1997 CHEVROLET LUMINA Recalls (2)

Campaign:
03V527000 on 12/17/2003
Component:
Steering:rack and pinion
Manufactured:
03/31/1996 - 07/30/1997
Affected:
750,283
Defect:
Certain passenger vehicles have lower pinion bearings in the power rack and pinion assembly in which the retainer tabs were not crimped properly. these retainers could fail and permit the ball bearings to escape.
Consequence:
If this occurs, the pinion shaft can be forced upward during left turns and back down as the steering wheel is moved back and to the right. if the pinion shaft moves further, the driver will need to exert more effort to turn the steering wheel, similar to a vehicle without power assisted steering. if the pinion shaft moves even further, the driver will require much higher effort to turn left and may not be able to turn the wheel as much as intended. with the maximum pinion shaft movement, which requires internal gear component damage, the driver can encounter high resistance to turning left, followed by unintended power assist to the right. in any of these conditions, a crash could occur.
Correction:
Dealers will install a new lower pinion bearing unless inspect of the existing bearing indicates that replacement of the gear assembly is necessary. owner notification began on february 5, 2004. owners should contact buick at 1-866-608-8080; chevrolet at 1-800-630-2438; oldsmobile at 1-800-630-6537; or pontiac at 1-800-620-7668.
Notes:
Gm recall no. 03062.customers can also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
Campaign:
07E021000 on 03/11/2007
Component:
Fuel system, other:storage:tank assembly:pressure relief devices
Affected:
742
Defect:
Certain delphi fuel pressure regulators, p/nos. fp10020-11b1, fp10026-11b1, and fp10027-11b1, sold after january 9, 2007, as aftermarket equipment for various passenger vehicles listed above. the universal pressure regulators (upr) were produced without an o'ring and retainer.
Consequence:
Fuel may leak, possibly resulting in a fire.
Correction:
Delphi will notify owners and replace the upr free of charge. the recall began on april 23, 2007. owners can contact delphi at 877-411-8770.
Notes:
This recall only pertains to aftermarket delphi fuel pressure regulators and has no relation to any original equipment installed by general motors.customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov.

1997 CHEVROLET LUMINA TSBs (47)

Bulletin:
577106A
Component:
103000 power train:automatic transmission
Summary:
Cold start rattle noise. *tw
Bulletin:
677164
Component:
103000 power train:automatic transmission
Summary:
Intermittent neutral or loss of drive at highway speeds or from fourth gear (replace control valve body assembly). *tw
Bulletin:
577106A
Component:
105300 power train:driveline:driveshaft
Summary:
Cold start rattle noise (diagnosis/service procedure). *tw
Bulletin:
676305
Component:
183000 vehicle speed control:cables
Summary:
Difficult to depress accelerator pedal and/or accelerator cable separation (install accelerator cable and clip). *tw
Bulletin:
549001A
Component:
353400 equipment:electrical:radio/tape deck/cd etc.
Summary:
Cln indicator appears on radio display and does not turn off (reset cln indicator with the eject button on tape). *tw
Bulletin:
970701738209
Component:
120000 exterior lighting
Summary:
Various drivers have concerns about the daytime running lamps (drl) not turning off with cluster lights when using dash mounted switch. *yc
Bulletin:
971101631041
Component:
162300 structure:body:door
Summary:
Comments on inoperative power door locks (front and/or rear doors).
Bulletin:
971101776304
Component:
073000 fuel system, gasoline:fuel injection system
Summary:
Subject pertaining to driveability symptoms due to fuel injector deposits. *yc
Bulletin:
970901776520
Component:
061000 engine and engine cooling:engine
Summary:
Experiencing an intermittent rough idle or misfire at idle after the engine is started. *yc
Bulletin:
970801676305
Component:
180000 vehicle speed control
Summary:
Some vehicles experience difficulties to depress accelerator pedal and/or an accelerator cable separation. *yc
Bulletin:
98776304A
Component:
073200 fuel system, gasoline:fuel injection system:injectors
Summary:
Some vehicles may experience a driveability symptom of long or hard starts, chuggle, rough idle and light or intermittent misfire. *yc
Bulletin:
98776514A
Component:
980000 unknown or other
Summary:
Some vehicles may experience a mil (malfunction indicator lamp) light illuminated on the vehicle's instrument panel. *yc
Bulletin:
98839010
Component:
140000 air bags
Summary:
Some customers may comment that the air bag warning light comes on intermittently or stays on. *yc
Bulletin:
990604005
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Some owners may experience a driveability symptom of long or hard starts, chuggle, rough idle and light or intermittent misfire. *tt
Bulletin:
99021
Component:
116000 electrical system:ignition
Summary:
Subject regarding spark plug wire failure. *tt
Bulletin:
990603007
Component:
090000 fuel system, other
Summary:
Some customers may comment that the fuel gauge reads incorrectly / fluctuates, and the low fuel chime sounds prematurely. *tt
Bulletin:
99021
Component:
116000 electrical system:ignition
Summary:
Subject regarding spark plug wire failure. *tt
Bulletin:
990603007A
Component:
090000 fuel system, other
Summary:
Conditions with inaccurate fuel gauge / fluctuates, premature low fuel chime. *tt
Bulletin:
990730030
Component:
106000 power train:axle assembly
Summary:
Some vehicles equipped with hydra-matic 3t40, 4t60 or 4t60-e transxales may comment on a grinding and / or growling noise that is noticeable when in park on incline. *tt
Bulletin:
990603007B
Component:
090000 fuel system, other
Summary:
Some customers may comment on the following conditions: 1) the fuel gauge reading incorrectly. 2) low fuel chime sounds prematurely. 3) fuel gauge may fluctuate from full to empty. *tt
Bulletin:
876002A
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Some v6 engines may, on a very infrequent basis, have an oil odor condition that is generally encountered after the engine's oil has been changed.typically the odor lasts approximately 1000 miles after the change of oil and then does not re
Bulletin:
533307B
Component:
020000 suspension
Summary:
Some vehicles may exhibit front suspension scrunch / popping type noise coming from the front of vehicle that is apparent during low speed turning maneuvers. *tt
Bulletin:
836317
Component:
070000 fuel system, gasoline
Summary:
Some operators of vehicles equipped with land mobile communcation systems, such as those utilized by law enforcement agencies, may comment on fuel pump related radio frequency interference during vehicle operation. *tt
Bulletin:
990604005A
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Some owners may comment on driveability symptons of long or hard starts, chuggle, rough idle and light or intermittent misfire due to clogged fuel injectors. *tt
Bulletin:
990603007C
Component:
090000 fuel system, other
Summary:
A condition may exist in which the fuel gauge reads incorrectly / fluctuates, low fuel chime sounds prematurely. *tt
Bulletin:
990730030A
Component:
106000 power train:axle assembly
Summary:
Owners of some vehicles equipped with hydra-matic 3t40, 4t60, 4t60-e or 4t65-e transaxles may comment on a grinding and / or growling noise that is noticeable when standing in park on a hill or slope with the engine running and the parking
Bulletin:
010601010A
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Subject regarding polymer service pistons. *tt
Bulletin:
32
Component:
980000 unknown or other
Summary:
Information regarding extra clips in the 4t65e transmission. *slc
Bulletin:
010730032B
Component:
103000 power train:automatic transmission
Summary:
Some owners may comment on a transmission oil leak. *tt updated *eh
Bulletin:
020601014
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Subject regarding revised lower intake manifold installation. *tt
Bulletin:
000730002B
Component:
102000 power train:manual transmission
Summary:
Concerns with slips, harsh upshift or garage shifts, launch shudders, flares, erratic shifts and intermittent concerns, diagnostic trouble code p1811 or p0748 set. *tt
Bulletin:
020730014
Component:
980000 unknown or other
Summary:
Information on servicing 4t65e transaxle spacer plate and gaskets. *tt
Bulletin:
020730014A
Component:
980000 unknown or other
Summary:
Information on servicing 4t65-e transaxle spacer plate and gaskets for various models from 1997 through 2002. *tt
Bulletin:
010601002A
Component:
061000 engine and engine cooling:engine
Summary:
Revised piston pin removal / installation procedure. *tt
Bulletin:
01880
Component:
100000 power train
Summary:
No tcc apply, malfunction indicator lamp (mil) on, tcc surge, possible p0740, p1870, or 39 after installation of a reman (srta) 4t60/4t60e. *tt
Bulletin:
01292004
Component:
015000 steering:hydraulic power assist system
Summary:
Power steering gear lower pinion bearing, safety recall 03062. *tt
Bulletin:
050525006
Component:
046300 service brakes, air:antilock:wheel speed sensor
Summary:
Revised front wheel speed sensor replacement procedure. *tt
Bulletin:
050604058
Component:
180000 vehicle speed control
Summary:
Intermittent chuggle or fishbite on light acceleration or a highway speeds with no diagnostic trouble codes (dtcs). *tt
Bulletin:
4615
Component:
040000 service brakes, air
Summary:
Abs pump running when not needed. *nj
Bulletin:
16NA260
Component:
353400 equipment:electrical:radio/tape deck/cd etc.
Summary:
This technical bulletin provides a procedure to reprogram the media disc player with the latest calibrations to correct a condition of the rear entertainment system not operating as intended in colder ambient temperature areas due to calibr
Bulletin:
PIP4723B
Component:
118000 electrical system: software
Summary:
This preliminary information communicates to the dealer the process for downloading or updating operating software for the tire pressure monitor, active fuel injector tester, multi media tester, pico scope, gr8 starting/charging tester and
Bulletin:
PIC4696A
Component:
353100 equipment:electrical:anti-theft devices
Summary:
This preliminary information communication provides information to the technician on how to unlock radios that are delco theftlock. technician will use the radio to get the scrambled code. technician will need to contact the radio unlock ce
Bulletin:
PIC4696B
Component:
353100 equipment:electrical:anti-theft devices
Summary:
This preliminary information communication provides information to the technician on how to unlock radios that are delco theftlock. technician will use the radio to get the scrambled code. technician will need to contact the radio unlock ce
Bulletin:
PI1217
Component:
100000 power train
Summary:
This preliminary bulletin provides a way to aid the technician in diagnosing transmission fluid leaking from the trans breather vent.
Bulletin:
05-06-04-035D
Component:
070000 fuel system, gasoline
Summary:
This informational bulletin provides the technician with information on what e85 fuel may due to a non e85 vehicle.
Bulletin:
17-NA-073
Component:
355200 equipment:other:owners/service/other manual
Summary:
This warranty administration bulletin provides policy information with the field action courtesy transportation policy.
Bulletin:
PIC4696C
Component:
150000 seat belts
Summary:
This preliminary information communication provides information to the technician on how to unlock radios that are delco theftlock. technician will use the radio to get the scrambled code. technician will need to contact the radio unlock ce

Home | Privacy