1996 CHEVROLET MONTE CARLO Recalls (3)
- Campaign:
- 96V122000 on 07/07/1996
- Component:
- Service brakes, hydraulic:power assist:vacuum
- Manufactured:
- 05/31/1996 - 05/31/1996
- Affected:
- 3,591
- Defect:
- These vehicles were assembled with one of the four brake booster tabs not properly located in the front of dash reinforcement assembly.
- Consequence:
- If this condition were present in a situation where stopping distances were small, a vehicle crash could occur.
- Correction:
- Dealers will inspect for proper booster installation. boosters found to be improperly located will be removed and reinstalled properly.
- Notes:
- System: brakes; hydraulic; power assist; booster. vehicle description: passenger vehicles. owner notification: owner notification is expected to begin in july 1996. note: owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact chevrolet at 1-800-222-1020. also contact the national highway traffic safety administration's auto safety hotline at 1-800-424-9393.
- Campaign:
- 01I014000 on 01/06/2002
- Component:
- Service brakes, hydraulic:foundation components
- Defect:
- This is not a safety recall in accordance with the safety act. however, it is deemed a safety improvement campaign by the agency. vehicle description: 1995-1999 chevrolet monte carlo z34 passenger vehicles. the braking performance in wet weather or wet road conditions is reduced more than a driver would expect.
- Consequence:
- The braking could feel delayed momentarily when light or moderate force is applied on the brake pedal while driving on wet roads or after going through a car wash.
- Correction:
- Dealer will modify the front fender liners to remove a portion of the closeout panels in the front wheel wells at no charge to the consumer. this service will be available through august 2004.
- Notes:
- Gm has decided to conduct a customer satisfaction campaign to modify the vehicle if an owner has experienced a greater than expected reduction or delay in braking on wet roads.owners can contact chevrolet at 1-800-222-1020, concerning this program.
- Campaign:
- 07E021000 on 03/11/2007
- Component:
- Fuel system, other:storage:tank assembly:pressure relief devices
- Affected:
- 742
- Defect:
- Certain delphi fuel pressure regulators, p/nos. fp10020-11b1, fp10026-11b1, and fp10027-11b1, sold after january 9, 2007, as aftermarket equipment for various passenger vehicles listed above. the universal pressure regulators (upr) were produced without an o'ring and retainer.
- Consequence:
- Fuel may leak, possibly resulting in a fire.
- Correction:
- Delphi will notify owners and replace the upr free of charge. the recall began on april 23, 2007. owners can contact delphi at 877-411-8770.
- Notes:
- This recall only pertains to aftermarket delphi fuel pressure regulators and has no relation to any original equipment installed by general motors.customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov.
1996 CHEVROLET MONTE CARLO TSBs (31)
- Bulletin:
- 577106A
- Component:
- 103000 power train:automatic transmission
- Summary:
- Cold start rattle noise. *tw
- Bulletin:
- 677164
- Component:
- 103000 power train:automatic transmission
- Summary:
- Intermittent neutral or loss of drive at highway speeds or from fourth gear (replace control valve body assembly). *tw
- Bulletin:
- 577106A
- Component:
- 105300 power train:driveline:driveshaft
- Summary:
- Cold start rattle noise (diagnosis/service procedure). *tw
- Bulletin:
- 736313
- Component:
- 070000 fuel system, gasoline
- Summary:
- Reduced engine performance, restricted fuel flow (clean fuel tank, replace in-line fuel filter and fuel pump strainer). *tw
- Bulletin:
- 676305
- Component:
- 183000 vehicle speed control:cables
- Summary:
- Difficult to depress accelerator pedal and/or accelerator cable separation (install accelerator cable and clip). *tw
- Bulletin:
- 549001A
- Component:
- 353400 equipment:electrical:radio/tape deck/cd etc.
- Summary:
- Cln indicator appears on radio display and does not turn off (reset cln indicator with the eject button on tape). *tw
- Bulletin:
- 970501736211
- Component:
- 062000 engine and engine cooling:cooling system
- Summary:
- Conditions containing engine overheating and/or loss of engine coolant. *yc
- Bulletin:
- 971101631041
- Component:
- 162300 structure:body:door
- Summary:
- Comments on inoperative power door locks (front and/or rear doors).
- Bulletin:
- 971101776304
- Component:
- 073000 fuel system, gasoline:fuel injection system
- Summary:
- Subject pertaining to driveability symptoms due to fuel injector deposits. *yc
- Bulletin:
- 9709013202B
- Component:
- 011000 steering:wheel and handle bar
- Summary:
- Experiencing intermittent steering column snap or click noise when turning. *yc
- Bulletin:
- 970801676305
- Component:
- 180000 vehicle speed control
- Summary:
- Some vehicles experience difficulties to depress accelerator pedal and/or an accelerator cable separation. *yc
- Bulletin:
- 970801735026
- Component:
- 036000 service brakes, hydraulic:antilock
- Summary:
- Comment that the abs light is on with diagnostic trouble codes (dtc's) 46 and 86 set as current or history. *yc
- Bulletin:
- 98776304A
- Component:
- 073200 fuel system, gasoline:fuel injection system:injectors
- Summary:
- Some vehicles may experience a driveability symptom of long or hard starts, chuggle, rough idle and light or intermittent misfire. *yc
- Bulletin:
- 990604005
- Component:
- 061100 engine and engine cooling:engine:gasoline
- Summary:
- Some owners may experience a driveability symptom of long or hard starts, chuggle, rough idle and light or intermittent misfire. *tt
- Bulletin:
- 99021
- Component:
- 116000 electrical system:ignition
- Summary:
- Subject regarding spark plug wire failure. *tt
- Bulletin:
- 99021
- Component:
- 116000 electrical system:ignition
- Summary:
- Subject regarding spark plug wire failure. *tt
- Bulletin:
- 990730030
- Component:
- 106000 power train:axle assembly
- Summary:
- Some vehicles equipped with hydra-matic 3t40, 4t60 or 4t60-e transxales may comment on a grinding and / or growling noise that is noticeable when in park on incline. *tt
- Bulletin:
- 876522
- Component:
- 330000 interior lighting
- Summary:
- A malfunction indicator lamp (mil) illuminating on the vehicle's instrument panel after a long deceleration with the transmission typically in the overdrive position. yd
- Bulletin:
- 876002A
- Component:
- 061100 engine and engine cooling:engine:gasoline
- Summary:
- Some v6 engines may, on a very infrequent basis, have an oil odor condition that is generally encountered after the engine's oil has been changed.typically the odor lasts approximately 1000 miles after the change of oil and then does not re
- Bulletin:
- 533307B
- Component:
- 020000 suspension
- Summary:
- Some vehicles may exhibit front suspension scrunch / popping type noise coming from the front of vehicle that is apparent during low speed turning maneuvers. *tt
- Bulletin:
- 990604005A
- Component:
- 061100 engine and engine cooling:engine:gasoline
- Summary:
- Some owners may comment on driveability symptons of long or hard starts, chuggle, rough idle and light or intermittent misfire due to clogged fuel injectors. *tt
- Bulletin:
- 990730030A
- Component:
- 106000 power train:axle assembly
- Summary:
- Owners of some vehicles equipped with hydra-matic 3t40, 4t60, 4t60-e or 4t65-e transaxles may comment on a grinding and / or growling noise that is noticeable when standing in park on a hill or slope with the engine running and the parking
- Bulletin:
- 010601010A
- Component:
- 061100 engine and engine cooling:engine:gasoline
- Summary:
- Subject regarding polymer service pistons. *tt
- Bulletin:
- 010601002A
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Revised piston pin removal / installation procedure. *tt
- Bulletin:
- 050604058
- Component:
- 180000 vehicle speed control
- Summary:
- Intermittent chuggle or fishbite on light acceleration or a highway speeds with no diagnostic trouble codes (dtcs). *tt
- Bulletin:
- 4615
- Component:
- 040000 service brakes, air
- Summary:
- Abs pump running when not needed. *nj
- Bulletin:
- PIP4723B
- Component:
- 118000 electrical system: software
- Summary:
- This preliminary information communicates to the dealer the process for downloading or updating operating software for the tire pressure monitor, active fuel injector tester, multi media tester, pico scope, gr8 starting/charging tester and
- Bulletin:
- PIC4696A
- Component:
- 353100 equipment:electrical:anti-theft devices
- Summary:
- This preliminary information communication provides information to the technician on how to unlock radios that are delco theftlock. technician will use the radio to get the scrambled code. technician will need to contact the radio unlock ce
- Bulletin:
- PIC4696B
- Component:
- 353100 equipment:electrical:anti-theft devices
- Summary:
- This preliminary information communication provides information to the technician on how to unlock radios that are delco theftlock. technician will use the radio to get the scrambled code. technician will need to contact the radio unlock ce
- Bulletin:
- 17-NA-073
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- This warranty administration bulletin provides policy information with the field action courtesy transportation policy.
- Bulletin:
- PIC4696C
- Component:
- 150000 seat belts
- Summary:
- This preliminary information communication provides information to the technician on how to unlock radios that are delco theftlock. technician will use the radio to get the scrambled code. technician will need to contact the radio unlock ce
Home | Privacy