1997 CHRYSLER CIRRUS Recalls (8)

Campaign:
97V095000 on 06/16/1997
Component:
Structure:body:hood:hinge and attachments
Manufactured:
03/29/1996 - 04/14/1997
Affected:
219,000
Defect:
Vehicle description: passenger vehicles. the secondary hood latch spring can disengage from its retention hole if the hood is slammed shut.
Consequence:
If this condition occurs simultaneously without engaging the primary latch, the hood would not be restrained increasing the risk of a vehicle crash.
Correction:
Dealers will replace the secondary hood latch spring with a longer end hook spring.
Notes:
Owner notification:owner notification began july 14, 1997.owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact chrysler at 1-800-853-1403.also contact the national highway traffic safety administration's auto safety hotline at 1-800-424-9393.
Campaign:
97V201000 on 11/19/1997
Component:
Suspension:front:control arm:lower ball joint
Manufactured:
07/30/1994 - 07/09/1997
Affected:
599,000
Defect:
Vehicle description: passenger vehicles. the lower control arm ball joint can separate due to loss of lubrication.
Consequence:
Separation of the ball joint could cause a loss of steering control increasing the risk of a vehicle crash.
Correction:
Dealers will inspect the ball joint end housing cover seal for leakage with a high pressure air tester and the rubber boot will be visually inspected for damage. if the cover seal leaks or the boot is damaged, the lower control arm will be replaced.
Notes:
Owner notification began december 15, 1997.owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact chrysler at 1-800-992-1997.also contact the national highway traffic safety administration's auto safety hotline at 1-800-424-9393.
Campaign:
98V183000 on 08/16/1998
Component:
Power train:automatic transmission:park/neutral start switch
Manufactured:
07/24/1994 - 01/20/1998
Affected:
685,000
Defect:
Vehicle description: passenger vehicles equipped with automatic transmissions. the adjustment of the cable connecting the console shifter mechanism to the ignition key can cause a trapped key condition which can result in a low force required to depress the shift button. a combination of applying a mis-adjusted release button with a low force attempt to shift out of park with the key in the locked position, can break the connecting pin in the shifter.
Consequence:
If this happens, the "ignition-park" interlock system will be nonfunctional.
Correction:
Dealers will inspect for proper operation of the system. any vehicles that are not functional after the inspection will have the shift mechanism and cable replaced with a "self-adjusting" design.
Notes:
Owner notification began october 26, 1998. owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact chrysler at 1-800-992-1997.also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
Campaign:
04V021000 on 01/14/2004
Component:
Power train:automatic transmission:lever and linkage:floor shift
Manufactured:
03/31/1992 - 07/30/1999
Affected:
2,315,768
Defect:
On certain passenger vehicles, the floor shifter ignition-park interlock may fail and allow the shifter to be moved out of the park position with the key removed. an inoperative interlock may also allow the key to be removed when the shifter has not been placed in the park position.
Consequence:
Either circumstance may result in the vehicle rolling away without warning.
Correction:
Dealers will install a new load-limiting push rod into the floor shifter lever of the affected vehicles. owner notification began on june 14, 2004. owners should contact daimlerchrysler at 1-800-853-1403.
Notes:
Daimlerchrysler recall no. c45.customers can also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
Campaign:
06E088000 on 10/25/2006
Component:
Fuel system, gasoline:delivery:fuel pump
Affected:
39,243
Defect:
Certain tigas fuel pump modules manufactured between june 1 and september 24, 2006, sold under various brand names and p/nos. these fuel pump modules are sold as aftermarket for use in certain daimlerchrysler vehicles listed above. silicone material used in manufacture of the flapper valve was out-of-specification, leading to excess swell of the flapper valve restricting the flow of fuel to the fuel pump module.
Consequence:
Fuel restriction could result in loss of power and/or engine stall, possibly resulting in a vehicle crash.
Correction:
Ti automotive will notify owners and replace the defective fuel pump modules free of charge. the recall began on october 6, 2006. owners may contact ti automotive toll-free at 1-877-461-1834.
Notes:
This recall only pertains to aftermarket fuel pump modules and has no relation to any original equipment installed on vehicles by daimlerchrysler.customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov.
Campaign:
06E091000 on 11/01/2006
Component:
Fuel system, gasoline:delivery:fuel pump
Affected:
24,358
Defect:
Certain airtex fuel pump modules, p/nos. e7089m, e7094m, e7113m, and e7129m, manufactured between june 1 and september 24, 2006. these fuel pump modules were sold as aftermarket for use in certain daimlerchrysler vehicles listed above. silicone material used in manufacture of the flapper valve was out-of-specification, leading to excess swell of the flapper valve restricting the flow of fuel to the fuel pump module.
Consequence:
Fuel restriction could result in loss of power and/or engine stall, possibly resulting in a vehicle crash.
Correction:
Airtex will notify owners and replace the defective fuel pump modules free of charge. the recall began on october 18, 2006. owners may contact airtex toll-free at 1-866-867-3759.
Notes:
This recall only pertains to aftermarket fuel pump modules and has no relation to any original equipment installed on vehicles by daimlerchrysler.customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov.
Campaign:
09E056000 on 10/12/2009
Component:
Suspension:front:control arm:lower ball joint
Affected:
5,787
Defect:
Qualis automotive is recalling certain aftermarket ball joints sold for use on certain passenger vehicles. the socket may have been excessively hardened which could cause it to crack near the retaining ring groove allowing the ball stud to separate under impact load. the subject ball joints were sold as four part numbers, d10945, d10946, g10945, and g10946. the affected control arms, d10945 and d10946, are stamped with the following dates on the ball joints: 134308, 135708, 100109, 102709, 104109, 105509, 107609, 108909, 110309, 113209, and 116609. the g10945 and g10946 are the same part as the d10945 and d10946 respectively. they are labeled differently depending on the aftermarket customer.
Consequence:
Separation of the ball stud from the socket of the ball joint housing would allow the control arm to collapse and the wheel to fold in causing loss of steering control, possibly resulting in a crash.
Correction:
Qualis automotive will replace the ball joints free of charge. the safety recall began on november 9, 2009. owners may contact qualis automotive at 1-800-493-4128.
Notes:
This recall only pertains to aftermarket ball joints and has no relation to any original equipment installed on vehicles produced by chrysler.owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to <a href=http://www.safercar.gov>http://www.safercar.gov</a> .
Campaign:
10E059000 on 12/26/2010
Component:
Suspension:front:control arm:lower arm
Affected:
22,689
Defect:
Federal-mogul is recalling certain replacement control arm assemblies, part numbers k7425, 10945, fa4510x, k7427, 10946, and fa4611x, sold for use on various passenger vehicles listed above. the ball joint on the control arm assembly can fail causing the ball stud to wear through the control arm housing resulting in noise and/or separation of the ball stud from the housing.
Consequence:
If there is a separation of the ball stud from the housing, the driver can loose steering control, possibly resulting in a vehicle crash.
Correction:
Federal-mogul will notify owners of record and replace the affected control arms free of charge. the safety recall began on january 28, 2011. owners may contact federal-mogul at 1-877-489-6659.
Notes:
This recall only pertains to replacement control arm assemblies and has no relation to any original equipment installed on vehicles manufactured by chrysler llc.owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to <a href=http://www.safercar.gov>http://www.safercar.gov</a> .

1997 CHRYSLER CIRRUS TSBs (86)

Bulletin:
230397
Component:
161000 structure:frame and members
Summary:
Difficult to clean light colored "chalky" residue from plastic body components that are molded in black. *tw
Bulletin:
090297
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
2.4l crankshaft/camshaft timing. *tw
Bulletin:
0808978
Component:
980000 unknown or other
Summary:
Rke inadequate/intermittent operation. *tw
Bulletin:
080997
Component:
355100 equipment:other:labels
Summary:
Air bag warning labels. *tw
Bulletin:
181197
Component:
116200 electrical system:ignition:module
Summary:
Erroneous mil illumination with hex codes $6a, $77, erroneous pcm resets, shift cycling, cold engine stumble, bucking. *tw
Bulletin:
190297
Component:
015000 steering:hydraulic power assist system
Summary:
Power steering system change. *tw
Bulletin:
182397A
Component:
011000 steering:wheel and handle bar
Summary:
Steering wheel shake at idle. *tw
Bulletin:
182397
Component:
011000 steering:wheel and handle bar
Summary:
Conditions with steering wheel shake at idle. *yc
Bulletin:
082097
Component:
353000 equipment:electrical
Summary:
Discussing rolling code technology and it's features on garage door openers. *yc
Bulletin:
070397
Component:
062000 engine and engine cooling:cooling system
Summary:
Various car owner's have expressed interest in using engine coolants made with propylene glycol instead of ethylene glycol. *yc
Bulletin:
970314210597
Component:
102000 power train:manual transmission
Summary:
Condition with tranaxle shudder during a 3rd gear to 3rd gear partial emcc ( electronically modulated converter clutch) engagement, 3rd gear partial emcc to 4th gear partial emcc engagement, or 4th gear to 4th gear emcc engagement. *yc
Bulletin:
970919083297
Component:
140000 air bags
Summary:
Authorized airbag deactivation for medical necessity. *yc
Bulletin:
020797
Component:
021000 suspension:front
Summary:
Front of vehicle experiencing a low frequency rumble/gear type noise. *yc
Bulletin:
190198
Component:
011000 steering:wheel and handle bar
Summary:
Condition with clunking or rattling in steering/wheel column. *yc
Bulletin:
080698
Component:
120000 exterior lighting
Summary:
Condition with indicator bulb does not light. *yc
Bulletin:
180198
Component:
063100 engine and engine cooling:exhaust system:emission control
Summary:
upstream 02 sensor shorted to voltage along with possible symptoms of sagging/hesitation or rough idle. *ak
Bulletin:
080298
Component:
353400 equipment:electrical:radio/tape deck/cd etc.
Summary:
Preventing antenna masts from becoming loose, a change was implemented to incorporate a torque prevailing feature on the antenna mast. *yc
Bulletin:
976498
Component:
980000 unknown or other
Summary:
Condition with rolling code garage door opener. *yc
Bulletin:
240898
Component:
353600 equipment:air conditioner
Summary:
Condition with the a/c system performance. *yc
Bulletin:
210798
Component:
106000 power train:axle assembly
Summary:
Subject on delayed transaxle engagement. *ak
Bulletin:
181898
Component:
061000 engine and engine cooling:engine
Summary:
Excessive cold crank time, start die out or weak run-up, sags/stumble/hesitation after a cold start, idle rpm cycling. *yc
Bulletin:
190398
Component:
015000 steering:hydraulic power assist system
Summary:
Power steering system noise following cold engine starts in low ambient temperatures. *yc
Bulletin:
210298
Component:
106000 power train:axle assembly
Summary:
Information on diagnostic / driveability improvements, transaxle that incorporates a transmission range sensor (trs) only. reduces a shudder condition that may be experienced during light throttle 1-2 upshift. *ak
Bulletin:
9830
Component:
061000 engine and engine cooling:engine
Summary:
Subject on labor operation time change for domestic 2.ol dohc and 2.4l head gasket replacement. *yc
Bulletin:
250298
Component:
063000 engine and engine cooling:exhaust system
Summary:
Subject regarding i/m ( inspection maintenance ) testing - obd ii "carb" readiness monitor information. *yc
Bulletin:
090598
Component:
061000 engine and engine cooling:engine
Summary:
A new multi-layer steel ( mls ) head gasket has been developed and is being implemented into production vehicles. *yc
Bulletin:
081798
Component:
145000 air bags:on-off switch assembly
Summary:
Subject regarding airbag on - off switches. *yc
Bulletin:
210499
Component:
103000 power train:automatic transmission
Summary:
Service and parts information on 1999 running changes to transmission range sensor (trs) *tt
Bulletin:
210599
Component:
103000 power train:automatic transmission
Summary:
Subject regarding reusable automatic transmission oil pan gasket. *tt
Bulletin:
210699
Component:
180000 vehicle speed control
Summary:
Conditions with intermittent loss of speed control. *tt
Bulletin:
232099
Component:
162700 structure:body:trunk lid
Summary:
Diamler chrysler corporation is now offering internal emergency trunk releases for selected vehicles. *tt
Bulletin:
181299
Component:
103100 power train:automatic transmission:control module (tcm, pcm)
Summary:
This bulletin explains the operation and application of the leak detection pump (ldp) monitor test. *tt
Bulletin:
9926
Component:
162700 structure:body:trunk lid
Summary:
Information pertaining to internal emergency trunk release dealer reimbursement. *tt
Bulletin:
9925
Component:
162700 structure:body:trunk lid
Summary:
Subject regarding the internal emergency trunk release. *tt
Bulletin:
090799
Component:
061000 engine and engine cooling:engine
Summary:
Information regarding 2.5l v-6 head gasket application. *tt
Bulletin:
090899
Component:
061000 engine and engine cooling:engine
Summary:
Technical service bulletin regarding multi-layer steel (mls) head gasket installation procedures. *tt
Bulletin:
210599A
Component:
103000 power train:automatic transmission
Summary:
This bulletin announces the availability and installation of a resuable automatic transmission oil pan gasket. *tt
Bulletin:
233599
Component:
220000 seats
Summary:
Information on child seat tether anchors. *tt
Bulletin:
020598
Component:
020000 suspension
Summary:
Intermittent popping sound coming from the front of the vehicle may be heard from either side. *yc
Bulletin:
081698
Component:
353400 equipment:electrical:radio/tape deck/cd etc.
Summary:
Information on installation of radio transmitting equipment. *ak
Bulletin:
090798
Component:
061000 engine and engine cooling:engine
Summary:
Subject regarding oil seepage at cam position sensor / misinterpreted head gasket leak. *yc
Bulletin:
183298
Component:
162000 structure:body
Summary:
Subject on flash programming failure recovery. *yc
Bulletin:
233099
Component:
980000 unknown or other
Summary:
Subject pertaining to a missing rear cup holder slide clip. *tt
Bulletin:
232099A
Component:
162700 structure:body:trunk lid
Summary:
Daimler chrysler is now offering internal emergency trunk releases for selected vehicles. *tt
Bulletin:
020797
Component:
021600 suspension:front:wheel bearing
Summary:
Concerns with low frequency rumble/ gear type noise from front of vehicel. *nlm
Bulletin:
070397
Component:
060000 engine and engine cooling
Summary:
Concerns with engine coolant usage. *nlm
Bulletin:
082097
Component:
110000 electrical system
Summary:
Information regarding garage door opener. *nlm
Bulletin:
0832097
Component:
110000 electrical system
Summary:
Information regarding nhtsa authorized airbag deactivation for medical necessity. *nlm
Bulletin:
090997
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Information on gasket surface preparation on aluminum engine components. *nlm
Bulletin:
140897
Component:
070000 fuel system, gasoline
Summary:
Information on poor drivability with high di (drivability index) fuel. *nlm
Bulletin:
181797
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Information on leak detection pump (ldp) dealer test mode. *nlm
Bulletin:
182497
Component:
061000 engine and engine cooling:engine
Summary:
Information on no start diagnostic cam/crank sensor $01 and $28. *nlm
Bulletin:
210597
Component:
103000 power train:automatic transmission
Summary:
Concerns with 41te/42le transaxle shudder during an emcc (electronically modulated converter clutch) shift. *nlm
Bulletin:
210997
Component:
102000 power train:manual transmission
Summary:
Information on 41te/42le service information. *nlm
Bulletin:
211497
Component:
103600 power train:automatic transmission:cooling unit and lines
Summary:
Concerns with transmission fluid auxiliary cooler. *nlm
Bulletin:
220197
Component:
190000 tires
Summary:
Information on tire and wheel runout. *nlm
Bulletin:
241197
Component:
353600 equipment:air conditioner
Summary:
Concerns with a/c evaporator odor. *nlm
Bulletin:
083799
Component:
145000 air bags:on-off switch assembly
Summary:
Daimlerchrysler corporation is now offerinb airbag on / off switches for selected vehicles. *tt
Bulletin:
180100
Component:
061000 engine and engine cooling:engine
Summary:
Subject regarding misdiagnosed leak detection pump systems with diagnostic trouble codes p1494, p0442 p0455, or p0456. *tt
Bulletin:
080600
Component:
114000 electrical system:wiring
Summary:
This bulletin provides a revised wire splice procedure and related parts. *tt
Bulletin:
230200
Component:
175200 latches/locks/linkages:trunk lid:lock
Summary:
Daimlerchrysler corporation is now offering internal emergency trunk releases for selection vehicles. *tt
Bulletin:
230800
Component:
220000 seats
Summary:
Subject regarding child seat tether anchors. *tt
Bulletin:
190299REVA
Component:
010000 steering
Summary:
Vehicles may experience clunking or rattle in steering wheel/steering column. *mjs
Bulletin:
233599REVA
Component:
162000 structure:body
Summary:
Subject on the child seat tether anchors. *mjs
Bulletin:
082700
Component:
140000 air bags
Summary:
Subject regarding non-deployed airbag handling procedures. *tt
Bulletin:
2300800B
Component:
220000 seats
Summary:
Subject regarding child seat tether anchors. *tt
Bulletin:
0800600REV
Component:
110000 electrical system
Summary:
Subject regarding wire splice repairs. *sb
Bulletin:
0900800
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
This bulletin involves installation of a new component to assist cam seal retention. *jb
Bulletin:
0801001
Component:
110000 electrical system
Summary:
Subject regarding airbag / clock spring service for various models including 2002 model year jeep liberty. *tt
Bulletin:
1801201
Component:
350000 equipment
Summary:
Subject regarding generic scan tool (gst), publication no. 81-170-00008 provided with this technical service bulletin to provide reference information when using generic scan tool on obdii vehicles. *tt
Bulletin:
2100601
Component:
103000 power train:automatic transmission
Summary:
Automatic transmission fluid usage atf+4. *tt *mj
Bulletin:
1802001
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Exhibiting rough idle, hard start and start & stall.*cls
Bulletin:
2302701
Component:
135200 visibility:rearview mirrors/devices:exterior
Summary:
Subject regarding outside rearview mirror glass replacement. *tt
Bulletin:
2301502
Component:
135200 visibility:rearview mirrors/devices:exterior
Summary:
Subject regarding outside rearview mirror glass replacement. *slc
Bulletin:
1802002
Component:
980000 unknown or other
Summary:
Flash programming failure recovery. *slc
Bulletin:
0801003
Component:
150000 seat belts
Summary:
Seat belt cinch bar service for various models including 2004 models. *tt
Bulletin:
20616
Component:
110000 electrical system
Summary:
P/n cbszr068aa: inspect & return: module kit - occupant restraint you have been identified as either having stock, or have stock in transit to your dealership. please return part number cbszr068aa as per the qir attached. replacement par
Bulletin:
22892
Component:
355200 equipment:other:owners/service/other manual
Summary:
Return: lamp assy - chmsl& cargo light you have been identified as either having stock, or have stock in transit to your dealership. please return all stock of follow ing part numbers:55372082ae, 55372082ad, 55372082ac, 55372082ab, 553720
Bulletin:
22867
Component:
110000 electrical system
Summary:
Inspect and return: solenoid module - transmission you have been identified as either having stock, or have stock in transit to your dealership. please return suspect stock of follow ing part numbers:52120000aa, 52119435af, 05078709ab. s
Bulletin:
22958
Component:
117000 digital instrument panel
Summary:
1nt30xdvac - inspect and return: panel - instrument panel you have been identified as either having stock, or have stock in transit to your dealership. please return suspect stock of part number 1n t30xdvac. see attachments for identifyin
Bulletin:
20244
Component:
350000 equipment
Summary:
Cbxdp361aa return: spacer kit - visor you have been identified as either having stock, or have stock in transit to your dealership. please return stock of part number cbxdp361aa. replacement part number is cbxdp361ab w hich is in stock a
Bulletin:
Volume 2, Issue
Component:
355200 equipment:other:owners/service/other manual
Summary:
Warranty operations newsletter updates from warranty operations
Bulletin:
Volume 2, Issue
Component:
355200 equipment:other:owners/service/other manual
Summary:
Warranty operations newsletter updates from warranty operations
Bulletin:
23137
Component:
350000 equipment
Summary:
Inspect and return: trim cover assy - a-pillar rt/lt you have been identified as either having stock, or have stock in transit to your dealership. please return suspect stock of part numbers: 1za04dx9ae, 1za05dx9ae. see attachments for id
Bulletin:
23104
Component:
120000 lighting (pws)
Summary:
05182535ad - lamp assy ?tail light lt you have been identified as either having stock, or have stock in transit to your dealership. please return suspect stock of part number 05182535ad . see attachments for identifying suspect stock. pl
Bulletin:
23027
Component:
114000 electrical system:wiring
Summary:
Return: wiring assy - engine you have been identified as either having stock, or have stock in transit to your dealership. please return stock packaged before 2016/07/31 (31 july, 2016)of follow ing part numbers:68176457af, 68176459af. p

Home | Privacy