires are affected.
- Consequence:
- Should the tread separate at highway speeds, a vehicle crash could occur, possibly resulting in personal injury or death.
- Correction:
- The replacement/reimbursement program for this campaign expired on march 31, 2002. however, customers can contact ford at 1-877-917-3673 or go on-line to www.ford.com for possible assistance.
- Campaign:
- 06E026000 on 03/22/2006
- Component:
- Exterior lighting
- Affected:
- 61,944
- Defect:
- Certain pro-a motors corner lamps, turn signals, and headlights sold as replacement lamps for use on certain passenger vehicles listed above. some combination lamps that are not equipped with amber side reflectors fail to conform to federal motor vehicle safety standard no. 108, lamps, reflective devices, and associated equipment.
- Consequence:
- Without the amber reflectors, the vehicle will be poorly illuminated, possibly resulting in a vehicle crash without warning.
- Correction:
- Pro-a motors will notify owners and offer to repurchase the lamps. the recall began on april 3, 2006. owners may contact pro-a motors at 323-838-2988.
- Notes:
- This recall only pertains to pro-a motors aftermarket lamps and has no relation to any original equipment installed on the listed passenger vehicles.for more information on the lamp model numbers, click on document search and view document titled "lamp model numbers."customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov.
- Campaign:
- 09E012000 on 04/06/2009
- Component:
- Exterior lighting
- Affected:
- 16,270
- Defect:
- Sabersport is recalling 16,270 combination corner and bumper lamp assemblies of various part numbers sold for use as aftermarket equipment for various passenger vehicles. these headlamps fail to conform to the requirements of federal motor vehicle safety standard no. 108, "lamps, reflective devices, and associated equipment." these lamps do not contain the required amber side reflectors.
- Consequence:
- Decreased lighting visibility may result in a vehicle crash.
- Correction:
- Sabersport will notify owners and offer a full refund for the noncompliant combination lamps. the safety recall began on may 11, 2009. owners may contact sabersport at 1-909-598-7589.
- Notes:
- This recall only pertains to aftermarket replacement equipment and has no relation to any original equipment installed on vehicles produced by the vehicle manufacturer.in order to determine if your aftermarket lamp assembly is affected by this noncompliance, please review the list of model numbers provided to us by sabersport.the list can be found under "document search" located at the bottom of your screen.owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to <a href=http://www.safercar.gov>http://www.safercar.gov</a> .
- Campaign:
- 09E025000 on 05/10/2009
- Component:
- Exterior lighting:headlights
- Affected:
- 42,540
- Defect:
- Dope, inc. is recalling 42,540 combination corner and bumper lamp assemblies of various part numbers sold for use as aftermarket equipment for various passenger vehicles. these headlamps fail to conform to the requirements of federal motor vehicle safety standard no. 108, "lamps, reflective devices, and associated equipment." these lamps do not contain the required amber side reflectors.
- Consequence:
- Decreased lighting visibility may result in a vehicle crash.
- Correction:
- Dope, inc. will notify owners and offer a full refund for the noncompliant combination lamps. the safety recall began on july 28, 2009. owners may contact dope, inc. at 1-626-272-1798.
- Notes:
- This recall only pertains to aftermarket replacement equipment and has no relation to any original equipment installed on vehicles produced by the vehicle manufacturer.in order to determine if your aftermarket lamp assembly is affected by this noncompliance, please review the list of model numbers provided to us by dope, inc.the list can be found under "document search" located at the bottom of your screen. owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to <a href=http://www.safercar.gov>http://www.safercar.gov</a> .
- Campaign:
- 09V399000 on 10/12/2009
- Component:
- Vehicle speed control
- Manufactured:
- 08/10/1994 - 08/29/2002
- Affected:
- 4,500,000
- Defect:
- Ford is recalling model years 1995-2003 windstar, 2000-2003 excursion diesel, 1993-1997 and 1999-2003 f-250 sd through f-550 sd diesel, 1992-2003 e-150 through e-550, 1995-2002 explorer, 1997 and 2002 mercury mountaineer, 1995-1997 and 2001-2003 ranger, and 1994 f53 vehicles equipped with the texas instruments speed control deactivation switch (scds). the scds may leak internally and then overheat, smoke, or burn.
- Consequence:
- A vehicle fire could occur with or without the engine running.
- Correction:
- Ford will notify owners that dealers will install a fused wiring harness in line with the scds. on 1999-2003 windstar vehicles with a leaking scds, dealers will also inspect the abs control module connector and repair as necessary. repairs will be completed free of charge. the safety recall began on october 27, 2009. owners may contact ford at 1-888-222-2751.
- Notes:
- Ford's recall campaign number is 09s09.owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to <a href=http://www.safercar.gov>http://www.safercar.gov</a> .
1997 FORD EXPLORER TSBs (368)
- Bulletin:
- BC0744961018
- Component:
- 190000 tires
- Summary:
- Firestone p235 tires may exhibit a high frequency vibration at 65-75 mph. *tt
- Bulletin:
- BC0755961017
- Component:
- 061110 engine and engine cooling:engine:gasoline:belts and associated pulleys
- Summary:
- Tensioner rattle . install a 1 inch shorter motorcraft belt (p/n f19z-8620-c). *tt
- Bulletin:
- BC0881961004
- Component:
- 022110 suspension:rear:springs:coil springs
- Summary:
- Thump/clunk noise in turns or over bumps may be caused by the kevlar patch wearing through on the torsion bar adjusters. *tt
- Bulletin:
- BC0882961004
- Component:
- 061100 engine and engine cooling:engine:gasoline
- Summary:
- Information for all base engine concerns of 4.0l sohc engines. *tt
- Bulletin:
- BC5180961001
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- Owners guide advises to use a fl-1a oil filter, fl-1a is incorrect. the correct filter is fl-820. *tt
- Bulletin:
- BC5188961001
- Component:
- 061110 engine and engine cooling:engine:gasoline:belts and associated pulleys
- Summary:
- Concern of a tensioner rattle w/ 4.0l sohc, install a 1 inch shorter motorcraft belt (p/n f19z-8620-c). *tt
- Bulletin:
- BC5195961001
- Component:
- 190000 tires
- Summary:
- Firestone p235 tires may exhibit a high frequency vibration at 65-75 mph. *tt
- Bulletin:
- BC5197961001
- Component:
- 106000 power train:axle assembly
- Summary:
- Some vehicles equipped w/ an ax4s transaxle may have been shipped w/ a low transaxle fluid level. *tt
- Bulletin:
- BC5225961001
- Component:
- 105300 power train:driveline:driveshaft
- Summary:
- Vehicles may experience a vibration during wide open throttle acceleration or while cruising at highway speeds. revised front driveshaft. *tt
- Bulletin:
- BC0324961101
- Component:
- 061100 engine and engine cooling:engine:gasoline
- Summary:
- Cold engine knock/tick noise. *tw
- Bulletin:
- BC0342961127
- Component:
- 114000 electrical system:wiring
- Summary:
- When a rear hego (cms) concern is noted, please check the rear cms hego for wire chafing/damage and loose hego wire. *tw
- Bulletin:
- BC0481961113
- Component:
- 063200 engine and engine cooling:exhaust system:manifold/header/muffler/tail pipe
- Summary:
- Vehicles may exhibit an exhaust manifold impingement noise. *tw
- Bulletin:
- BC0533961108
- Component:
- 036100 service brakes, hydraulic:antilock:control unit/module
- Summary:
- Instructions for diagnosing faulty abs sensors. *tw
- Bulletin:
- BC0534961108
- Component:
- 105300 power train:driveline:driveshaft
- Summary:
- Driveshaft design may cause floorpan vibration while at highway speeds or with throttle wide open. *tw
- Bulletin:
- BC0069961101
- Component:
- 106000 power train:axle assembly
- Summary:
- Concern of binding/axle wind-up at low speed. *tw
- Bulletin:
- BC5231961101
- Component:
- 021000 suspension:front
- Summary:
- Vehicle lean. *tw
- Bulletin:
- BC5238961101
- Component:
- 063200 engine and engine cooling:exhaust system:manifold/header/muffler/tail pipe
- Summary:
- Vehicle may exhibit an exhaust manifold impingement noise. *tw
- Bulletin:
- 96246
- Component:
- 114000 electrical system:wiring
- Summary:
- Wiring - electrical diode identification and service replacements. *tw
- Bulletin:
- 96249
- Component:
- 103700 power train:automatic transmission:torque converter
- Summary:
- Torque converter - leak test procedure - service tip. *tw
- Bulletin:
- 962410
- Component:
- 103000 power train:automatic transmission
- Summary:
- Transmission - e40d - 4r70w - 4r44e - 5r55e - new digital transmission range sensor - diagnosis service tip. *tw
- Bulletin:
- 96221
- Component:
- 131000 visibility:windshield
- Summary:
- Windshield and interior glass - fog/film. *tw
- Bulletin:
- 96222
- Component:
- 034000 service brakes, hydraulic:foundation components
- Summary:
- Brakes - elimination of sanding rotors and drums - service tip. *tw
- Bulletin:
- 96225
- Component:
- 075000 fuel system, gasoline:carburetor system
- Summary:
- Mass air flow sensor - replacement as an assembly - service tip. *tw
- Bulletin:
- 96226
- Component:
- 353600 equipment:air conditioner
- Summary:
- Air conditioning - compressor failure - insufficient amount of refrigerant oil. *tw
- Bulletin:
- 962511
- Component:
- 116200 electrical system:ignition:module
- Summary:
- Powertrain control module -reprogram powertrain control module (pcm) - service procedures - service tip. *tw
- Bulletin:
- 962612
- Component:
- 103700 power train:automatic transmission:torque converter
- Summary:
- Transaxle - torque converter replacement guidelines and torque converter/transaxle cooling system cleaning procedures - service tip. *tw
- Bulletin:
- BC0012970201
- Component:
- 114000 electrical system:wiring
- Summary:
- Customers report inoperable remote entry or keyless entry feature. the cause has been identified as a static build-up on the seat that damages the rap module. *jd
- Bulletin:
- BC0050970201
- Component:
- 123000 exterior lighting:tail lights
- Summary:
- When servicing the lamp outage module (lom) on the above vehicles please verify if the vehicle has 1) an aftermarket kit for trailer towing or 2) aftermarket kit allowing the vehicle to be towed. *jd
- Bulletin:
- BC0133970201
- Component:
- 104000 power train:transfer case (4-wheel drive)
- Summary:
- Revised vent tube for 1995-97 explorers & mountaineers with water ingestion into transfer case. *jd
- Bulletin:
- BC0184970201
- Component:
- 101100 power train:clutch assembly:pedal/linkage
- Summary:
- procedure to purge potential water contamination from transfer case. *jd
- Bulletin:
- BC0190970201
- Component:
- 060000 engine and engine cooling
- Summary:
- Vehicles built prior to 10/1/96 may have been built with wrong temp gauge system parts. *jd
- Bulletin:
- BC0206970201
- Component:
- 104000 power train:transfer case (4-wheel drive)
- Summary:
- Transfer case bind or shudder. *jd
- Bulletin:
- BC0225970201
- Component:
- 106000 power train:axle assembly
- Summary:
- Binding/axle wind-up at low speed. *jd
- Bulletin:
- BC0257970201
- Component:
- 162300 structure:body:door
- Summary:
- Power locks cycle by themselves remove each power lock switch and measure the open resistance. *jd
- Bulletin:
- BC0317970201
- Component:
- 103000 power train:automatic transmission
- Summary:
- Driveline wind-up in "4-auto" mode. *jd
- Bulletin:
- BC0324970201
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Cold engine knock/tick noise. *jd
- Bulletin:
- BC1011297020
- Component:
- 104000 power train:transfer case (4-wheel drive)
- Summary:
- 4.0l ohv/sohc 4x4 explorers with transfer case bind or shudder. *jd
- Bulletin:
- BC1012797020
- Component:
- 104000 power train:transfer case (4-wheel drive)
- Summary:
- Revised vent tube for vehicles with water ingestion into transfer case. *jd
- Bulletin:
- BC1015097020
- Component:
- 120000 exterior lighting
- Summary:
- Lamp outage module (lom) on the vehicles- please verify if the vehicle has: 1) an aftermarket kit for trailer towing or 2) aftermarket kit allowing the vehicle to be towed. *jd
- Bulletin:
- BC1016497020
- Component:
- 162300 structure:body:door
- Summary:
- Inoperable remote entry or keyless entry feature. the cause has been identified as a static build-up on the seat that damages the rap module. *jd
- Bulletin:
- 97116
- Component:
- 103000 power train:automatic transmission
- Summary:
- Transfer case- water ingestion through vent tube. *jd
- Bulletin:
- BC0012972301
- Component:
- 162300 structure:body:door
- Summary:
- Customers report inoperable remote entry or keyless entry feature. *jd
- Bulletin:
- BC0050972301
- Component:
- 114000 electrical system:wiring
- Summary:
- When servicing the lamp outage module (lom) on a vehicle please verify if the vehicle has 1) an aftermarket kit for trailer towing or 2) aftermarket kit allowing the vehicle to be towed. *jd
- Bulletin:
- BC0317972301
- Component:
- 105000 power train:driveline
- Summary:
- Driveline wind-up in "4-auto" mode. *jd
- Bulletin:
- BC3363972301
- Component:
- 116200 electrical system:ignition:module
- Summary:
- The ngs displays incorrect date for the ing gem pid on the vehicles. *jd
- Bulletin:
- BC3441972301
- Component:
- 103800 power train:automatic transmission:park/neutral start switch
- Summary:
- As of 1/7/97 the automatic shift lock feature tag that was affixed around the gear selector, has been discontinued for prodution. *jd
- Bulletin:
- BC3481972301
- Component:
- 063200 engine and engine cooling:exhaust system:manifold/header/muffler/tail pipe
- Summary:
- Exhaust noise heard in the passenger compartment most present at tip-in a nd cruise after ssm 5238 has been performed. *jd
- Bulletin:
- BC3483972301
- Component:
- 980000 unknown or other
- Summary:
- The vehicle will shift 1,2,3,4,5 regardless of throttle postion. *jd
- Bulletin:
- BC3484972301
- Component:
- 103400 power train:automatic transmission:lever and linkage:column shift
- Summary:
- When performing tsb 96-24-16, the existing transfer case vibration damper should not be adapted and reinstalled to the service replacement transfer case. *jd
- Bulletin:
- BC3485972301
- Component:
- 062300 engine and engine cooling:cooling system:hose
- Summary:
- 4.0l equipped vehicles may experience temperature gauge fluctuation that may be accompanied with a thumping noise or feel in the coolant hose with the engine at normal operating temperature. *jd
- Bulletin:
- BC3491972301
- Component:
- 061200 engine and engine cooling:engine:diesel
- Summary:
- Some 4.0l engines with block heaters may experience coolant leaks due to interference with the block. *jd
- Bulletin:
- BC3493972301
- Component:
- 021000 suspension:front
- Summary:
- Vehicles exhibiting a pulsating, cyclical type of noise coming from the front axle tube area from 0 to 45 mph. *jd
- Bulletin:
- BC3494972301
- Component:
- 063200 engine and engine cooling:exhaust system:manifold/header/muffler/tail pipe
- Summary:
- Various vehicles may experience a high pitched whistle during heavy acceleration at 3800-5000 rpm when engine is warm- to fix, remove existing muffler and replace with same part. *jd
- Bulletin:
- BC1018997230
- Component:
- 061200 engine and engine cooling:engine:diesel
- Summary:
- Block heaters may experience coolant leaks due to interference with the block. *jd
- Bulletin:
- BC1019197230
- Component:
- 021000 suspension:front
- Summary:
- Exhibiting a pulsating, cyclical type of noise coming from the front axle tube area from 0 to 45 mph. *jd
- Bulletin:
- BC1019297230
- Component:
- 063200 engine and engine cooling:exhaust system:manifold/header/muffler/tail pipe
- Summary:
- Vehicles may experience a high pitched whistle during heavy acceleration at 3800-5000 rpm when engine is warm. *jd
- Bulletin:
- BC1019497230
- Component:
- 021230 suspension:front:springs:air suspension system
- Summary:
- Vehicles may exhibit reverse operating characteristics when switching the air suspension switch from normal to off road. *jd
- Bulletin:
- BC1019597230
- Component:
- 063200 engine and engine cooling:exhaust system:manifold/header/muffler/tail pipe
- Summary:
- Exhaust noise heard in the passenger compartment most present a tip-in a nd cruise after ssm 5238 has been performed. *jd
- Bulletin:
- BC1019797230
- Component:
- 980000 unknown or other
- Summary:
- The vehicles will shift 1,2,3,4,5 regardless of throttle position. *jd
- Bulletin:
- BC1019897230
- Component:
- 103400 power train:automatic transmission:lever and linkage:column shift
- Summary:
- Performing tsb 96-24-16, the existing transfer case vibration damper should not be adapted and reinstalled to the service replacement transfer case.
- Bulletin:
- BC1019997230
- Component:
- 062300 engine and engine cooling:cooling system:hose
- Summary:
- 4.0l equipped vehicles may experience temperature gauge fluctuation that may be accompnied with a thumping noise or feel in the coolant hoses with the engine at normal operating temperature. *jd
- Bulletin:
- BC1022797230
- Component:
- 116200 electrical system:ignition:module
- Summary:
- The ngs displays incorrect data for the ign gem pid on the vehicles. *jd
- Bulletin:
- BC1024097230
- Component:
- 180000 vehicle speed control
- Summary:
- Increased throttle efforts may be noted on some 4.0l sohc equipped vehicles due to throttle plate alignment. *jd
- Bulletin:
- BC1025297230
- Component:
- 022000 suspension:rear
- Summary:
- Front axle vent leaks on 1997 exsplorers built before 11/1/06. *jd
- Bulletin:
- BC0317A97020
- Component:
- 106000 power train:axle assembly
- Summary:
- Driveline wind-up in 4-auto mode. *tw
- Bulletin:
- 9735
- Component:
- 353600 equipment:air conditioner
- Summary:
- Air conditioning- r-134a tracer dye installed in a/c system and three o-ring spring lock couplers- service tip. *jd
- Bulletin:
- 9738
- Component:
- 162300 structure:body:door
- Summary:
- Remote keyless entry- rke inoperative- vehicles built through 10/30/96. *jd
- Bulletin:
- 97312
- Component:
- 353400 equipment:electrical:radio/tape deck/cd etc.
- Summary:
- Cd player- "skips"- high series console- normal driving conditions. *jd
- Bulletin:
- 97314
- Component:
- 104000 power train:transfer case (4-wheel drive)
- Summary:
- Transfer case- binding or shudder- diagnostics- vehicles with 4.0l engine- service tip. *jd
- Bulletin:
- 9747
- Component:
- 160000 structure
- Summary:
- Frame- rivet replacement with bolts- service tips. *jd
- Bulletin:
- BC3092970225
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Rear crankshaft seal oil leaks. *tw
- Bulletin:
- BC3132970221
- Component:
- 355100 equipment:other:labels
- Summary:
- Incorrect oil viscosity label in engine compartment. *tw
- Bulletin:
- BC1028397020
- Component:
- 116200 electrical system:ignition:module
- Summary:
- The 1997 explorer 4.0l sohc is the only vehicle equipped with a new style (black plastic) dpfe sensor. *jd
- Bulletin:
- BC3134970221
- Component:
- 116000 electrical system:ignition
- Summary:
- Oem spark plugs may exhibit a concern of an open circuit caused by an internal crack. *tw
- Bulletin:
- BC3155970219
- Component:
- 061100 engine and engine cooling:engine:gasoline
- Summary:
- 4.0l shoc engine quits while driving and will not restart. *tw
- Bulletin:
- BC3156970219
- Component:
- 061100 engine and engine cooling:engine:gasoline
- Summary:
- Explorers equipped with the 4.0l sohc engine may exhibit a hiss/whistle at tip in. *tw
- Bulletin:
- BC1030297020
- Component:
- 180000 vehicle speed control
- Summary:
- Engine may exhibit a hiss/whistle at tip-in from the throttle body/iac area of the engine. *jd
- Bulletin:
- BC1031297020
- Component:
- 980000 unknown or other
- Summary:
- Some vehicle engine compartment decals may incorrectly list 10w30 for oil viscosity. *jd
- Bulletin:
- BC1033197020
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Vehicles with rear crankshaft seal oil leaks. *jd
- Bulletin:
- BC1035497020
- Component:
- 116000 electrical system:ignition
- Summary:
- 4.0l sohc engine comes from the factory with single platinum plugs. *jd
- Bulletin:
- BC1035597020
- Component:
- 062100 engine and engine cooling:cooling system:radiator assembly
- Summary:
- Radiators may exhibit a coolant leak at the end tank seals in cold temperatures. *jd
- Bulletin:
- BC3274970207
- Component:
- 121000 exterior lighting:headlights
- Summary:
- Replacement headlamp bulbs - several aftermarket companies are offering replacement bulbs with a higher wattage that are not dot approved - sold with disclaimer of "for off-road use only" - the bulbs draw more current than the oem bulbs a
- Bulletin:
- BC3282970206
- Component:
- 116200 electrical system:ignition:module
- Summary:
- Gem concern - check for more than one gem controlled component that is inoperative or for a string of false gem dtc's received in memory. *tw
- Bulletin:
- BC3283970206
- Component:
- 171100 latches/locks/linkages:doors:latch
- Summary:
- Door latch switch is causing the door ajar light/chime not to work properly. *tw
- Bulletin:
- 9776
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Idle- "booming" noise heard at idle- 4.0l sohc engine- vehicles built from 7/29/96 through 11/11/96. *jd
- Bulletin:
- 9751
- Component:
- 220000 seats
- Summary:
- Interior- leather seat cleaning procedure- service tip. *jd
- Bulletin:
- 9755
- Component:
- 116200 electrical system:ignition:module
- Summary:
- Malfunction indicator lamp (mil)- mil illumination- diagnostic trouble code (dtc) p0446 stored in memory. *jd
- Bulletin:
- 97511
- Component:
- 103000 power train:automatic transmission
- Summary:
- Fluid- transmission fluid usage charts. *jd
- Bulletin:
- 97513
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Idle- "booming" noise heard at idle- 4.0l engine- vehicles built from 7/29/96 through 11/11/96. *jd
- Bulletin:
- 97514
- Component:
- 353400 equipment:electrical:radio/tape deck/cd etc.
- Summary:
- Cd player- "skips"- high series console- normal driving conditions. *jd
- Bulletin:
- 9768
- Component:
- 980000 unknown or other
- Summary:
- Fuel economy- customer expectations versus vehicle usage. *jd
- Bulletin:
- 96E57
- Component:
- 063000 engine and engine cooling:exhaust system
- Summary:
- Emissions recall 96e57 - certain 1996 explorers equipped with the 4.0l engines and built at the louisville assembly plant on 11/18/95 and certain 1997 explorers equipped with the 4.0l engines and built at the louisville assembly plant from
- Bulletin:
- BC2236970501
- Component:
- 162000 structure:body
- Summary:
- Vehicles may exhibit a center console squeak or rattle. *tw
- Bulletin:
- BC2237970501
- Component:
- 063130 engine and engine cooling:exhaust system:emission control:gas recirculation valve (egr valve)
- Summary:
- Recall 97s67 - modification of the pcv valve requires a special tool whicl will sent to listed parts managers. *tw
- Bulletin:
- BC2246970501
- Component:
- 136000 visibility:windshield wiper/washer
- Summary:
- Vehicles built on or after 4/14/97 will no longer have a rear washer bottle - a redesigned front washer bottle will supply the fluid to both washers. *tw
- Bulletin:
- BC2301970501
- Component:
- 102000 power train:manual transmission
- Summary:
- New clutch slave cylinder with a redesigned lip seal. *tw
- Bulletin:
- BC2302970501
- Component:
- 116200 electrical system:ignition:module
- Summary:
- Dtc p0402 in memory under investigation by engineering. *tw
- Bulletin:
- BC2306970501
- Component:
- 161000 structure:frame and members
- Summary:
- Some running board pads may warped. *tw
- Bulletin:
- BC2313970501
- Component:
- 116200 electrical system:ignition:module
- Summary:
- May 1997 gem software has errors - june software is correct. *tw
- Bulletin:
- BC2383970501
- Component:
- 116200 electrical system:ignition:module
- Summary:
- Service fix for vehicles which exhibit shudder/bind in turns while in 4x4 mode.
- Bulletin:
- BC2384970501
- Component:
- 161000 structure:frame and members
- Summary:
- Liftgate lock concerns on vehicles built through 12/96. *tw
- Bulletin:
- BC2440970501
- Component:
- 980000 unknown or other
- Summary:
- 1997 4.0l sohc 4x4 explorers and 1997 5.0l awd explorers/mountaineers should not be equipped with a vibration damper on the transfer case. *tw
- Bulletin:
- BC2442970501
- Component:
- 162300 structure:body:door
- Summary:
- Liftgate locks will not lock/unlock when actuated by the power switches. *tw
- Bulletin:
- BC3092970501
- Component:
- 061100 engine and engine cooling:engine:gasoline
- Summary:
- Engineering is investigating rear crankshaft oil leaks. *tw
- Bulletin:
- BC105609705
- Component:
- 116200 electrical system:ignition:module
- Summary:
- Vehicles may exhibit shudder/bind in turns while in 4x4 auto mode. *tw
- Bulletin:
- BC105789705
- Component:
- 116200 electrical system:ignition:module
- Summary:
- Vehicles with dtc p0402 in memory are under investigation by engineering department. *tw
- Bulletin:
- BC105829705
- Component:
- 161000 structure:frame and members
- Summary:
- Some running board pads may be warped. *tw
- Bulletin:
- BC105979705
- Component:
- 101000 power train:clutch assembly
- Summary:
- Update information for 1997 4r44e and 5r55e transmissions - there are two (2) different size direct clutch steel plates when servicing 4r44e or 5r55e transmissions. *tw
- Bulletin:
- BC106049705
- Component:
- 136000 visibility:windshield wiper/washer
- Summary:
- Vehicles built after 4/14/97 no longer have a rear washer bottle - redesigned front washer bottle will service the front and rear washers. *tw
- Bulletin:
- 97050110611
- Component:
- 162000 structure:body
- Summary:
- Vehicles may exhibit a center console squeak. *tw
- Bulletin:
- 97050110613
- Component:
- 020000 suspension
- Summary:
- When performing tsb 97-4-9, do not use a baffle to correct hte issue, use the revised axle cover plate. *tw
- Bulletin:
- 97050110634
- Component:
- 162500 structure:body:tailgate
- Summary:
- Engineering is investigating concerns of broken liftgate glass. *yc
- Bulletin:
- 971110972312
- Component:
- 105000 power train:driveline
- Summary:
- Concerns with "pinging" or "creaking" being heard from the driveline when shifting from park to drive or reverse, between drive and reverse, or when engaging the clutch. *yc
- Bulletin:
- 97090297183
- Component:
- 103100 power train:automatic transmission:control module (tcm, pcm)
- Summary:
- Experiencing difficulties with the malfunction indicator lamp (mil). *yc
- Bulletin:
- 97090297189
- Component:
- 062000 engine and engine cooling:cooling system
- Summary:
- Experiencing a "thumping" noise or tempeature gauge fluctation with some vehicles. *yc
- Bulletin:
- 9831
- Component:
- 162000 structure:body
- Summary:
- Repairs to vinyl covered surfaces. *yc
- Bulletin:
- 9833
- Component:
- 162000 structure:body
- Summary:
- Service tips for surface defect removal without repainting. *yc
- Bulletin:
- 98021698311
- Component:
- 021000 suspension:front
- Summary:
- Some vehicles may exhibit a drift/pull, show signs of tire wear, or exhibit poor ride quality. *yc
- Bulletin:
- 985A5
- Component:
- 034530 service brakes, hydraulic:foundation components:disc:rotor
- Summary:
- Hub-mount brake rotor machining equipment from rotunda is now approved for warranty and service use. *yc
- Bulletin:
- 985A11
- Component:
- 034000 service brakes, hydraulic:foundation components
- Summary:
- Service tip information regarding elimination of sanding rotors and drums. *yc
- Bulletin:
- 9888
- Component:
- 103000 power train:automatic transmission
- Summary:
- Information on a new transmission fluid usage chart. *yc
- Bulletin:
- 9889
- Component:
- 031000 service brakes, hydraulic:pedals and linkages
- Summary:
- Some customers notice a grinding, whining, pulsing, or fluttering at the brake pedal at speeds below 19 km/h (12 mph). *yc
- Bulletin:
- 9845
- Component:
- 045300 service brakes, air:disc:rotor
- Summary:
- Availability of hub-mount brake rotor machining equipment. *yc
- Bulletin:
- 9852
- Component:
- 190000 tires
- Summary:
- Information on tire company telephone numbers for customer assistance. *yc
- Bulletin:
- 98514
- Component:
- 105000 power train:driveline
- Summary:
- Concerns with a whistling or hissing noise from the main control area occuring while idling in drive and / or reverse on some vehicles. *tt
- Bulletin:
- 9864
- Component:
- 063000 engine and engine cooling:exhaust system
- Summary:
- Information on a buzzing or rattle noise from the exhaust system. *tt
- Bulletin:
- 9873
- Component:
- 353400 equipment:electrical:radio/tape deck/cd etc.
- Summary:
- Experiencing a whining / buzzing noise in the speakers of the entertainment radio or two-way radio. *tt
- Bulletin:
- 980313
- Component:
- 063000 engine and engine cooling:exhaust system
- Summary:
- Experiencing idle vibration / exhaust boom. *yc
- Bulletin:
- 980318
- Component:
- 103400 power train:automatic transmission:lever and linkage:column shift
- Summary:
- Conditions with axle wind-up on tight turns with control trac transfer case. *yc
- Bulletin:
- 980319
- Component:
- 036000 service brakes, hydraulic:antilock
- Summary:
- Concerns with false abs activation while light braking at low speeds. *yc
- Bulletin:
- 980324
- Component:
- 061100 engine and engine cooling:engine:gasoline
- Summary:
- Concerns of cold engine upper knock / tick. *yc
- Bulletin:
- 982540
- Component:
- 500000 child seat
- Summary:
- Concerns with built-in rear child safety seat may not easily accommodate some children. *yc
- Bulletin:
- 98259
- Component:
- 980000 unknown or other
- Summary:
- Some vinyl covered items such as dash panels, door trim panels, consoles, etc., may exhibit a small dent, scuff, abrasion and/ or discoloration resulting from assembly, transit, dealer prep and/or customer usage. *yc
- Bulletin:
- 982511
- Component:
- 061100 engine and engine cooling:engine:gasoline
- Summary:
- Service tips on composite fuel rail. *yc
- Bulletin:
- 982515
- Component:
- 220000 seats
- Summary:
- Conditions with the front seat back lever bent. *yc
- Bulletin:
- 98211
- Component:
- 061100 engine and engine cooling:engine:gasoline
- Summary:
- Experiencing a noise and vibration during idle.
- Bulletin:
- 982122
- Component:
- 180000 vehicle speed control
- Summary:
- Some customers have reported the throttle stuck at idle on some vehicles. *yc
- Bulletin:
- 982010
- Component:
- 063000 engine and engine cooling:exhaust system
- Summary:
- Experiencing a " buzzing " or " rattling " noise from the exhaust system. *yc
- Bulletin:
- 982019
- Component:
- 221600 seats:front assembly:power adjust
- Summary:
- Concerns with the power seat control button ( knob ) may detach from the switch actuator. *yc
- Bulletin:
- 98234
- Component:
- 162800 structure:body:hood
- Summary:
- Air intake tube contacting hood insulator causing insulator wear. *yc
- Bulletin:
- 98238
- Component:
- 353600 equipment:air conditioner
- Summary:
- Condensate may leak onto the passenger floor on some vehicles. *yc
- Bulletin:
- 982310
- Component:
- 063100 engine and engine cooling:exhaust system:emission control
- Summary:
- Mass air flow (maf)- sensor contamination- service tip. *ak
- Bulletin:
- 982312
- Component:
- 103000 power train:automatic transmission
- Summary:
- Issues regareding diagnostic trouble codes ( dtcs ) p0705, p0708, p1704, and / or p1705 may be stored in memory. *yc
- Bulletin:
- 982320
- Component:
- 138000 visibility:defroster/defogger system
- Summary:
- Some vehicles with a very low odometer reading may experience a lack temperature control. *yc
- Bulletin:
- 982323
- Component:
- 162000 structure:body
- Summary:
- Information regarding replacement and / or repairs on any lock component. *yc
- Bulletin:
- 98246
- Component:
- 110000 electrical system
- Summary:
- Ford motor company has released a new electrical grease ( f8az - 19g208-aa ) to reduce the possibility of moisture corrosion at the terminals. *yc
- Bulletin:
- 9943
- Component:
- 100000 power train
- Summary:
- Information regarding reprogramming powertrain control modules (pcms). *tt
- Bulletin:
- 9946
- Component:
- 103000 power train:automatic transmission
- Summary:
- Concerns with transmission fluid leaking at radiator. *tt
- Bulletin:
- 5652
- Component:
- 353400 equipment:electrical:radio/tape deck/cd etc.
- Summary:
- Complaints that the in-dash cd stops operating when hot. *tt
- Bulletin:
- 5814
- Component:
- 103000 power train:automatic transmission
- Summary:
- Service tips for checking transmission fluid level. *tt
- Bulletin:
- 5852
- Component:
- 140000 air bags
- Summary:
- Vehicles exhibiting intermittent illumination of air bag light with diagnostic trouble code b1924. *tt
- Bulletin:
- 12571
- Component:
- 104000 power train:transfer case (4-wheel drive)
- Summary:
- Experiencing a whinning noise from the transfer case. *tt
- Bulletin:
- 12624
- Component:
- 061100 engine and engine cooling:engine:gasoline
- Summary:
- Some vehicles may exhibit a hesitation / lack of power on re-acceleration after decelerating from 45 - 65 mph to a slow roll condition. *tt
- Bulletin:
- 9814
- Component:
- 034530 service brakes, hydraulic:foundation components:disc:rotor
- Summary:
- Subject regarding the availability of hub-mount brake rotor machining equipment. *tt
- Bulletin:
- 98112
- Component:
- 103000 power train:automatic transmission
- Summary:
- Subject regarding a new service center support that uses a thrust bearing (#3 and #4) in place of thrust washers has been released. *tt
- Bulletin:
- 98113
- Component:
- 160000 structure
- Summary:
- Subject pertaining to red rust stains on the edges of the bumper center vent and fog lamp openings. *tt
- Bulletin:
- 98117
- Component:
- 120000 exterior lighting
- Summary:
- Some vehicle may exhibit malfunction indicator lamp (mil) illuminated with diagnostic trouble codes (dtcs) po171, po174, p1131 and / or p1151 stored in memory. *tt
- Bulletin:
- 98118
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Experiencing an audible noise in engine.
- Bulletin:
- 98124
- Component:
- 114000 electrical system:wiring
- Summary:
- Subject regarding an overheating condition occurring to the lamp outage module (lom-2) with the installation of certain aftermarket trailer kits that improperly connect to the tail and brake lamps circuits. *tt
- Bulletin:
- 98126
- Component:
- 114000 electrical system:wiring
- Summary:
- Subject regarding lamp outage module housing and surrounding plastic components melted - eddie bauer and limited edition models equipped with message centers and improperly connected tow wiring kits (vehicles being towed). *tt
- Bulletin:
- 976011
- Component:
- 070000 fuel system, gasoline
- Summary:
- Experiencing difficulty diagnosing vehicles with evaporative fuel system diagnostic trouble codes. *tt
- Bulletin:
- 99S09
- Component:
- 182000 vehicle speed control:linkages
- Summary:
- Recall information regarding speed control cable replacement. *tt
- Bulletin:
- 98R03
- Component:
- 063000 engine and engine cooling:exhaust system
- Summary:
- Subject regarding positive crankcase ventilation (pcv) tube modification. *tt
- Bulletin:
- 98R03
- Component:
- 063130 engine and engine cooling:exhaust system:emission control:gas recirculation valve (egr valve)
- Summary:
- Safety recall letter informing owners of modification to the positive crankcase ventilation (pcv) system. *tt
- Bulletin:
- 9988
- Component:
- 353600 equipment:air conditioner
- Summary:
- Concerns or erratic or insufficient temperature control. *tt
- Bulletin:
- 99816
- Component:
- 061100 engine and engine cooling:engine:gasoline
- Summary:
- Ford motor company now recommends sae 5w-30 viscosity grade for servicing any ford gasoline-powered vehicle regardless of model year. *tt
- Bulletin:
- 9996
- Component:
- 103000 power train:automatic transmission
- Summary:
- Experiencing a delayed or no 2-3 upshift, primarily when the transmission is cold on vehicles with ford qality remanufactured (fqr) 4r70w transmission exchange units with julian build between 062-97 and 040-99. *tt
- Bulletin:
- 99129
- Component:
- 353400 equipment:electrical:radio/tape deck/cd etc.
- Summary:
- Experiencing a whine / buzz type noise in the speakers of the entertainment radio or two-way radio on vehicles with an in-tank electric fuel pump. *tt
- Bulletin:
- 99104
- Component:
- 980000 unknown or other
- Summary:
- The malfunction indicator lamp (mil) may illuminate and diagnostic trouble codes (dtcs) p0171, p0174, p1131, and / or p1151 may be present with or without misfire, rolling idle, rough idle, etc. *tt
- Bulletin:
- 99139
- Component:
- 125000 exterior lighting:brake lights
- Summary:
- Conditions with the brake lamps inadvertently disabling the brake shift interlock. *tt
- Bulletin:
- 9946
- Component:
- 103600 power train:automatic transmission:cooling unit and lines
- Summary:
- Concerns with transmission fluid leaking at the radiator. *tt
- Bulletin:
- 060199
- Component:
- 180000 vehicle speed control
- Summary:
- Customer may complain of an intermittent stumble / buck / jerk at 38 mph while in high gear and at very light throttle application. *tt
- Bulletin:
- 6429
- Component:
- 162000 structure:body
- Summary:
- Information on refilling tissues for the center console facial tissue compartment. *tt
- Bulletin:
- 12905
- Component:
- 106000 power train:axle assembly
- Summary:
- Some vehicles may experience axle wind up and / or clunking, popping, ratcheting type noises when making cornering maneuvers on vehicles equipped with a four wheel drive hi or low range mode. *tt
- Bulletin:
- 995157
- Component:
- 190000 tires
- Summary:
- Information on maintaining tire pressure. *tt
- Bulletin:
- 983074
- Component:
- 106000 power train:axle assembly
- Summary:
- Concerns with axle wind-up and / or clunking, popping, ratcheting type noises when making cornering maneuvers. *tt
- Bulletin:
- 983109
- Component:
- 061100 engine and engine cooling:engine:gasoline
- Summary:
- Information regarding engines added to the fqr (ford quality renewal) assembly program. *tt
- Bulletin:
- 99142
- Component:
- 980000 unknown or other
- Summary:
- Vehicles with a4wd transmission and 4.0l engine may have the 4x4 indicator lamps flashing. *tt
- Bulletin:
- 99156
- Component:
- 353600 equipment:air conditioner
- Summary:
- Some vehicles may exhibit a burning odor or smoke, and / or rustling noise occuring when the blower motor is running if leaves or foreign material enters the blower case. *tt
- Bulletin:
- 996777
- Component:
- 015300 steering:hydraulic power assist:power steering fluid
- Summary:
- Exhibiting a power steering fluid leak from the steering gear boot(s). *tt
- Bulletin:
- 9913035
- Component:
- 182000 vehicle speed control:linkages
- Summary:
- Vehicles may experience a no start condition when parked on an incline with the vehicle in a nose down position and less than 1/4 tank of fuel. *tt
- Bulletin:
- 99203
- Component:
- 162200 structure:body:bumpers
- Summary:
- Information on replacing the front bumper bracket. *tt
- Bulletin:
- 99206
- Component:
- 353600 equipment:air conditioner
- Summary:
- Concerns with burning odor or smoke, and / or rustling noise while blower motor is on. *tt
- Bulletin:
- 99222
- Component:
- 114000 electrical system:wiring
- Summary:
- Subject on a wire harness terminal repair kit available for repairing electrical wiring harnesses. *tt
- Bulletin:
- 99223
- Component:
- 061100 engine and engine cooling:engine:gasoline
- Summary:
- A no start condition when vehicle is parked on an incline with the vehicle in a nose down position and less than 1/4 tank of fuel may occur. *tt
- Bulletin:
- 99185
- Component:
- 980000 unknown or other
- Summary:
- Vehicles built between 3/15/1997 and 12/31/1998 and with 4r70w transmissions may experience delayed or no 2-3 upshift, transmission control indicator lamp illuminated with diagnostic trouble code p0782 stored in memory. *tt
- Bulletin:
- 99194
- Component:
- 034000 service brakes, hydraulic:foundation components
- Summary:
- Information for servicing and diagnosing brake vibration, brake inspection, and brake friction material replacement. *tt
- Bulletin:
- 99196
- Component:
- 353600 equipment:air conditioner
- Summary:
- Information on identifying non-approved / alternate refrigerants which could cause safety, and performance concerns if installed in ford a/c systems. *tt
- Bulletin:
- 99234
- Component:
- 980000 unknown or other
- Summary:
- Information on diagnosing a vehicle with malfunction indicator lamp illuminated and diagnostic trouble codes p0442 and p0455 stored in continuous memory. *tt
- Bulletin:
- 99238
- Component:
- 062000 engine and engine cooling:cooling system
- Summary:
- A temperature gauge fluctuation and / or a knocking / thumping noise may be audible inthe passenger compartment on some vehicles. *tt
- Bulletin:
- 99242
- Component:
- 162300 structure:body:door
- Summary:
- Information on replacing and / or repairing malfunctioning (door, ignition and decklid) locks. *tt
- Bulletin:
- 6926
- Component:
- 980000 unknown or other
- Summary:
- Subject regarding the engine hotline phone numbers for 1997 - 2000 model year vehicles. *tt
- Bulletin:
- 6980
- Component:
- 980000 unknown or other
- Summary:
- Some vehicles may exhibit the check engine light on with diagnostic trouble code po420. *tt
- Bulletin:
- 6986
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Information regarding 4.0l sohc camshaft bolt torque. *tt
- Bulletin:
- 6987
- Component:
- 061100 engine and engine cooling:engine:gasoline
- Summary:
- Some vehicles may exhibit engine noise(cam chain noise). *tt
- Bulletin:
- 6993
- Component:
- 061100 engine and engine cooling:engine:gasoline
- Summary:
- Subject regarding 4.0l sohc engine repair procedure update. *tt
- Bulletin:
- 6997
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Some service manuals may list the incorrect camshaft position sensor alignment tool for vehicles with various engine sizes. *tt
- Bulletin:
- 7079
- Component:
- 220000 seats
- Summary:
- Information regarding seat that will not move forward. *mjs
- Bulletin:
- 7083
- Component:
- 354600 equipment:mechanical:wrecker and wheel lift devices
- Summary:
- Information regarding neutral tow kit availability. *mjs
- Bulletin:
- 13170
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Information regarding 4.0 l sohc camshaft bolt torque. *mjs
- Bulletin:
- 13171
- Component:
- 061100 engine and engine cooling:engine:gasoline
- Summary:
- Information regarding 4.0l sohc engine noise (cam chain noise). *mjs
- Bulletin:
- 13172
- Component:
- 061100 engine and engine cooling:engine:gasoline
- Summary:
- Information regarding sohc engine noise (cam chain noise). *mjs
- Bulletin:
- 13177
- Component:
- 061100 engine and engine cooling:engine:gasoline
- Summary:
- Information regarding 4.0l sohc engine repair procedure update. *mjs
- Bulletin:
- 13180
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Information regarding camshaft position (cmp) sensor alignment tool chart. *mjs
- Bulletin:
- 13218
- Component:
- 220000 seats
- Summary:
- Information regarding seat that willl not move forward. *mjs
- Bulletin:
- 13222
- Component:
- 354600 equipment:mechanical:wrecker and wheel lift devices
- Summary:
- Information regarding neutral tow kit available. *mjs
- Bulletin:
- 13260
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Service tips information provided to assist when servicing vehicles with short block assembly. *tt
- Bulletin:
- 7138
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Service tip information when servicing the 4.0l sohc short block assembly. *tt
- Bulletin:
- 7270
- Component:
- 061100 engine and engine cooling:engine:gasoline
- Summary:
- Some vehicles equipped with 4.0l sohc engines may exhibit a vibration / moan / boom at idle. *tt
- Bulletin:
- 98163
- Component:
- 162300 structure:body:door
- Summary:
- Locks failed. yd
- Bulletin:
- 981512
- Component:
- 063100 engine and engine cooling:exhaust system:emission control
- Summary:
- A direct replacement part for the evaporative emission canister and bracket assembly. ak
- Bulletin:
- 981514
- Component:
- 061100 engine and engine cooling:engine:gasoline
- Summary:
- A vehicle vibrates during a hot or cold idle condition.
- Bulletin:
- 7316
- Component:
- 106220 power train:axle assembly:axle shaft:seal
- Summary:
- Some vehicles may exhibit an oil leak from the front axle pinion seal. *tt
- Bulletin:
- 13388
- Component:
- 354600 equipment:mechanical:wrecker and wheel lift devices
- Summary:
- Vehicles equipped the neutral tow feature, be aware that when the neutral tow feature is enabled and the customer places the vehicle into the neutral mode, the neutral tow indicator will go out when the gem goes to sleep. *tt
- Bulletin:
- 13412
- Component:
- 103000 power train:automatic transmission
- Summary:
- Some vehicles may exhibit a condition of no 4x4 low range engagement or a stuck in 4x4 low range, with no (dtc) diagnostic trouble code stored in the gem. *tt
- Bulletin:
- 13415
- Component:
- 022110 suspension:rear:springs:coil springs
- Summary:
- Exhibiting a squeak type noise from the rear stabilizer bar while driving, especially when going over bumps. *tt
- Bulletin:
- 13424
- Component:
- 036000 service brakes, hydraulic:antilock
- Summary:
- Some vehicles equipped with four wheel anti lock brakes may exhibit wheel speed parameter identifications which read n/a immediately or above 7 mph. *tt
- Bulletin:
- 13426
- Component:
- 020000 suspension
- Summary:
- Exhibiting very light steering vibration / shimmy / nibble at engine idle or low speeds. *tt
- Bulletin:
- 981613
- Component:
- 103600 power train:automatic transmission:cooling unit and lines
- Summary:
- Transmission fluid leaks at radiator. yd
- Bulletin:
- 98165
- Component:
- 353600 equipment:air conditioner
- Summary:
- Evaporator core failed, causing the air conditioner to drip on to passenger floor. yd
- Bulletin:
- 981617
- Component:
- 980000 unknown or other
- Summary:
- Floor mat installation procedure service tip. yd
- Bulletin:
- 6574
- Component:
- 185000 vehicle speed control:cruise control
- Summary:
- Some vehicles may exhibit an occasional hoot / moan from the idle air control (iac) valve. *tt
- Bulletin:
- 6603
- Component:
- 105000 power train:driveline
- Summary:
- Some vehicles may exhibit an audible pinging or creaking noise that may be heard from the driveline when engine torque is initially applied to the driveline. *tt
- Bulletin:
- 6640
- Component:
- 140000 air bags
- Summary:
- Exhibiting an air bag lamp on intermittently with lamp fault code (lfc) 24, or diagnostic trouble code b1924 and / or b1342 stored in memory. *tt
- Bulletin:
- 7353
- Component:
- 103000 power train:automatic transmission
- Summary:
- Some vehicles may exhibit a condition of no 4x4 low range engagement or a stuck in 4x4 low range, with no diagnostic trouble codes stored in the gem module. *tt
- Bulletin:
- 7360
- Component:
- 021100 suspension:front:stabilizer bar
- Summary:
- Some vehicles may exhibit a squeak noise from the rear while driving, especially when going bumps. *tt
- Bulletin:
- 7366
- Component:
- 102000 power train:manual transmission
- Summary:
- Some vehicles equipped with manual transmission may exhibit neutral gear rollover noise (a light metallic rattling sound from the transmission) which occurs at idle with transmission in neutral clutch engaged (clutch pedal up). *tt
- Bulletin:
- 7367
- Component:
- 036000 service brakes, hydraulic:antilock
- Summary:
- Some vehicles equipped with four wheel anti-lock brakes (4wabs) may exhibit wheel speed parameter identifications (pids) which read n/a immediately or above 7 mph when viewed using the new generation star (ngs) tester. *tt
- Bulletin:
- 7468
- Component:
- 103000 power train:automatic transmission
- Summary:
- Some vehicles may exhibit a vibration / groan on acceleration or take off.
- Bulletin:
- 7471
- Component:
- 061100 engine and engine cooling:engine:gasoline
- Summary:
- Some vehicles equipped with 4.0l ohv engines may exhibit excessive oil consumption as reported by the customer. *tt
- Bulletin:
- 7494
- Component:
- 103100 power train:automatic transmission:control module (tcm, pcm)
- Summary:
- All vehicles with electronic shift on the fly transfer cases will display contact plate pids opposite of what the 1999 or earlier workshop manual indicates when using ngs with 15.0 level or later software. *tt
- Bulletin:
- 13440
- Component:
- 015000 steering:hydraulic power assist system
- Summary:
- Experiencing very light steering vibration / shimmy / nibble at engine idle or low speeds (parking lot type maneuvers). *tt
- Bulletin:
- 13482
- Component:
- 103000 power train:automatic transmission
- Summary:
- Some vehicles may exhibit a vibration / groan on acceleration or take-off due to the rear transmission mount being twisted and allowing a ground out condition to occur. *tt
- Bulletin:
- 13484
- Component:
- 061100 engine and engine cooling:engine:gasoline
- Summary:
- Vehicles equipped with 4.0l ohv engines may exhibit excessive oil consumption as reported by the customer. *tt
- Bulletin:
- 13504
- Component:
- 106220 power train:axle assembly:axle shaft:seal
- Summary:
- Concerns with vehicles exhibiting an oil leak from the front axle pinion seal. engineering is currently addressing this issue through the high milage / time-in-service concern resolution process. *tt
- Bulletin:
- 13527
- Component:
- 061100 engine and engine cooling:engine:gasoline
- Summary:
- Some vehicles equipped with 4.0l sohc engines may exhibit an overheat condition that may be attributed to the thermostat. engineering is currently investigating this issue and is looking for thermostats and coolants samples from these
- Bulletin:
- 0015
- Component:
- 103000 power train:automatic transmission
- Summary:
- Information regarding the new transmission cooler flusher- service tip. *mjs
- Bulletin:
- 8119
- Component:
- 330000 interior lighting
- Summary:
- Some vehicles equipped with 5.0l engine and all wheel drive (awd) transfer case may exhibit a condition of 4x4 indicators flashing and multiple gem diagnostic trouble codes. *tt
- Bulletin:
- 8149
- Component:
- 354600 equipment:mechanical:wrecker and wheel lift devices
- Summary:
- Subject regarding neutral tow inoperative after gem replacement. *tt
- Bulletin:
- 8164
- Component:
- 350000 equipment
- Summary:
- Information on 5r55e - 4r55e - 4r44e pump alignment tools. *tt
- Bulletin:
- 7918
- Component:
- 105500 power train:driveline:differential unit
- Summary:
- Front axle pinion lil seal leaks.
- Bulletin:
- 13857
- Component:
- 980000 unknown or other
- Summary:
- Some vehicles equipped with 5.0l engines and all wheel drive (awd) transfer case may exhibit a condition of 4x4 indicators flashing and multiple gem diagnostic trouble codes. *tt
- Bulletin:
- 13723
- Component:
- 104000 power train:transfer case (4-wheel drive)
- Summary:
- Some all wheel drive vehicles may experience a low speed whining noise from the transfer case. *mjs
- Bulletin:
- 13745
- Component:
- 100000 power train
- Summary:
- Some vehicles may experience a condition of no 4 x 4 low range engagement or a stuck in 4 x 4 low range. *mjs
- Bulletin:
- 13752
- Component:
- 106220 power train:axle assembly:axle shaft:seal
- Summary:
- Some vehicles may exhibit an oil leak from the front axle pinion seal. *mjs
- Bulletin:
- 985045
- Component:
- 021000 suspension:front
- Summary:
- Revised message regarding steering wheel shimmy, vibration or grunt on slow speed turns action on sohc equipped vehicles, perform tsb 98-21-01. *tt
- Bulletin:
- 12115
- Component:
- 190000 tires
- Summary:
- Information regarding the tire inflation pressure for all models during predelivery process and during maintenance intervals. *mjs
- Bulletin:
- 12150
- Component:
- 060000 engine and engine cooling
- Summary:
- Information concerning the replacement of the engines on vehicles equipped with a 4.0l sohc that require service. *mjs
- Bulletin:
- 12154
- Component:
- 116300 electrical system:ignition:anti-theft controller
- Summary:
- Some vehicles equipped with pats (securilock) except certain models now have availability of fleet keys through rotunda. *mjs
- Bulletin:
- 5049
- Component:
- 061100 engine and engine cooling:engine:gasoline
- Summary:
- Brief information regarding upper engine noise. *tt
- Bulletin:
- 985064
- Component:
- 061100 engine and engine cooling:engine:gasoline
- Summary:
- Repeat message regarding engine stalling *tt
- Bulletin:
- 12174
- Component:
- 061100 engine and engine cooling:engine:gasoline
- Summary:
- Some vehicles may exhibit a hard start/long crank, cold start stall, cold rough idle concern. *mjs
- Bulletin:
- 985128
- Component:
- 103400 power train:automatic transmission:lever and linkage:column shift
- Summary:
- Some vehicles with electronic shift on the fly 4x4 systems may stick in 4x4 low. *tt
- Bulletin:
- 985144
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- All vehicles equipped with 4.0l sohc that require engine service please note that the xl2z-6m289-aa (drive assembly-camshaft-lh) must be used on 4.0l sohc engines if replacement is required. *tt
- Bulletin:
- 985157
- Component:
- 190000 tires
- Summary:
- Information on setting the tire inflation pressure for 1991 through 1999 model year vehicles in the pre-delivery process and during maintenance intervals. *tt
- Bulletin:
- 0083
- Component:
- 022000 suspension:rear
- Summary:
- Some vehicles equipped with a 5.0l engine may exhibit a rubbing noise during right hand turns from the rear of the vehicle. **mr
- Bulletin:
- 8164
- Component:
- 980000 unknown or other
- Summary:
- Information regarding pump alignment tools. **mr
- Bulletin:
- 8493
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Some vehicles may experience an oil leak at the rear crankshaft area after service. **mr
- Bulletin:
- 8512
- Component:
- 106220 power train:axle assembly:axle shaft:seal
- Summary:
- Some vehicles may exhibit an oil leak from the front axle pinion oil seal area. **mr
- Bulletin:
- 14048
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Some vehicles may experience an oil leak at the rear crankshaft area after service. **mr
- Bulletin:
- 14056
- Component:
- 106220 power train:axle assembly:axle shaft:seal
- Summary:
- Some vehicles may exhibit an oil leak from the front axle pinion oil seal area. **mr
- Bulletin:
- 14061
- Component:
- 980000 unknown or other
- Summary:
- Some vehicles may come in for a malfunction indicator lamp (mil) on with diagnostic trouble code p0171 and/or p0174 in self test. **mr
- Bulletin:
- 11512
- Component:
- 138110 visibility:defroster/defogger system:windshield:blower
- Summary:
- Engineering is investigating concerns of noisy front system blower motors on certain vehicles. *tt
- Bulletin:
- 98-4732
- Component:
- 021000 suspension:front
- Summary:
- Steering wheel shimmies, vibration or grunt on slow speed turns..
- Bulletin:
- 6203
- Component:
- 070000 fuel system, gasoline
- Summary:
- Some vehicles may exhibit a no start condition when parked on an incline with the vehicle in a nose down position and less than 1/4 tank of fuel. *tt
- Bulletin:
- 6896
- Component:
- 061100 engine and engine cooling:engine:gasoline
- Summary:
- Some vehicles may exhibit an engine noise which may be perceived by the customer as a piston / connecting rod bearing knock. *tt
- Bulletin:
- 13261
- Component:
- 061100 engine and engine cooling:engine:gasoline
- Summary:
- Service tips when servicing a 4.0l sohc short block assembly. *tt
- Bulletin:
- 12710
- Component:
- 071100 fuel system, gasoline:storage:tank assembly
- Summary:
- Some vehicles may exhibit a no start condition when parked on an incline with the vehicle in a noise down position and less than 1/4 tank of fuel. *tt
- Bulletin:
- 12512
- Component:
- 102000 power train:manual transmission
- Summary:
- Brief information on checking transmission fluid level. *t
- Bulletin:
- 12518
- Component:
- 353400 equipment:electrical:radio/tape deck/cd etc.
- Summary:
- Concerns with the in-dash cd stops operating when hot / radio display reads cd too hot. *tt
- Bulletin:
- 12529
- Component:
- 141100 air bags:frontal:sensor/control module
- Summary:
- Some vehicles may exhibit an air bag light on intermittently with diagnostic trouble code b1924. *tt
- Bulletin:
- 13049
- Component:
- 014200 steering:rack and pinion:rack
- Summary:
- Exhibiting a power steering fluid leak from the steering gear boot(s). *tt
- Bulletin:
- 13118
- Component:
- 061100 engine and engine cooling:engine:gasoline
- Summary:
- Some vehicles may exhibit an engine noise which may be perceived by the customer as a piston / connecting rod bearing knock. *tt
- Bulletin:
- 13154
- Component:
- 061100 engine and engine cooling:engine:gasoline
- Summary:
- Subject regarding engine hotline phone numbers. *tt
- Bulletin:
- 12852
- Component:
- 162000 structure:body
- Summary:
- Use kleenex brand juniors or li'l travelers to refill tissues for certain vehicles with the high series center console facial tissue compartment. *tt
- Bulletin:
- 13300
- Component:
- 061100 engine and engine cooling:engine:gasoline
- Summary:
- Some vehicles with 4.0l sohc engines may exhibit a vibration / moan / boom at idle. *tt
- Bulletin:
- 13404
- Component:
- 106220 power train:axle assembly:axle shaft:seal
- Summary:
- Some 4x4 vehicles may exhibit an oil leak from the front axle pinion seal. *tt
- Bulletin:
- 13505
- Component:
- 103400 power train:automatic transmission:lever and linkage:column shift
- Summary:
- All 4x4 vehicles with electronic shift onthe fly transfer cases will display contact plate pids opposite of the 1999 or earlier workshop manual indicates when using ngs with 15.0 level or later software. *tt
- Bulletin:
- 98-4817
- Component:
- 115000 electrical system:fuses and circuit breakers
- Summary:
- Some 1997-1998 explorer/mountaineer/expedition or navigator vehicles with 4-wd 4x4 system may exhibit both
- Bulletin:
- 4619
- Component:
- 980000 unknown or other
- Summary:
- Some vehicles may exhibit malfunction indicator light on with evaporative diagnostic trouble codes p0442, p0455 set. *tt
- Bulletin:
- 4623
- Component:
- 061100 engine and engine cooling:engine:gasoline
- Summary:
- Brief information for vehicles exhibiting engine stall. *tt
- Bulletin:
- 4634
- Component:
- 020000 suspension
- Summary:
- Steering wheel shimmy, vibration or grunt on slow speed turns. *tt
- Bulletin:
- 4642
- Component:
- 221200 seats:front assembly:recliner
- Summary:
- Some vehicles may come in for a bent front seat back recliner lever. *tt
- Bulletin:
- 99-8-15
- Component:
- 162300 structure:body:door
- Summary:
- Subject regarding door trim panel replacement - service tip. *tt
- Bulletin:
- 99111
- Component:
- 980000 unknown or other
- Summary:
- Information designed to aid in the diagnosis, testing and repair of noise, vibration and harshness (nvh) concerns. *tt
- Bulletin:
- 991210
- Component:
- 980000 unknown or other
- Summary:
- Ford motor company has released a private labeled material to be used for iron particle / acid rain service repairs. *tt
- Bulletin:
- 99152
- Component:
- 103000 power train:automatic transmission
- Summary:
- Information on the new flush and fill tool available through rotunda. *tt
- Bulletin:
- 4703
- Component:
- 200000 wheels
- Summary:
- Some trucks built with 16 inch chrome styled steel wheels and trucks built with 16 inch steel wheels may exhibit signs of rust around the edges of the wheels. *tt
- Bulletin:
- 11759
- Component:
- 220000 seats
- Summary:
- Some vehicles may come in for a bent front seat back recliner lever. *tt
- Bulletin:
- 11811
- Component:
- 200000 wheels
- Summary:
- Some vehicles built with 16 inch chrome styled steel wheels and with 16 inch steel wheels may exhibit signs of rust around the edges of the wheels. *tt
- Bulletin:
- 5128
- Component:
- 103400 power train:automatic transmission:lever and linkage:column shift
- Summary:
- Some vehicles with electronic shift on the fly 4x4 systems may stick in 4x4 low. engineering is investigating. *tt
- Bulletin:
- 5203
- Component:
- 185000 vehicle speed control:cruise control
- Summary:
- Some vehicles may exhibit a hard start / long crank, cold start stall, cold rough idle concern. *tt
- Bulletin:
- 5249
- Component:
- 020000 suspension
- Summary:
- Information on vehicles exhibiting steering wheel shimmy, vibration or grunt on slow speed turns. *tt
- Bulletin:
- 5256
- Component:
- 061100 engine and engine cooling:engine:gasoline
- Summary:
- Information on vehicles exhibiting upper engine noise. *tt
- Bulletin:
- 5272
- Component:
- 061100 engine and engine cooling:engine:gasoline
- Summary:
- Brief information regarding engine stall condition. *tt
- Bulletin:
- 12227
- Component:
- 110000 electrical system
- Summary:
- For all vehicles with generic electronic module (gem) concerns that require a module replacement, the technician must call for approval before removing and / or replacing the module. *tt
- Bulletin:
- 12230
- Component:
- 036000 service brakes, hydraulic:antilock
- Summary:
- All vehicles with antilock brake module concerns that require a module replacement, the technician must call for approval before removing and / or replacing the module. *tt
- Bulletin:
- 12298
- Component:
- 103000 power train:automatic transmission
- Summary:
- Some vehicles equipped with 4r70w transmissions may exhibit delayed or no 2-3 upshift, primarily when the transmission is cold. transmission control indicator light (tcil) may also flash with diagnostic trouble code p0782. *tt
- Bulletin:
- 9987
- Component:
- 103100 power train:automatic transmission:control module (tcm, pcm)
- Summary:
- Some vehicles may exhibit harsh downshift from 3rd to 1st gear while stopping; hesitation after acceleration from stop; and / or lack of power after acceleration from stop. *tt
- Bulletin:
- 090308
- Component:
- 980000 unknown or other
- Summary:
- Mil light on with evaporative dtc p0442, p0455
- Bulletin:
- 980324
- Component:
- 061100 engine and engine cooling:engine:gasoline
- Summary:
- Cold engine upper knock/tick. *ak
- Bulletin:
- 983092
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Rear crankshaft seal oil leak. *ak
- Bulletin:
- 00M12
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Ford motor company is providing additional coverage for the 4.0l sohc camshaft chain tensioner and lower intake manifold gasket. *tt
- Bulletin:
- 00243
- Component:
- 181000 vehicle speed control:accelerator pedal
- Summary:
- On some vehicles, the accelerator pedal bracket may become loose or separated from the dash panel. this may be caused by repeated excessive force on the accelerator pedal, resulting in cracking of the dash panel sheet metal at the acceler
- Bulletin:
- 002310
- Component:
- 103600 power train:automatic transmission:cooling unit and lines
- Summary:
- Subject regarding contamination from prior transmission concerns or excess wear may be trapped in the transmission fluid cooling system. *tt
- Bulletin:
- 00E11
- Component:
- 350000 equipment
- Summary:
- Service action bulletin regarding on-board diagnostic system upgrade. *tt
- Bulletin:
- 00M12
- Component:
- 061100 engine and engine cooling:engine:gasoline
- Summary:
- Subject regarding owner notification suppllemental program for vehicles equipped with 4.0l sohc engines - camshaft chain tensioner and lower intake manifold gasket additional coverage. *tt
- Bulletin:
- 14560
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Vehicles may experience start up timing chain noise. *jb
- Bulletin:
- 14583
- Component:
- 062100 engine and engine cooling:cooling system:radiator assembly
- Summary:
- Concerns with broken thermostats on engines. *jb
- Bulletin:
- 14617
- Component:
- 062100 engine and engine cooling:cooling system:radiator assembly
- Summary:
- Subject pertaining to broken thermostat. *jb
- Bulletin:
- 01M01
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Subject regarding advance notice on upcoming owner notification program which will provide additional coverage on the front cam chain guide assembly on certain vehicles. *tt
- Bulletin:
- 00L09
- Component:
- 355100 equipment:other:labels
- Summary:
- Subject pertaining to supplemental tire inflation label. *jb
- Bulletin:
- 00M11
- Component:
- 022000 suspension:rear
- Summary:
- Subject regarding additional coverage program for sway bar links. *jb
- Bulletin:
- 00201
- Component:
- 072100 fuel system, gasoline:delivery:fuel pump
- Summary:
- Some vehicles may exhibit hesitation on acceleration or while turning. *jb
- Bulletin:
- 00213
- Component:
- 353600 equipment:air conditioner
- Summary:
- Subject regarding climate control - eatc - blower motor control service tips. *jb
- Bulletin:
- 14371
- Component:
- 020000 suspension
- Summary:
- Subject regarding pop / creak noise from the rear underbody while driving. *jb
- Bulletin:
- 00E11
- Component:
- 103100 power train:automatic transmission:control module (tcm, pcm)
- Summary:
- Service action 00e11, supplement #1 - update information regarding on-board diagnostic system upgrade. *tt
- Bulletin:
- 0186
- Component:
- 106000 power train:axle assembly
- Summary:
- On some vehicles, including sport and sport trac, the front axle leaks fluid from the vent tube. *tt
- Bulletin:
- 01M01
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Owner notification program regarding additional coverage program for front cam chain guide assembly which may wear or break and cause excessive cam chain noise that does not go away after five minutes of engine operation. *tt
- Bulletin:
- 14819
- Component:
- 106000 power train:axle assembly
- Summary:
- Some 4x4 vehicles may exhibit a fluid leak from the front axle vent tube. *tt
- Bulletin:
- 14847
- Component:
- 106000 power train:axle assembly
- Summary:
- Concerns with vehicles exhbit fluid leakage from the front axle vent tube. *tt
- Bulletin:
- 14868
- Component:
- 061100 engine and engine cooling:engine:gasoline
- Summary:
- Some vehicles equipped with the 4.0 sohc engine may exhibit a primary chain rattle noise (sometimes described as a spark knock-type noise). *tt
- Bulletin:
- 01M01
- Component:
- 061100 engine and engine cooling:engine:gasoline
- Summary:
- Subject regarding additional coverage on the front cam chain guide assembly for rental vehicles with 4.0l single overhead cam (sohc) engines. *tt
- Bulletin:
- 13154
- Component:
- 980000 unknown or other
- Summary:
- Subject regarding 4.0l engine hotline phone numbers. *tt
- Bulletin:
- 01M01
- Component:
- 061100 engine and engine cooling:engine:gasoline
- Summary:
- Subject regarding owner notification program 01m01 regarding additional coverage for front cam chain guide assembly. *tt
- Bulletin:
- 13752
- Component:
- 106220 power train:axle assembly:axle shaft:seal
- Summary:
- Some 4x4 vehicles may exhibit an oil leak from the front axle pinion seal. *tt
- Bulletin:
- 13879
- Component:
- 110000 electrical system
- Summary:
- Information on replacing a gem module on 4x4 vehicles equipped with 4.0l sohc, ohv and the neutral tow kit. *tt
- Bulletin:
- 14265
- Component:
- 180000 vehicle speed control
- Summary:
- Some vehicles may exhibit an intermittent hesitation on acceleration or while turning. *tt
- Bulletin:
- 15040
- Component:
- 061100 engine and engine cooling:engine:gasoline
- Summary:
- Some explorer / sport / sport trac equipped with a 4.0l sohc engine may exhibit a start-up noise condition from the left front of the engine. *tt
- Bulletin:
- 9987
- Component:
- 103100 power train:automatic transmission:control module (tcm, pcm)
- Summary:
- Some vehicles may exhibit harsh downshift from 3rd to 1st gear while stopping, hesitation after acceleration from stop and / or lack of power after acceleration from stop on vehicles with 4.0l or 5.0l engines. *tt
- Bulletin:
- 15006
- Component:
- 061100 engine and engine cooling:engine:gasoline
- Summary:
- Some vehicles with 4.0l sohc engines may make a start-up noise from the left front of the engine. *tt
- Bulletin:
- 070101
- Component:
- 061100 engine and engine cooling:engine:gasoline
- Summary:
- Subject regarding owner notification program 01m01 supplement #2: revised technical instructions and new labor operation. nlm
- Bulletin:
- 01156
- Component:
- 138120 visibility:defroster/defogger system:windshield:heater core
- Summary:
- Some vehicles may exhibit heater core leaks. *slc
- Bulletin:
- 01157
- Component:
- 980000 unknown or other
- Summary:
- Information regarding transmission fluid usage charts. *slc
- Bulletin:
- 15168
- Component:
- 034000 service brakes, hydraulic:foundation components
- Summary:
- Some vehicles may exhibit an intermittent high frequency brake squeal noise. *yh
- Bulletin:
- 01181
- Component:
- 103800 power train:automatic transmission:park/neutral start switch
- Summary:
- Brake shift interlock.*jb
- Bulletin:
- 15249
- Component:
- 034000 service brakes, hydraulic:foundation components
- Summary:
- Concerns with high brake pedal force to stop after rotor machining. *tt
- Bulletin:
- 00M11
- Component:
- 021220 suspension:front:springs:torsion bar
- Summary:
- Information regarding front sway bar link . *yh
- Bulletin:
- 01197
- Component:
- 061100 engine and engine cooling:engine:gasoline
- Summary:
- Some vehicles equipped with the 4.0l ohv engine may exhibit an engine noise which may be perceived by the customer as a piston / onnecting rod bearing knock. *tt
- Bulletin:
- 01205
- Component:
- 061100 engine and engine cooling:engine:gasoline
- Summary:
- Some vehicles may exhibit vacuum or air leaks in the intake manifold and / or engine system causing diagnostic trouble codes p0171 and or p0174. *tt
- Bulletin:
- 01B77
- Component:
- 190000 tires
- Summary:
- Owner notification program supplement 7 revised information - regarding replacement of wilderness at tires. *tt
- Bulletin:
- 0214
- Component:
- 061100 engine and engine cooling:engine:gasoline
- Summary:
- Some engine assemblies with aluminum cylinder heads repaired in-vehile have been found to leak coolant and/or oil from the cylinder head gasket area. *tt
- Bulletin:
- 15532
- Component:
- 072200 fuel system, gasoline:delivery:hoses, lines/piping, and fittings
- Summary:
- Information on vehicles exhibitng fuel line damage due to pinching/squeezing of the fuel return line. *tt
- Bulletin:
- 15040
- Component:
- 061100 engine and engine cooling:engine:gasoline
- Summary:
- Some vehicles including 1997 through 1999 explorer sport trac equipped with a 4.0l sohc engine may exhibit a start-up noise from the left front of the engine. *tt
- Bulletin:
- 15563
- Component:
- 980000 unknown or other
- Summary:
- Information regarding malfunction indicator light illuminating with diagnostic trouble code p0300/p0301.*yh
- Bulletin:
- 01246
- Component:
- 061100 engine and engine cooling:engine:gasoline
- Summary:
- Engine oil system priming procedures, service tips for reports of premature engine failure. *tt
- Bulletin:
- 0232
- Component:
- 980000 unknown or other
- Summary:
- Some vehicles equipped with the 4.0l sohc engine may exhibit a check engine light on with diagnostic trouble codes p0300 (random misfire) or p0301. *tt
- Bulletin:
- 02138
- Component:
- 102000 power train:manual transmission
- Summary:
- Low line pressure reading at wide open throttle (wot), slipping shifts and / or delayed engagements with possible diagnostic trouble codes p0732, p0733, p1762 set on vehicles built before 12/1/2001. *tt
- Bulletin:
- 0242
- Component:
- 106000 power train:axle assembly
- Summary:
- Certain vehicles with 4x4 or all-wheel drive may have a fluid leak from the front axle vent tube. *tt
- Bulletin:
- 16040
- Component:
- 010000 steering
- Summary:
- Experiencing a clicking / popping noise from the upper steering column area when turning the steering wheel. *tt
- Bulletin:
- 15692
- Component:
- 020000 suspension
- Summary:
- Some vehicles may exhibit a squeak, snap, rattle, or clunk in the front end when turning or going over bumps. *tt
- Bulletin:
- 15887
- Component:
- 100000 power train
- Summary:
- Some vehicles may exhibit a no 1-2 upshift, no 2-3 upshift, a no engine braking condition in manual 1 or diagnostic trouble code p0732 (gear 2 incorrect ratio) or p0733 (gear 3 incorrect ratio). *tt
- Bulletin:
- 15910
- Component:
- 034000 service brakes, hydraulic:foundation components
- Summary:
- Concerns with brake vibration, roughness and / or grinding noise, and excessive brake rotor corrosion. *tt
- Bulletin:
- 0282
- Component:
- 100000 power train
- Summary:
- Some vehicles built prior to 9/15/2001 may exhibit low line pressure readings while in drive, no 2nd gear, no 3rd gear, no engine braking in manual 1st and slipping shifts and / or delayed engagements. *tt
- Bulletin:
- 870197
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Incorrectly installed gear driven camshaft position (cmp) sensor synchronizer assemblies causing surge, lost of power, malfunction indicator lamp on and diagnostic trouble codes p1336, p1309 and p0340. *tt
- Bulletin:
- 0358
- Component:
- 106000 power train:axle assembly
- Summary:
- Fluid may leak out of the front axle vent tube. *tt *jb
- Bulletin:
- 16735
- Component:
- 022000 suspension:rear
- Summary:
- Various noise issues from the rear leaf springs while driving. *tt
- Bulletin:
- 0398
- Component:
- 090000 fuel system, other
- Summary:
- Malfunction indicator lamp (mil) illumination with diagnostic trouble codes p0442, p0455, p0456, p0457, p1442 or check fuel cap lamp illuminated with diagnostic trouble code p0457. *tt
- Bulletin:
- 03148
- Component:
- 103600 power train:automatic transmission:cooling unit and lines
- Summary:
- New transmission cooler flusher - service tips. 2003 escort and super duty f series included. *tt
- Bulletin:
- 16935
- Component:
- 100000 power train
- Summary:
- An uncommanded shift to 4x4 low. *tt
- Bulletin:
- 03181
- Component:
- 110000 electrical system
- Summary:
- Remote keyless entry (rke) - service tips. *tt
- Bulletin:
- 03261
- Component:
- 103000 power train:automatic transmission
- Summary:
- New service part - number 5 needle bearing and race kit - 4r70w transmission - service tip. *tt
- Bulletin:
- 02221
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Engine-gear driven synchronizers-incorrect installation-camshaft position synchronizer (cmp) installation tool correct application. *mj
- Bulletin:
- 16385
- Component:
- 021230 suspension:front:springs:air suspension system
- Summary:
- Air ride control lamp on after shock absorber replacement / contact request. *tt
- Bulletin:
- 02176
- Component:
- 032100 service brakes, hydraulic:switches:brake light
- Summary:
- Lamp-brake-invadvertent disabling of brake shift interlock. *mj
- Bulletin:
- 042107
- Component:
- 103100 power train:automatic transmission:control module (tcm, pcm)
- Summary:
- General (pcm) power train control module programming procedures. *tt
- Bulletin:
- 030508
- Component:
- 106000 power train:axle assembly
- Summary:
- Front axle leaks fluid from vent tube - vehicles equipped with 4x4 or awd. *tt
- Bulletin:
- RCDNN-00V402-817
- Component:
- 021100 suspension:front:stabilizer bar
- Summary:
- This recall action involves replacement of the front stabilizer bar links in certain 1995 through 1997 model year explorer and mountaineer vehicles. under certain conditions, predominantly in cold weather areas, a front stabilizer bar
Home | Privacy