1996 FORD TAURUS Recalls (8)

Campaign:
96V016000 on 01/29/1996
Component:
Service brakes, hydraulic:switches:brake warning
Manufactured:
05/31/1995 - 08/31/1995
Affected:
76,500
Defect:
The brake system fluid level indicator lamp switch can malfunction. this does not comply with fmvss no. 105, "hydraulic brake systems."
Consequence:
Consequence of non-compliance: if the switch malfuntions, the brake system warning lamp will either remain illuminated continuously or fail to light as intended when the fluid level falls to a certain level. in either case, the vehicle operator would not be warned of a low brake fluid level condition.
Correction:
Dealers will replace the brake system fluid level indicator lamp switches.
Notes:
System: brakes; hydraulic; switch; brake warning; fmvss no. 105.vehicle description: passenger vehicles. note: owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time, should contact ford at 1-800-392-3673. also contact the national highway traffic safety administration's auto safety hotline at 1-800-424-9393.
Campaign:
96V086000 on 05/16/1996
Component:
Power train:automatic transmission
Manufactured:
06/30/1995 - 09/30/1995
Affected:
100,000
Defect:
The park pawl shaft was improperly positioned when the roll pin that retains it was installed during transmission assembly. if the shaft was not properly positioned, the roll pin may not have lined up with the groove in the shaft and have been crushed at assembly. also, a burr could have been raised on the shaft.
Consequence:
This could result in the park pawl occasionally not engaging when the transmission selector lever is placed in the park position. this could result in the vehicle rolling as if in neutral if the vehicle operator does not apply the parking brake.
Correction:
Dealers will inspect the park pawl shaft roll pin. if the roll pin is damaged, both the roll pin and the park pawl shaft will be replaced. in addition, owners will be reminded to fully apply the parking brake, in addition to placing the transmission in park.
Notes:
System: power train; transmission; automatic. vehicle description: passenger vehicles and mini-vans equipped with ford ax4s automatic transaxles. note: owner notification is expected to begin in mid-june 1996. note: owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time, should contact ford at 1-800-392-3673. also contact the national highway traffic safety administration's auto safety hotline at 1-800-424-9393.
Campaign:
96V151000 on 08/26/1996
Component:
Fuel system, gasoline:fuel injection system
Manufactured:
10/01/1995 - 07/18/1996
Affected:
4,700
Defect:
The fuel pressure regulator located on the fuel rail in the engine compartment has a vacuum diaphragm that was damaged during manufacture of the regulator.
Consequence:
If the diaphragm tears or ruptures, liquid fuel could enter the intake manifold plenum through the vacuum line resulting in either release of fuel from the air cleaner assembly or the exhaust system. fuel release in the presence of an ignition source could potentially result in a fire.
Correction:
Dealers will inspect the fuel pressure regulator. those regulators produced during the suspect time period will be replaced.
Notes:
Owner notification:owner notification is expected to begin september 9, 1996. note:owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time, should contact ford at 1-800-392-3673.also contact the national highway traffic safety administration's auto safety hotline at 1-800-424-9393.
Campaign:
96V166000 on 09/22/1996
Component:
Power train:automatic transmission:gear position indication (prndl)
Manufactured:
07/31/1996 - 08/27/1996
Affected:
40,000
Defect:
The park pawl abutment bracket has a sharp edge which can cause the parking pawl to hang up and not engage the park gear. this would allow the vehicle to move even though the gear shift indicator shows that the vehicle is in park.
Consequence:
Unintended and unexpected vehicle movement can result in personal injury and property damage.
Correction:
Dealers will inspect and, if necessary, replace the park pawl abutment bracket.
Notes:
Owner notification:owner notification is expected to begin september 23, 1996.note:owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact ford at 1-800-392-3673.also contact the national highway traffic safety administration's auto safety hotline at 1-800-424-9393.
Campaign:
96V176000 on 09/25/1996
Component:
Power train:automatic transmission
Manufactured:
04/06/1995 - 08/15/1996
Affected:
340,000
Defect:
The automatic transmission park pawl shaft may not be free to rotate as intended. if the park pawl shaft does not rotate, it would prevent the park pawl from engaging the park gear when the shift lever is in the park position.
Consequence:
This condition could result in the vehicle rolling as if in neutral with the shift lever in the park position.
Correction:
Dealers will inspect the park pawl shaft rotation and those shafts with restricted rotation will be replaced with a shorter shaft that will not restrict rotation.
Notes:
Owner notification:owner notification is expected to being september 30, 1996. note:owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact ford at 1-800-392-3673.also contact the national highway traffic safety administration's auto safety hotline at 1-800-424-9393.
Campaign:
98V067000 on 03/26/1998
Component:
Fuel system, gasoline:storage:tank assembly
Affected:
400
Defect:
Vehicle description: passenger vehicles previously serviced under ford service bulletin 97-17-9 from august 1997 through december 1997. these vehicles were inadvertenly equipped with an 18-gallon fuel tank rather than the 16-gallon as specified. the 18-gallon tank has a second valve location where a shipping plug should be installed.
Consequence:
If this shipping plug is displaced, fuel leakage can result. fuel leakage in the presence of an ignition source could potentially result in a fire.
Correction:
Dealers will install the correct fuel tank.
Notes:
Owner notification began june 17, 1998.owners who take their vehicles to an authorized dealer on an agreed upon service date and do not not receive the free remedy within a reasonable time should contact ford at 1-800-392-3673.also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
Campaign:
06E026000 on 03/22/2006
Component:
Exterior lighting
Affected:
61,944
Defect:
Certain pro-a motors corner lamps, turn signals, and headlights sold as replacement lamps for use on certain passenger vehicles listed above. some combination lamps that are not equipped with amber side reflectors fail to conform to federal motor vehicle safety standard no. 108, lamps, reflective devices, and associated equipment.
Consequence:
Without the amber reflectors, the vehicle will be poorly illuminated, possibly resulting in a vehicle crash without warning.
Correction:
Pro-a motors will notify owners and offer to repurchase the lamps. the recall began on april 3, 2006. owners may contact pro-a motors at 323-838-2988.
Notes:
This recall only pertains to pro-a motors aftermarket lamps and has no relation to any original equipment installed on the listed passenger vehicles.for more information on the lamp model numbers, click on document search and view document titled "lamp model numbers."customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov.
Campaign:
09E012000 on 04/06/2009
Component:
Exterior lighting
Affected:
16,270
Defect:
Sabersport is recalling 16,270 combination corner and bumper lamp assemblies of various part numbers sold for use as aftermarket equipment for various passenger vehicles. these headlamps fail to conform to the requirements of federal motor vehicle safety standard no. 108, "lamps, reflective devices, and associated equipment." these lamps do not contain the required amber side reflectors.
Consequence:
Decreased lighting visibility may result in a vehicle crash.
Correction:
Sabersport will notify owners and offer a full refund for the noncompliant combination lamps. the safety recall began on may 11, 2009. owners may contact sabersport at 1-909-598-7589.
Notes:
This recall only pertains to aftermarket replacement equipment and has no relation to any original equipment installed on vehicles produced by the vehicle manufacturer.in order to determine if your aftermarket lamp assembly is affected by this noncompliance, please review the list of model numbers provided to us by sabersport.the list can be found under "document search" located at the bottom of your screen.owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to <a href=http://www.safercar.gov>http://www.safercar.gov</a> .

1996 FORD TAURUS TSBs (281)

Bulletin:
DNP95B74
Component:
063000 engine and engine cooling:exhaust system
Summary:
announcement of delivery hold and dealer notification program 95b74 for 1996 model taurus and sable cars equipped with 3.0l engines having calibration codes 6-10a-ro7 and 6-10s-ro7 (all 2v 3.0l engines) built at the atlanta assembly plant
Bulletin:
95154
Component:
353400 equipment:electrical:radio/tape deck/cd etc.
Summary:
equipment - rotunda - new for servicing 1996 taurus/sable. *sd
Bulletin:
BC0091960102
Component:
103000 power train:automatic transmission
Summary:
for concerns of loss of radio sound, power windows & lock functions & increased p/s effort when trans is shifted into reverse or drive, perform proper diagnostics for these concerns. if no solution is found the cause of these concerns may
Bulletin:
BC0111960102
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
revised r10 calibration is available for random stalls, no starts, performance complaints & codes 1358, 1475, & 1479. parts limited but pcm can be revised w/ sbds. tsb to be issued soon.
Bulletin:
BC0234960102
Component:
162000 structure:body
Summary:
correct adhesive for the headliner is wsb-m2g355-a a tsb is forthcoming for a new headliner for early built units. will include more push pins.
Bulletin:
BC0236960102
Component:
072000 fuel system, gasoline:delivery
Summary:
hard/no start condition after extended soak on steep incline, may be caused by fuel delivery module (9a407). there is no service action at this time. engineering is investigating improvements to fuel system.
Bulletin:
BC0244960102
Component:
185000 vehicle speed control:cruise control
Summary:
3.0l, ax4s/ax4n transaxle, trans engagements from park to reverse or drive may be harsh after start up from engine high idle speed as high idle speed as high as 1400 prm after start up & require upto 2 minutes to return to normal idle (700
Bulletin:
95199
Component:
103000 power train:automatic transmission
Summary:
the ax4s transaxles contain elastomeric gaskets for the main control cover and the bottom pan. these new gaskets replace the cork-style gaskets. the elastomeric gasket has improved duability and sealing capability and is reusable.
Bulletin:
95212
Component:
036000 service brakes, hydraulic:antilock
Summary:
the use of petroleum-based grease as a lubricant in servicing disc brakes is no longer acceptable because it may be incompatible with the rubber material used in the disc brake system. if petroleum-based grease is used to lubricate any par
Bulletin:
BC0685961024
Component:
103000 power train:automatic transmission
Summary:
Procedure for stalling on decel & misfire codes when updating the calibration from r-11 to r-12. *tt
Bulletin:
BC0700961022
Component:
063000 engine and engine cooling:exhaust system
Summary:
Vehicles exhibiting lean codes p0171 & p0174 (vacuum leak). note: low fuel pressure/delivery can also set these codes. *tt
Bulletin:
BC0713961021
Component:
070000 fuel system, gasoline
Summary:
Concerns of a surge (powertrain shuffle) at 35-40 mph. *tt
Bulletin:
BC0762961016
Component:
034530 service brakes, hydraulic:foundation components:disc:rotor
Summary:
Repetitive thumping/knocking noise proportional to wheel speed when braking. *tt
Bulletin:
BC0776961015
Component:
140000 air bags
Summary:
Air bag test results directs tech to b1977-4, which is incorrect. it should direct tech to b1937-4. *tt
Bulletin:
BC0850961007
Component:
114300 electrical system:wiring: rear compartment/trunk
Summary:
Concerns of vehicle stall, hesitation stumble, rough idle, missing, fuel pressure, or fuel pressure related check the rear ground. *tt
Bulletin:
BC0851961007
Component:
020000 suspension
Summary:
Procedure for concerns of ride quality. *tt
Bulletin:
BC5191961001
Component:
103000 power train:automatic transmission
Summary:
For concerns of stalling, reflash pcm w/ 1996 calibration (r11 level). *tt
Bulletin:
BC5195961001
Component:
190000 tires
Summary:
Firestone p235 tires may exhibit a high frequency vibration at 65-75 mph. *tt
Bulletin:
BC9584961001
Component:
015000 steering:hydraulic power assist system
Summary:
Information for concerns of grunt or groan during wheel return from full right turn. *tt
Bulletin:
BC9683961001
Component:
103000 power train:automatic transmission
Summary:
Procedure for updating the calibration from r-11 to r-12 for stalling on decel & misfire codes on 3.0l vehicles. *tt
Bulletin:
BC0307961101
Component:
015000 steering:hydraulic power assist system
Summary:
Groan noise from power steering. *tw
Bulletin:
BC0308961101
Component:
021000 suspension:front
Summary:
Thump/clunk noise from front suspension area. *tw
Bulletin:
BC0309961101
Component:
072000 fuel system, gasoline:delivery
Summary:
Surge at steady state cruise (power train shuffel). *tw
Bulletin:
BC0313961101
Component:
116200 electrical system:ignition:module
Summary:
Check engine light, code p030x, with no driveability complaint. *tw
Bulletin:
BC0464961115
Component:
162300 structure:body:door
Summary:
Concerns of taurus/sable front door handles that have high efforts and/or feel rough when operating. *tw
Bulletin:
BC0504961111
Component:
114000 electrical system:wiring
Summary:
Repeat fuse failure, concerns of inoperative speed control and/or air conditioning. *tw
Bulletin:
BC0535961108
Component:
980000 unknown or other
Summary:
The egr tube torque specifications in service manual are incorrect. *tw
Bulletin:
BC0542961107
Component:
103300 power train:automatic transmission:gear position indication (prndl)
Summary:
Instructions on performing the inspection during recall 96s51. *tw
Bulletin:
96241
Component:
980000 unknown or other
Summary:
Interior trim - headliner sag in rear - vehicles built through 11/15/95. *tw
Bulletin:
96246
Component:
114000 electrical system:wiring
Summary:
Wiring - electrical diode identification and service replacements. *tw
Bulletin:
96249
Component:
103700 power train:automatic transmission:torque converter
Summary:
Torque converter - leak test procedure - service tip. *tw
Bulletin:
96221
Component:
131000 visibility:windshield
Summary:
Windshield and interior glass - fog/film. *tw
Bulletin:
96222
Component:
034000 service brakes, hydraulic:foundation components
Summary:
Brakes - elimination of sanding rotors and drums - service tip. *tw
Bulletin:
96223
Component:
185000 vehicle speed control:cruise control
Summary:
Long crank - sticking idle air control (iac) valve - vehicles built from 11/1/94 through 3/30/96 -stall - after starting when engine allowed to soak from 1-4 hours - sticking idle air control (iac) valve. *tw
Bulletin:
96224
Component:
116200 electrical system:ignition:module
Summary:
Malfunction indicator lamp (mil) illuminated - diagnostic trouble code (dtc) p0176 - 3.0l flexible fuel vehicles using ethanol/methanol (e85/m85) and/or gasoline - vehicles built through 8/16/96. *tw
Bulletin:
96225
Component:
075000 fuel system, gasoline:carburetor system
Summary:
Mass air flow sensor - replacement as an assembly - service tip. *tw
Bulletin:
96251
Component:
162300 structure:body:door
Summary:
Door handles - outside - high efforts and/or rough feeling while operating - vehicles equipped with illuminated entry built through 8/5/96. *tw
Bulletin:
96252
Component:
171100 latches/locks/linkages:doors:latch
Summary:
Locks - replace and/or repair any lock component - service tip. *tw
Bulletin:
96255
Component:
015000 steering:hydraulic power assist system
Summary:
Steering - continuous reduction in power steering assist when shifting into reverse or drive - vehicles with 3.0l engine. *tw
Bulletin:
962510
Component:
116200 electrical system:ignition:module
Summary:
Malfunction indicator lamp (mil) - diagnostic trouble codes (dtcs) p0300, p0301, p0302, p0303, p0304, p0305, p0306, p0307 and/or p0308 stored in memory. *tw
Bulletin:
962511
Component:
116200 electrical system:ignition:module
Summary:
Powertrain control module -reprogram powertrain control module (pcm) - service procedures - service tip. *tw
Bulletin:
962515
Component:
161000 structure:frame and members
Summary:
Noise-"creaking" in a-pillar when going over bumps and/or turning-vehicles built through 12/31/96. *jd
Bulletin:
96263
Component:
022000 suspension:rear
Summary:
Suspension - rear - availability of camber kit to improve inner edge wear on rear tires. *tw
Bulletin:
96265
Component:
116200 electrical system:ignition:module
Summary:
Malfunction indicator lamp (mil) - diagnostic trouble codes (dtcs) p0300, p0301, p0302, p0303, p0304, p0305, p0306, p0307, and/or p0308 stored in memory. *tw
Bulletin:
96266
Component:
110000 electrical system
Summary:
Relay - relay-equipped subsystems diagnostic procedures - service tip. *tw
Bulletin:
96267
Component:
353600 equipment:air conditioner
Summary:
Air conditioning - vf2 a/c compressor - service information - 3.0l 2valve taurus gl vehicles built through 4/97. *tw
Bulletin:
962612
Component:
103700 power train:automatic transmission:torque converter
Summary:
Transaxle - torque converter replacement guidelines and torque converter/transaxle cooling system cleaning procedures - service tip. *tw
Bulletin:
962613
Component:
103000 power train:automatic transmission
Summary:
Transaxle - ax4s - extended 2-3 shift and/or higher than expected engine rpm during 2-3 shift at light to medium throttle and/or no 2-3 shift - vehicles equipped with 3.0l engine - service tip. *tw
Bulletin:
BC0011970201
Component:
103000 power train:automatic transmission
Summary:
A buzz noise in ax4s transaxles on 1996/97 taurus/sable and windstars. *jd
Bulletin:
BC0042970201
Component:
116200 electrical system:ignition:module
Summary:
For 1996 3.ol 2-valve vehicles stop updating the processor to the r-12 calibration. *jd
Bulletin:
BC0130970201
Component:
021210 suspension:front:springs:coil springs
Summary:
removing or replacing one of the front strut springs on a 1996/97 taurus or sable vehicle use rotunda #014-00781 strut spring compressor master set. *jd
Bulletin:
BC0144970201
Component:
034000 service brakes, hydraulic:foundation components
Summary:
Residual brake pressure on the rear brakes of a 1996-1997 taurus or sable, make sure to support the rear control arms to remain at the normal ride height position. if the rear contral arm on the drivers side is allowed to hang all the way d
Bulletin:
BC0151970201
Component:
116200 electrical system:ignition:module
Summary:
Exhibithing a hesitation/stumble. this applies to calibratrions. *jd
Bulletin:
BC0152970201
Component:
162310 structure:body:door:hinge and attachments
Summary:
Water leak in the rear of a taurus or sable wagon, check for water entering in at the rear hatch hinges. *jd
Bulletin:
BC0180970201
Component:
061000 engine and engine cooling:engine
Summary:
The crankshaft damper bolt, found underneath the pulley has a standard right and left hand thread. to avoid damage to plastic, avoid using heat. *jd
Bulletin:
BC0196970201
Component:
072100 fuel system, gasoline:delivery:fuel pump
Summary:
Noisy fuel pumps on 1996/1997 taurus/sable vehicles. revised fuel pump to aleviate noise. *jd
Bulletin:
BC0251970201
Component:
036400 service brakes, hydraulic:antilock:abs warning light
Summary:
Abs indicator illumination with dtc c1095. *jd
Bulletin:
BC0252970201
Component:
062000 engine and engine cooling:cooling system
Summary:
Uneven idle rpm, stall, rough running, surge, and/or spark knock when the cooling fans come on at a idle. *jd
Bulletin:
BC0307970201
Component:
014000 steering:rack and pinion
Summary:
Groan noise from power steering. *jd
Bulletin:
BC0308970201
Component:
021000 suspension:front
Summary:
Thump/clunk noise from front suspension area. *jd
Bulletin:
BC1010197020
Component:
072100 fuel system, gasoline:delivery:fuel pump
Summary:
Noisy fuel pumps on 1996/97 vehicles. a revised fuel pump has been released with a modified manifold outlet to reduce noise. *jd
Bulletin:
BC1010297020
Component:
061000 engine and engine cooling:engine
Summary:
Engines are equipped with a unique crankshaft pulley assembly which threads into the crankshaft damper using a left-handed thread. heating the crankshaft pulley will damage the rubber components. *jd
Bulletin:
BC1011397020
Component:
116200 electrical system:ignition:module
Summary:
Vehicles exhibiting a hesitation/stumble- condition is noticeable at tip in and during a 4-2 downshift- new calibration. *jd
Bulletin:
BC101209702
Component:
103000 power train:automatic transmission
Summary:
Verify the transaxle installed in the vehicle is the correct model and model year for the vehicle. *jd
Bulletin:
BC1012397020
Component:
034000 service brakes, hydraulic:foundation components
Summary:
Residual brake presure on the rear brakes of a 1996-1997 vehicle, make sure to support the rear control arms to remain at the normal ride height position- support during lifting process. *jd
Bulletin:
BC1012497020
Component:
020000 suspension
Summary:
Removing or replacing one of the front strut spring on a vehicle us a rotunda #014-00781 strut spring compressor master set. *jd
Bulletin:
BC1013997010
Component:
353400 equipment:electrical:radio/tape deck/cd etc.
Summary:
May have no audio in cddj mode. *jd
Bulletin:
9713
Component:
013000 steering:gear box (other than rack and pinion)
Summary:
A "grunting" or "groaning" noise may occur as the steering wheel returns to its center position during a full right turn on some vehicles- this may be due to the steering gear valve sleeve creating a resonance through the steering system.
Bulletin:
9723
Component:
161000 structure:frame and members
Summary:
Frame - subframe insulators - clunk on heavy acceleration and/or deceleration heard or felt in floor pan area - vehicles built through 2/28/97. *tw
Bulletin:
9724
Component:
011000 steering:wheel and handle bar
Summary:
Steering - grunting or groaning noise during steering wheel return from full right turn - vehicles built through 11/8/96. *tw
Bulletin:
9725
Component:
021220 suspension:front:springs:torsion bar
Summary:
Suspension - clunking noise from front suspension - taurus sable built through 1/14/97 - continental built through 12/16/96. *tw
Bulletin:
BC0011972301
Component:
106000 power train:axle assembly
Summary:
Buzz noise in ax4s transaxles. *jd
Bulletin:
BC0042972301
Component:
103000 power train:automatic transmission
Summary:
For 1996 3.0l 2-valve vehicles stop updating the processor to the r-12 calibration. this update may cause the vehicle to stall on cold engagement. *jd
Bulletin:
BC0307972301
Component:
111000 electrical system:battery
Summary:
Battery goes dead- check the current draw with an ammeter. *jd
Bulletin:
BC0308972301
Component:
021100 suspension:front:stabilizer bar
Summary:
Thump/clunk noise from front suspension area. *jd
Bulletin:
BC0309972301
Component:
116000 electrical system:ignition
Summary:
Surge at steady cruise (power train shuffle), misfire codes, stalls at high ambient temperatures. *jd
Bulletin:
BC3410972301
Component:
160000 structure
Summary:
Water leak at the right front floor on vehicles, check for a broken cowl top inner panel shield. *jd
Bulletin:
BC3423971201
Component:
061000 engine and engine cooling:engine
Summary:
3.0l-2v vehicles built at the atlanta assembly plant from june, 1995 until january 3, 1996, that experience a misfire condition &/or noise from the front end accessory drive should have the c/s pulley inspected for correct installation. *j
Bulletin:
BC3482972301
Component:
021400 suspension:front:macpherson strut
Summary:
Replacing front rear struts on a vehicle, the replacement strut may appear to be appoximately 2" too short. *jd
Bulletin:
BC3502972301
Component:
980000 unknown or other
Summary:
When running pp test b1522-1, test says to install ngs and select pid hood sw- pid hood sw should read "closed" with the hood closed and "ajar" with the hood open. *jd
Bulletin:
BC1016397230
Component:
021000 suspension:front
Summary:
Buzz noise in ax4s transaxles at all speeds or idle on vehicles. *jd
Bulletin:
BC1018397230
Component:
162800 structure:body:hood
Summary:
When running pp test b1522-1, test says to install ngs and select pid hood sw. *jd
Bulletin:
BC1019697230
Component:
021400 suspension:front:macpherson strut
Summary:
Replacing front or rear struts on a 1996/97 vehicle, the replacement strut may appear to be approximately 2" too short when compared to the strut in the vehicle. *jd
Bulletin:
BC1021397230
Component:
061000 engine and engine cooling:engine
Summary:
1996 3.0l-2v efi vehicles built at the atlanta assembly plant from june, 1995 until january 3, 1996, that experience a misfire condition &/or noise from the front end accessory drive should have the c/s pulley inspected for correct installa
Bulletin:
BC1021497230
Component:
161000 structure:frame and members
Summary:
Water leak at the right front floor, check for a broken cowl top inner panel shield. *jd
Bulletin:
BC0291970201
Component:
121000 exterior lighting:headlights
Summary:
Headlamp adjustment instructions. *tw
Bulletin:
BC0307A97020
Component:
111000 electrical system:battery
Summary:
Battery oes dead overnight. *tw
Bulletin:
BC1024897230
Component:
162000 structure:body
Summary:
Some vehicles may exhibit a fluttering noise when in floor mode. *jd
Bulletin:
BC1025097230
Component:
116300 electrical system:ignition:anti-theft controller
Summary:
Passive anti-theft system. *jd
Bulletin:
BC0308A97020
Component:
021000 suspension:front
Summary:
Thump/klunk noise from front suspension area. *tw
Bulletin:
BC0309970201
Component:
116200 electrical system:ignition:module
Summary:
Surge at steady state cruise (power train shuffle), misfire codes,stalls at high ambient temperatures. *tw
Bulletin:
BC1026397230
Component:
116200 electrical system:ignition:module
Summary:
Update to ssm 10133 for hesitation/stumble of vehicles. *jd
Bulletin:
9735
Component:
353600 equipment:air conditioner
Summary:
Air conditioning- r-134a tracer dye installed in a/c system and three o-ring spring lock couplers- service tip. *jd
Bulletin:
BC3061970228
Component:
015000 steering:hydraulic power assist system
Summary:
Repeat power steering grunt/groan after completion of tsb 97-02-04. *tw
Bulletin:
BC3100970224
Component:
980000 unknown or other
Summary:
Micron filter - reminder that the filter must be changed every 15000 miles - symptoms that might indicate need for change include poor a/c-heater performance and/or window fogging. *tw
Bulletin:
BC1026397020
Component:
116200 electrical system:ignition:module
Summary:
Concern of surge between 35-45 mph. *jd
Bulletin:
BC1027697020
Component:
116200 electrical system:ignition:module
Summary:
This is an update to an existing oasis message for hessitation/stumble on vehicles. *jd
Bulletin:
BC3142970220
Component:
015000 steering:hydraulic power assist system
Summary:
Groan or moan noise from the power steering when returning from a right turn. *tw
Bulletin:
BC3144970220
Component:
980000 unknown or other
Summary:
Tsb 96-26-05 does not list calibrations 6-14s-r08, 6-14s-r10 and 6-14s-r11 as qualifiers for reprogramming the pcm - these are california calibrations. *tw
Bulletin:
BC3152970219
Component:
061110 engine and engine cooling:engine:gasoline:belts and associated pulleys
Summary:
Knock or whop noise from the engine compartment near the front of the engine. *tw
Bulletin:
BC1029897020
Component:
061110 engine and engine cooling:engine:gasoline:belts and associated pulleys
Summary:
Knock or wop noise from the engine compartment near the front of the engine. *jd
Bulletin:
BC1030697020
Component:
015000 steering:hydraulic power assist system
Summary:
Groan or moan noise from the power steering when returning from a right turn. *jd
Bulletin:
BC1032697020
Component:
138000 visibility:defroster/defogger system
Summary:
Vehicles have a cabin air filter that must be changed every 15000 miles. *jd
Bulletin:
BC3205970214
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Concern of water ingestion in engine. *tw
Bulletin:
BC3206970214
Component:
116200 electrical system:ignition:module
Summary:
Update calibration information to correct hesitation/stumble noticeable at tip in.
Bulletin:
BC3211970213
Component:
070000 fuel system, gasoline
Summary:
Diagnosis of mil code p0172, p0175, p1150 and p1152 or a stall on low speed decel or accel. *tw
Bulletin:
BC3216970213
Component:
116200 electrical system:ignition:module
Summary:
Stall on cold engagement. *tw
Bulletin:
BC3217970213
Component:
116200 electrical system:ignition:module
Summary:
Surge between 35-45 mph. *tw
Bulletin:
BC3271970207
Component:
138000 visibility:defroster/defogger system
Summary:
Vehicles may exhibit a fluttering noise, when in floor mode, due to the floor/defrost door separating from the mylar backing. *tw
Bulletin:
BC3272970207
Component:
116300 electrical system:ignition:anti-theft controller
Summary:
Vehicles are equipped with passive anti-theft system (pats) - vehicle will not start without the correct ignition key. *tw
Bulletin:
9771
Component:
061000 engine and engine cooling:engine
Summary:
Stall- stalling on transaxle engagement- cold engine- 3.0l 2-valve vehicles. *jd
Bulletin:
9772
Component:
061000 engine and engine cooling:engine
Summary:
Hesitation- on acceleration- vehicles with 3.0l 4-valve engine. *jd
Bulletin:
9751
Component:
220000 seats
Summary:
Interior- leather seat cleaning procedure- service tip. *jd
Bulletin:
97511
Component:
103000 power train:automatic transmission
Summary:
Fluid- transmission fluid usage charts. *jd
Bulletin:
9763
Component:
140000 air bags
Summary:
Steering- steering column- air bag sliding contact servicing- service tip. *jd
Bulletin:
9765
Component:
061000 engine and engine cooling:engine
Summary:
Hesitation- on acceleration- vehicles with 3.0l 4-valve engine. *jd
Bulletin:
9766
Component:
061000 engine and engine cooling:engine
Summary:
Stall- stalling on transaxle engagement- cold engine- 3.0l 2-valve vehicles. *jd
Bulletin:
9767
Component:
116200 electrical system:ignition:module
Summary:
Malfunction indicator lamp (mil)- diagnostic trouble codes (dtcs) p0172, p0175, p1130, p1150 and/or p1152 stored in memory and/or stall on low speed acceleration or deceleration- 3.4l sho vehicles only. *jd
Bulletin:
9768
Component:
980000 unknown or other
Summary:
Fuel economy- customer expectations versus vehicle usage. *jd
Bulletin:
97610
Component:
061000 engine and engine cooling:engine
Summary:
Blower motor- "chirping" or "squeaking" from blower motor at low speeds. *jd
Bulletin:
97613
Component:
116200 electrical system:ignition:module
Summary:
Transaxle- ax4s/ax4n- diagnostic trouble codes (dtcs) 628, p0741 and/or p1744 stored in memory after transaxle exchange. *jd
Bulletin:
ONP/96E59
Component:
071000 fuel system, gasoline:storage
Summary:
Emission recall 96e59 - fuel delivery module wiring connector seal and vapor vent assembly replacement - 1996 flex fuel vehicles. *tw
Bulletin:
BC2224970501
Component:
061110 engine and engine cooling:engine:gasoline:belts and associated pulleys
Summary:
Vehicles may experience a knock or wop noise in the passenger compartment. *tw
Bulletin:
BC2310970501
Component:
140000 air bags
Summary:
Deactivation procedure - clarification of instructions in service manual. *tw
Bulletin:
BC2311970501
Component:
022100 suspension:rear:springs
Summary:
Some vehicles may exhibit a clunking noise from the rear suspension when driving over bumps. *tw
Bulletin:
BC2380970501
Component:
103000 power train:automatic transmission
Summary:
Harsh 1-2 upshift. *tw
Bulletin:
BC105739705
Component:
141000 air bags:frontal
Summary:
When performing the air bag deactivation procedure, the service manuals do not clearly state which simulators to use on the passenger side air bag. *tw
Bulletin:
BC105959705
Component:
061110 engine and engine cooling:engine:gasoline:belts and associated pulleys
Summary:
Some vehicles may experience a knock or wop noise in the passenger compartment. *tw
Bulletin:
97010510636
Component:
072100 fuel system, gasoline:delivery:fuel pump
Summary:
Vehicles exhibiting hard/no start condition when vehicles parked for an extended period of time in a nose-up position. *yc
Bulletin:
97111097231
Component:
021000 suspension:front
Summary:
Diagnostic and inspection procedure for front suspension noise. *yc
Bulletin:
97111097234
Component:
113000 electrical system:starter assembly
Summary:
Vehicles exhibiting a "squeaking" or "chirping" from the blower motor at low blower motor speeds. *yc
Bulletin:
97111097237
Component:
100000 power train
Summary:
Concerns with harsh engagements and harsh shifts with diagnostic trouble codes (dtcs) 628, p0741 and/or p1744. *yc
Bulletin:
97090297181
Component:
061000 engine and engine cooling:engine
Summary:
Some vehicles during wet weather conditions and/or when driving through puddles and /or the crankshaft pulley may be damaged. *yc
Bulletin:
97090297184
Component:
353400 equipment:electrical:radio/tape deck/cd etc.
Summary:
Some vehicles may experience static in the am band of the radio while driving. *yc
Bulletin:
9802169837
Component:
105000 power train:driveline
Summary:
Some vehicles may experience an no forward or reverse movement. *yc
Bulletin:
9802169838
Component:
102000 power train:manual transmission
Summary:
Transaxles use a new transmission fluid. *yc
Bulletin:
985A5
Component:
034530 service brakes, hydraulic:foundation components:disc:rotor
Summary:
Hub-mount brake rotor machining equipment from rotunda is now approved for warranty and service use. *yc
Bulletin:
985A11
Component:
034000 service brakes, hydraulic:foundation components
Summary:
Service tip information regarding elimination of sanding rotors and drums. *yc
Bulletin:
985A13
Component:
034500 service brakes, hydraulic:foundation components:disc
Summary:
The use of petroleum-based grease as a lubricant in servicing disc brakes is no longer acceptable. *yc
Bulletin:
98B18
Component:
062000 engine and engine cooling:cooling system
Summary:
Owner notification program 98b18- cooling system by-pass kit installation. *ak
Bulletin:
9888
Component:
103000 power train:automatic transmission
Summary:
Information on a new transmission fluid usage chart. *yc
Bulletin:
9845
Component:
045300 service brakes, air:disc:rotor
Summary:
Availability of hub-mount brake rotor machining equipment. *yc
Bulletin:
9852
Component:
190000 tires
Summary:
Information on tire company telephone numbers for customer assistance. *yc
Bulletin:
9864
Component:
063000 engine and engine cooling:exhaust system
Summary:
Information on a buzzing or rattle noise from the exhaust system. *tt
Bulletin:
9865
Component:
103700 power train:automatic transmission:torque converter
Summary:
Torque converter clutch not engaging and/or diagnostic trouble code (dtc) p0741 or p1744 stored in memory. *yc
Bulletin:
9873
Component:
353400 equipment:electrical:radio/tape deck/cd etc.
Summary:
Experiencing a whining / buzzing noise in the speakers of the entertainment radio or two-way radio. *tt
Bulletin:
9874
Component:
061000 engine and engine cooling:engine
Summary:
A new silicone gasket and sealant. *yc
Bulletin:
980305
Component:
062000 engine and engine cooling:cooling system
Summary:
Vehicles experiencing coolant odor, coolant overflow, high or fluctuating temp gauge readings, blown or leaking hoses, blown head gasket, failed engine, and lack of heat. *yc
Bulletin:
980314
Component:
116200 electrical system:ignition:module
Summary:
Experiencing a hard start / long crank. *yc
Bulletin:
982523
Component:
061000 engine and engine cooling:engine
Summary:
Some engine valves may exhibit a customer concern of a moan noise at idle. *ak
Bulletin:
982675
Component:
106220 power train:axle assembly:axle shaft:seal
Summary:
A revised forward clutch inner seal for the axod, axode, ax4s & ax4n transaxle is available with improved sealing and reduced chance of the seal rolling during installation. *yc
Bulletin:
982742
Component:
010000 steering
Summary:
Some vehicles may exhibit a steering groan noise. *yc
Bulletin:
98251
Component:
072100 fuel system, gasoline:delivery:fuel pump
Summary:
Concerns of a possible chafing of the fuel pump assembly wires resulting in an open fuse and/or inoperable fuel pump assembly or a no start condition. *yc
Bulletin:
982513
Component:
133000 visibility:power window devices and controls
Summary:
Exhibiting an inoperative power window. *yc
Bulletin:
982514
Component:
061000 engine and engine cooling:engine
Summary:
Concerns with the timing arrows/flags on the back of the camshaft sprocket (s) are mis-marked by as much as 30 degrees rotation. *yc
Bulletin:
982112
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Some vehicles experience a hard start/long crank time condition. *yc
Bulletin:
982010
Component:
063000 engine and engine cooling:exhaust system
Summary:
Experiencing a " buzzing " or " rattling " noise from the exhaust system. *yc
Bulletin:
982310
Component:
063100 engine and engine cooling:exhaust system:emission control
Summary:
Mass air flow (maf)- sensor contamination- service tip. *ak
Bulletin:
982323
Component:
162000 structure:body
Summary:
Information regarding replacement and / or repairs on any lock component. *yc
Bulletin:
98241
Component:
012200 steering:column locking:anti-theft device
Summary:
Diagnostic service tips on passive anti theft system ( pats ). *yc
Bulletin:
98246
Component:
110000 electrical system
Summary:
Ford motor company has released a new electrical grease ( f8az - 19g208-aa ) to reduce the possibility of moisture corrosion at the terminals. *yc
Bulletin:
9941
Component:
015000 steering:hydraulic power assist system
Summary:
Experiencing a moaning noise from the power steering during engine idle. *tt
Bulletin:
9943
Component:
100000 power train
Summary:
Information regarding reprogramming powertrain control modules (pcms). *tt
Bulletin:
98B23S1
Component:
062000 engine and engine cooling:cooling system
Summary:
Installation of cooling system by-pass kit. *tt
Bulletin:
5518
Component:
061000 engine and engine cooling:engine
Summary:
Information on servicing oil pan gasket leaks. *tt
Bulletin:
5897
Component:
017500 steering:linkages:tie rod assembly
Summary:
Experiencing a squeaking and / or popping noise from the front outer tire rods. *tt
Bulletin:
12559
Component:
101100 power train:clutch assembly:pedal/linkage
Summary:
Concerns with reverse clutch that could become sheared or torn in extremely cold temperatures. *tt
Bulletin:
12616
Component:
103400 power train:automatic transmission:lever and linkage:column shift
Summary:
Information on transaxle service case replacement with oss (output shaft speed sensor) hole. *tt
Bulletin:
9814
Component:
034530 service brakes, hydraulic:foundation components:disc:rotor
Summary:
Subject regarding the availability of hub-mount brake rotor machining equipment. *tt
Bulletin:
98110
Component:
116300 electrical system:ignition:anti-theft controller
Summary:
Subject regarding passive anti theft system (pats) diagnostic service tips. *tt
Bulletin:
99816
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Ford motor company now recommends sae 5w-30 viscosity grade for servicing any ford gasoline-powered vehicle regardless of model year. *tt
Bulletin:
99127
Component:
980000 unknown or other
Summary:
Some vehicles may exhibit a malfunction indicator lamp (mil) with diagnostic trouble code (dtc) p1135 or p1155 stored in memory and / or a long crank / slow start. *tt
Bulletin:
99129
Component:
353400 equipment:electrical:radio/tape deck/cd etc.
Summary:
Experiencing a whine / buzz type noise in the speakers of the entertainment radio or two-way radio on vehicles with an in-tank electric fuel pump. *tt
Bulletin:
99139
Component:
125000 exterior lighting:brake lights
Summary:
Conditions with the brake lamps inadvertently disabling the brake shift interlock. *tt
Bulletin:
983112
Component:
103000 power train:automatic transmission
Summary:
Some vehicles may exhibit an intermittent neutral condition after driving and coming to a stop. *tt
Bulletin:
983221
Component:
180000 vehicle speed control
Summary:
Exhibiting a vibration at sppeds of 45 mph and above with the cruise on.
Bulletin:
983566
Component:
116300 electrical system:ignition:anti-theft controller
Summary:
Information regarding programming / diagnosing passive anti-theft system (pats) related issues. *tt
Bulletin:
983566
Component:
116300 electrical system:ignition:anti-theft controller
Summary:
Information on programming / diagnosing any passive anti-theft system (pats) related issues. *tt
Bulletin:
983496
Component:
162800 structure:body:hood
Summary:
Some vehicles may exhibit b1522 or gem "hood sw" pid concerns. *tt
Bulletin:
996735
Component:
106000 power train:axle assembly
Summary:
Some vehicles equipped with the ax4s transaxle may exhibit a harsh 3-2 downshift when coasting around a corner and then stepping into the throttle to accelerate away from the corner. *tt
Bulletin:
99222
Component:
114000 electrical system:wiring
Summary:
Subject on a wire harness terminal repair kit available for repairing electrical wiring harnesses. *tt
Bulletin:
99183
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Service tip information on revised oil pan gasket replacement procedure. *tt
Bulletin:
99184
Component:
106000 power train:axle assembly
Summary:
Some vehicles equipped with ax4s transaxle, may exhibit a harsh 2-3 downshift may occur when coasting around a corner and then accelerating. *tt
Bulletin:
99194
Component:
034000 service brakes, hydraulic:foundation components
Summary:
Information for servicing and diagnosing brake vibration, brake inspection, and brake friction material replacement. *tt
Bulletin:
99195
Component:
353600 equipment:air conditioner
Summary:
Service information for musty and mildew type odors coming from the air conditioning / heating system. *tt
Bulletin:
99196
Component:
353600 equipment:air conditioner
Summary:
Information on identifying non-approved / alternate refrigerants which could cause safety, and performance concerns if installed in ford a/c systems. *tt
Bulletin:
99242
Component:
162300 structure:body:door
Summary:
Information on replacing and / or repairing malfunctioning (door, ignition and decklid) locks. *tt
Bulletin:
6997
Component:
061000 engine and engine cooling:engine
Summary:
Some service manuals may list the incorrect camshaft position sensor alignment tool for vehicles with various engine sizes. *tt
Bulletin:
13180
Component:
061000 engine and engine cooling:engine
Summary:
Information regarding camshaft position (cmp) sensor alignment tool chart. *mjs
Bulletin:
13250
Component:
180000 vehicle speed control
Summary:
Information regarding slight vibration upon acceleration. *mjs
Bulletin:
98163
Component:
162300 structure:body:door
Summary:
Locks failed. yd
Bulletin:
98B23
Component:
062000 engine and engine cooling:cooling system
Summary:
The owner notification program 98b23 contained incorrect labor allowance and coolant part number information
Bulletin:
98B27
Component:
062000 engine and engine cooling:cooling system
Summary:
Coolant by-pass kit replacement on certain taurus vehicles. engines previously repaired with 98b18 service by-pass kit.
Bulletin:
98B26
Component:
061000 engine and engine cooling:engine
Summary:
Cooling system by-pass kit installation on certain taurus vehicles equipped with 3.0l vulcan methanol engines. gasoline or ethanol engines are covered by owner notification program 98b23.*ak
Bulletin:
0015
Component:
103000 power train:automatic transmission
Summary:
Information regarding the new transmission cooler flusher- service tip. *mjs
Bulletin:
7855
Component:
980000 unknown or other
Summary:
Vehicles may exhibit intermittent instrument control panel (icp) illumination.
Bulletin:
8199
Component:
021100 suspension:front:stabilizer bar
Summary:
Some vehicles may exhibit a rattling or clunking noise from the front end (front stabilizer link) under normal driving conditions.
Bulletin:
8016
Component:
980000 unknown or other
Summary:
Some vehicles may exhibit an intermittent loss of instrument control panel (icp).
Bulletin:
8316
Component:
353400 equipment:electrical:radio/tape deck/cd etc.
Summary:
Some vehicles equipped with compact disc changer may exhibit a 6 disc cd changer that is not ejecting the magazine or is not responding to command from the radio.
Bulletin:
13802
Component:
980000 unknown or other
Summary:
Some vehicles may exhibit an intermittent loss of instrument control panel (icp) illumination. *mjs
Bulletin:
984984
Component:
061000 engine and engine cooling:engine
Summary:
Some vehicles equipped with 3.0l 2-valve engines may exhibit a spark knock concern on acceleration. *tt
Bulletin:
984986
Component:
103700 power train:automatic transmission:torque converter
Summary:
Exhibiting a higher than expected engine rpm (flare) and harsh bump on the 3-2 torque demand down shift at light throttle (tip in) 16-24 km/h (10-15 mph). *tt
Bulletin:
12079
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Vehicles may exhibit a buzz or rattle condition on a cold start or during a low rpm stead speed. *mjs
Bulletin:
5048
Component:
060000 engine and engine cooling
Summary:
Repeat message regarding contaminated / corroded coolant, high or fluctuating temp gauge; coolant odor, coolant overflow, blown or leaking hoses, blown head gasket, failed engine, lack of heat. *tt
Bulletin:
12154
Component:
116300 electrical system:ignition:anti-theft controller
Summary:
Some vehicles equipped with pats (securilock) except certain models now have availability of fleet keys through rotunda. *mjs
Bulletin:
12163
Component:
180000 vehicle speed control
Summary:
Some vehicles may exhibit a slight vibration during acceleration only. *mjs
Bulletin:
12169
Component:
103100 power train:automatic transmission:control module (tcm, pcm)
Summary:
Some vehicles may exhibit a ngs error message after ngs/sbts pcm reprogramming. *mjs
Bulletin:
985065
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Repeat message regarding hard start / long crank condition. *tt
Bulletin:
985083
Component:
063140 engine and engine cooling:exhaust system:emission control:catalytic convertor
Summary:
Some vehicles (3.0l 4 valve only) may exhibit a catalytic converter buzz or rattle condition on a cold start or during a low rpm steady speed. *tt
Bulletin:
12174
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Some vehicles may exhibit a hard start/long crank, cold start stall, cold rough idle concern. *mjs
Bulletin:
12178
Component:
100000 power train
Summary:
Information regarding tsb 98-5a-12 (transaxle/transmission/transfer case-vehicles towed behind recreational vehicles-recommended guidelines) does not list towing information for certain model vehicles. *mjs
Bulletin:
12189
Component:
072100 fuel system, gasoline:delivery:fuel pump
Summary:
Information on installation a new fuel pump , ensure that the pump has plastic sheathing over the wires. *mjs
Bulletin:
9676
Component:
980000 unknown or other
Summary:
A condition may exist where the malfunction indicator lamp (mil) may illuminate and code 0446 may be stored in memory. *tt
Bulletin:
9678
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Concerns with the right side engine block drain plug hole and plug is oversized. *tt
Bulletin:
9811481
Component:
061000 engine and engine cooling:engine
Summary:
Some vehicles equipped with 3.0l 4-valve engines may exhibit a customer concern of a moan noise at idle. *tt
Bulletin:
8016
Component:
114200 electrical system:wiring:interior/under dash
Summary:
Some vehicles may exhibit an intermittent loss of integrated control panel (icp) illumination. **mr**
Bulletin:
8583
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Some vehicles may exhibit dtc p1518 and / or p1519, related to intake manifold runner control (imrc). *mr
Bulletin:
14087
Component:
075000 fuel system, gasoline:carburetor system
Summary:
Some vehicles may exhibit diagnostic trouble code p1518 and/or p1519, related to intake manifold runner control (imrc). **mr
Bulletin:
11530
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
When diagnosing crank / no start on certain vehicles equipped with passive anti-theft (pats) check the customers key ring for any magnetic objects like the mobile speedpass key which may affect the signal transmission between the pats key a
Bulletin:
98-4724
Component:
062000 engine and engine cooling:cooling system
Summary:
Contaminated/corroded coolant, high or fluctuating temperature gauge. *ak
Bulletin:
98-4731
Component:
021000 suspension:front
Summary:
Clunk or plop coming from front end. *ak
Bulletin:
98-4735
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Hard start/long crank.
Bulletin:
98-4737
Component:
180000 vehicle speed control
Summary:
Engine spark knock on acceleration. *ak
Bulletin:
98-4741
Component:
071100 fuel system, gasoline:storage:tank assembly
Summary:
Fuel gauge accuracy or fuel gauge erratic operation. *ak
Bulletin:
12570
Component:
017500 steering:linkages:tie rod assembly
Summary:
Some vehicles may exhibit front outer tie rods squeak and / or pop noise over bumps and / or turning. *tt
Bulletin:
985A6
Component:
036000 service brakes, hydraulic:antilock
Summary:
Some vehicles may cycle when brakes are applied on rough roads or on an incline while making a sharp turn. *yc
Bulletin:
4621
Component:
060000 engine and engine cooling
Summary:
Some vehicles may exhibit contaminated / corroded coolant, high or fluctuating temp gauge, coolant odor, coolant overflow, blown or leaking hoses, blown head gasket, failed engine, lack of heat. *tt
Bulletin:
4630
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Subject regarding general stalling concerns. *tt
Bulletin:
4636
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Diagnosing hard start / long crank condition. *tt
Bulletin:
4655
Component:
353600 equipment:air conditioner
Summary:
Information on the service evaporator assemblies. *tt
Bulletin:
99-8-15
Component:
162300 structure:body:door
Summary:
Subject regarding door trim panel replacement - service tip. *tt
Bulletin:
99111
Component:
980000 unknown or other
Summary:
Information designed to aid in the diagnosis, testing and repair of noise, vibration and harshness (nvh) concerns. *tt
Bulletin:
991210
Component:
980000 unknown or other
Summary:
Ford motor company has released a private labeled material to be used for iron particle / acid rain service repairs. *tt
Bulletin:
99152
Component:
103000 power train:automatic transmission
Summary:
Information on the new flush and fill tool available through rotunda. *tt
Bulletin:
4675
Component:
070000 fuel system, gasoline
Summary:
Some vehicles may exhibit a hard / no start concern when parked in a steep nose-up position with less than 1/4 tank of fuel and for an extended period of time. *tt
Bulletin:
4707
Component:
106000 power train:axle assembly
Summary:
Some vehicles with ax4s transaxles may exhibit a concern of increased engine rpm and bump on the 3-2 torque demand down shift at light throttle (tip-in) between 10-15 mph. *tt
Bulletin:
11773
Component:
353600 equipment:air conditioner
Summary:
Subject regarding service evaporator assemblies. *tt
Bulletin:
11792
Component:
071100 fuel system, gasoline:storage:tank assembly
Summary:
Some vehicles may exhibit a hard / no start concern when parked in a steep nose-up position with less than 1/4 tank of fuel and for an extended period of time. *tt
Bulletin:
11815
Component:
103100 power train:automatic transmission:control module (tcm, pcm)
Summary:
Some vehicles with ax4s transaxles may exhibit a concern of increased engine rpm and bump on the 3-2 torque demand down shift at light throttle (tip-in) between 10-15 mph. *tt
Bulletin:
5203
Component:
185000 vehicle speed control:cruise control
Summary:
Some vehicles may exhibit a hard start / long crank, cold start stall, cold rough idle concern. *tt
Bulletin:
5205
Component:
103100 power train:automatic transmission:control module (tcm, pcm)
Summary:
Some vehicles may exhibit a ngs error message, total checksum error after ngs / sbts pcm reprogramming. *tt
Bulletin:
5226
Component:
072100 fuel system, gasoline:delivery:fuel pump
Summary:
Information on installing a new fuel pump on certain vehicles. *tt
Bulletin:
5255
Component:
060000 engine and engine cooling
Summary:
Some vehicles may exhibit contaminated / corroded coolant, high or fluctuating temp gauge, coolant odor, coolant overflow, blown or leaking hoses, blown head gasket, failed engine, and or lack of heat. *tt
Bulletin:
5301
Component:
133000 visibility:power window devices and controls
Summary:
Information on vehicles exhibiting an inoperative power window. *tt
Bulletin:
12238
Component:
133000 visibility:power window devices and controls
Summary:
Some vehicles may exhibit an inoperative power window concerns. *tt
Bulletin:
980312
Component:
980000 unknown or other
Summary:
Engine check lamp on with misfire dtc(s).
Bulletin:
00263
Component:
133000 visibility:power window devices and controls
Summary:
Some vehicles may exhibit a power window that will not operate downward because it's stuck / bound to the weathership header. *tt
Bulletin:
14584
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Subject regarding flex fuel vechicle oil and fuel recommendations. *jb
Bulletin:
00203
Component:
980000 unknown or other
Summary:
A separation between layers of the instrument panel.*jb
Bulletin:
00191
Component:
980000 unknown or other
Summary:
Some vehicles may experience a separation between layers of the instrument panel. *jb
Bulletin:
0162
Component:
116300 electrical system:ignition:anti-theft controller
Summary:
Vehicles equipped with passive anti-theft system (pats) may not start or crank. *tt
Bulletin:
14856
Component:
063000 engine and engine cooling:exhaust system
Summary:
Some vehicles equpped with 3.0l 2v vulcan or 4v duratec engine may exhibit an exhaust rust-thru, weld fatigue condition between the two toeboard catalysts where a tie-in bracket is welded to the formed inlet pipe of the rear bank toeboard c
Bulletin:
0147
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Subject regarding engine oil recommendations for use in 2001 vehicles - sae 5w-20 motor oil. *tt
Bulletin:
13802
Component:
330000 interior lighting
Summary:
Some vehicles may exhibit an intermittent loss of integrated control panel (icp) illumination. audio and climate controls continue to operate during the icp's loss of illumination condition. this may be caused by a faulty internal ribbo
Bulletin:
14319
Component:
140000 air bags
Summary:
Information regarding passenger air bag module be replacement during normal vehicle service after restraint system diagnostics. *tt
Bulletin:
01116
Component:
062000 engine and engine cooling:cooling system
Summary:
Some vehicles may exhibit cooling system conditions such contaminated / corroded coolant; leaking / discolored coolant overflow bottles; vibration from engine; leaking heater core; coolant overflow; high temperature gauge readings, etc.
Bulletin:
01124
Component:
061000 engine and engine cooling:engine
Summary:
On some vehicles, engine oil may continue to leak from the engine oil pan gasket area after an engine oil pan gasket repair has been performed. *tt
Bulletin:
01156
Component:
138120 visibility:defroster/defogger system:windshield:heater core
Summary:
Some vehicles may exhibit heater core leaks. *slc
Bulletin:
01157
Component:
980000 unknown or other
Summary:
Information regarding transmission fluid usage charts. *slc
Bulletin:
15142
Component:
106000 power train:axle assembly
Summary:
Some vehicles may exhibit a harsh 2-3 shift after installing a remanufactured automatic transaxle. *yh
Bulletin:
01181
Component:
103800 power train:automatic transmission:park/neutral start switch
Summary:
Brake shift interlock.*jb
Bulletin:
0214
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Some engine assemblies with aluminum cylinder heads repaired in-vehile have been found to leak coolant and/or oil from the cylinder head gasket area. *tt
Bulletin:
15370
Component:
100000 power train
Summary:
Some vehicles may exhibit a groan/buzz/vibration when the gear selector is in park. *tt
Bulletin:
15392
Component:
100000 power train
Summary:
Some vehicles may exhibit a park pullout clunk noise when shifting from park to another gear position. *tt
Bulletin:
15390
Component:
063130 engine and engine cooling:exhaust system:emission control:gas recirculation valve (egr valve)
Summary:
Some vehicles may exhibit a check engine light and/or egr diagnostic trouble codes 332, p0401, p1407 (lackof egr flow). *tt
Bulletin:
01246
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Engine oil system priming procedures, service tips for reports of premature engine failure. *tt
Bulletin:
02153
Component:
980000 unknown or other
Summary:
Some vehicles equipped with the 3.0l 4v duratec engine may exhibit a malfunction indicator lamp illuminated with a diagnostic trouble code p1518, intake manifold runner control. *tt
Bulletin:
15879
Component:
061000 engine and engine cooling:engine
Summary:
Some sho vehicles may exhibit a ticking noise originating from the valve cover area. *tt
Bulletin:
870197
Component:
061000 engine and engine cooling:engine
Summary:
Incorrectly installed gear driven camshaft position (cmp) sensor synchronizer assemblies causing surge, lost of power, malfunction indicator lamp on and diagnostic trouble codes p1336, p1309 and p0340. *tt
Bulletin:
03123
Component:
103700 power train:automatic transmission:torque converter
Summary:
Torque converter clutch not engaging when commanded and/or diagnostic trouble codes p0741 or p1744 stored in memory. models from 1996 to 2003. *tt
Bulletin:
03141
Component:
061000 engine and engine cooling:engine
Summary:
In vehicle loctite service procedure for camshaft tube and gear. *tt
Bulletin:
03148
Component:
103600 power train:automatic transmission:cooling unit and lines
Summary:
New transmission cooler flusher - service tips. 2003 escort and super duty f series included. *tt
Bulletin:
03181
Component:
110000 electrical system
Summary:
Remote keyless entry (rke) - service tips. *tt
Bulletin:
17358
Component:
100000 power train
Summary:
Groan/buzz/vibration when the gear selector is in park with the vehicle parked on an incline. *tt this bulletin updates previous bulletin 17358, dated 11/01/2003 to include 2005 models. *tt
Bulletin:
02221
Component:
061000 engine and engine cooling:engine
Summary:
Engine-gear driven synchronizers-incorrect installation-camshaft position synchronizer (cmp) installation tool correct application. *mj
Bulletin:
02236
Component:
138130 visibility:defroster/defogger system:windshield:controls/wiring
Summary:
Erratic operation of the cool/warm function of the temperature control system - repair procedure for stratification (secondary) temperature blend door. *tt
Bulletin:
02176
Component:
032100 service brakes, hydraulic:switches:brake light
Summary:
Lamp-brake-invadvertent disabling of brake shift interlock. *mj
Bulletin:
031404
Component:
061000 engine and engine cooling:engine
Summary:
Engine misfire or running - coil on plug (cop) ignition systems - wds cop kit diagnostic tips. to include various 2005 models. * ar this article 04161 supersedes tsb 03-14-04.
Bulletin:
02208
Component:
353600 equipment:air conditioner
Summary:
Climate control a/c service tech tips. *eh
Bulletin:
18614
Component:
060000 engine and engine cooling
Summary:
Surge, idle roll, rough idle only when the engine cooling fans are operating. *tt
Bulletin:
041601
Component:
060000 engine and engine cooling
Summary:
Wds cop kit diagnostic tip - coil on plug (cop) ignition systems - engine misfire or rough running. *tt

Home | Privacy