1996 TOYOTA TACOMA Recalls (6)

Campaign:
96E001000 on 01/21/1996
Component:
Vehicle speed control
Manufactured:
10/31/1995 - 11/30/1995
Affected:
5,145
Defect:
These cruise control systems fail to hold the speed set by the driver and can accelerate above the intended set speed.
Consequence:
Unintended acceleration can increase the potential for a vehicle accident.
Correction:
Dealers will replace these cruise control assemblies.
Notes:
System: fuel; throttle linkages and control equipment description:aftermarket cruise control system installed on certain toyota passenger vehicles and light duty pickup trucks sold in toyota dealerships serviced by southeast toyota and gulf states toyota distributors.the dealers would be located in the following states: florida, alabama, georgia, north carolina, and south carolina for southeast toyotaand texas, oklahoma, mississippi, louisiana, and arkansas for gulf states toyota.note: owners who take their vehicles to an authorized dealer in these affected states, on an agreed upon service date and do not receive the free remedy within a reasonable time should contact rostra at 1-910-276-4853 or toyota at 1-800-331-4331.also contact the national highway traffic safety administration's auto safety hotline at 1-800-424-9393.
Campaign:
96V129000 on 07/14/1996
Component:
Suspension:front
Affected:
90,000
Defect:
Under certain driving conditions, the front suspension support can crack leading to failure of the support.
Consequence:
This condition can result in loss of vehicle control.
Correction:
Dealers will repair the suspension support.
Notes:
System: suspension; independent; front. vehicle description: light duty pickup truck. owner notification: owner notification is expected to begin in late august 1996. note: owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact toyota at 1-800-331-4331. also contact the national highway traffic safety administration's auto safety hotline at 1-800-424-9393.
Campaign:
06E026000 on 03/22/2006
Component:
Exterior lighting
Affected:
61,944
Defect:
Certain pro-a motors corner lamps, turn signals, and headlights sold as replacement lamps for use on certain passenger vehicles listed above. some combination lamps that are not equipped with amber side reflectors fail to conform to federal motor vehicle safety standard no. 108, lamps, reflective devices, and associated equipment.
Consequence:
Without the amber reflectors, the vehicle will be poorly illuminated, possibly resulting in a vehicle crash without warning.
Correction:
Pro-a motors will notify owners and offer to repurchase the lamps. the recall began on april 3, 2006. owners may contact pro-a motors at 323-838-2988.
Notes:
This recall only pertains to pro-a motors aftermarket lamps and has no relation to any original equipment installed on the listed passenger vehicles.for more information on the lamp model numbers, click on document search and view document titled "lamp model numbers."customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov.
Campaign:
06E049000 on 06/04/2006
Component:
Exterior lighting
Affected:
27,176
Defect:
Certain ck motorsports combination headlights, clear corner, bumper, and side marker lights sold as replacement lamps for use on the passenger vehicles listed above. some combination lamps that are not equipped with amber side reflectors fail to conform to federal motor vehicle safety standard no. 108, lamps, reflective devices, and associated equipment.
Consequence:
Without the amber reflectors, the vehicle will be poorly illuminated, possibly resulting in a vehicle crash without warning.
Correction:
Ck motorsport will notify owners and replace the noncompliant lamps free of charge. the recall began on july 1, 2006. owners may contact ck motorsport at 1-909-610-7211.
Notes:
This recall only pertains to aftermarket replacement equipment and has no relation to any original equipment installed on vehicles manufactured by the vehicle manufacturers.for more information on the lamp model numbers, click on document search and view document titled "lamp model numbers."customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov.
Campaign:
09E012000 on 04/06/2009
Component:
Exterior lighting
Affected:
16,270
Defect:
Sabersport is recalling 16,270 combination corner and bumper lamp assemblies of various part numbers sold for use as aftermarket equipment for various passenger vehicles. these headlamps fail to conform to the requirements of federal motor vehicle safety standard no. 108, "lamps, reflective devices, and associated equipment." these lamps do not contain the required amber side reflectors.
Consequence:
Decreased lighting visibility may result in a vehicle crash.
Correction:
Sabersport will notify owners and offer a full refund for the noncompliant combination lamps. the safety recall began on may 11, 2009. owners may contact sabersport at 1-909-598-7589.
Notes:
This recall only pertains to aftermarket replacement equipment and has no relation to any original equipment installed on vehicles produced by the vehicle manufacturer.in order to determine if your aftermarket lamp assembly is affected by this noncompliance, please review the list of model numbers provided to us by sabersport.the list can be found under "document search" located at the bottom of your screen.owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to <a href=http://www.safercar.gov>http://www.safercar.gov</a> .
Campaign:
09E025000 on 05/10/2009
Component:
Exterior lighting:headlights
Affected:
42,540
Defect:
Dope, inc. is recalling 42,540 combination corner and bumper lamp assemblies of various part numbers sold for use as aftermarket equipment for various passenger vehicles. these headlamps fail to conform to the requirements of federal motor vehicle safety standard no. 108, "lamps, reflective devices, and associated equipment." these lamps do not contain the required amber side reflectors.
Consequence:
Decreased lighting visibility may result in a vehicle crash.
Correction:
Dope, inc. will notify owners and offer a full refund for the noncompliant combination lamps. the safety recall began on july 28, 2009. owners may contact dope, inc. at 1-626-272-1798.
Notes:
This recall only pertains to aftermarket replacement equipment and has no relation to any original equipment installed on vehicles produced by the vehicle manufacturer.in order to determine if your aftermarket lamp assembly is affected by this noncompliance, please review the list of model numbers provided to us by dope, inc.the list can be found under "document search" located at the bottom of your screen. owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to <a href=http://www.safercar.gov>http://www.safercar.gov</a> .

1996 TOYOTA TACOMA TSBs (51)

Bulletin:
SU00197
Component:
022141 suspension:rear:springs:leaf spring assembly:leaf
Summary:
To improve road feel and ride comfort under certain rough road conditions, changes have been made to the rear leaf springs and all four shock absorbers. *jd
Bulletin:
EG00297
Component:
063000 engine and engine cooling:exhaust system
Summary:
Evap charcoal canister noise. *jd
Bulletin:
97052300197
Component:
011000 steering:wheel and handle bar
Summary:
Information on steering wheel vibration. *yc
Bulletin:
97120500697
Component:
353600 equipment:air conditioner
Summary:
Improvement of the a/c suction hose. *yc
Bulletin:
001-98
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Improving engine idle smoothness by increasing idle speed from 600 rpm to 700 rpm. *yc
Bulletin:
TC99002
Component:
061000 engine and engine cooling:engine
Summary:
Subject on special service campaign x01 to replace the cylinder head gaskets. *yc
Bulletin:
AC00299
Component:
138000 visibility:defroster/defogger system
Summary:
Production changes to the cowl top louver and heater unit have been made to improve resistance to snow entry into the heater unit and improve durability of air mix door on vehicles within certain vin ranges. *tt
Bulletin:
AX00499
Component:
354600 equipment:mechanical:wrecker and wheel lift devices
Summary:
Subject regarding toyota dinghy towing guide. *tt
Bulletin:
TC99005
Component:
061000 engine and engine cooling:engine
Summary:
Special service campaign x01 involving replacement of the cylinder head gaskets installed on certain vehicles equipped with the 3.4 liter v6 engine. *tt
Bulletin:
EG00399
Component:
185000 vehicle speed control:cruise control
Summary:
This bulletin states that the operating logic on certain vehicles' ecms has been revised to improve engine idle smoothness (with transmission in d range). *tt
Bulletin:
080498
Component:
062300 engine and engine cooling:cooling system:hose
Summary:
Subject regarding upper and lower radiator hose. *tt
Bulletin:
120299
Component:
063130 engine and engine cooling:exhaust system:emission control:gas recirculation valve (egr valve)
Summary:
Parts information for vehicles equipped with exhaust gas recirculation (egr). *tt
Bulletin:
EG00699
Component:
063100 engine and engine cooling:exhaust system:emission control
Summary:
Subject regarding 5vz oxygen sensor improvement for vehicles built before certain vin ranges. *tt
Bulletin:
TC00599
Component:
101100 power train:clutch assembly:pedal/linkage
Summary:
Information on minimizing clutch pedal squeaking noise when depressing or releasing the clutch pedal on vehicles equipped with manual transmissions. *tt
Bulletin:
EG01199
Component:
063100 engine and engine cooling:exhaust system:emission control
Summary:
Subject regarding 5vz oxygen sensor improvement. *tt
Bulletin:
DL00199
Component:
105300 power train:driveline:driveshaft
Summary:
This service bulletin provides the location of the grease fittings for the propeller shaft joints. *tt
Bulletin:
TC00599
Component:
101100 power train:clutch assembly:pedal/linkage
Summary:
Information to minimize clutch pedal squeaking noise when depressing or releasing the clutch pedal. *tt
Bulletin:
BO00100
Component:
162000 structure:body
Summary:
Information regarding a new anti-chip tape developed to help prevent repeat occurrences of paint chipping on the rear quarter panels. *tt
Bulletin:
DL00199
Component:
105300 power train:driveline:driveshaft
Summary:
This bulletin provides the location of the grease fittings for the propeller shaft joints as well as the type of grease to use with each fitting location. *tt
Bulletin:
EG01199
Component:
063100 engine and engine cooling:exhaust system:emission control
Summary:
Information introducing design changes to the 5vz oxygen sensor to reduce possibility of moisture contacting the ceramic element. *tt
Bulletin:
BO01200
Component:
135200 visibility:rearview mirrors/devices:exterior
Summary:
Information introducing changes made to improve the adjustability of the driver's side exterior rear view mirror on vehicles starting with vin 4tawn72n9xz564100. *tt
Bulletin:
010199
Component:
063100 engine and engine cooling:exhaust system:emission control
Summary:
Subject regarding 5vz oxygen sensor improvement. *tt
Bulletin:
BO01900
Component:
200000 wheels
Summary:
Subject regarding front mudguards for vehicles starting with vin 4tapm62n*yz653866. *tt
Bulletin:
116
Component:
135200 visibility:rearview mirrors/devices:exterior
Summary:
Electronic mail regarding exterior mirror assembly. *tt
Bulletin:
BO01901
Component:
151100 seat belts:front:anchorage
Summary:
Information regarding shoulder belt anchor tape set. *jb
Bulletin:
TC01031
Component:
061000 engine and engine cooling:engine
Summary:
Subject regarding head gasket replacement. *yd
Bulletin:
DL00203
Component:
106000 power train:axle assembly
Summary:
Rear axle seal design change. *tt
Bulletin:
PG00503
Component:
198000 tires:temporary/emergency spare tire
Summary:
Spare tire carrier operation. various modlels including the 2004 landcruiser and 4 runner. *tt
Bulletin:
03704
Component:
061000 engine and engine cooling:engine
Summary:
Engine bank 1 and bank 2 a/f and 02 identification. various toyota models. *tt
Bulletin:
POL08-03
Component:
161000 structure:frame and members
Summary:
Toyota service campaign: see document search button for owner letter. customer support program - warranty coverage extension for frame rust corrosion perforation on certain 1995 through 2000 my tacoma vehicles. *nj
Bulletin:
LSC-90-D
Component:
161000 structure:frame and members
Summary:
Toyota service campaign: see document search button for owner letter. a number of vehicles operating in severe cold climate areas with high road salt used exhibited excessive rust corrosion to the frame, causing perforation of the metal.
Bulletin:
TC-11-013
Component:
161000 structure:frame and members
Summary:
Toyota service campaign: see document search button for owner letter. a service campaign to apply anti-corrosion materials for vehicles in cold states. 1996-2004 tacomas. *rm
Bulletin:
T-SB-0014-11 Rev
Component:
103000 power train:automatic transmission
Summary:
Tsb: the purpose of this service bulletin is to provide information regarding the installation of the correct torque converter bolts during automatic transmission/transaxle assembly replacement. incorrect torque converter bolts or missing w
Bulletin:
T-SB-0134-14
Component:
100000 power train
Summary:
Tsb: the purpose of this bulletin is to provide precautions to follow when installing an automatic transmission/transaxle assembly to avoid mil "on" shifting issues and/or transmission damage. use the information in this bulletin when insta
Bulletin:
T-SB-0101-11 Rev
Component:
110000 electrical system
Summary:
Tsb: when servicing interior electrical switches and components, please note the precautions in this bulletin to avoid damaging electrical components and switches. many lubricants, cleaners, and automotive chemicals contain silicone or othe
Bulletin:
T-SB-0101-11 Rev
Component:
110000 electrical system
Summary:
Tsb: when servicing interior electrical switches and components, please note the precautions in this bulletin to avoid damaging electrical components and switches. many lubricants, cleaners, and automotive chemicals contain silicone or othe
Bulletin:
T-SB-0304-17
Component:
162300 structure:body:door
Summary:
Tsb: vehicle replacement certification labels (the vinyl label installed on the driver door or door post) and vin plates (the metal plate riveted to dashboard) may be available from toyota, provided the request meets one of the criteria lis
Bulletin:
T-SB-0304-17_Rev
Component:
350000 equipment
Summary:
Tsb: supersession notice the information contained in this bulletin supersedes service bulletin nos. pg021-88, pg015-89, pg0015-90, pg002-91, pg002-93, pg005-97, pg007-01, pg007-07, and t-sb-0144-08. service bulletin nos. pg021-88, pg015-89
Bulletin:
T-TT-0213-13
Component:
140000 air bags
Summary:
Toyota vehicles are equipped with supplemental restraint systems (srs), including various airbags and in some models, seat belt pre-tensioners, to help reduce the risk of injury in a collision. if a customer expresses any concerns that the
Bulletin:
T-SB-0141-13
Component:
050000 parking brake
Summary:
A new special service tool (sst 09709-00002) has been introduced to aid in the inspection procedure for certain vehicles equipped with a floor pedal-type parking brake system. this bulletin references the correct method for installing the b
Bulletin:
T-SB-0185-13
Component:
130000 visibility
Summary:
The following procedures are recommended during routine maintenance or in the event of a customer concern for wiper performance.
Bulletin:
TS-BO030-01 Obso
Component:
130000 visibility/wiper (pws)
Summary:
This bulletin is now obsolete. please see t-sb-0185-13.
Bulletin:
T-SB-0071-11 Rev
Component:
100000 power train
Summary:
The purpose of this service bulletin is to provide precautions to follow when installing an automatic transmission/transaxle assembly to avoid mil ?on,? shifting issues, and/or transmission damage. use the information in this bulletin when
Bulletin:
T-TT-0010-10 Rev
Component:
060000 engine (pws)
Summary:
Tech tip: low battery voltage can contribute to a mil "on" condition for p0335 (crankshaft position
Bulletin:
T-SB-0144-08_Obs
Component:
350000 equipment
Summary:
Tsb: obsolete notice november 21, 2017: this bulletin is now obsolete. please see t-sb-0304-17.
Bulletin:
T-TT-0213-13
Component:
140000 air bags
Summary:
Toyota vehicles are equipped with srs, including various airbags and in some models, seat belt pre-tensioners, to help reduce the risk of injury in a collision. if a customer expresses any concerns that the srs airbags or pretensioner devi
Bulletin:
WLK052418
Component:
063000 engine and engine cooling:exhaust system
Summary:
Provides instructions for returning walker exhaust systems' bm premium pipe (p/n 55096). because the part did not have the oxygen sensor fitting drilled out, it will not allow the sensor to be installed.
Bulletin:
T-SB-0304-17_Rev
Component:
350000 equipment
Summary:
Tsb: revision notice july 31, 2018 rev2: ? the supersession notice has been updated. january 11, 2018 rev1: ? the supersession notice has been updated. any previous printed versions of this bulletin should be discarded. supersession notice
Bulletin:
PG004-97-Obsolet
Component:
350000 equipment
Summary:
Technical service bulletin: obsolete notice: july 31, 2018: this bulletin is now obsolete. please see t-sb-0304-17.
Bulletin:
PG006-01-Obsolet
Component:
350000 equipment
Summary:
Technical service bulletin: obsolete notice: july 31, 2018: this bulletin is now obsolete. please see t-sb-0304-17.
Bulletin:
Safety Recall an
Component:
350000 equipment
Summary:
Update on technician certification requirements.

Home | Privacy