1997 FORD ECONOLINE Recalls (4)

Campaign:
96V193000 on 10/16/1996
Component:
Electrical system:battery:cables
Manufactured:
06/09/1996 - 09/04/1996
Affected:
5,000
Defect:
The battery cable harness does not have adequate protection from contacting and being damaged by the right engine mount.
Consequence:
If the battery cable or starter wire insulation is damaged by such contact, a short to ground can occur resulting in overheating of the wiring and possible ignition of surrounding components.
Correction:
Dealers will inspect for chafing of the cable and will add insulation and a tie strap to the battery cable harness.
Notes:
Owner notification:owner notification began october 14, 1996. note:owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact ford at 1-800-392-3673.also contact the national highway traffic safety administration's auto safety hotline at 1-800-424-9393.
Campaign:
08V051000 on 02/03/2008
Component:
Vehicle speed control:cruise control
Manufactured:
09/02/1991 - 09/14/2003
Affected:
225,000
Defect:
Ford is recalling 225,000 my 1992-2003 econoline, my 1993-1995 taurus sho, my 1992-1998 crown victoria, my 1993 bronco, f-series, my 1995-1997 f-series super duty stripped chassis, my 1992-1998 mercury grand marquis, and my 1992-1995 lincoln town car vehicles. the affected vehicles were previously repaired using a wiring harness that is not compatible with the vehicle circuit polarity.
Consequence:
As a result, the fuse is located in the output circuit rather than in the intended input power feed circuit, and may not offer the intended protection in the event of an electrical short to ground.
Correction:
Dealers will install a new wiring harness, or replace the mating electrical component. the recall began on february 18, 2008. owners may contact ford at 1-800-392-3673.
Notes:
Ford recall no. 08s01.customers may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov.
Campaign:
09E012000 on 04/06/2009
Component:
Exterior lighting
Affected:
16,270
Defect:
Sabersport is recalling 16,270 combination corner and bumper lamp assemblies of various part numbers sold for use as aftermarket equipment for various passenger vehicles. these headlamps fail to conform to the requirements of federal motor vehicle safety standard no. 108, "lamps, reflective devices, and associated equipment." these lamps do not contain the required amber side reflectors.
Consequence:
Decreased lighting visibility may result in a vehicle crash.
Correction:
Sabersport will notify owners and offer a full refund for the noncompliant combination lamps. the safety recall began on may 11, 2009. owners may contact sabersport at 1-909-598-7589.
Notes:
This recall only pertains to aftermarket replacement equipment and has no relation to any original equipment installed on vehicles produced by the vehicle manufacturer.in order to determine if your aftermarket lamp assembly is affected by this noncompliance, please review the list of model numbers provided to us by sabersport.the list can be found under "document search" located at the bottom of your screen.owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to <a href=http://www.safercar.gov>http://www.safercar.gov</a> .
Campaign:
09E025000 on 05/10/2009
Component:
Exterior lighting:headlights
Affected:
42,540
Defect:
Dope, inc. is recalling 42,540 combination corner and bumper lamp assemblies of various part numbers sold for use as aftermarket equipment for various passenger vehicles. these headlamps fail to conform to the requirements of federal motor vehicle safety standard no. 108, "lamps, reflective devices, and associated equipment." these lamps do not contain the required amber side reflectors.
Consequence:
Decreased lighting visibility may result in a vehicle crash.
Correction:
Dope, inc. will notify owners and offer a full refund for the noncompliant combination lamps. the safety recall began on july 28, 2009. owners may contact dope, inc. at 1-626-272-1798.
Notes:
This recall only pertains to aftermarket replacement equipment and has no relation to any original equipment installed on vehicles produced by the vehicle manufacturer.in order to determine if your aftermarket lamp assembly is affected by this noncompliance, please review the list of model numbers provided to us by dope, inc.the list can be found under "document search" located at the bottom of your screen. owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to <a href=http://www.safercar.gov>http://www.safercar.gov</a> .

1997 FORD ECONOLINE TSBs (262)

Bulletin:
BC0693961023
Component:
185000 vehicle speed control:cruise control
Summary:
Investigating 7.3l irregular idle. *tt
Bulletin:
BC0695961023
Component:
063000 engine and engine cooling:exhaust system
Summary:
'off-idle' vibration/boom/drone emitting from the exhaust system on 4.2l engines. *tt
Bulletin:
BC0696961023
Component:
116000 electrical system:ignition
Summary:
Concerns of check engine light (mil) w/ codes p0300 thru p0308 & eng runes rough/misses. *tt
Bulletin:
BC0750961017
Component:
072100 fuel system, gasoline:delivery:fuel pump
Summary:
Spade terminal between sender & fuel pump has been changed to a eyelet terminal. *tt
Bulletin:
BC0754961017
Component:
171100 latches/locks/linkages:doors:latch
Summary:
Vehicles may experience flickering interior courtesy lights while turning or going over bumps. *tt
Bulletin:
BC0782961014
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Concerns of check engine light 'on'. *tt
Bulletin:
BC0844961008
Component:
102000 power train:manual transmission
Summary:
E4od trans may emit a tick/rattle noise when driving at light loads in 1st gear at 1100 to 1800 rpm rpm. *tt
Bulletin:
BC0853961007
Component:
110000 electrical system
Summary:
Airbag light on & code 21, may be caused by an electromagnetic interference generated within the electrical system. *tt
Bulletin:
BC0883961004
Component:
063200 engine and engine cooling:exhaust system:manifold/header/muffler/tail pipe
Summary:
Vehicles may exhibit an exhaust leak &/or noise due to warped exhaust manifolds. *tt
Bulletin:
BC0884961004
Component:
073200 fuel system, gasoline:fuel injection system:injectors
Summary:
For misfire concerns on 4.2l/4.6l/5.4l/6.8l engines. *tt
Bulletin:
BC5187961001
Component:
171100 latches/locks/linkages:doors:latch
Summary:
Experience vehicle w/ flickering interior courtesy lights while turning or going over bumps. *tt
Bulletin:
BC5195961001
Component:
190000 tires
Summary:
Firestone p235 tires may exhibit a high frequency vibration at 65-75 mph. *tt
Bulletin:
BC5197961001
Component:
106000 power train:axle assembly
Summary:
Some vehicles equipped w/ an ax4s transaxle may have been shipped w/ a low transaxle fluid level. *tt
Bulletin:
BC5201961001
Component:
185000 vehicle speed control:cruise control
Summary:
Investigating 7.3l irregular idle. *tt
Bulletin:
BC5203961001
Component:
063000 engine and engine cooling:exhaust system
Summary:
'off-idle' vibration/boom/drone emitting from the exhaust system on vehicles equipped w/ 4.2l engines. *tt
Bulletin:
BC5219961001
Component:
980000 unknown or other
Summary:
Incorrect information in 1997 evtm manual. pin call-outs illustrations for c224 & c225 are in reverse order. *tt
Bulletin:
BC0315961101
Component:
061110 engine and engine cooling:engine:gasoline:belts and associated pulleys
Summary:
Fead belt squeal, cold only. *tw
Bulletin:
BC0320961101
Component:
070000 fuel system, gasoline
Summary:
Rolling idle/stall. *tw
Bulletin:
BC0322961101
Component:
061000 engine and engine cooling:engine
Summary:
Hard starting with dtc's p0341, p0344. *tw
Bulletin:
BC0340961127
Component:
116200 electrical system:ignition:module
Summary:
Certain 1997 vehciles may have been built with the 240 second misfire delay. *tw
Bulletin:
BC0362961125
Component:
140000 air bags
Summary:
If on a 1977 econoline the key chimes sound 5 times during the start or during vehicle operation, this indicates that the airbag lamp has a fault and there is a fault in the air bag system. *tw
Bulletin:
BC0363961125
Component:
140000 air bags
Summary:
1997 econolines equipped with passenger side air bag exhibiting code 29 or other intermittent air bag codes. *tw
Bulletin:
BC0477961114
Component:
116000 electrical system:ignition
Summary:
Engineering is investigating dealership concerns with fouled or cracked spark plugs. *tw
Bulletin:
BC0603961101
Component:
980000 unknown or other
Summary:
Correction to 1997 econoline evtm page 60-5 - pin call-outs on illustrations for c224 and c225 are in reverse order. *tw
Bulletin:
BC0042961101
Component:
140000 air bags
Summary:
Diagnostic instructions for econolines equipped with a passenger side airbag and an error code of 29. *tw
Bulletin:
BC0054961101
Component:
116200 electrical system:ignition:module
Summary:
Vehicles may have been built with a 240 second misfire delay. *tw
Bulletin:
BC007191101
Component:
133000 visibility:power window devices and controls
Summary:
Econolines with power windows may experience an open 30 amp fuse. *tw
Bulletin:
96246
Component:
114000 electrical system:wiring
Summary:
Wiring - electrical diode identification and service replacements. *tw
Bulletin:
96249
Component:
103700 power train:automatic transmission:torque converter
Summary:
Torque converter - leak test procedure - service tip. *tw
Bulletin:
962410
Component:
103000 power train:automatic transmission
Summary:
Transmission - e40d - 4r70w - 4r44e - 5r55e - new digital transmission range sensor - diagnosis service tip. *tw
Bulletin:
962418
Component:
103000 power train:automatic transmission
Summary:
Transmission - e40d - revised design forward planet thrust washer - service tip. *tw
Bulletin:
96221
Component:
131000 visibility:windshield
Summary:
Windshield and interior glass - fog/film. *tw
Bulletin:
96222
Component:
034000 service brakes, hydraulic:foundation components
Summary:
Brakes - elimination of sanding rotors and drums - service tip. *tw
Bulletin:
96225
Component:
075000 fuel system, gasoline:carburetor system
Summary:
Mass air flow sensor - replacement as an assembly - service tip. *tw
Bulletin:
962511
Component:
116200 electrical system:ignition:module
Summary:
Powertrain control module -reprogram powertrain control module (pcm) - service procedures - service tip. *tw
Bulletin:
962523
Component:
116000 electrical system:ignition
Summary:
Runs rough - malfunction indicator lamp (mil) on - diagnostic trouble codes (dtcs) p0300 through p0308 stored in memory - vehicles built through 10/14/96 with 4.6l engine. *tw
Bulletin:
962612
Component:
103700 power train:automatic transmission:torque converter
Summary:
Transaxle - torque converter replacement guidelines and torque converter/transaxle cooling system cleaning procedures - service tip. *tw
Bulletin:
BC0052970201
Component:
112000 electrical system:alternator/generator/regulator
Summary:
1997 econoline equipped with 7.3l engines may experience an inoperative charging system. the terminal b+ connection at the alternator may be broken due to high tension on the terminal from the wireing harness. *jd
Bulletin:
BC0053970201
Component:
103000 power train:automatic transmission
Summary:
Some 1995 and all 1996 and 1997 vehicles with e40d transmissions have been built with a reusable elastomeric transmission fluid pan gasket. *jd
Bulletin:
BC0211970201
Component:
162300 structure:body:door
Summary:
Power windows may experience an open 30 amp fuse. new window regulator motor. *jd
Bulletin:
BC0315970201
Component:
061000 engine and engine cooling:engine
Summary:
Fead belt squeal, cold only. revised belt released. *jd
Bulletin:
BC0320970201
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Rolling idle/stall. *jd
Bulletin:
BC1015297020
Component:
112000 electrical system:alternator/generator/regulator
Summary:
Vehicles may experience an inoperative charging system. *jd
Bulletin:
BC1015397020
Component:
103000 power train:automatic transmission
Summary:
Vehicles with e4od transmissions have been built with a reusable elastomeric transmission fluid pan gasket. *jd
Bulletin:
BC0052972301
Component:
112000 electrical system:alternator/generator/regulator
Summary:
Vehicles equipped with 7.3l engines may experience an inoperative charging system- the terminal b+ connection at the alternator may be broken due to high tension on the terminal from the wiring harness. jd
Bulletin:
BC0053972301
Component:
104000 power train:transfer case (4-wheel drive)
Summary:
Some 1995 and all 1996 and 1997 vehicles with e4od transmissions have been built with a reusable elastomeric transmission fluid pan gasket. *jd
Bulletin:
BC0056972301
Component:
061110 engine and engine cooling:engine:gasoline:belts and associated pulleys
Summary:
Some vehicles with air conditioning can exhibit a cold start accessory drive belt noise (chirp) concern. *jd
Bulletin:
BC0320972301
Component:
061000 engine and engine cooling:engine
Summary:
Rolling idle/stall- cylinder contribution test, and injector buzz test. *jd
Bulletin:
BC0325972301
Component:
061000 engine and engine cooling:engine
Summary:
Some 5.4l front end serpetntine belts may make some noise between temperatures fo 30 f-50 f. *jd
Bulletin:
BC3373972301
Component:
980000 unknown or other
Summary:
7.3l engine which has a rolling idle condition and has a calibaration of 7-90ck-r10 or 7-90n-r10, can service the idle condition by reprogramming the pcm with the january sbds update disk.
Bulletin:
BC3420972301
Component:
013000 steering:gear box (other than rack and pinion)
Summary:
Vehicles built between august 1996 - september 1996 with speed control and air bags may experience a noise in the steering wheel while turning. *jd
Bulletin:
BC3551972301
Component:
353400 equipment:electrical:radio/tape deck/cd etc.
Summary:
Vehicles without rear radio controls may experience inoperative rear speakers. *jd
Bulletin:
BC1016997230
Component:
353400 equipment:electrical:radio/tape deck/cd etc.
Summary:
Rear radio controls may experience inoperative rear speakers. *jd
Bulletin:
BC1020597230
Component:
011000 steering:wheel and handle bar
Summary:
Vehicles built between august 1996-september 1996 with speed control and airbags may experience a noise in the steering wheel while turning. *jd
Bulletin:
BC1022397230
Component:
980000 unknown or other
Summary:
Vehicles with 7.3l engine which as a rolling idle condition and has a calibaration of 7-90c-r10, 7-90k-r10, 7-90n-r10. or 7-90q-r10, you can service the idle condition by reprogramming the pcm with the february sbds update disk. *jd
Bulletin:
9735
Component:
353600 equipment:air conditioner
Summary:
Air conditioning- r-134a tracer dye installed in a/c system and three o-ring spring lock couplers- service tip. *jd
Bulletin:
9747
Component:
160000 structure
Summary:
Frame- rivet replacement with bolts- service tips. *jd
Bulletin:
97410
Component:
103600 power train:automatic transmission:cooling unit and lines
Summary:
Transmission- e4od- cooler bypass valve service during transmission overhaul- service tip. *jd
Bulletin:
BC3341973101
Component:
980000 unknown or other
Summary:
Effective immediately the 5.8l engine assembly for the vehicle is available as a ford quality renewal assembly. *jd
Bulletin:
BC1028197020
Component:
036000 service brakes, hydraulic:antilock
Summary:
Flashing airbag light after replacing the ecs module. *jd
Bulletin:
BC3213970213
Component:
140000 air bags
Summary:
Continuously flashing airbag after replacing the ecs module and no codes present. *tw
Bulletin:
BC3274970207
Component:
121000 exterior lighting:headlights
Summary:
Replacement headlamp bulbs - several aftermarket companies are offering replacement bulbs with a higher wattage that are not dot approved - sold with disclaimer of "for off-road use only" - the bulbs draw more current than the oem bulbs a
Bulletin:
97710
Component:
133000 visibility:power window devices and controls
Summary:
Power windows- inoperative- fuse opens- vehicles built 9/1/96 through 1/13/97. *jd
Bulletin:
9755
Component:
116200 electrical system:ignition:module
Summary:
Malfunction indicator lamp (mil)- mil illumination- diagnostic trouble code (dtc) p0446 stored in memory. *jd
Bulletin:
97511
Component:
103000 power train:automatic transmission
Summary:
Fluid- transmission fluid usage charts. *jd
Bulletin:
97512
Component:
061000 engine and engine cooling:engine
Summary:
Idle- rolling idle- surge- vehicles built 8/96 through 12/96 with 7.3l engine. *jd
Bulletin:
9768
Component:
980000 unknown or other
Summary:
Fuel economy- customer expectations versus vehicle usage. *jd
Bulletin:
97625
Component:
353600 equipment:air conditioner
Summary:
Air conditioning- no temperature control- vehicles built through 11/21/96. *jd
Bulletin:
BC2393970501
Component:
036000 service brakes, hydraulic:antilock
Summary:
The proper adapter for connecting the 1997 econoline 4 wheel anti-lock brake system to the breakout box is the rotunda 007-00108 abs adapter. *tw
Bulletin:
971110972313
Component:
102000 power train:manual transmission
Summary:
A new design transmission case and extension housing has been released. *yc
Bulletin:
971110972314
Component:
102000 power train:manual transmission
Summary:
Exhibiting a harsh 1-2 upshift during light throttle. *yc
Bulletin:
971110972314
Component:
102000 power train:manual transmission
Summary:
Exhibiting a harsh 1-2 upshift during light throttle. *yc
Bulletin:
971110972314
Component:
102000 power train:manual transmission
Summary:
Exhibiting a harsh 1-2 upshift during light throttle. *yc
Bulletin:
971110972314
Component:
102000 power train:manual transmission
Summary:
Exhibiting a harsh 1-2 upshift during light throttle. *yc
Bulletin:
971110972314
Component:
102000 power train:manual transmission
Summary:
Exhibiting a harsh 1-2 upshift during light throttle. *yc
Bulletin:
971110972314
Component:
102000 power train:manual transmission
Summary:
Exhibiting a harsh 1-2 upshift during light throttle. *yc
Bulletin:
971110972314
Component:
102000 power train:manual transmission
Summary:
Exhibiting a harsh 1-2 upshift during light throttle. *yc
Bulletin:
971110972314
Component:
102000 power train:manual transmission
Summary:
Exhibiting a harsh 1-2 upshift during light throttle. *yc
Bulletin:
971110972314
Component:
102000 power train:manual transmission
Summary:
Exhibiting a harsh 1-2 upshift during light throttle. *yc
Bulletin:
971110972314
Component:
102000 power train:manual transmission
Summary:
Exhibiting a harsh 1-2 upshift during light throttle. *yc
Bulletin:
971110972314
Component:
102000 power train:manual transmission
Summary:
Exhibiting a harsh 1-2 upshift during light throttle. *yc
Bulletin:
971110972314
Component:
102000 power train:manual transmission
Summary:
Exhibiting a harsh 1-2 upshift during light throttle. *yc
Bulletin:
971110972314
Component:
102000 power train:manual transmission
Summary:
Exhibiting a harsh 1-2 upshift during light throttle. *yc
Bulletin:
971110972314
Component:
102000 power train:manual transmission
Summary:
Exhibiting a harsh 1-2 upshift during light throttle. *yc
Bulletin:
971110972314
Component:
102000 power train:manual transmission
Summary:
Exhibiting a harsh 1-2 upshift during light throttle. *yc
Bulletin:
971110972314
Component:
102000 power train:manual transmission
Summary:
Exhibiting a harsh 1-2 upshift during light throttle. *yc
Bulletin:
971110972314
Component:
102000 power train:manual transmission
Summary:
Exhibiting a harsh 1-2 upshift during light throttle. *yc
Bulletin:
971110972314
Component:
102000 power train:manual transmission
Summary:
Exhibiting a harsh 1-2 upshift during light throttle. *yc
Bulletin:
971110972314
Component:
102000 power train:manual transmission
Summary:
Exhibiting a harsh 1-2 upshift during light throttle. *yc
Bulletin:
971110972314
Component:
102000 power train:manual transmission
Summary:
Exhibiting a harsh 1-2 upshift during light throttle. *yc
Bulletin:
971110972314
Component:
102000 power train:manual transmission
Summary:
Exhibiting a harsh 1-2 upshift during light throttle. *yc
Bulletin:
971110972314
Component:
102000 power train:manual transmission
Summary:
Exhibiting a harsh 1-2 upshift during light throttle. *yc
Bulletin:
971110972314
Component:
102000 power train:manual transmission
Summary:
Exhibiting a harsh 1-2 upshift during light throttle. *yc
Bulletin:
971110972314
Component:
102000 power train:manual transmission
Summary:
Exhibiting a harsh 1-2 upshift during light throttle. *yc
Bulletin:
971110972314
Component:
102000 power train:manual transmission
Summary:
Exhibiting a harsh 1-2 upshift during light throttle. *yc
Bulletin:
971110972314
Component:
102000 power train:manual transmission
Summary:
Exhibiting a harsh 1-2 upshift during light throttle. *yc
Bulletin:
971110972314
Component:
102000 power train:manual transmission
Summary:
Exhibiting a harsh 1-2 upshift during light throttle. *yc
Bulletin:
971110972314
Component:
102000 power train:manual transmission
Summary:
Exhibiting a harsh 1-2 upshift during light throttle. *yc
Bulletin:
971110972314
Component:
102000 power train:manual transmission
Summary:
Exhibiting a harsh 1-2 upshift during light throttle. *yc
Bulletin:
971110972314
Component:
102000 power train:manual transmission
Summary:
Exhibiting a harsh 1-2 upshift during light throttle. *yc
Bulletin:
971110972314
Component:
102000 power train:manual transmission
Summary:
Exhibiting a harsh 1-2 upshift during light throttle. *yc
Bulletin:
971110972314
Component:
102000 power train:manual transmission
Summary:
Exhibiting a harsh 1-2 upshift during light throttle. *yc
Bulletin:
971110972314
Component:
102000 power train:manual transmission
Summary:
Exhibiting a harsh 1-2 upshift during light throttle. *yc
Bulletin:
971110972314
Component:
102000 power train:manual transmission
Summary:
Exhibiting a harsh 1-2 upshift during light throttle. *yc
Bulletin:
971110972314
Component:
102000 power train:manual transmission
Summary:
Exhibiting a harsh 1-2 upshift during light throttle. *yc
Bulletin:
971110972314
Component:
102000 power train:manual transmission
Summary:
Exhibiting a harsh 1-2 upshift during light throttle. *yc
Bulletin:
971110972314
Component:
102000 power train:manual transmission
Summary:
Exhibiting a harsh 1-2 upshift during light throttle. *yc
Bulletin:
971110972314
Component:
102000 power train:manual transmission
Summary:
Exhibiting a harsh 1-2 upshift during light throttle. *yc
Bulletin:
971110972314
Component:
102000 power train:manual transmission
Summary:
Exhibiting a harsh 1-2 upshift during light throttle. *yc
Bulletin:
971110972314
Component:
102000 power train:manual transmission
Summary:
Exhibiting a harsh 1-2 upshift during light throttle. *yc
Bulletin:
971110972314
Component:
102000 power train:manual transmission
Summary:
Exhibiting a harsh 1-2 upshift during light throttle. *yc
Bulletin:
971110972314
Component:
102000 power train:manual transmission
Summary:
Exhibiting a harsh 1-2 upshift during light throttle. *yc
Bulletin:
971110972314
Component:
102000 power train:manual transmission
Summary:
Exhibiting a harsh 1-2 upshift during light throttle. *yc
Bulletin:
971110972314
Component:
102000 power train:manual transmission
Summary:
Exhibiting a harsh 1-2 upshift during light throttle. *yc
Bulletin:
971110972314
Component:
102000 power train:manual transmission
Summary:
Exhibiting a harsh 1-2 upshift during light throttle. *yc
Bulletin:
971110972314
Component:
102000 power train:manual transmission
Summary:
Exhibiting a harsh 1-2 upshift during light throttle. *yc
Bulletin:
971110972314
Component:
102000 power train:manual transmission
Summary:
Exhibiting a harsh 1-2 upshift during light throttle. *yc
Bulletin:
971110972314
Component:
102000 power train:manual transmission
Summary:
Exhibiting a harsh 1-2 upshift during light throttle. *yc
Bulletin:
971110972314
Component:
102000 power train:manual transmission
Summary:
Exhibiting a harsh 1-2 upshift during light throttle. *yc
Bulletin:
971110972314
Component:
102000 power train:manual transmission
Summary:
Exhibiting a harsh 1-2 upshift during light throttle. *yc
Bulletin:
971110972314
Component:
102000 power train:manual transmission
Summary:
Exhibiting a harsh 1-2 upshift during light throttle. *yc
Bulletin:
971110972314
Component:
102000 power train:manual transmission
Summary:
Exhibiting a harsh 1-2 upshift during light throttle. *yc
Bulletin:
97090297187
Component:
102000 power train:manual transmission
Summary:
Some vehicles may stall when the transmission is placed into gear. *yc
Bulletin:
9831
Component:
162000 structure:body
Summary:
Repairs to vinyl covered surfaces. *yc
Bulletin:
98021698310
Component:
151300 seat belts:front:retractor
Summary:
Some vehicles seat belts may be slow to retract. *yc
Bulletin:
985A5
Component:
034530 service brakes, hydraulic:foundation components:disc:rotor
Summary:
Hub-mount brake rotor machining equipment from rotunda is now approved for warranty and service use. *yc
Bulletin:
985A11
Component:
034000 service brakes, hydraulic:foundation components
Summary:
Service tip information regarding elimination of sanding rotors and drums. *yc
Bulletin:
9888
Component:
103000 power train:automatic transmission
Summary:
Information on a new transmission fluid usage chart. *yc
Bulletin:
9845
Component:
045300 service brakes, air:disc:rotor
Summary:
Availability of hub-mount brake rotor machining equipment. *yc
Bulletin:
98418
Component:
138130 visibility:defroster/defogger system:windshield:controls/wiring
Summary:
Absence of temperature control on some vehicles. *yc
Bulletin:
98419
Component:
980000 unknown or other
Summary:
Some vehicles may exhibit a flashing transmission control indicator lamp (tcil) and diagnostic trouble codes (dtcs) 62,628, and/or 1728. *yc
Bulletin:
98423
Component:
103000 power train:automatic transmission
Summary:
Some vehicles may experience a harsh 1/2 shift while driving under light throttle conditions. *yc
Bulletin:
9852
Component:
190000 tires
Summary:
Information on tire company telephone numbers for customer assistance. *yc
Bulletin:
9859
Component:
116100 electrical system:ignition:switch
Summary:
A hard to turn ignition key, and/or a hard to remove key from ignition cylinder may occur on some vehicles. *yc
Bulletin:
98510
Component:
353600 equipment:air conditioner
Summary:
Concerns with no temperature control. *yc
Bulletin:
9864
Component:
063000 engine and engine cooling:exhaust system
Summary:
Information on a buzzing or rattle noise from the exhaust system. *tt
Bulletin:
9873
Component:
353400 equipment:electrical:radio/tape deck/cd etc.
Summary:
Experiencing a whining / buzzing noise in the speakers of the entertainment radio or two-way radio. *tt
Bulletin:
98710
Component:
180000 vehicle speed control
Summary:
A harsh 1-2 shift while driving under light throttle conditions. *yc
Bulletin:
98E02
Component:
100000 power train
Summary:
Reprogrammingpowertrain control module calibration codes on some 1997 vehicles. *yc
Bulletin:
982544
Component:
103000 power train:automatic transmission
Summary:
Some motor home vehicles equipped with e4od transmissions may experience hydraulic system malfunctions after replacing the transmission case. *yc
Bulletin:
98259
Component:
980000 unknown or other
Summary:
Some vinyl covered items such as dash panels, door trim panels, consoles, etc., may exhibit a small dent, scuff, abrasion and/ or discoloration resulting from assembly, transit, dealer prep and/or customer usage. *yc
Bulletin:
982512
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Some vehicles with higher odometer readings may experience a hesitation on acceleration just off idle and misfire complaints with malfunction indicator lalmp ( mil ) on. *yc
Bulletin:
98205
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Exhibiting rough idle and engine miss due to injector bore scuffing at green engine break-in. *yc
Bulletin:
982010
Component:
063000 engine and engine cooling:exhaust system
Summary:
Experiencing a " buzzing " or " rattling " noise from the exhaust system. *yc
Bulletin:
982019
Component:
221600 seats:front assembly:power adjust
Summary:
Concerns with the power seat control button ( knob ) may detach from the switch actuator. *yc
Bulletin:
982310
Component:
063100 engine and engine cooling:exhaust system:emission control
Summary:
Mass air flow (maf)- sensor contamination- service tip. *ak
Bulletin:
982312
Component:
103000 power train:automatic transmission
Summary:
Issues regareding diagnostic trouble codes ( dtcs ) p0705, p0708, p1704, and / or p1705 may be stored in memory. *yc
Bulletin:
982313
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Some vehicles with a 7.3l direct injection (di) turbo diesel engine, one or more of the following concerns may be present: rough idle, stalling, hesitation/ stumble, loss / lack of power, poor fuel economy, and excessive oil consumption.
Bulletin:
982314
Component:
061110 engine and engine cooling:engine:gasoline:belts and associated pulleys
Summary:
Premature wear of the belt tensioner may occur on some vehicles. *yc
Bulletin:
982323
Component:
162000 structure:body
Summary:
Information regarding replacement and / or repairs on any lock component. *yc
Bulletin:
98246
Component:
110000 electrical system
Summary:
Ford motor company has released a new electrical grease ( f8az - 19g208-aa ) to reduce the possibility of moisture corrosion at the terminals. *yc
Bulletin:
9943
Component:
100000 power train
Summary:
Information regarding reprogramming powertrain control modules (pcms). *tt
Bulletin:
5892
Component:
980000 unknown or other
Summary:
Subject regarding techinical hotline assistance for bi-fuel vehicles with gfi alternate fuel systems. *tt
Bulletin:
12593
Component:
161000 structure:frame and members
Summary:
Concerns with cracks on the right rear side of the #1 frame crossmember. *tt
Bulletin:
9814
Component:
034530 service brakes, hydraulic:foundation components:disc:rotor
Summary:
Subject regarding the availability of hub-mount brake rotor machining equipment. *tt
Bulletin:
98113
Component:
160000 structure
Summary:
Subject pertaining to red rust stains on the edges of the bumper center vent and fog lamp openings. *tt
Bulletin:
98114
Component:
171100 latches/locks/linkages:doors:latch
Summary:
Information provided to aid the techinician in diagnosing and repairing various door lock and latch concerns. *tt
Bulletin:
98123
Component:
103000 power train:automatic transmission
Summary:
Some vehicles may exhibit a flashing transmission control indicator lamp (tcil) and diagnostic trouble codes (dtcs) 62, 628, and / or 1728 may be stored in memory. *tt
Bulletin:
98129
Component:
103000 power train:automatic transmission
Summary:
Some vehicles may exhibit a 1st gear "ticking" noise. *tt
Bulletin:
976011
Component:
073000 fuel system, gasoline:fuel injection system
Summary:
Subject on relative injector flow test success story. *tt
Bulletin:
99816
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Ford motor company now recommends sae 5w-30 viscosity grade for servicing any ford gasoline-powered vehicle regardless of model year. *tt
Bulletin:
9996
Component:
103000 power train:automatic transmission
Summary:
Experiencing a delayed or no 2-3 upshift, primarily when the transmission is cold on vehicles with ford qality remanufactured (fqr) 4r70w transmission exchange units with julian build between 062-97 and 040-99. *tt
Bulletin:
9997
Component:
011000 steering:wheel and handle bar
Summary:
Some vehicles may exhibit a "squeaking" or "moaning" noise from the steering column while turning. *tt
Bulletin:
99129
Component:
353400 equipment:electrical:radio/tape deck/cd etc.
Summary:
Experiencing a whine / buzz type noise in the speakers of the entertainment radio or two-way radio on vehicles with an in-tank electric fuel pump. *tt
Bulletin:
99139
Component:
125000 exterior lighting:brake lights
Summary:
Conditions with the brake lamps inadvertently disabling the brake shift interlock. *tt
Bulletin:
6417
Component:
020000 suspension
Summary:
Addressing tire balance hints. *tt
Bulletin:
6461
Component:
010000 steering
Summary:
Concerns of a clunk felt / heard in the steering wheel. *t
Bulletin:
12890
Component:
071100 fuel system, gasoline:storage:tank assembly
Summary:
Brief information on removing the fuel tank solenoid valve thread. *tt
Bulletin:
12915
Component:
011000 steering:wheel and handle bar
Summary:
Customer may complain of a clunk felt / heard in the steering wheel. *tt
Bulletin:
996034
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Experiencing a engine knock at cold start-up. *tt
Bulletin:
983106
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Information regarding engine assemblies being added to the fqr (ford quality renewal) program. *tt
Bulletin:
983215
Component:
061000 engine and engine cooling:engine
Summary:
Some vehicles with may exhibit higher than normal engine idle speeds. *tt
Bulletin:
983281
Component:
162000 structure:body
Summary:
Some customers may experience a noise while turning. *tt
Bulletin:
983283
Component:
036000 service brakes, hydraulic:antilock
Summary:
Addressing a concern with an amber abs warning indicator illuminated with code 1095 or 1096 stored in memory of the 4wabs module. *tt
Bulletin:
983312
Component:
150000 seat belts
Summary:
Some vehciles may exhibit a slow retracting seat belt. *tt
Bulletin:
9811339
Component:
073200 fuel system, gasoline:fuel injection system:injectors
Summary:
Information on the revised fuel injector o-ring kit. *tt
Bulletin:
9811341
Component:
140000 air bags
Summary:
Information on servicing an illuminated air bag lamp. *tt
Bulletin:
99164
Component:
116000 electrical system:ignition
Summary:
Concerns with a hard to turn ignition key and / or a hard to remove key from ignition cylinder. *tt
Bulletin:
983570
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Some engines may exhibit oil leakage. *tt
Bulletin:
99141
Component:
021500 suspension:front:control arm
Summary:
Subject regarding a high number of ball joints being replaced as the result of routine inspections or of complaints of tire wear and loose feelings in the steering system. *tt
Bulletin:
99141
Component:
010000 steering
Summary:
Complaints of tire wear and loose feelings in the steering system. *tt
Bulletin:
991411
Component:
161000 structure:frame and members
Summary:
Some vehicles may exhibit a crack on the right rear side of the #1 crossmember resulting in a creaking noise while turning the wheel or driving over uneven surfaces. *tt
Bulletin:
996890
Component:
141100 air bags:frontal:sensor/control module
Summary:
Some vehicles with an illuminated air bag lamp may have modified seat configurations which may have been changed by modifiers or the customer. *tt
Bulletin:
99E03
Component:
091100 fuel system, other:storage:tank assembly
Summary:
Emission recall for vehicles that were built with a fuel filler-valve which could leak while the vehicle is being operated which can exceed evaporative emissions standards. *tt
Bulletin:
99222
Component:
114000 electrical system:wiring
Summary:
Subject on a wire harness terminal repair kit available for repairing electrical wiring harnesses. *tt
Bulletin:
99185
Component:
980000 unknown or other
Summary:
Vehicles built between 3/15/1997 and 12/31/1998 and with 4r70w transmissions may experience delayed or no 2-3 upshift, transmission control indicator lamp illuminated with diagnostic trouble code p0782 stored in memory. *tt
Bulletin:
991811
Component:
162000 structure:body
Summary:
Subject regarding front passenger side stepwell cover not flush. *tt
Bulletin:
99194
Component:
034000 service brakes, hydraulic:foundation components
Summary:
Information for servicing and diagnosing brake vibration, brake inspection, and brake friction material replacement. *tt
Bulletin:
99196
Component:
353600 equipment:air conditioner
Summary:
Information on identifying non-approved / alternate refrigerants which could cause safety, and performance concerns if installed in ford a/c systems. *tt
Bulletin:
99236
Component:
102000 power train:manual transmission
Summary:
Subject regarding 4r100 transmission flexplate replacement for vehicles with 7.3l diesel engine. *tt
Bulletin:
992311
Component:
980000 unknown or other
Summary:
Experiencing intermittent or low range of the remote keyless entry (rke) system. *tt
Bulletin:
99242
Component:
162300 structure:body:door
Summary:
Information on replacing and / or repairing malfunctioning (door, ignition and decklid) locks. *tt
Bulletin:
6997
Component:
061000 engine and engine cooling:engine
Summary:
Some service manuals may list the incorrect camshaft position sensor alignment tool for vehicles with various engine sizes. *tt
Bulletin:
13180
Component:
061000 engine and engine cooling:engine
Summary:
Information regarding camshaft position (cmp) sensor alignment tool chart. *mjs
Bulletin:
7263
Component:
034400 service brakes, hydraulic:foundation components:drum
Summary:
Some vehicles with rear brake drums may exhibit brake squeal noise. *tt
Bulletin:
98163
Component:
162300 structure:body:door
Summary:
Locks failed. yd
Bulletin:
98151
Component:
120000 exterior lighting
Summary:
Malfunction indicator lamp failed. yd
Bulletin:
981512
Component:
063100 engine and engine cooling:exhaust system:emission control
Summary:
A direct replacement part for the evaporative emission canister and bracket assembly. ak
Bulletin:
13367
Component:
034430 service brakes, hydraulic:foundation components:drum:drum
Summary:
Some vehicles with rear brake drums may exhibit brake squeal noise. *tt
Bulletin:
98168
Component:
103000 power train:automatic transmission
Summary:
Transmission- e40d/4r100-1989-99-main controls, separator plates and separator plate gaskets usage chart. yd
Bulletin:
6505
Component:
071100 fuel system, gasoline:storage:tank assembly
Summary:
Brief information on removing the fuel tank solenoid valve on natural gas vehicles. *tt
Bulletin:
6538
Component:
010000 steering
Summary:
Some vehicles built before april 1, 1999 may have a customer concern of a clunk felt / heard in the steering wheel. *tt
Bulletin:
6585
Component:
061000 engine and engine cooling:engine
Summary:
Some vehicles equipped with 7.3l dit diesel engines may develop a cracked flexplate. *tt
Bulletin:
7475
Component:
185000 vehicle speed control:cruise control
Summary:
Some vehicles equipped with 73l dit engine may exhibit a rough engine idle. *tt
Bulletin:
13488
Component:
185000 vehicle speed control:cruise control
Summary:
Some vehicles equipped with 7.3l dit engine may exhibit a rough engine idle. *tt
Bulletin:
0015
Component:
103000 power train:automatic transmission
Summary:
Information regarding the new transmission cooler flusher- service tip. *mjs
Bulletin:
0038
Component:
103600 power train:automatic transmission:cooling unit and lines
Summary:
Vehicles may experience solid particle contaminants from prior transmission concerns or excess wear, may be trapped in the transmission fluid cooling system is not properly flushed, fluid in-line filter kit. *mjs
Bulletin:
8260
Component:
162310 structure:body:door:hinge and attachments
Summary:
Some vehicles may exhibit a-pillar sheet metal cracks around front door hinges; front door skin separates and door inner sheet metal cracked around front hinges; or front doors open too far and extend into the front fenders. *tt
Bulletin:
00610
Component:
185000 vehicle speed control:cruise control
Summary:
Information on the 7.3l dit engines, rotunda tool has issued an injector performance analyzer that may now be pruchased as an effective aid in helping to resolve rough idle concerns. *mjs
Bulletin:
00611
Component:
103100 power train:automatic transmission:control module (tcm, pcm)
Summary:
Some bi-fuel vehicles may require powertrain control module (pcm) replacement during service and may not run on cng or lpg., recalibration of the pcm/replacement. *mjs
Bulletin:
13934
Component:
162310 structure:body:door:hinge and attachments
Summary:
Some vehicles may exhibit a-pillar sheet metal cracks around front door hinges; front door skin separates and door inner sheet metal cracked around front hinges; or front doors open too far and extend into the front fenders. *tt
Bulletin:
00510
Component:
020000 suspension
Summary:
Customers may be concerned that vehicle looks like it dogtracks, due to a unique feature of the vehicle that combine to create an optical illusion of dogtracking, a condition which the rear axle is not square to the chassis. *mjs
Bulletin:
12070
Component:
021000 suspension:front
Summary:
Vehicles that are loaded to the upper end of fvw, with the majority of the load between the axles, may exhibit inner edge tire wear due to incorrect alignment. *mjs
Bulletin:
12123
Component:
021000 suspension:front
Summary:
Vehicles may exhibit a steering pull to the right or left, due to incorrect front end alignment settings. *mjs
Bulletin:
12139
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Some vehicles equipped with 4.6l or 6.8l engines may exhibit a cold start engine noise until warmed up. *mjs
Bulletin:
12162
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Some vehicles equipped with 6.8l engines, may exhibit a customer concern or engine roar or engine noise for the first few minutes of operation after a cold start. *mjs
Bulletin:
985097
Component:
036400 service brakes, hydraulic:antilock:abs warning light
Summary:
Some vehicles with 4wabs may have an amber abs warning indicator illuminated with code c1095 or c1096 stored in memory of the 4wabs module. *tt
Bulletin:
985102
Component:
021000 suspension:front
Summary:
Some vehicles that are loaded to the upper end of gvw, with the majority of the load between the axles, may exhibit inner edge tire wear due to incorrect alignment. *tt
Bulletin:
985153
Component:
020000 suspension
Summary:
Some vehicles may exhibit a steering pull to the right or left. *tt
Bulletin:
6290
Component:
062100 engine and engine cooling:cooling system:radiator assembly
Summary:
Information regarding the improved radiator support. *tt
Bulletin:
12767
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Exhibiting a vibration that may be interpreted as an nvh condition. *tt
Bulletin:
12741
Component:
062100 engine and engine cooling:cooling system:radiator assembly
Summary:
Some vehicles under severe duty cycles may exhibit cracks on the lower radiator support. *tt
Bulletin:
13117
Component:
141100 air bags:frontal:sensor/control module
Summary:
Some vehicles with an illuminated air bag lamp may have modified seat configurations. *tt
Bulletin:
12835
Component:
190000 tires
Summary:
Subject regarding tire balance hint. *tt
Bulletin:
12870
Component:
010000 steering
Summary:
Some customers may comment on a clunk felt / heard in the steering wheel. *tt
Bulletin:
4664
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
This bulletin states that for certain vehicles it is not possible to set the check engine light and set diagnostic trouble code p0455 (evaporative emissions gross leak) if a customer refuels the vehicle with the engine running. *
Bulletin:
99-8-15
Component:
162300 structure:body:door
Summary:
Subject regarding door trim panel replacement - service tip. *tt
Bulletin:
99111
Component:
980000 unknown or other
Summary:
Information designed to aid in the diagnosis, testing and repair of noise, vibration and harshness (nvh) concerns. *tt
Bulletin:
991210
Component:
980000 unknown or other
Summary:
Ford motor company has released a private labeled material to be used for iron particle / acid rain service repairs. *tt
Bulletin:
99152
Component:
103000 power train:automatic transmission
Summary:
Information on the new flush and fill tool available through rotunda. *tt
Bulletin:
11781
Component:
980000 unknown or other
Summary:
Information on setting the check engine light and setting diagnostic trouble code p0455 (evaporative emissions gross leak). *tt
Bulletin:
4981
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Some vehicles equipped with 5.4l engines may exhibit a cold start engine knock concern until warmed up. *tt
Bulletin:
5257
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Information on vehicles exhibiting cold engine knock. *tt
Bulletin:
5371
Component:
980000 unknown or other
Summary:
Some vehicles may exhibit a concern with poor range of the remote keyless entry (rke) transmitter. *tt
Bulletin:
12230
Component:
036000 service brakes, hydraulic:antilock
Summary:
All vehicles with antilock brake module concerns that require a module replacement, the technician must call for approval before removing and / or replacing the module. *tt
Bulletin:
12287
Component:
980000 unknown or other
Summary:
Some vehicles may exhibit a concern with poor range of the remote keyless entry (rke) transmitter. *tt
Bulletin:
00L05
Component:
355100 equipment:other:labels
Summary:
This service action requires the replacement of two emission control labels. *tt
Bulletin:
00239
Component:
110000 electrical system
Summary:
A condition may exist with possible electronc damage occuring to the compuvalve from voltage spikes between the compuvalve connections when connecting or disconnecting the main compuvalve harness c4025. *tt
Bulletin:
002310
Component:
103600 power train:automatic transmission:cooling unit and lines
Summary:
Subject regarding contamination from prior transmission concerns or excess wear may be trapped in the transmission fluid cooling system. *tt
Bulletin:
00261
Component:
185000 vehicle speed control:cruise control
Summary:
Some vehicles equipped with a 4.6l, 5.4l, or 6.8l engine may exhibit a rough idle / miss after start-up in cold ambient temperatures. *tt
Bulletin:
00154
Component:
106000 power train:axle assembly
Summary:
Information on rear axle whine-vehicles equipped with dana 80 axles-5.4l/6.8l and 7.3l. *jb
Bulletin:
00154
Component:
106000 power train:axle assembly
Summary:
Some vehicles with dana 80 rear axles may exhibit an excessive amount of axle whine noise. *jb
Bulletin:
14365
Component:
061110 engine and engine cooling:engine:gasoline:belts and associated pulleys
Summary:
This bulletin addresses concerns a noise at intial engine startup when cold from the accessory drive belt. *jb
Bulletin:
0147
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Subject regarding engine oil recommendations for use in 2001 vehicles - sae 5w-20 motor oil. *tt
Bulletin:
01119
Component:
161000 structure:frame and members
Summary:
Some vehicles with high odometer reading or severe service may exhibit a creaking noise when turning wheel or driving over uneven surfaces on vehicles produce before 2/6/2001. *tt
Bulletin:
01156
Component:
138120 visibility:defroster/defogger system:windshield:heater core
Summary:
Some vehicles may exhibit heater core leaks. *slc
Bulletin:
15271
Component:
091110 fuel system, other:storage:tank assembly:filling/charging
Summary:
Dedicated cng regulator bowl kit available. *jg
Bulletin:
15871
Component:
353400 equipment:electrical:radio/tape deck/cd etc.
Summary:
Some vehicles may exhibit interference and / or static in the land-mobile radio. *tt
Bulletin:
16683
Component:
061000 engine and engine cooling:engine
Summary:
False failure of the vapor management valve (vmv). *tt *jb
Bulletin:
16697
Component:
061000 engine and engine cooling:engine
Summary:
Exhaust air rush noise and lower power. *tt *jb
Bulletin:
16916
Component:
110000 electrical system
Summary:
Repeated blown fuses for rear in vehicle circuits with inoperative rear brake or tail lamps. *tt
Bulletin:
16999
Component:
061000 engine and engine cooling:engine
Summary:
High pressure oil pump leak. *tt
Bulletin:
03148
Component:
103600 power train:automatic transmission:cooling unit and lines
Summary:
New transmission cooler flusher - service tips. 2003 escort and super duty f series included. *tt
Bulletin:
16945
Component:
061120 engine and engine cooling:engine:gasoline:turbo-charger
Summary:
An oil leak at the turbocharger pedestal around the exhaust backpressure actuator. *tt
Bulletin:
03213
Component:
061120 engine and engine cooling:engine:gasoline:turbo-charger
Summary:
A no-start or reduced power condition may occur intermittently. *tt
Bulletin:
032131
Component:
061000 engine and engine cooling:engine
Summary:
Rough idle and engine miss due to injector bore scuffing at green engine break-in. *tt
Bulletin:
032132
Component:
061000 engine and engine cooling:engine
Summary:
Some vehicles equipped with aftermarket modifications may exhibit a crank but no start or a hard start/long crank condition. *tt
Bulletin:
032137
Component:
061000 engine and engine cooling:engine
Summary:
For 7.3l dit engines, rotunda tool has issued an injector performance analyzer that may now be purchased as an effective aid in helping to resolve rough idle concerns. *tt
Bulletin:
16480
Component:
110000 electrical system
Summary:
Diagnostic trouble code (dtc) p0340, possible false code. various models including 1994-1996 ford excursion. *tt
Bulletin:
17467
Component:
080000 fuel system, diesel
Summary:
Engine or fuel system concerns when using fuel with greater than 5% biodiesel concentration. *tt
Bulletin:
04E10
Component:
072200 fuel system, gasoline:delivery:hoses, lines/piping, and fittings
Summary:
Emission recall 04e10: compressed natural gas (cng) vehicles - fitting connector replacement. *mj
Bulletin:
17385
Component:
141100 air bags:frontal:sensor/control module
Summary:
Air bag lamp illuminated. *tt

Home | Privacy