1996 MERCURY MYSTIQUE Recalls (10)

Campaign:
97V225000 on 12/17/1997
Component:
Vehicle speed control:cables
Manufactured:
04/17/1994 - 08/14/1996
Affected:
38,000
Defect:
Vehicle description: passenger vehicles equipped with the traction control option. the throttle cables were damaged during vehicle assembly leading to fraying or separation of the throttle cable.
Consequence:
This condition could prevent the engine from returning to idle.
Correction:
Dealers will replace the throttle cable with a revised design that is less susceptible to bending or kinking during installation.
Notes:
Owner notification is expected to begin january 13, 1998. owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact ford at 1-800-392-3673.also contact the national highway traffic safety administration's auto safety hotline at 1-800-424-9393.
Campaign:
98V233000 on 09/24/1998
Component:
Power train:automatic transmission:lever and linkage:floor shift
Manufactured:
07/17/1994 - 01/11/1998
Affected:
175,000
Defect:
Vehicle description: passenger vehicles. the floor shift automatic transmission control can be damaged if subjected to certain interior cleaning products. the gear position indicator can deteriorate and not correctly indicate the actual gear position.
Consequence:
This condition can result in incorrect gear selection.
Correction:
Dealers will replace the automatic transmission floor shift control.
Notes:
Owner notification began november 20, 1998.owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact ford at 1-800-392-3673.also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
Campaign:
99V103000 on 05/09/1999
Component:
Exterior lighting:headlights:switch
Manufactured:
04/19/1995 - 08/23/1998
Affected:
605,581
Defect:
Vehicle description: passenger vehicles. the terminals at the headlight switch and wiring harness connector can experience heat damage as a result of overheating.
Consequence:
The damage could result in distortion of the terminal causing an open circuit in the instrument panel illumination, parking lamp, and tail lamp circuits.
Correction:
Dealers will install a headlamp switch wiring connector containing bronze terminals and an inspection, and replacement if necessary, of the headlamp switch.
Notes:
Owner notification began july 16, 1999. owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact ford at 1-800-392-3673.also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
Campaign:
99V247000 on 09/22/1999
Component:
Fuel system, gasoline:storage:tank assembly:filler pipe and cap
Manufactured:
01/31/1996 - 03/19/1996
Affected:
22,324
Defect:
Vehicle description: passenger vehicles. the fuel filler pipe vent hose may have less than the intended level of ozone resistance, which could result in the hose becoming brittle and cracking.
Consequence:
A cracked hose could result in fuel leakage when the vehicle is being fueled.
Correction:
Dealers will install a fuel filler vent hose contacting the appropriate blend of pvc and nitrile rubber.
Notes:
Ford recall no. 99s24. owner notification began october 11, 1999.owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact ford at 1-800-392-3673.also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
Campaign:
00V075000 on 03/13/2000
Component:
Service brakes, hydraulic:foundation components
Manufactured:
03/31/1996 - 08/23/1998
Affected:
436,200
Defect:
Vehicle description: passenger vehicles not equipped with the anti-lock braking system (abs). a pressure conscious reducing valve (pcrv) in the rear brakes may be subject to corrosion and result in malfunction, when operated in areas that use salt compounds on the roadway for de-icing or dust control.
Consequence:
If both pcrv's malfunction, vehicle handling could be adversely affected during braking as a result of the rear wheels locking, increasing the risk of a crash.
Correction:
Dealers will install improved pcrv's in the rear brake system. this recall was expanded in september 2000 to include 1999 and 2000 ford contour, mercury mystique and cougar vehicles.
Notes:
Owner notification began april 3, 2000 for the 1996-1998 model vehicles and on october 11, 2000, for the 1999-2000 model vehicles.owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact ford at 1-800-392-3673. also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
Campaign:
00V367000 on 11/06/2000
Component:
Engine and engine cooling
Manufactured:
04/17/1994 - 12/28/1995
Affected:
262,559
Defect:
Vehicle description: 1995 passenger vehicles equipped with the 2.0l and 2.5l engines, and 1996 vehicles equipped with 2.5l engines. tightening of the engine cooling fan motor bearings, up to and including motor stall, can result in increased motor torque and higher than normal motor current and accompanying high motor temperatures.
Consequence:
Overheating of the cooling fan motor due to excessive current can result in smoke and odors from bearing grease, insulation and other internal motor components. if electrical current continues to be applied to the motor, internal motor components could ignite possibly igniting other engine compartment components.
Correction:
Dealers will install a positive temperature coefficient device in-line with each fan motor. ford will also extend the warranty on the engine cooling fan assembly to a total of 8 years of service or 100,000 miles from the warranty start date, whichever occurs first. if the vehicle already has more than 100,000 miles, this coverage will last until july 31, 2001.
Notes:
Owner notification began february 5, 2001. owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact ford at 1-800-392-3673. also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
Campaign:
01V230000 on 07/12/2001
Component:
Electrical system
Manufactured:
05/31/1996 - 05/30/1998
Affected:
342,962
Defect:
On certain my 1996-1998 passenger vehicles built at the kansas city, cuautitlan assembly plants or on my 1999 passenger vehcles built at the automotive alliance international assembly plants, the rough surface of the heater blower resistor's stainless steel blades can damage the copper surface of the wiring harness connector. the damage could, over time, cause increased resistance in the connector and, due to subsequent terminal relaxation, result in an open circuit condition.
Consequence:
The open circuit could lead to electrical arcing that could melt the connector housing material creasing the potential for a fire.
Correction:
Dealers will install a new heater blower resistor and a new wire jumper harness. owner notification began august 29, 2001. owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact ford at 1-800-392-3673.
Notes:
Ford recall no.01s22.also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
Campaign:
01I009000 on 07/18/2001
Component:
Visibility:defroster/defogger system:windshield:controls/wiring
Manufactured:
07/31/1994 - 02/06/1997
Affected:
566,979
Defect:
This is not a safety recall in accordance with the safety act. however, it is deemed a safety improvement campaign by the agency. vehicle description: 1995-1997 ford contour and mercury mystique vehicles. the heater blower resistor could overheat causing the attached electrical connector to melt.
Consequence:
This could create the potential for a fire.
Correction:
Ford will provide additional warranty coverage for the heater blower switch for 10 years from original date of sale of the vehicle or 150,000 miles, whichever comes first. dealers will install a new heater blower resistor and a new wire jumper harness free of charge.
Notes:
Ford has decided to conduct an extended coverage program to extend the warranty coverage for potential heather blower resistor problems. owners can contact ford at1-866-436-7332, concerning this program.
Campaign:
06E022000 on 03/12/2006
Component:
Service brakes, hydraulic
Affected:
7,440
Defect:
Certain aftermarket brake hydraulic master cylinders sold as replacement brake cylinders for certain ford, daimlerchrysler, and jeep passenger vehicles. these brake cylinders were sold under the brand names of napa, raybestos, aimco, ac delco, carquest, bendix, and wagner. only products that were manufactured from july 27, 2005 through january 17, 2006 (date codes 0529 through 0602) are subject to this recall. when subject to very cold temperatures, an internal seal in the master cylinder could lose flexibility and may cause brake fluid to leak.
Consequence:
Loss of brake fluid can lead to a decrease in brake line pressure and an increase in stopping distance, which can result in a vehicle crash.
Correction:
Affinia (brake parts, inc.) will replace the subject brake hydraulic master cylinders free of charge. the recall began on march 20, 2006. owners can contact affina group customer service at 1-800-323-0354.
Notes:
This recall only pertains to aftermarket napa, raybestos, ac delco, aimco, carquest, and bendix brake hydraulic master cylinders and has no relation to any original equipment installed on daimlerchrysler or ford vehicles.customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov.
Campaign:
08E033000 on 04/16/2008
Component:
Suspension
Affected:
6,903
Defect:
Federal mogul is recalling 6,903 aftermarket ball joint assemblies shipped between november 9, 2007 and march 26, 2008, which may have been packaged with incorrect nuts. the part numbers packaged with incorrect nuts are: k7147, k7329, k8683, and 104353. these parts were made for use on the various vehicles listed above.
Consequence:
The nuts included in the packaging for these ball joint assemblies are missing the intended prevailing torque (self-locking) feature. if the incorrect nut was to become loose, the joining members may loosen leading to a separation of the ball joint. this may result in loss of vehicle control, possibly resulting in a vehicle crash.
Correction:
Federal mogul will notify owners and replace the parts free of charge. the recall began on may 22, 2008. owners can contact federal mogul at 877-489-6659.
Notes:
This recall only pertains to aftermarket ball joint assemblies and has no relation to any original equipment installed on vehicles manufactured by the vehicle manufacturers.customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov.

1996 MERCURY MYSTIQUE TSBs (205)

Bulletin:
BC0090960102
Component:
185000 vehicle speed control:cruise control
Summary:
to improve startability of 2.0l engine at ambient temps below 0 deg f (-18 c) depress the accelerator to approx. 1/4 throttle & crank for 5 sec. if the engine does not start, continue cranking while depressing the accelerator to initialize
Bulletin:
BC0100960102
Component:
032100 service brakes, hydraulic:switches:brake light
Summary:
discharged battery or brake lights stuck on may be caused by a mal- adjusted brake light switch.
Bulletin:
BC0181960102
Component:
071100 fuel system, gasoline:storage:tank assembly
Summary:
for concerns of hard start/no start, start/stalls or hesitation, make sure the tank contains fresh 87 octane fuel from a high volume service station in your area. this concern may be caused by summer blend fuels with low rvp (reid vapor pr
Bulletin:
BC0183960102
Component:
011000 steering:wheel and handle bar
Summary:
open fuse 30 may be caused by interference between the instrument cluster flex circuit & the lh side steering column retaining bolt. if damage is present, remove the lh steering column retaining bolt & install a 1.5mm (1/16 inch) washer (p
Bulletin:
BC0185960102
Component:
133000 visibility:power window devices and controls
Summary:
front door windows which bend or come out of the track may be repaired by the following procedure (refer to the service manual).
Bulletin:
BC0186960102
Component:
103000 power train:automatic transmission
Summary:
engineering is investigating a concern on the cd4e transaxle where transmission fluid mists from the transaxle vent tube. this concern causes transmission fluid to puddle on top of the transaxle & can be perceived as a pan gasket or seal l
Bulletin:
BC0237960102
Component:
185000 vehicle speed control:cruise control
Summary:
2.5l cold start/stall. perform normal diagnostics including the use of sbds to determine system faults. if no error codes are indicated by normal diagnostics, replace idle air control valve, p/n f5rz-9f715-a for 1995 model. use f5dz-9f715-
Bulletin:
95212
Component:
036000 service brakes, hydraulic:antilock
Summary:
the use of petroleum-based grease as a lubricant in servicing disc brakes is no longer acceptable because it may be incompatible with the rubber material used in the disc brake system. if petroleum-based grease is used to lubricate any par
Bulletin:
BC0783961014
Component:
103000 power train:automatic transmission
Summary:
New pcm calibration to correct low speed maneuver, high ambient temp, & start/run/stall concerns. *tt
Bulletin:
BC0784961014
Component:
106000 power train:axle assembly
Summary:
Weld connection concern w/ the forward/direct/coast clutch cylinder & hub assy. *tt
Bulletin:
BC0785961014
Component:
114100 electrical system:wiring:front underhood
Summary:
Diagnosing charging or starting system concerns of potential chafe between circuit 30 & the subframe in the area between the alternator & the mega-fuse. *tt
Bulletin:
BC0824961010
Component:
070000 fuel system, gasoline
Summary:
Complaints of stalling on 1996 & 1997 vehicles w/ 2.0l cd4e. *tt
Bulletin:
BC5191961001
Component:
103000 power train:automatic transmission
Summary:
For concerns of stalling, reflash pcm w/ 1996 calibration (r11 level). *tt
Bulletin:
BC9640961001
Component:
073200 fuel system, gasoline:fuel injection system:injectors
Summary:
Concern of one or more injectors staying on at times.
Bulletin:
BC9641961001
Component:
070000 fuel system, gasoline
Summary:
Complaints of stalling on vehicles with 2.0l cd4e engines. *tt
Bulletin:
BC9666961001
Component:
061000 engine and engine cooling:engine
Summary:
2.5l duratec engine exchanges no longer include front end accessory drive component, oil level indicator, water pump belt/tensioner, egr tube, linkshaft bracket or exhaust manifolds. *tt
Bulletin:
BC9688961001
Component:
353000 equipment:electrical
Summary:
Information for when diagnosing concerns w/ factory installed cellular phones. *tt
Bulletin:
BC9692961001
Component:
353600 equipment:air conditioner
Summary:
Revised evaporator case f7rz-19850-ga for water dripping from evaporator case onto the floor while the a/c system is operating. *tt
Bulletin:
BC0301961101
Component:
116200 electrical system:ignition:module
Summary:
Intermittent stalling during high ambient temperatures and parking lot maneuvers. *tw
Bulletin:
BC0302961101
Component:
980000 unknown or other
Summary:
Carpet pulls from under right front door. *tw
Bulletin:
BC0303961101
Component:
073000 fuel system, gasoline:fuel injection system
Summary:
Vibration at idle. *tw
Bulletin:
BC0350961126
Component:
162300 structure:body:door
Summary:
Inoperative power door locks. *tw
Bulletin:
BC0501961111
Component:
022000 suspension:rear
Summary:
Squeaks from the rear suspension. *tw
Bulletin:
BC0502961111
Component:
132000 visibility:glass, side/rear
Summary:
Concerns of moulding at bottom of door window glass coming loose. *tw
Bulletin:
BC0503961111
Component:
034520 service brakes, hydraulic:foundation components:disc:pads
Summary:
Improved front brake pad. *tw
Bulletin:
96246
Component:
114000 electrical system:wiring
Summary:
Wiring - electrical diode identification and service replacements. *tw
Bulletin:
96248
Component:
102000 power train:manual transmission
Summary:
Noise - grinding or clashing heard when shifting into 3rd gear - vehicles with mtx-75 transaxle - vehicles built through 9/1/96. *tw
Bulletin:
96249
Component:
103700 power train:automatic transmission:torque converter
Summary:
Torque converter - leak test procedure - service tip. *tw
Bulletin:
96221
Component:
131000 visibility:windshield
Summary:
Windshield and interior glass - fog/film. *tw
Bulletin:
96222
Component:
034000 service brakes, hydraulic:foundation components
Summary:
Brakes - elimination of sanding rotors and drums - service tip. *tw
Bulletin:
96223
Component:
185000 vehicle speed control:cruise control
Summary:
Long crank - sticking idle air control (iac) valve - vehicles built from 11/1/94 through 3/30/96 -stall - after starting when engine allowed to soak from 1-4 hours - sticking idle air control (iac) valve. *tw
Bulletin:
96225
Component:
075000 fuel system, gasoline:carburetor system
Summary:
Mass air flow sensor - replacement as an assembly - service tip. *tw
Bulletin:
96256
Component:
051000 parking brake:conventional
Summary:
Parking brake - parking brake sticks and binds - does not release - vehicles equipped with rear disc brakes. *tw
Bulletin:
962510
Component:
116200 electrical system:ignition:module
Summary:
Malfunction indicator lamp (mil) - diagnostic trouble codes (dtcs) p0300, p0301, p0302, p0303, p0304, p0305, p0306, p0307 and/or p0308 stored in memory. *tw
Bulletin:
962511
Component:
116200 electrical system:ignition:module
Summary:
Powertrain control module -reprogram powertrain control module (pcm) - service procedures - service tip. *tw
Bulletin:
96265
Component:
116200 electrical system:ignition:module
Summary:
Malfunction indicator lamp (mil) - diagnostic trouble codes (dtcs) p0300, p0301, p0302, p0303, p0304, p0305, p0306, p0307, and/or p0308 stored in memory. *tw
Bulletin:
962612
Component:
103700 power train:automatic transmission:torque converter
Summary:
Transaxle - torque converter replacement guidelines and torque converter/transaxle cooling system cleaning procedures - service tip. *tw
Bulletin:
962614
Component:
103000 power train:automatic transmission
Summary:
Transaxle - cd4e - harsh shift and/or engagement - diagnostic trouble code 628 or p0741. *tw
Bulletin:
BC0043970201
Component:
330000 interior lighting
Summary:
Engineering is investigating incidents of low coolant light illumination on 2.5l contour/mystiques. *jd
Bulletin:
BC0044970201
Component:
103000 power train:automatic transmission
Summary:
Intermittent surging, bucking or shudder concern, intermediate erratic speddometer and/or possibly dtc452. *jd
Bulletin:
BC0142970201
Component:
162300 structure:body:door
Summary:
Concerns of locking doors, a revised door lock bezel is coming. *jd
Bulletin:
BC0195970201
Component:
980000 unknown or other
Summary:
Buzz/rattle on tip in during cruise that appears to come from center of right side of the instrument panel. *jd
Bulletin:
BC0201970201
Component:
036400 service brakes, hydraulic:antilock:abs warning light
Summary:
Abs light on/wheel speed sensor codes may be caused by corrosion of terminals. *jd
Bulletin:
BC0224970201
Component:
063140 engine and engine cooling:exhaust system:emission control:catalytic convertor
Summary:
Revised catalysts are now available. *jd
Bulletin:
BC0303970201
Component:
061000 engine and engine cooling:engine
Summary:
Vibration at idle. *jd
Bulletin:
BC1008697020
Component:
036400 service brakes, hydraulic:antilock:abs warning light
Summary:
Abs light on/wheel speed sensor codes may be caused by corrosion of terminals at the hcu and wire harness 22 pin connector. *jd
Bulletin:
BC1012197020
Component:
162300 structure:body:door
Summary:
Concerns of locking doors, a revised door lock bezel is coming- customers may lock themselves out of the vehicle. *jd
Bulletin:
BC9599970201
Component:
063140 engine and engine cooling:exhaust system:emission control:catalytic convertor
Summary:
Revised catalysts are now availabel for vehicles. new part should be used when a restricted/damaged catalyst is encountered, or when catalyst support material is found in the egr tube. *jd
Bulletin:
9721
Component:
131000 visibility:windshield
Summary:
Door glass - window belt line moulding loose or falls off - vehicles built through 10/31/96. *tw
Bulletin:
BC0043972301
Component:
330000 interior lighting
Summary:
Low coolant light illumination on 2.5l vehicles. *jd
Bulletin:
BC0044972301
Component:
105000 power train:driveline
Summary:
Intermittent surging, bucking or shudder concern, intermediate erratic speedometer and/or possibly dtc 452- inspect the vss and speedo gear. *jd
Bulletin:
BC0301972301
Component:
980000 unknown or other
Summary:
Buzz/rattle on tip in - instrument panel area. *jd
Bulletin:
BC0302972301
Component:
063130 engine and engine cooling:exhaust system:emission control:gas recirculation valve (egr valve)
Summary:
Dtc's 332 or p1401 - lack of egr flow. *jd
Bulletin:
BC0303972301
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Vibration at idle. *jd
Bulletin:
BC3490972301
Component:
980000 unknown or other
Summary:
The third/fourth synchronizer assembly should be installed with the large collar facing outward- the service manual incorrectly advises to install the third/fourth gear assembly with the small collar facing out. *jd
Bulletin:
BC1018897230
Component:
980000 unknown or other
Summary:
The third/fourth synchronizer assembly should be installed with the large collar facing outward (toward reverse gear). *jd
Bulletin:
BC0300A97020
Component:
036000 service brakes, hydraulic:antilock
Summary:
Multiple abs codes. *tw
Bulletin:
BC0301970201
Component:
980000 unknown or other
Summary:
Buzz/rattle on tip in - instrument panel area. *tw
Bulletin:
BC0302970201
Component:
063130 engine and engine cooling:exhaust system:emission control:gas recirculation valve (egr valve)
Summary:
Egr issues - if normal pc/ed diagnosis fails, failure may be due to carbon deposits. *tw
Bulletin:
BC0303A97020
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Vibration at idle. *tw
Bulletin:
BC1024297230
Component:
138120 visibility:defroster/defogger system:windshield:heater core
Summary:
Vehicles may be equipped with 95 level heater cores. *jd
Bulletin:
BC1026697230
Component:
101100 power train:clutch assembly:pedal/linkage
Summary:
Vehicles exhibiting harsh shifts and/or harsh engagement accompanied by dtcs 628 or p0741. *jd
Bulletin:
9731
Component:
980000 unknown or other
Summary:
Carpet- poor fit and/or pulls from underneath cowl side trim panel- vehicles built through 10/18/96. *jd
Bulletin:
9735
Component:
353600 equipment:air conditioner
Summary:
Air conditioning- r-134a tracer dye installed in a/c system and three o-ring spring lock couplers- service tip. *jd
Bulletin:
9741
Component:
061000 engine and engine cooling:engine
Summary:
Hard start- cold ambient temperatures near or below -18 degrees celsius (0 degrees fahrenheit)- hehicles with 2.0l engine. *jd
Bulletin:
9746
Component:
022000 suspension:rear
Summary:
Transaxle- cd4e- harsh shift and/or engagement- diagnostic trouble code (dtc) 628 or p0741- service tip. *jd
Bulletin:
BC3100970224
Component:
980000 unknown or other
Summary:
Micron filter - reminder that the filter must be changed every 15000 miles - symptoms that might indicate need for change include poor a/c-heater performance and/or window fogging. *tw
Bulletin:
BC3162970218
Component:
105500 power train:driveline:differential unit
Summary:
Clicking noise caused by differential lube tube contacting differential case. *tw
Bulletin:
BC1032697020
Component:
138000 visibility:defroster/defogger system
Summary:
Vehicles have a cabin air filter that must be changed every 15000 miles. *jd
Bulletin:
BC3204970214
Component:
103000 power train:automatic transmission
Summary:
Harsh shifts and/or harsh engagement accompanied by dtc's 628 or p0741. *tw
Bulletin:
BC3226970212
Component:
162700 structure:body:trunk lid
Summary:
Water entry into luggage compartment. *tw
Bulletin:
BC9692970201
Component:
353600 equipment:air conditioner
Summary:
Water drips from the evaporator case onto the floor while the a/c system is operating. *jd
Bulletin:
BC3227970212
Component:
061110 engine and engine cooling:engine:gasoline:belts and associated pulleys
Summary:
Fead belt slips when wet or alternator light on/decreased power steering assist. *tw
Bulletin:
BC3232970211
Component:
061110 engine and engine cooling:engine:gasoline:belts and associated pulleys
Summary:
Battery illumination and decreased power steering assist when driving through deep puddles. *tw
Bulletin:
BC3245970210
Component:
161000 structure:frame and members
Summary:
Rear appliques - service kit being developed to repair damaged appliques from license plate changes. *tw
Bulletin:
BC3274970207
Component:
121000 exterior lighting:headlights
Summary:
Replacement headlamp bulbs - several aftermarket companies are offering replacement bulbs with a higher wattage that are not dot approved - sold with disclaimer of "for off-road use only" - the bulbs draw more current than the oem bulbs a
Bulletin:
BC3284970206
Component:
138120 visibility:defroster/defogger system:windshield:heater core
Summary:
Some early built 96 model year contour/mystique may be equipped with 95 level heater cores. *tw
Bulletin:
9751
Component:
220000 seats
Summary:
Interior- leather seat cleaning procedure- service tip. *jd
Bulletin:
9752
Component:
052000 parking brake:driveline
Summary:
Parking brake- parking brake sticks and binds- does not release- vehicles equipped with rear disc brakes. *jd
Bulletin:
9759
Component:
103600 power train:automatic transmission:cooling unit and lines
Summary:
Leak- automatic transmission fluid- cd4e transaxle in fluid collection on main control assembly. *jd
Bulletin:
97511
Component:
103000 power train:automatic transmission
Summary:
Fluid- transmission fluid usage charts. *jd
Bulletin:
9768
Component:
980000 unknown or other
Summary:
Fuel economy- customer expectations versus vehicle usage. *jd
Bulletin:
BC2243970501
Component:
138000 visibility:defroster/defogger system
Summary:
Climate control system - vacuum motor links falling off - repair with locally procured star washer. *tw
Bulletin:
BC2395970501
Component:
162300 structure:body:door
Summary:
Customer complaints of doors that lock inadvertently. *tw
Bulletin:
BC2432970501
Component:
980000 unknown or other
Summary:
Engine oil pressure specification. *tw
Bulletin:
BC2446970501
Component:
090000 fuel system, other
Summary:
Some 96 & 97 vehicles misbuilt with 1998 model year fuel gauge. *tw
Bulletin:
BC106019705
Component:
138000 visibility:defroster/defogger system
Summary:
Climate control system vacuum motor links falling off may be repaired by adding the appropriate size internal star washer retainer to the end of the shaft after installing the link. *tw
Bulletin:
97050110616
Component:
063000 engine and engine cooling:exhaust system
Summary:
Concerns of sulphur odor from exhaust system. *tw
Bulletin:
97111097234
Component:
113000 electrical system:starter assembly
Summary:
Vehicles exhibiting a "squeaking" or "chirping" from the blower motor at low blower motor speeds. *yc
Bulletin:
985A5
Component:
034530 service brakes, hydraulic:foundation components:disc:rotor
Summary:
Hub-mount brake rotor machining equipment from rotunda is now approved for warranty and service use. *yc
Bulletin:
985A11
Component:
034000 service brakes, hydraulic:foundation components
Summary:
Service tip information regarding elimination of sanding rotors and drums. *yc
Bulletin:
985A13
Component:
034500 service brakes, hydraulic:foundation components:disc
Summary:
The use of petroleum-based grease as a lubricant in servicing disc brakes is no longer acceptable. *yc
Bulletin:
985A17
Component:
050000 parking brake
Summary:
Some vehicles parking brake equipped with rear disc brakes may stick and/or bind when attempting to release. *yc
Bulletin:
9881
Component:
353400 equipment:electrical:radio/tape deck/cd etc.
Summary:
Issue with door speaker grilles may crack during normal usage on some vehicles. *yc
Bulletin:
9886
Component:
062000 engine and engine cooling:cooling system
Summary:
An engine coolant loss may occur from the engine block heater area. *yc
Bulletin:
9888
Component:
103000 power train:automatic transmission
Summary:
Information on a new transmission fluid usage chart. *yc
Bulletin:
97E61
Component:
063000 engine and engine cooling:exhaust system
Summary:
Experiencing a premature failure of the catalyst substrate material in the catalyst / exhaust manifold assembly. *yc
Bulletin:
9841
Component:
980000 unknown or other
Summary:
During removal the license plate attaching fasteners may break. *yc
Bulletin:
9845
Component:
045300 service brakes, air:disc:rotor
Summary:
Availability of hub-mount brake rotor machining equipment. *yc
Bulletin:
9852
Component:
190000 tires
Summary:
Information on tire company telephone numbers for customer assistance. *yc
Bulletin:
980309
Component:
036000 service brakes, hydraulic:antilock
Summary:
Information regarding multiple abs codes. *yc
Bulletin:
982672
Component:
061000 engine and engine cooling:engine
Summary:
Some vehicles may exhibit a customers concern of a rattling sound from engine timing belt area during warm-up. *yc
Bulletin:
982514
Component:
061000 engine and engine cooling:engine
Summary:
Concerns with the timing arrows/flags on the back of the camshaft sprocket (s) are mis-marked by as much as 30 degrees rotation. *yc
Bulletin:
98213
Component:
062100 engine and engine cooling:cooling system:radiator assembly
Summary:
Concerns with temperature reads high within normal range when engine is at normal operating temperature. *yc
Bulletin:
98207
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Some vehicles may experience a stall or rough idle after starting in ambient temperatures. *yc
Bulletin:
982010
Component:
063000 engine and engine cooling:exhaust system
Summary:
Experiencing a " buzzing " or " rattling " noise from the exhaust system. *yc
Bulletin:
982310
Component:
063100 engine and engine cooling:exhaust system:emission control
Summary:
Mass air flow (maf)- sensor contamination- service tip. *ak
Bulletin:
982311
Component:
106000 power train:axle assembly
Summary:
Minimal clearance of the cd4e transaxle to subframe makes transaxle installation and removal more difficult. *yc
Bulletin:
98246
Component:
110000 electrical system
Summary:
Ford motor company has released a new electrical grease ( f8az - 19g208-aa ) to reduce the possibility of moisture corrosion at the terminals. *yc
Bulletin:
98B21
Component:
061000 engine and engine cooling:engine
Summary:
Subject on engine block heaters. *tt
Bulletin:
9943
Component:
100000 power train
Summary:
Information regarding reprogramming powertrain control modules (pcms). *tt
Bulletin:
5810
Component:
141000 air bags:frontal
Summary:
Subject on steering wheel & airbag replacement. *tt
Bulletin:
5849
Component:
353600 equipment:air conditioner
Summary:
Some vehicles may exhibit a left air conditioning panel register discharge temperature that is warmer than the center and / or right vents. *tt
Bulletin:
9814
Component:
034530 service brakes, hydraulic:foundation components:disc:rotor
Summary:
Subject regarding the availability of hub-mount brake rotor machining equipment. *tt
Bulletin:
976007
Component:
133000 visibility:power window devices and controls
Summary:
Information on the service bay diagnostic system (sbds) and reselecting an incorrect qualifier. *tt
Bulletin:
9989
Component:
034000 service brakes, hydraulic:foundation components
Summary:
Some vehicles may exhibit a groaning noise from the front brakes during city driving. *tt
Bulletin:
99816
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Ford motor company now recommends sae 5w-30 viscosity grade for servicing any ford gasoline-powered vehicle regardless of model year. *tt
Bulletin:
99139
Component:
125000 exterior lighting:brake lights
Summary:
Conditions with the brake lamps inadvertently disabling the brake shift interlock. *tt
Bulletin:
6320
Component:
020000 suspension
Summary:
Concerns with vibration at 60 - 70 mph. *tt
Bulletin:
996041
Component:
102000 power train:manual transmission
Summary:
Vehicles may exhibit a hard to shift condition in cold weather. *tt
Bulletin:
9912781
Component:
020000 suspension
Summary:
Experiencing vibration at 60 - 70 mph (110 - 12- kph). *tt
Bulletin:
983081
Component:
034420 service brakes, hydraulic:foundation components:drum:shoes/linings
Summary:
Concerns with incorrect brake shoe / lining assembly. *tt
Bulletin:
983216
Component:
046300 service brakes, air:antilock:wheel speed sensor
Summary:
Some vehicles may exhibit multiple wheel speed sensor codes. *tt
Bulletin:
98-0314
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Conditions with misfire diagnostic trouble codes with 2.0l engine. *tt
Bulletin:
983583
Component:
162000 structure:body
Summary:
Some vehicles may experience a vibration at highway speeds. *tt
Bulletin:
983590
Component:
061000 engine and engine cooling:engine
Summary:
Information regarding the malfunction indicator light (mil) and misfire diagnostic trouble codes (dtcs) p0300, p0301, p0302, p0303, p0304, p0305, and p0306 with no driveability concerns. *tt
Bulletin:
9810799
Component:
150000 seat belts
Summary:
Subject regarding seat belt locator button replacement. *tt
Bulletin:
9913137
Component:
113000 electrical system:starter assembly
Summary:
Concerns with 2.5l engine equipped vehicles and cd4e transaxle exhibiting a starter grinding noise and / or lack of starter drive engagement. *tt
Bulletin:
99M07
Component:
138130 visibility:defroster/defogger system:windshield:controls/wiring
Summary:
Owner notification program for additonal coverage on heater blower switch, resistor and attached wire connectors replacement. this additional coverage is provided in case the vehicle owner experiences durability concerns with these compo
Bulletin:
99M01
Component:
138130 visibility:defroster/defogger system:windshield:controls/wiring
Summary:
Owner notification program providing additional coverage for replacement of the blower switch, resistor and attached wire connectors. this additional coverage is provided in case the vehicle owner experiences durability concerns with thes
Bulletin:
99201
Component:
106000 power train:axle assembly
Summary:
Concerns with a harsh shift felt at large throttle openings (or at heavy acceleration rate) on some vehicles. *tt
Bulletin:
99222
Component:
114000 electrical system:wiring
Summary:
Subject on a wire harness terminal repair kit available for repairing electrical wiring harnesses. *tt
Bulletin:
99194
Component:
034000 service brakes, hydraulic:foundation components
Summary:
Information for servicing and diagnosing brake vibration, brake inspection, and brake friction material replacement. *tt
Bulletin:
99195
Component:
353600 equipment:air conditioner
Summary:
Service information for musty and mildew type odors coming from the air conditioning / heating system. *tt
Bulletin:
99196
Component:
353600 equipment:air conditioner
Summary:
Information on identifying non-approved / alternate refrigerants which could cause safety, and performance concerns if installed in ford a/c systems. *tt
Bulletin:
99249
Component:
103000 power train:automatic transmission
Summary:
This bulletin addresses an issue with the automatic transmission fluid seeping from the vent, resulting in fluid collecting on the main control assembly. *tt
Bulletin:
6906
Component:
113000 electrical system:starter assembly
Summary:
Exhibiting a starter grinding noise and / or lack of starter drive engagement. *tt
Bulletin:
6994
Component:
105500 power train:driveline:differential unit
Summary:
Concerns with vehicles exhibiting a driveline rattle or clunking type noise during tip-in or transmission gear engagement. *tt
Bulletin:
13178
Component:
103000 power train:automatic transmission
Summary:
Information regarding clunk/rattle on tip-in or transmission gear engagement. *mjs
Bulletin:
13316
Component:
105000 power train:driveline
Summary:
Exhibiting a driveline rattle or clunking type noise during tip-in or transmission gear engagement. *tt
Bulletin:
13364
Component:
020000 suspension
Summary:
Customer may comment on vibration at 60 - 70 mph at cruise. *tt
Bulletin:
98166
Component:
060000 engine and engine cooling
Summary:
The temperature gauge reads high in the normal range when engine is at normal operating temperature.
Bulletin:
11725
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Some vehicles may exhibit a knocking or clunking sound during rapid acceleration / deceleration as when letting off and putting your foot down on the accelerator quickly. *tt
Bulletin:
7344
Component:
020000 suspension
Summary:
Some vehicles may exhibit a vibration at 60-70 mph. *tt
Bulletin:
7349
Component:
105000 power train:driveline
Summary:
Some vehicles equipped with 2.5l engine and cd4e transmission may exhibit a driveline rattle or clunking type noise during tip-in or transmission gear engagement. *tt
Bulletin:
7430
Component:
180000 vehicle speed control
Summary:
Information regarding speed control switch voltage readings - service tip. *tt
Bulletin:
0015
Component:
103000 power train:automatic transmission
Summary:
Information regarding the new transmission cooler flusher- service tip. *mjs
Bulletin:
7864
Component:
114200 electrical system:wiring:interior/under dash
Summary:
World wide diagnostics service tip.
Bulletin:
0019
Component:
106000 power train:axle assembly
Summary:
Information regarding several internal changes that have been implemented on the mrx-75 transaxle to improve shift efforts. *mjs
Bulletin:
7923
Component:
101000 power train:clutch assembly
Summary:
Clutch will not engage after service.
Bulletin:
13761
Component:
101000 power train:clutch assembly
Summary:
Some vehicles equipped with 2.0l engines may exhibit symptoms of clutch slippage or no clutch engagement after performinb repairs to the clutch system. *mjs
Bulletin:
12075
Component:
011000 steering:wheel and handle bar
Summary:
Vehicles built prior to 6/16/98 may have a broken/detached ip clustr bezel gaphider. the hider is a hinged flap between the steering column shroud and the ip bezel. *mjs
Bulletin:
12140
Component:
140000 air bags
Summary:
Some vehicles equipped ith 2.0l may require replacement of the left air bag module or steering wheel during normal repair situations. *mjs
Bulletin:
985089
Component:
114200 electrical system:wiring:interior/under dash
Summary:
Some vehicles built prior to 6/16/98 may have a broken / detached instrument panel cluster bezel gaphider. *tt
Bulletin:
12174
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Some vehicles may exhibit a hard start/long crank, cold start stall, cold rough idle concern. *mjs
Bulletin:
96712
Component:
106000 power train:axle assembly
Summary:
Subjec regarding the mtx-75 transaxles will be installed certain mode year vehicles. *tt
Bulletin:
99-4700
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Some 1995/1996 2.5lford, contour/ mercury, mystique vehicles may run rough and display an illuminated mil after recall 97e61 is performed. *ak
Bulletin:
6201
Component:
034000 service brakes, hydraulic:foundation components
Summary:
Experiencing a front brake groan during city driving. *tt
Bulletin:
6243
Component:
162700 structure:body:trunk lid
Summary:
Online service information pertaining to various decklid release issues. *tt
Bulletin:
12707
Component:
034000 service brakes, hydraulic:foundation components
Summary:
Some vehicles may exhibit a front brake groan. *tt
Bulletin:
12726
Component:
162700 structure:body:trunk lid
Summary:
Information regarding decklid release issues. *tt
Bulletin:
6091738
Component:
020000 suspension
Summary:
Some vehicles may exhibit a vibration at 60 - 70 mph (100 - 115 kph). *tt
Bulletin:
12508
Component:
141000 air bags:frontal
Summary:
Some vehicles may require steering wheel and airbag replacement. *tt
Bulletin:
12525
Component:
353600 equipment:air conditioner
Summary:
Concerns with the left air conditioning panel register discharge temperature that is warmer than the center and / or right vents. *tt
Bulletin:
13379
Component:
105500 power train:driveline:differential unit
Summary:
Some vehicles equipped with 2.5l engine and cd4e transmission may exhibit a driveline rattle or clunking type noise during tip-in or transmission gear engagement. *tt
Bulletin:
13454
Component:
180000 vehicle speed control
Summary:
Subject regarding the speed control switch voltage readings - service tip. *tt
Bulletin:
4624
Component:
980000 unknown or other
Summary:
Brief information regarding vehicles with malfunction indicator light on with diagnostic trouble code p0171 set. *tt
Bulletin:
99-8-15
Component:
162300 structure:body:door
Summary:
Subject regarding door trim panel replacement - service tip. *tt
Bulletin:
99111
Component:
980000 unknown or other
Summary:
Information designed to aid in the diagnosis, testing and repair of noise, vibration and harshness (nvh) concerns. *tt
Bulletin:
991210
Component:
980000 unknown or other
Summary:
Ford motor company has released a private labeled material to be used for iron particle / acid rain service repairs. *tt
Bulletin:
99152
Component:
103000 power train:automatic transmission
Summary:
Information on the new flush and fill tool available through rotunda. *tt
Bulletin:
4700
Component:
980000 unknown or other
Summary:
Some vehicles may run rough and display an illuminated malfunction indicator lamp after recall 97e61 is performed. *tt
Bulletin:
4702
Component:
980000 unknown or other
Summary:
Som e vehicles may illuminate the malfunction indicator lamp on or run rough after recall 97e61 is performed. * tt
Bulletin:
11808
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Some vehicles may run rough and display an illuminated malfunction indicator light on after recall 97e61 is performed. *tt
Bulletin:
11810
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Some vehicles may illuminate the malfunction indicator light on or run rough after recall 97e61 is performed. *tt
Bulletin:
5203
Component:
185000 vehicle speed control:cruise control
Summary:
Some vehicles may exhibit a hard start / long crank, cold start stall, cold rough idle concern. *tt
Bulletin:
5306
Component:
980000 unknown or other
Summary:
Some vehicles maye xhibit exhibit a malfunction indicator lamp illuminated with diagnostic trouble code p0171 and p0172 stored in memory. *tt
Bulletin:
980309
Component:
116000 electrical system:ignition
Summary:
Stall on cold start when cold. *ak
Bulletin:
14490
Component:
980000 unknown or other
Summary:
Some vehicles equipped with 2.5l duratec (24v) engine may exhibit diagnostic trouble code p0420 and / or p0430. *tt
Bulletin:
00M13
Component:
062200 engine and engine cooling:cooling system:fan
Summary:
Owner notification program regarding additonal coverage for the engine cooling fan. *tt
Bulletin:
00S03
Component:
034000 service brakes, hydraulic:foundation components
Summary:
Safety recall pertaining to brake pressure control reducing valve replacement. *jb
Bulletin:
00182
Component:
106000 power train:axle assembly
Summary:
Some vehicles may exhibit no forward gear ranges due to the misalignment of the forward / coast clutch cylinder snap ring with respect to the legs of the forward clutch piston. *jb
Bulletin:
14375
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Some vehicles equipped with a 2.5l duratec engine may exhibit an engine overheat condition due to lack of circulation of coolant. *jb
Bulletin:
0147
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Subject regarding engine oil recommendations for use in 2001 vehicles - sae 5w-20 motor oil. *tt
Bulletin:
14775
Component:
121300 exterior lighting:headlights:high/low beam dimmer switch
Summary:
Some vehicles equipped with daytime running lamps (drl) may exhibit the high beam indicator in the instrument cluster flashing when the daytime running lamps are on. *tt
Bulletin:
15065
Component:
138000 visibility:defroster/defogger system
Summary:
Some vehicles may exhibit a/c discharge air temperatures differences of greater than 10 degrees f from registers on left side of dash than on right. *tt
Bulletin:
01156
Component:
138120 visibility:defroster/defogger system:windshield:heater core
Summary:
Some vehicles may exhibit heater core leaks. *slc
Bulletin:
01157
Component:
980000 unknown or other
Summary:
Information regarding transmission fluid usage charts. *slc
Bulletin:
01M07
Component:
138130 visibility:defroster/defogger system:windshield:controls/wiring
Summary:
Some vehicles may experience a loss of function with the heater blower motor switch in one or more switch positions. *slc
Bulletin:
01181
Component:
103800 power train:automatic transmission:park/neutral start switch
Summary:
Brake shift interlock.*jb
Bulletin:
15241
Component:
021600 suspension:front:wheel bearing
Summary:
Some vehicles may exhibit a noise that appears to come from the front wheel bearings. *tt
Bulletin:
0214
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Some engine assemblies with aluminum cylinder heads repaired in-vehile have been found to leak coolant and/or oil from the cylinder head gasket area. *tt
Bulletin:
15241
Component:
021600 suspension:front:wheel bearing
Summary:
Some vehicles may exhibit a noise that appears to come from the front wheel bearings. *tt
Bulletin:
15390
Component:
063130 engine and engine cooling:exhaust system:emission control:gas recirculation valve (egr valve)
Summary:
Some vehicles may exhibit a check engine light and/or egr diagnostic trouble codes 332, p0401, p1407 (lackof egr flow). *tt
Bulletin:
01246
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Engine oil system priming procedures, service tips for reports of premature engine failure. *tt
Bulletin:
0224
Component:
106000 power train:axle assembly
Summary:
Some vehicles equipped with the cd4e transaxle may exhibit harsh and delayed 1-2/2-3 upshifts after transaxle or turbine shaft speed sensor replacement, possible diagnostic trouble codes 628, 642, 645, 646, 647, 648, p0731, p0732, p0734, p0
Bulletin:
15636
Component:
120000 exterior lighting
Summary:
Concern with headlamps and/or instrument panel lamps dimming slightly at idle. *tt
Bulletin:
15894
Component:
103000 power train:automatic transmission
Summary:
Subject regarding automatic shifter assembly or the indicator housing replacement. *tt
Bulletin:
16880
Component:
110000 electrical system
Summary:
Inoperative shift interlock solenoid or repeat instrument interface module failure. *tt
Bulletin:
03148
Component:
103600 power train:automatic transmission:cooling unit and lines
Summary:
New transmission cooler flusher - service tips. 2003 escort and super duty f series included. *tt
Bulletin:
03181
Component:
110000 electrical system
Summary:
Remote keyless entry (rke) - service tips. *tt
Bulletin:
02176
Component:
032100 service brakes, hydraulic:switches:brake light
Summary:
Lamp-brake-invadvertent disabling of brake shift interlock. *mj
Bulletin:
02208
Component:
353600 equipment:air conditioner
Summary:
Climate control a/c service tech tips. *eh
Bulletin:
022001
Component:
353000 equipment:electrical
Summary:
Replacement speaker installation tips. *tt
Bulletin:
9903
Component:
114100 electrical system:wiring:front underhood
Summary:
Under hood wire harness. additional 10 years or 100,000 miles. ford. *kb

Home | Privacy