1996 FORD PROBE Recalls (4)
- Campaign:
- 96V090000 on 05/29/1996
- Component:
- Air bags
- Manufactured:
- 10/31/1995 - 10/31/1995
- Affected:
- 2,740
- Defect:
- The supplementary air bag inflatable restraint caution label located on the driver side sun visor does not contain the statement, "do not install rearward facing child seats in any front passenger seat position." this does not comply with the requirements of fmvss no. 208, "occupant crash protection."
- Consequence:
- Consequence of non-compliance: operators could fail to notice and heed the warning label.
- Correction:
- A new caution label, with installation instructions, will be sent directly to owners. owners can install the label or, if they wish, can have their dealer install the label for them.
- Notes:
- System: interior; passive restraint; air bag; fmvss no. 208. vehicle description: passenger vehicles.note: owner notification is expected to begin on or before july 17, 1996. note: owners who do not receive the new caution label within a reasonable time without charge can contact ford at 1-800-392-3673. also contact the national highway traffic safety administration's auto safety hotline at 1-800-424-9393.
- Campaign:
- 05E065000 on 10/05/2005
- Component:
- Fuel system, gasoline
- Affected:
- 42,962
- Defect:
- Certain spx filtran fuel filters with a 45-degree angle inlet tube, model 800f350-s1, sold as replacement filters for 1993-1997 ford probe,1993-2001 mazda 626 and mx-6, and 1983-1994 loyal, 3-door coupe, hatchback, sedan, wagon, brat, dl, gl, gl-10, rx, xt, and xt6 passenger vehicles with efi or turbo engines. these filters are packaged as wix, napa, and carquest brand fuel filters. certain spx filtran fuel filters with a 90-degree angle inlet tube, model 800f300-s2, sold as replacement filters for 19983-1994 subaru vehicles with efi or turbo engines. these filters are packaged as wix, napa, and carquest brand fuel filters. fuel may leak from the filter due to non-conforming brazing welds where the inlet tube is connected to the filter can.
- Consequence:
- In the presence of an ignition source, a vehicle fire can occur.
- Correction:
- Spx will notify its customers and provide a full refund. the recall began september 27, 2005. owners may contact mr. chris greeson at 704-869-3733 or contact the wix information hotline at 800-949-6698.
- Notes:
- Customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236; (tty:1-800-424-9153); or go to http://www.safercar.gov.
- Campaign:
- 06E026000 on 03/22/2006
- Component:
- Exterior lighting
- Affected:
- 61,944
- Defect:
- Certain pro-a motors corner lamps, turn signals, and headlights sold as replacement lamps for use on certain passenger vehicles listed above. some combination lamps that are not equipped with amber side reflectors fail to conform to federal motor vehicle safety standard no. 108, lamps, reflective devices, and associated equipment.
- Consequence:
- Without the amber reflectors, the vehicle will be poorly illuminated, possibly resulting in a vehicle crash without warning.
- Correction:
- Pro-a motors will notify owners and offer to repurchase the lamps. the recall began on april 3, 2006. owners may contact pro-a motors at 323-838-2988.
- Notes:
- This recall only pertains to pro-a motors aftermarket lamps and has no relation to any original equipment installed on the listed passenger vehicles.for more information on the lamp model numbers, click on document search and view document titled "lamp model numbers."customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov.
- Campaign:
- 06E065000 on 07/16/2006
- Component:
- Exterior lighting
- Affected:
- 3,593
- Defect:
- Certain aj motorsport combination lamps sold as replacement lamps for use on the above listed passenger vehicles. combination lamps not equipped with amber side reflectors fail to conform with the requirements of federal motor vehicle safety standard no. 108, lamps, reflective devices, and associated equipment.
- Consequence:
- Lack of amber side reflectors in the lamps will decrease lighting visibility to other drivers and may possibly result in a vehicle crash.
- Correction:
- Aj motorsport will notify owners and offer reimbursement for the lamps. the recall began on july 31, 2006. owners may contact aj motorsport at 626-618-2026.
- Notes:
- This recall only pertains to aj motorsport aftermarket lamps and has no relation to any original equipment installed on the listed passenger vehicles.for more information on the lamp model numbers, click on document search and view document titled "lamp model numbers."customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov.
1996 FORD PROBE TSBs (83)
- Bulletin:
- BC0180960102
- Component:
- 131000 visibility:windshield
- Summary:
- Unknown
- Bulletin:
- BC0186960102
- Component:
- 103000 power train:automatic transmission
- Summary:
- engineering is investigating a concern on the cd4e transaxle where transmission fluid mists from the transaxle vent tube. this concern causes transmission fluid to puddle on top of the transaxle & can be perceived as a pan gasket or seal l
- Bulletin:
- 95212
- Component:
- 036000 service brakes, hydraulic:antilock
- Summary:
- the use of petroleum-based grease as a lubricant in servicing disc brakes is no longer acceptable because it may be incompatible with the rubber material used in the disc brake system. if petroleum-based grease is used to lubricate any par
- Bulletin:
- BC0760961016
- Component:
- 101000 power train:clutch assembly
- Summary:
- Wave spring located under the forward one-way clutch in no longer one piece. it has been 'split'. *tt
- Bulletin:
- BC0763961016
- Component:
- 151200 seat belts:front:webbing
- Summary:
- Shoulder belt that is slow to retract may be caused by a twist in the seat belt webbing behind the 'b' pillar trim. *tt
- Bulletin:
- BC0784961014
- Component:
- 106000 power train:axle assembly
- Summary:
- Weld connection concern w/ the forward/direct/coast clutch cylinder & hub assy. *tt
- Bulletin:
- BC5191961001
- Component:
- 103000 power train:automatic transmission
- Summary:
- For concerns of stalling, reflash pcm w/ 1996 calibration (r11 level). *tt
- Bulletin:
- BC5195961001
- Component:
- 190000 tires
- Summary:
- Firestone p235 tires may exhibit a high frequency vibration at 65-75 mph. *tt
- Bulletin:
- BC0304961101
- Component:
- 061100 engine and engine cooling:engine:gasoline
- Summary:
- Metallic ticking noise from upper engine. *tw
- Bulletin:
- BC0327961129
- Component:
- 140000 air bags
- Summary:
- Concerns of the air bag light flashing code may be caused by an inadequate connection between the driver's side air bag module and the clock spring.
- Bulletin:
- BC0422961119
- Component:
- 102000 power train:manual transmission
- Summary:
- Concerns of transmission popping out of 3rd or 5th gear. *tw
- Bulletin:
- 96245
- Component:
- 114000 electrical system:wiring
- Summary:
- Malfunction indicator lamp (mil) illumination - diagnostic trouble code (dtc) p1794 stored in continuous memory - probe with 2.5l, escort with 1.8l and aspire. *tw
- Bulletin:
- 96249
- Component:
- 103700 power train:automatic transmission:torque converter
- Summary:
- Torque converter - leak test procedure - service tip. *tw
- Bulletin:
- 96221
- Component:
- 131000 visibility:windshield
- Summary:
- Windshield and interior glass - fog/film. *tw
- Bulletin:
- 96222
- Component:
- 034000 service brakes, hydraulic:foundation components
- Summary:
- Brakes - elimination of sanding rotors and drums - service tip. *tw
- Bulletin:
- 96225
- Component:
- 075000 fuel system, gasoline:carburetor system
- Summary:
- Mass air flow sensor - replacement as an assembly - service tip. *tw
- Bulletin:
- 96254
- Component:
- 140000 air bags
- Summary:
- Restraint system - air bag module - diagnostic fault code 51 - improved diagnostics and repair. *tw
- Bulletin:
- 962511
- Component:
- 116200 electrical system:ignition:module
- Summary:
- Powertrain control module -reprogram powertrain control module (pcm) - service procedures - service tip. *tw
- Bulletin:
- 962516
- Component:
- 105200 power train:driveline:constant velocity joint
- Summary:
- Axke leaks - fluid leaks from front of vehicle at axle shafts - new design replacement cv joint boots. *tw
- Bulletin:
- 962612
- Component:
- 103700 power train:automatic transmission:torque converter
- Summary:
- Transaxle - torque converter replacement guidelines and torque converter/transaxle cooling system cleaning procedures - service tip. *tw
- Bulletin:
- 962614
- Component:
- 103000 power train:automatic transmission
- Summary:
- Transaxle - cd4e - harsh shift and/or engagement - diagnostic trouble code 628 or p0741. *tw
- Bulletin:
- BC0304970201
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Metallic ticking noise from upper engine. *jd
- Bulletin:
- BC1010397020
- Component:
- 091130 fuel system, other:storage:tank assembly:pressure relief devices
- Summary:
- Hard to start/long crank time concern on 96-97 vehicles due to fuel pressure leak down. *jd
- Bulletin:
- 9729
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Noise - buzz/vibration in reverse and/or clicking noise accompanied by vibration on right hand turns during accleration - vehicles built through 1/6/97 with 2.0l engine and cd4e transaxle. *tw
- Bulletin:
- BC0327972301
- Component:
- 140000 air bags
- Summary:
- Air bag light flashing code 32 may be caused by all inadequate connection between the drivers side air bag module and the clock spring. *jd
- Bulletin:
- BC1023297230
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Vehicles exhibiting a top of engine knock noise when starting a cold engine. *jd
- Bulletin:
- BC1026697230
- Component:
- 101100 power train:clutch assembly:pedal/linkage
- Summary:
- Vehicles exhibiting harsh shifts and/or harsh engagement accompanied by dtcs 628 or p0741. *jd
- Bulletin:
- 9733
- Component:
- 120000 exterior lighting
- Summary:
- Malfunction indicator lamp- diagnostic trouble code 181 or p0171 may be stored in memory- rough idle- reduced power- hesitation on acceleration- vehicles built through 11/19/95. *jd
- Bulletin:
- 9735
- Component:
- 353600 equipment:air conditioner
- Summary:
- Air conditioning- r-134a tracer dye installed in a/c system and three o-ring spring lock couplers- service tip. *jd
- Bulletin:
- 9746
- Component:
- 022000 suspension:rear
- Summary:
- Transaxle- cd4e- harsh shift and/or engagement- diagnostic trouble code (dtc) 628 or p0741- service tip. *jd
- Bulletin:
- BC1026997020
- Component:
- 120000 exterior lighting
- Summary:
- 2.0l with the mil on and code p0421. *jd
- Bulletin:
- BC1030597020
- Component:
- 980000 unknown or other
- Summary:
- Paint blister, peel or crack concerns. *jd
- Bulletin:
- BC3162970218
- Component:
- 105500 power train:driveline:differential unit
- Summary:
- Clicking noise caused by differential lube tube contacting differential case. *tw
- Bulletin:
- BC3204970214
- Component:
- 103000 power train:automatic transmission
- Summary:
- Harsh shifts and/or harsh engagement accompanied by dtc's 628 or p0741. *tw
- Bulletin:
- BC3220970212
- Component:
- 116200 electrical system:ignition:module
- Summary:
- Mil code - p0421 - do not attempt repairs. *tw
- Bulletin:
- 9751
- Component:
- 220000 seats
- Summary:
- Interior- leather seat cleaning procedure- service tip. *jd
- Bulletin:
- 9759
- Component:
- 103600 power train:automatic transmission:cooling unit and lines
- Summary:
- Leak- automatic transmission fluid- cd4e transaxle in fluid collection on main control assembly. *jd
- Bulletin:
- 97511
- Component:
- 103000 power train:automatic transmission
- Summary:
- Fluid- transmission fluid usage charts. *jd
- Bulletin:
- 9768
- Component:
- 980000 unknown or other
- Summary:
- Fuel economy- customer expectations versus vehicle usage. *jd
- Bulletin:
- BC2372970501
- Component:
- 070000 fuel system, gasoline
- Summary:
- A hard to start/long crank time concern on 96-97 probe vehicles may be due to fuel pressure leak down. *tw
- Bulletin:
- 985A5
- Component:
- 034530 service brakes, hydraulic:foundation components:disc:rotor
- Summary:
- Hub-mount brake rotor machining equipment from rotunda is now approved for warranty and service use. *yc
- Bulletin:
- 985A11
- Component:
- 034000 service brakes, hydraulic:foundation components
- Summary:
- Service tip information regarding elimination of sanding rotors and drums. *yc
- Bulletin:
- 985A13
- Component:
- 034500 service brakes, hydraulic:foundation components:disc
- Summary:
- The use of petroleum-based grease as a lubricant in servicing disc brakes is no longer acceptable. *yc
- Bulletin:
- 9888
- Component:
- 103000 power train:automatic transmission
- Summary:
- Information on a new transmission fluid usage chart. *yc
- Bulletin:
- 9845
- Component:
- 045300 service brakes, air:disc:rotor
- Summary:
- Availability of hub-mount brake rotor machining equipment. *yc
- Bulletin:
- 9852
- Component:
- 190000 tires
- Summary:
- Information on tire company telephone numbers for customer assistance. *yc
- Bulletin:
- 9864
- Component:
- 063000 engine and engine cooling:exhaust system
- Summary:
- Information on a buzzing or rattle noise from the exhaust system. *tt
- Bulletin:
- 9873
- Component:
- 353400 equipment:electrical:radio/tape deck/cd etc.
- Summary:
- Experiencing a whining / buzzing noise in the speakers of the entertainment radio or two-way radio. *tt
- Bulletin:
- 9874
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- A new silicone gasket and sealant. *yc
- Bulletin:
- 982010
- Component:
- 063000 engine and engine cooling:exhaust system
- Summary:
- Experiencing a " buzzing " or " rattling " noise from the exhaust system. *yc
- Bulletin:
- 982310
- Component:
- 063100 engine and engine cooling:exhaust system:emission control
- Summary:
- Mass air flow (maf)- sensor contamination- service tip. *ak
- Bulletin:
- 982311
- Component:
- 106000 power train:axle assembly
- Summary:
- Minimal clearance of the cd4e transaxle to subframe makes transaxle installation and removal more difficult. *yc
- Bulletin:
- 98246
- Component:
- 110000 electrical system
- Summary:
- Ford motor company has released a new electrical grease ( f8az - 19g208-aa ) to reduce the possibility of moisture corrosion at the terminals. *yc
- Bulletin:
- 9943
- Component:
- 100000 power train
- Summary:
- Information regarding reprogramming powertrain control modules (pcms). *tt
- Bulletin:
- 9814
- Component:
- 034530 service brakes, hydraulic:foundation components:disc:rotor
- Summary:
- Subject regarding the availability of hub-mount brake rotor machining equipment. *tt
- Bulletin:
- 99816
- Component:
- 061100 engine and engine cooling:engine:gasoline
- Summary:
- Ford motor company now recommends sae 5w-30 viscosity grade for servicing any ford gasoline-powered vehicle regardless of model year. *tt
- Bulletin:
- 99129
- Component:
- 072100 fuel system, gasoline:delivery:fuel pump
- Summary:
- Information on "whining" / "buzzing" noise coming through entertainment or two-way radio speaker caused by the fuel pump. *tt
- Bulletin:
- 99129
- Component:
- 353400 equipment:electrical:radio/tape deck/cd etc.
- Summary:
- Experiencing a whine / buzz type noise in the speakers of the entertainment radio or two-way radio on vehicles with an in-tank electric fuel pump. *tt
- Bulletin:
- 99139
- Component:
- 125000 exterior lighting:brake lights
- Summary:
- Conditions with the brake lamps inadvertently disabling the brake shift interlock. *tt
- Bulletin:
- 983151
- Component:
- 103100 power train:automatic transmission:control module (tcm, pcm)
- Summary:
- Some vehicles with a p0421 code stored in the powertrain control module (pcm) may not be able to identify the calibration when reprogramming. *ak
- Bulletin:
- 99222
- Component:
- 114000 electrical system:wiring
- Summary:
- Subject on a wire harness terminal repair kit available for repairing electrical wiring harnesses. *tt
- Bulletin:
- 99183
- Component:
- 061100 engine and engine cooling:engine:gasoline
- Summary:
- Service tip information on revised oil pan gasket replacement procedure. *tt
- Bulletin:
- 99194
- Component:
- 034000 service brakes, hydraulic:foundation components
- Summary:
- Information for servicing and diagnosing brake vibration, brake inspection, and brake friction material replacement. *tt
- Bulletin:
- 99196
- Component:
- 353600 equipment:air conditioner
- Summary:
- Information on identifying non-approved / alternate refrigerants which could cause safety, and performance concerns if installed in ford a/c systems. *tt
- Bulletin:
- 99249
- Component:
- 103000 power train:automatic transmission
- Summary:
- This bulletin addresses an issue with the automatic transmission fluid seeping from the vent, resulting in fluid collecting on the main control assembly. *tt
- Bulletin:
- 6583
- Component:
- 014200 steering:rack and pinion:rack
- Summary:
- Information on servicing the left steering rack bushing. *tt
- Bulletin:
- 0015
- Component:
- 103000 power train:automatic transmission
- Summary:
- Information regarding the new transmission cooler flusher- service tip. *mjs
- Bulletin:
- 9812016
- Component:
- 980000 unknown or other
- Summary:
- Some vehicles may exhibit a concern where the check engine falfunction indicator lamp (mil) may illuminate in below freezing temperatures and diagnostic trouble code (dtc) p1407 is stored in continuous memory.
- Bulletin:
- 985016
- Component:
- 980000 unknown or other
- Summary:
- Some vehicles may exhibit a concern where the check engine malfunction indicator lamp may illuminate in below freezing temperatures and diagnostic trouble code p1407 is stored in continuous memory. *tt
- Bulletin:
- 985A12
- Component:
- 354600 equipment:mechanical:wrecker and wheel lift devices
- Summary:
- Recommended guidelines for towing behind recreational vehicles. *tt
- Bulletin:
- 99-8-15
- Component:
- 162300 structure:body:door
- Summary:
- Subject regarding door trim panel replacement - service tip. *tt
- Bulletin:
- 99111
- Component:
- 980000 unknown or other
- Summary:
- Information designed to aid in the diagnosis, testing and repair of noise, vibration and harshness (nvh) concerns. *tt
- Bulletin:
- 991210
- Component:
- 980000 unknown or other
- Summary:
- Ford motor company has released a private labeled material to be used for iron particle / acid rain service repairs. *tt
- Bulletin:
- 99152
- Component:
- 103000 power train:automatic transmission
- Summary:
- Information on the new flush and fill tool available through rotunda. *tt
- Bulletin:
- 00182
- Component:
- 106000 power train:axle assembly
- Summary:
- Some vehicles may exhibit no forward gear ranges due to the misalignment of the forward / coast clutch cylinder snap ring with respect to the legs of the forward clutch piston. *jb
- Bulletin:
- 14936
- Component:
- 106000 power train:axle assembly
- Summary:
- Some vehicles equipped with cd4e auto transaxles may exhibit diagnostic trouble codes for gear ratio or harsh and delayed 1-2 / 2-3 upshifts after transaxle or turbine speed sensor (tss) replacement. *tt
- Bulletin:
- 01156
- Component:
- 138120 visibility:defroster/defogger system:windshield:heater core
- Summary:
- Some vehicles may exhibit heater core leaks. *slc
- Bulletin:
- 01157
- Component:
- 980000 unknown or other
- Summary:
- Information regarding transmission fluid usage charts. *slc
- Bulletin:
- 01181
- Component:
- 103800 power train:automatic transmission:park/neutral start switch
- Summary:
- Brake shift interlock.*jb
- Bulletin:
- 01246
- Component:
- 061100 engine and engine cooling:engine:gasoline
- Summary:
- Engine oil system priming procedures, service tips for reports of premature engine failure. *tt
- Bulletin:
- 0224
- Component:
- 106000 power train:axle assembly
- Summary:
- Some vehicles equipped with the cd4e transaxle may exhibit harsh and delayed 1-2/2-3 upshifts after transaxle or turbine shaft speed sensor replacement, possible diagnostic trouble codes 628, 642, 645, 646, 647, 648, p0731, p0732, p0734, p0
- Bulletin:
- 03181
- Component:
- 110000 electrical system
- Summary:
- Remote keyless entry (rke) - service tips. *tt
- Bulletin:
- 02176
- Component:
- 032100 service brakes, hydraulic:switches:brake light
- Summary:
- Lamp-brake-invadvertent disabling of brake shift interlock. *mj
Home | Privacy