1996 FORD F-150 Recalls (7)

Campaign:
96E010000 on 03/28/1996
Component:
Seats
Affected:
2,400
Defect:
The seat recliner to seat frame attaching bolts on these vehicles could loosen, fatigue and fracture, allowing the seat back to suddenly recline.
Consequence:
If this were to occur to the driver's seat, this could result in a sudden loss of vehicle control increasing the risk of a vehicle accident.
Correction:
Dealers will remove all foam and/or fabric sandwiched between the recliner assembly and the seat frame, install washers between the seat recliner and the seat frame at each attachment point, and install new attaching bolts torqued to a higher specification. these corrections will be made to both the driver's and passenger's seats.
Notes:
System: interior; seat track anchors and seat.equipment description: front high-back bucket seats or 60/40 split bench seats provided by vehicle safety systems for installation in light duty pickup extended cab conversion trucks.note: owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time, should contact vss at 1-800-742-5043. also contact the national highway traffic safety administration's auto safety hotline at 1-800-424-9393.
Campaign:
96V161000 on 09/02/1996
Component:
Equipment:other:labels
Manufactured:
12/14/1995 - 03/10/1996
Affected:
134,770
Defect:
The certification labels on the involved vehicles has incorrect rear tire inflation pressure designations. this does not comply with fmvss no. 120, "tire selection and rims for motor vehicles other than passenger cars."
Consequence:
Incorrect inflation pressures could cause premature wear of the rear tires. .
Correction:
Owners will be provided with correct certification labels and instructions for installing these labels. dealers can install this label if the owner so desires.
Notes:
Owner notification:owner notification is expected to begin october 18, 1996. note:owners who do not receive the correct label within a reasonable time free of charge should contact ford at 1-800-392-3673.also contact the national highway traffic safety administration's auto safety hotline at 1-800-424-9393.
Campaign:
05V388000 on 09/06/2005
Component:
Vehicle speed control
Affected:
4,500,000
Defect:
On certain pickup trucks and sport utility vehicles equipped with speed control, the speed control deactivation switch may overheat, smoke, or burn.
Consequence:
A fire at the switch could occur.
Correction:
By letter dated september 12, 2005, owners were instructed to return their vehicles to their dealers to have the speed control deactivation switch disconnected. owners who have had their speed control deactivated are being notified that parts will be available and advised to make an appointment to reconnect the speed control beginning in february 2006. owners who did not have their speed control deactivated are being notified to have their system remedied beginning in february 2006. owners are urged to avail themselves of the free disconnect service as soon as possible because of the significant risk of fire. owners may contact ford at 1-800-392-3673. (note: also see recalls 05v017 and 06v286)
Notes:
Ford recall no. 05s28.customers may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov.
Campaign:
06E026000 on 03/22/2006
Component:
Exterior lighting
Affected:
61,944
Defect:
Certain pro-a motors corner lamps, turn signals, and headlights sold as replacement lamps for use on certain passenger vehicles listed above. some combination lamps that are not equipped with amber side reflectors fail to conform to federal motor vehicle safety standard no. 108, lamps, reflective devices, and associated equipment.
Consequence:
Without the amber reflectors, the vehicle will be poorly illuminated, possibly resulting in a vehicle crash without warning.
Correction:
Pro-a motors will notify owners and offer to repurchase the lamps. the recall began on april 3, 2006. owners may contact pro-a motors at 323-838-2988.
Notes:
This recall only pertains to pro-a motors aftermarket lamps and has no relation to any original equipment installed on the listed passenger vehicles.for more information on the lamp model numbers, click on document search and view document titled "lamp model numbers."customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov.
Campaign:
06E049000 on 06/04/2006
Component:
Exterior lighting
Affected:
27,176
Defect:
Certain ck motorsports combination headlights, clear corner, bumper, and side marker lights sold as replacement lamps for use on the passenger vehicles listed above. some combination lamps that are not equipped with amber side reflectors fail to conform to federal motor vehicle safety standard no. 108, lamps, reflective devices, and associated equipment.
Consequence:
Without the amber reflectors, the vehicle will be poorly illuminated, possibly resulting in a vehicle crash without warning.
Correction:
Ck motorsport will notify owners and replace the noncompliant lamps free of charge. the recall began on july 1, 2006. owners may contact ck motorsport at 1-909-610-7211.
Notes:
This recall only pertains to aftermarket replacement equipment and has no relation to any original equipment installed on vehicles manufactured by the vehicle manufacturers.for more information on the lamp model numbers, click on document search and view document titled "lamp model numbers."customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov.
Campaign:
09E012000 on 04/06/2009
Component:
Exterior lighting
Affected:
16,270
Defect:
Sabersport is recalling 16,270 combination corner and bumper lamp assemblies of various part numbers sold for use as aftermarket equipment for various passenger vehicles. these headlamps fail to conform to the requirements of federal motor vehicle safety standard no. 108, "lamps, reflective devices, and associated equipment." these lamps do not contain the required amber side reflectors.
Consequence:
Decreased lighting visibility may result in a vehicle crash.
Correction:
Sabersport will notify owners and offer a full refund for the noncompliant combination lamps. the safety recall began on may 11, 2009. owners may contact sabersport at 1-909-598-7589.
Notes:
This recall only pertains to aftermarket replacement equipment and has no relation to any original equipment installed on vehicles produced by the vehicle manufacturer.in order to determine if your aftermarket lamp assembly is affected by this noncompliance, please review the list of model numbers provided to us by sabersport.the list can be found under "document search" located at the bottom of your screen.owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to <a href=http://www.safercar.gov>http://www.safercar.gov</a> .
Campaign:
09E025000 on 05/10/2009
Component:
Exterior lighting:headlights
Affected:
42,540
Defect:
Dope, inc. is recalling 42,540 combination corner and bumper lamp assemblies of various part numbers sold for use as aftermarket equipment for various passenger vehicles. these headlamps fail to conform to the requirements of federal motor vehicle safety standard no. 108, "lamps, reflective devices, and associated equipment." these lamps do not contain the required amber side reflectors.
Consequence:
Decreased lighting visibility may result in a vehicle crash.
Correction:
Dope, inc. will notify owners and offer a full refund for the noncompliant combination lamps. the safety recall began on july 28, 2009. owners may contact dope, inc. at 1-626-272-1798.
Notes:
This recall only pertains to aftermarket replacement equipment and has no relation to any original equipment installed on vehicles produced by the vehicle manufacturer.in order to determine if your aftermarket lamp assembly is affected by this noncompliance, please review the list of model numbers provided to us by dope, inc.the list can be found under "document search" located at the bottom of your screen. owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to <a href=http://www.safercar.gov>http://www.safercar.gov</a> .

1996 FORD F-150 TSBs (121)

Bulletin:
95616
Component:
062000 engine and engine cooling:cooling system
Summary:
cooling system - leaking radiator hose - upgraded hose clamps. *tw
Bulletin:
BC4178950401
Component:
061000 engine and engine cooling:engine
Summary:
Unknown
Bulletin:
BC0131960102
Component:
106000 power train:axle assembly
Summary:
4x4 front axles must use hypoid 4x4 gear oil p/n f1tz-19580-a & high temp 4x4 front axle & wheel bearing grease when servicing. it is not recommended to use heavier weight lubes in these front axles.
Bulletin:
95212
Component:
036000 service brakes, hydraulic:antilock
Summary:
the use of petroleum-based grease as a lubricant in servicing disc brakes is no longer acceptable because it may be incompatible with the rubber material used in the disc brake system. if petroleum-based grease is used to lubricate any par
Bulletin:
BC0693961023
Component:
185000 vehicle speed control:cruise control
Summary:
Investigating 7.3l irregular idle. *tt
Bulletin:
BC0844961008
Component:
102000 power train:manual transmission
Summary:
E4od trans may emit a tick/rattle noise when driving at light loads in 1st gear at 1100 to 1800 rpm rpm. *tt
Bulletin:
BC0883961004
Component:
063200 engine and engine cooling:exhaust system:manifold/header/muffler/tail pipe
Summary:
Vehicles may exhibit an exhaust leak &/or noise due to warped exhaust manifolds. *tt
Bulletin:
BC5191961001
Component:
103000 power train:automatic transmission
Summary:
For concerns of stalling, reflash pcm w/ 1996 calibration (r11 level). *tt
Bulletin:
BC5195961001
Component:
190000 tires
Summary:
Firestone p235 tires may exhibit a high frequency vibration at 65-75 mph. *tt
Bulletin:
BC5201961001
Component:
185000 vehicle speed control:cruise control
Summary:
Investigating 7.3l irregular idle. *tt
Bulletin:
BC9688961001
Component:
353000 equipment:electrical
Summary:
Information for when diagnosing concerns w/ factory installed cellular phones. *tt
Bulletin:
BC0326961129
Component:
141000 air bags:frontal
Summary:
When diagnosing an air bag lamp flash-out code 33 (passenger side air bag high resistance or open) on a 1994-1996 f150 or bronco that is not equipped with a passenger side air bag, check for proper ground from pin 7, circuit 629, at the air
Bulletin:
BC0475961114
Component:
011000 steering:wheel and handle bar
Summary:
A "clunk" noise heard/felt through the steering column when maneuvering in parking lots, driving in stop and go traffic or driving over bumps. *tw
Bulletin:
BC0001196110
Component:
011000 steering:wheel and handle bar
Summary:
A 'clunk' noise may be heard/felt through the steering column when maneuvering in parking lots, driving in stop and go traffic or driving over bumps. *tw
Bulletin:
BC0057961101
Component:
141000 air bags:frontal
Summary:
Diagnosing an air bag lamp flash-out code 33 (passenger side air bag high resistance or open)
Bulletin:
96246
Component:
114000 electrical system:wiring
Summary:
Wiring - electrical diode identification and service replacements. *tw
Bulletin:
96249
Component:
103700 power train:automatic transmission:torque converter
Summary:
Torque converter - leak test procedure - service tip. *tw
Bulletin:
962418
Component:
103000 power train:automatic transmission
Summary:
Transmission - e40d - revised design forward planet thrust washer - service tip. *tw
Bulletin:
96221
Component:
131000 visibility:windshield
Summary:
Windshield and interior glass - fog/film. *tw
Bulletin:
96222
Component:
034000 service brakes, hydraulic:foundation components
Summary:
Brakes - elimination of sanding rotors and drums - service tip. *tw
Bulletin:
96223
Component:
185000 vehicle speed control:cruise control
Summary:
Long crank - sticking idle air control (iac) valve - vehicles built from 11/1/94 through 3/30/96 -stall - after starting when engine allowed to soak from 1-4 hours - sticking idle air control (iac) valve. *tw
Bulletin:
96225
Component:
075000 fuel system, gasoline:carburetor system
Summary:
Mass air flow sensor - replacement as an assembly - service tip. *tw
Bulletin:
96226
Component:
353600 equipment:air conditioner
Summary:
Air conditioning - compressor failure - insufficient amount of refrigerant oil. *tw
Bulletin:
962212
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Engine compartment noise - buzzing or knocking - right front of engine - after starting - 4.9l engines - f series built from 8/1/94 through 10/15/95 - econolines built from 8/15/94 through 10/15/95. *tw
Bulletin:
96252
Component:
171100 latches/locks/linkages:doors:latch
Summary:
Locks - replace and/or repair any lock component - service tip. *tw
Bulletin:
962510
Component:
116200 electrical system:ignition:module
Summary:
Malfunction indicator lamp (mil) - diagnostic trouble codes (dtcs) p0300, p0301, p0302, p0303, p0304, p0305, p0306, p0307 and/or p0308 stored in memory. *tw
Bulletin:
962511
Component:
116200 electrical system:ignition:module
Summary:
Powertrain control module -reprogram powertrain control module (pcm) - service procedures - service tip. *tw
Bulletin:
962521
Component:
011000 steering:wheel and handle bar
Summary:
Steering - clunk noise from steering column on accelerating and braking. *tw
Bulletin:
96265
Component:
116200 electrical system:ignition:module
Summary:
Malfunction indicator lamp (mil) - diagnostic trouble codes (dtcs) p0300, p0301, p0302, p0303, p0304, p0305, p0306, p0307, and/or p0308 stored in memory. *tw
Bulletin:
962612
Component:
103700 power train:automatic transmission:torque converter
Summary:
Transaxle - torque converter replacement guidelines and torque converter/transaxle cooling system cleaning procedures - service tip. *tw
Bulletin:
962620
Component:
107000 power train:axle hubs
Summary:
Noise - ratcheting - front axle - 4x4 - self engagement of automatic hub locks. *tw
Bulletin:
BC0053970201
Component:
103000 power train:automatic transmission
Summary:
Some 1995 and all 1996 and 1997 vehicles with e40d transmissions have been built with a reusable elastomeric transmission fluid pan gasket. *jd
Bulletin:
BC1015397020
Component:
103000 power train:automatic transmission
Summary:
Vehicles with e4od transmissions have been built with a reusable elastomeric transmission fluid pan gasket. *jd
Bulletin:
97114
Component:
061000 engine and engine cooling:engine
Summary:
Engine compartment noise-"buzzing or knocking"- right front of engine-after starting. *jd
Bulletin:
9726
Component:
116200 electrical system:ignition:module
Summary:
Malfunction indicator lamp (mil) illuminated - gaseous fuel prep (gfp) vehicles - powertrain control module (pcm) reprogramming required - vehicles with 2.0l or 4.9l engine. *tw
Bulletin:
BC0053972301
Component:
104000 power train:transfer case (4-wheel drive)
Summary:
Some 1995 and all 1996 and 1997 vehicles with e4od transmissions have been built with a reusable elastomeric transmission fluid pan gasket. *jd
Bulletin:
BC0326972301
Component:
141100 air bags:frontal:sensor/control module
Summary:
Air bag lamp flash-out code 33 on vehicles equiped with a passenger side air bag. *jd
Bulletin:
BC3363972301
Component:
116200 electrical system:ignition:module
Summary:
The ngs displays incorrect date for the ing gem pid on the vehicles. *jd
Bulletin:
BC3520972301
Component:
102000 power train:manual transmission
Summary:
High shift efforts on manual transmission. *jd
Bulletin:
BC1017297230
Component:
102000 power train:manual transmission
Summary:
High shift efforts on manual transmission. *jd
Bulletin:
BC1022797230
Component:
116200 electrical system:ignition:module
Summary:
The ngs displays incorrect data for the ign gem pid on the vehicles. *jd
Bulletin:
9735
Component:
353600 equipment:air conditioner
Summary:
Air conditioning- r-134a tracer dye installed in a/c system and three o-ring spring lock couplers- service tip. *jd
Bulletin:
97310
Component:
021242 suspension:front:springs:leaf spring assembly:hanger,bracket
Summary:
Noise- "popping/creaking"- front frame or suspension brackets- frame- "popping/creaking"- fastener replacement. *jd
Bulletin:
9747
Component:
160000 structure
Summary:
Frame- rivet replacement with bolts- service tips. *jd
Bulletin:
9748
Component:
061110 engine and engine cooling:engine:gasoline:belts and associated pulleys
Summary:
Accessory drive belts- fead belt comes off- vehicles with 4.9l engine. *jd
Bulletin:
BC3282970206
Component:
116200 electrical system:ignition:module
Summary:
Gem concern - check for more than one gem controlled component that is inoperative or for a string of false gem dtc's received in memory. *tw
Bulletin:
BC3287970206
Component:
101100 power train:clutch assembly:pedal/linkage
Summary:
The clutch may be hard to depress due to dust/contamination entering the slave cylinder. *tw
Bulletin:
9778
Component:
121000 exterior lighting:headlights
Summary:
Headlamp- headlamp housing melts- ambulance and emergency vehicles only. *jd
Bulletin:
9779
Component:
114100 electrical system:wiring:front underhood
Summary:
Wiring- aftermarket wiring alterations- service tip. *jd
Bulletin:
97511
Component:
103000 power train:automatic transmission
Summary:
Fluid- transmission fluid usage charts. *jd
Bulletin:
9768
Component:
980000 unknown or other
Summary:
Fuel economy- customer expectations versus vehicle usage. *jd
Bulletin:
97628
Component:
021700 suspension:front:hub
Summary:
Noise- "ratcheting"- front axle- 4x4- self-engagement of automatic hub locks- bronco, f-150 and f-250 under 8500# gvw. *jd
Bulletin:
BC2301970501
Component:
102000 power train:manual transmission
Summary:
New clutch slave cylinder with a redesigned lip seal. *tw
Bulletin:
97050110621
Component:
500000 child seat
Summary:
Part number information for the use of a child seat tether. *tw
Bulletin:
97090297187
Component:
102000 power train:manual transmission
Summary:
Some vehicles may stall when the transmission is placed into gear. *yc
Bulletin:
985A5
Component:
034530 service brakes, hydraulic:foundation components:disc:rotor
Summary:
Hub-mount brake rotor machining equipment from rotunda is now approved for warranty and service use. *yc
Bulletin:
985A11
Component:
034000 service brakes, hydraulic:foundation components
Summary:
Service tip information regarding elimination of sanding rotors and drums. *yc
Bulletin:
985A13
Component:
034500 service brakes, hydraulic:foundation components:disc
Summary:
The use of petroleum-based grease as a lubricant in servicing disc brakes is no longer acceptable. *yc
Bulletin:
9888
Component:
103000 power train:automatic transmission
Summary:
Information on a new transmission fluid usage chart. *yc
Bulletin:
9845
Component:
045300 service brakes, air:disc:rotor
Summary:
Availability of hub-mount brake rotor machining equipment. *yc
Bulletin:
98419
Component:
980000 unknown or other
Summary:
Some vehicles may exhibit a flashing transmission control indicator lamp (tcil) and diagnostic trouble codes (dtcs) 62,628, and/or 1728. *yc
Bulletin:
9852
Component:
190000 tires
Summary:
Information on tire company telephone numbers for customer assistance. *yc
Bulletin:
9864
Component:
063000 engine and engine cooling:exhaust system
Summary:
Information on a buzzing or rattle noise from the exhaust system. *tt
Bulletin:
982010
Component:
063000 engine and engine cooling:exhaust system
Summary:
Experiencing a " buzzing " or " rattling " noise from the exhaust system. *yc
Bulletin:
982323
Component:
162000 structure:body
Summary:
Information regarding replacement and / or repairs on any lock component. *yc
Bulletin:
98246
Component:
110000 electrical system
Summary:
Ford motor company has released a new electrical grease ( f8az - 19g208-aa ) to reduce the possibility of moisture corrosion at the terminals. *yc
Bulletin:
9943
Component:
100000 power train
Summary:
Information regarding reprogramming powertrain control modules (pcms). *tt
Bulletin:
9814
Component:
034530 service brakes, hydraulic:foundation components:disc:rotor
Summary:
Subject regarding the availability of hub-mount brake rotor machining equipment. *tt
Bulletin:
98122
Component:
138000 visibility:defroster/defogger system
Summary:
Performance enhancement for defroster. *tt
Bulletin:
98123
Component:
103000 power train:automatic transmission
Summary:
Some vehicles may exhibit a flashing transmission control indicator lamp (tcil) and diagnostic trouble codes (dtcs) 62, 628, and / or 1728 may be stored in memory. *tt
Bulletin:
99816
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Ford motor company now recommends sae 5w-30 viscosity grade for servicing any ford gasoline-powered vehicle regardless of model year. *tt
Bulletin:
9996
Component:
103000 power train:automatic transmission
Summary:
Experiencing a delayed or no 2-3 upshift, primarily when the transmission is cold on vehicles with ford qality remanufactured (fqr) 4r70w transmission exchange units with julian build between 062-97 and 040-99. *tt
Bulletin:
99129
Component:
353400 equipment:electrical:radio/tape deck/cd etc.
Summary:
Experiencing a whine / buzz type noise in the speakers of the entertainment radio or two-way radio on vehicles with an in-tank electric fuel pump. *tt
Bulletin:
99139
Component:
125000 exterior lighting:brake lights
Summary:
Conditions with the brake lamps inadvertently disabling the brake shift interlock. *tt
Bulletin:
12905
Component:
106000 power train:axle assembly
Summary:
Some vehicles may experience axle wind up and / or clunking, popping, ratcheting type noises when making cornering maneuvers on vehicles equipped with a four wheel drive hi or low range mode. *tt
Bulletin:
983074
Component:
106000 power train:axle assembly
Summary:
Concerns with axle wind-up and / or clunking, popping, ratcheting type noises when making cornering maneuvers. *tt
Bulletin:
9913125
Component:
103000 power train:automatic transmission
Summary:
Sone police vehicles and other vehicles with 4r70w may exhibit a vibration and / or transmission extension housing bushing damage from sustained high speed operation. *tt
Bulletin:
99222
Component:
114000 electrical system:wiring
Summary:
Subject on a wire harness terminal repair kit available for repairing electrical wiring harnesses. *tt
Bulletin:
99194
Component:
034000 service brakes, hydraulic:foundation components
Summary:
Information for servicing and diagnosing brake vibration, brake inspection, and brake friction material replacement. *tt
Bulletin:
99196
Component:
353600 equipment:air conditioner
Summary:
Information on identifying non-approved / alternate refrigerants which could cause safety, and performance concerns if installed in ford a/c systems. *tt
Bulletin:
99242
Component:
162300 structure:body:door
Summary:
Information on replacing and / or repairing malfunctioning (door, ignition and decklid) locks. *tt
Bulletin:
7100
Component:
103000 power train:automatic transmission
Summary:
Information regarding transmission trouble codes. *mjs
Bulletin:
98122
Component:
138000 visibility:defroster/defogger system
Summary:
Information on the defroster performance enhancement.
Bulletin:
98163
Component:
162300 structure:body:door
Summary:
Locks failed. yd
Bulletin:
981512
Component:
063100 engine and engine cooling:exhaust system:emission control
Summary:
A direct replacement part for the evaporative emission canister and bracket assembly. ak
Bulletin:
13412
Component:
103000 power train:automatic transmission
Summary:
Some vehicles may exhibit a condition of no 4x4 low range engagement or a stuck in 4x4 low range, with no (dtc) diagnostic trouble code stored in the gem. *tt
Bulletin:
98168
Component:
103000 power train:automatic transmission
Summary:
Transmission- e40d/4r100-1989-99-main controls, separator plates and separator plate gaskets usage chart. yd
Bulletin:
7353
Component:
103000 power train:automatic transmission
Summary:
Some vehicles may exhibit a condition of no 4x4 low range engagement or a stuck in 4x4 low range, with no diagnostic trouble codes stored in the gem module. *tt
Bulletin:
0015
Component:
103000 power train:automatic transmission
Summary:
Information regarding the new transmission cooler flusher- service tip. *mjs
Bulletin:
0038
Component:
103600 power train:automatic transmission:cooling unit and lines
Summary:
Vehicles may experience solid particle contaminants from prior transmission concerns or excess wear, may be trapped in the transmission fluid cooling system is not properly flushed, fluid in-line filter kit. *mjs
Bulletin:
13745
Component:
100000 power train
Summary:
Some vehicles may experience a condition of no 4 x 4 low range engagement or a stuck in 4 x 4 low range. *mjs
Bulletin:
00611
Component:
103100 power train:automatic transmission:control module (tcm, pcm)
Summary:
Some bi-fuel vehicles may require powertrain control module (pcm) replacement during service and may not run on cng or lpg., recalibration of the pcm/replacement. *mjs
Bulletin:
985A46
Component:
020000 suspension
Summary:
Some vehicles may exhibit a drift or pull to the left while braking. *tt
Bulletin:
12154
Component:
116300 electrical system:ignition:anti-theft controller
Summary:
Some vehicles equipped with pats (securilock) except certain models now have availability of fleet keys through rotunda. *mjs
Bulletin:
96711
Component:
102000 power train:manual transmission
Summary:
Some 4r70w transmissions were built with a unique case and require a spacer to be installed between the low / reverse servo cover and retaining ring. *tt
Bulletin:
96715
Component:
171100 latches/locks/linkages:doors:latch
Summary:
Subject regarding a new single key locksets installed on certain trial vehicles. *tt
Bulletin:
96727
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Experiencing a knocking noise when the engine is cold and under acceleration. *tt
Bulletin:
96728
Component:
101000 power train:clutch assembly
Summary:
Service tip information regarding the reverse clutch piston and piston seal usage. *tt
Bulletin:
985A12
Component:
354600 equipment:mechanical:wrecker and wheel lift devices
Summary:
Recommended guidelines for towing behind recreational vehicles. *tt
Bulletin:
00133
Component:
350000 equipment
Summary:
Some vehicles may exhibit a false high spark advance readings when using a new generator star (ngs) tester. *tt
Bulletin:
6242
Component:
106100 power train:axle assembly:banjo housing
Summary:
Experiencing a vibration and / or transmission extension housing bushing damage. *tt
Bulletin:
12725
Component:
106100 power train:axle assembly:banjo housing
Summary:
Some vehicles may exhibit a vibration and / or transmission extension housing bushing damage from sustained high speed operation. *tt
Bulletin:
13505
Component:
103400 power train:automatic transmission:lever and linkage:column shift
Summary:
All 4x4 vehicles with electronic shift onthe fly transfer cases will display contact plate pids opposite of the 1999 or earlier workshop manual indicates when using ngs with 15.0 level or later software. *tt
Bulletin:
99-8-15
Component:
162300 structure:body:door
Summary:
Subject regarding door trim panel replacement - service tip. *tt
Bulletin:
99111
Component:
980000 unknown or other
Summary:
Information designed to aid in the diagnosis, testing and repair of noise, vibration and harshness (nvh) concerns. *tt
Bulletin:
991210
Component:
980000 unknown or other
Summary:
Ford motor company has released a private labeled material to be used for iron particle / acid rain service repairs. *tt
Bulletin:
00239
Component:
110000 electrical system
Summary:
A condition may exist with possible electronc damage occuring to the compuvalve from voltage spikes between the compuvalve connections when connecting or disconnecting the main compuvalve harness c4025. *tt
Bulletin:
002310
Component:
103600 power train:automatic transmission:cooling unit and lines
Summary:
Subject regarding contamination from prior transmission concerns or excess wear may be trapped in the transmission fluid cooling system. *tt
Bulletin:
01156
Component:
138120 visibility:defroster/defogger system:windshield:heater core
Summary:
Some vehicles may exhibit heater core leaks. *slc
Bulletin:
01157
Component:
980000 unknown or other
Summary:
Information regarding transmission fluid usage charts. *slc
Bulletin:
15113
Component:
091100 fuel system, other:storage:tank assembly
Summary:
Some vehicles may exhibit a fuel fill valve sealing condition. *yd
Bulletin:
01181
Component:
103800 power train:automatic transmission:park/neutral start switch
Summary:
Brake shift interlock.*jb
Bulletin:
01214
Component:
180000 vehicle speed control
Summary:
Information to aid in diagnosis for clarification of lock-off solenoid and solenoid tank valve coil rsistances for bi-fuel vehicles. *tt
Bulletin:
01246
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Engine oil system priming procedures, service tips for reports of premature engine failure. *tt
Bulletin:
02105
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Some bi-fuel cang and lpg vehicles may exhibit a no start condition. *tt
Bulletin:
03102
Component:
070000 fuel system, gasoline
Summary:
Compressed natural gas (cng). rough idle or no start when cold. vehicles equipped with cng bi-fuel engine only. *tt
Bulletin:
03103
Component:
061000 engine and engine cooling:engine
Summary:
Vehicles without the coolant lock-off may exhibit a no start condition. *tt
Bulletin:
03148
Component:
103600 power train:automatic transmission:cooling unit and lines
Summary:
New transmission cooler flusher - service tips. 2003 escort and super duty f series included. *tt
Bulletin:
032125
Component:
114000 electrical system:wiring
Summary:
Aftermarket wiring alterations - service tip. *tt
Bulletin:
17777
Component:
022140 suspension:rear:springs:leaf spring assembly
Summary:
Rear leaf spring noise. *tt
Bulletin:
02176
Component:
032100 service brakes, hydraulic:switches:brake light
Summary:
Lamp-brake-invadvertent disabling of brake shift interlock. *mj

Home | Privacy