1995 FORD F-250 Recalls (4)

Campaign:
96V064000 on 04/21/1996
Component:
Seats
Manufactured:
09/30/1993 - 03/31/1995
Affected:
31,000
Defect:
The wire harness for the power lumbar feature on the seat is underneath the front seat cushion support wires. the support wires on the driver seat can contact and damage the insulation harness resulting in a high resistance electrical short through the support wires.
Consequence:
Consequence of defect: over heating of the support wires could result, and melting, smoke, or possible igntion of the surrounding materials could occur.
Correction:
Dealers will inspect the seats on the affected vehicles. if no damage is found, the driver seat wire harness will be covered with a protective convolute tubing, wrapped with electrical tape and the harness will be rerouted. if damage is found, the wire harness will be replaced.
Notes:
System: interior; tracks and anchors; front seat; lumbar system. vehicle description: super cab pickup trucks equipped with an optional40/20/40 power front driver seat. note: owner notification should begin during the last week of may 1996. note: owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time, should contact ford at 1-800-392-3673. also contact the national highway traffic safety administration's auto safety hotline at 1-800-424-9393.
Campaign:
05V388000 on 09/06/2005
Component:
Vehicle speed control
Affected:
4,500,000
Defect:
On certain pickup trucks and sport utility vehicles equipped with speed control, the speed control deactivation switch may overheat, smoke, or burn.
Consequence:
A fire at the switch could occur.
Correction:
By letter dated september 12, 2005, owners were instructed to return their vehicles to their dealers to have the speed control deactivation switch disconnected. owners who have had their speed control deactivated are being notified that parts will be available and advised to make an appointment to reconnect the speed control beginning in february 2006. owners who did not have their speed control deactivated are being notified to have their system remedied beginning in february 2006. owners are urged to avail themselves of the free disconnect service as soon as possible because of the significant risk of fire. owners may contact ford at 1-800-392-3673. (note: also see recalls 05v017 and 06v286)
Notes:
Ford recall no. 05s28.customers may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov.
Campaign:
06E049000 on 06/04/2006
Component:
Exterior lighting
Affected:
27,176
Defect:
Certain ck motorsports combination headlights, clear corner, bumper, and side marker lights sold as replacement lamps for use on the passenger vehicles listed above. some combination lamps that are not equipped with amber side reflectors fail to conform to federal motor vehicle safety standard no. 108, lamps, reflective devices, and associated equipment.
Consequence:
Without the amber reflectors, the vehicle will be poorly illuminated, possibly resulting in a vehicle crash without warning.
Correction:
Ck motorsport will notify owners and replace the noncompliant lamps free of charge. the recall began on july 1, 2006. owners may contact ck motorsport at 1-909-610-7211.
Notes:
This recall only pertains to aftermarket replacement equipment and has no relation to any original equipment installed on vehicles manufactured by the vehicle manufacturers.for more information on the lamp model numbers, click on document search and view document titled "lamp model numbers."customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov.
Campaign:
06V286000 on 08/01/2006
Component:
Vehicle speed control
Affected:
1,200,000
Defect:
On certain trucks equipped with speed control, gasoline or natural gas engines, the speed control deactivation switch may overheat.
Consequence:
Overheating could result in smoke or burn and an underhood fire.
Correction:
Dealers will install a fused wiring harness into the speed control system free of charge. the recall began on august 7, 2006. owners may contact ford at 1-866-436-7332. (note: also see recalls 05v017 and 05v388)
Notes:
Ford recall no. 05s28.customers may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov.

1995 FORD F-250 TSBs (189)

Bulletin:
BC2893950401
Component:
103000 power train:automatic transmission
Summary:
new auxillary powertrain kit. *tw
Bulletin:
BC2922950401
Component:
162200 structure:body:bumpers
Summary:
revised mounting torque for bumpers. *tw
Bulletin:
BC2982950401
Component:
138000 visibility:defroster/defogger system
Summary:
whistle noise when temperature set at full heat and high blower. *tw
Bulletin:
BC4178950401
Component:
061000 engine and engine cooling:engine
Summary:
engines undergoing a running change to smaller diameter a/c compressor pulley. *tw
Bulletin:
95514
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
revised oil fill procedures. *tw
Bulletin:
95521
Component:
114100 electrical system:wiring:front underhood
Summary:
under hood wire harness may become chafed. *tw
Bulletin:
9568
Component:
061000 engine and engine cooling:engine
Summary:
revised oil pan gasket. *tw
Bulletin:
95613
Component:
073000 fuel system, gasoline:fuel injection system
Summary:
a no start or reduced power condition may occur intermittently on some vehicles. *tw
Bulletin:
95615
Component:
353600 equipment:air conditioner
Summary:
whistle noise from ac with controls on max a/c. *tw
Bulletin:
95616
Component:
062000 engine and engine cooling:cooling system
Summary:
cooling system - leaking radiator hose - upgraded hose clamps. *tw
Bulletin:
95617
Component:
061000 engine and engine cooling:engine
Summary:
early wear of fead tensioner pulley on vehicles with 5.0l/5.8l engines. *tw
Bulletin:
BC2621950503
Component:
062200 engine and engine cooling:cooling system:fan
Summary:
low fan speed at idle has been identified as a potential service issue. *tw
Bulletin:
BC2701950503
Component:
011000 steering:wheel and handle bar
Summary:
light clicking sensation or looseness as the steering wheel is turned. *tw
Bulletin:
9579
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
vehicles with 7.3l direct injection diesel engines may experience one or more of the following conditions: rough idle, stalling hesitation/stumble, loss/lack of power, poor fuel economy excessive oil consumption. *tw
Bulletin:
95710
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
some vehicles may exhibit a poor idle quality and/or low output after the engine returns to the idle speed. *tw
Bulletin:
95712
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
during highway deceleration or engine start-up, there may be a hooting noise coming from the engine compartment. *tw
Bulletin:
95716
Component:
138000 visibility:defroster/defogger system
Summary:
the a/c heater blower wheel may fracture on some vehicles due to ice formation in the blower housing. *tw
Bulletin:
95719
Component:
063000 engine and engine cooling:exhaust system
Summary:
green condensate or white smoke coming from exhaust pipe. *tw
Bulletin:
9585
Component:
221200 seats:front assembly:recliner
Summary:
a rattle from the split seat bench may be due to a loose or missing seat bushing. *tw
Bulletin:
9588
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
knocking noise on initial start-up. *tw
Bulletin:
9597
Component:
021000 suspension:front
Summary:
Unknown
Bulletin:
95912
Component:
111000 electrical system:battery
Summary:
Unknown
Bulletin:
95107
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
vehicles may exhibit a poor idle quality and/or low output after the engine returns to idle speed. *tw
Bulletin:
95108
Component:
073200 fuel system, gasoline:fuel injection system:injectors
Summary:
vehicles may be hard to start after the fuel injectors have been replaced. *tw
Bulletin:
951010
Component:
180000 vehicle speed control
Summary:
lack of accelerator control when moving off the idle position. *tw
Bulletin:
951013
Component:
034100 service brakes, hydraulic:foundation components:master cylinder
Summary:
brakes - hydraulic - hydromax brake reserevoir mounting bracket separation. *tw
Bulletin:
951015
Component:
063000 engine and engine cooling:exhaust system
Summary:
hydromounted cab - evaporative emission lines rubbing on the fender. *tw
Bulletin:
BC4336950705
Component:
021000 suspension:front
Summary:
front suspension clunk. *tw
Bulletin:
951112
Component:
103000 power train:automatic transmission
Summary:
revised design transmission rear case bushing. *tw
Bulletin:
BC4225
Component:
061000 engine and engine cooling:engine
Summary:
Unknown
Bulletin:
BC1351950906
Component:
073200 fuel system, gasoline:fuel injection system:injectors
Summary:
rough idle or miss may be due to loose injector hold down bolt. *tw
Bulletin:
BC4369950906
Component:
021300 suspension:front:shock absorber
Summary:
4x4 trucks produced at michigan truck plant between may 15 and june 6, 1995 may exhibit a front suspension clunk or rattle. *tw
Bulletin:
BC1432995090
Component:
061000 engine and engine cooling:engine
Summary:
engine moan at approximately 1900 rpm due to the flywheel dampening of engine pulses. *tw
Bulletin:
951616
Component:
353600 equipment:air conditioner
Summary:
air conditioning-lack of cooling at idle-a/c system shuts off due to high system pressures-7.3l di turbo f-series built before 4/14/95 and 7.3l di turbo econolines built before 4/21/95. *sd
Bulletin:
951713
Component:
112000 electrical system:alternator/generator/regulator
Summary:
generator-motorcraft 95amp-front bearing concern-fd1060/1460 engines- vehicles built before 7/3/95. *sd
Bulletin:
951714
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
engine- 'knocking' noise - when operating engine at 200-2300 rpm - fd1460 engine
Bulletin:
BC0131960102
Component:
106000 power train:axle assembly
Summary:
4x4 front axles must use hypoid 4x4 gear oil p/n f1tz-19580-a & high temp 4x4 front axle & wheel bearing grease when servicing. it is not recommended to use heavier weight lubes in these front axles.
Bulletin:
951914
Component:
103000 power train:automatic transmission
Summary:
some e4od transmissions w/ build dates 5b03 (feb. 3, 1995) and 5e31 (may 31, 1995) may have a valve, in the pump, that restricts fluid flow (fig 1). this valve may become stuck in the valve bore and restrict lubrication. symptoms may inclu
Bulletin:
95212
Component:
036000 service brakes, hydraulic:antilock
Summary:
the use of petroleum-based grease as a lubricant in servicing disc brakes is no longer acceptable because it may be incompatible with the rubber material used in the disc brake system. if petroleum-based grease is used to lubricate any par
Bulletin:
212395
Component:
103000 power train:automatic transmission
Summary:
bulletin applies to vehicles equipped w/ a 31th transaxle. transaxle slips momentarily (engine rpm increases/flares) during light throttle 2-3 upshifts.
Bulletin:
BC0678961025
Component:
102000 power train:manual transmission
Summary:
Information on aode/4r7w transmission main control & case replacement. *tt
Bulletin:
BC0682961024
Component:
105300 power train:driveline:driveshaft
Summary:
Vehicles may exhibit a driveline vibration or noise while driving at highway speeds on steady cruise or decel. *tt
Bulletin:
BC0820961010
Component:
103000 power train:automatic transmission
Summary:
Revised eec calibration has been incorporated in pcm calibrations for vehicles which display lack of power due to torque converter engagement scheduling, catalytic converter failures, rough idle or hard start on hot restart. *tt
Bulletin:
BC0844961008
Component:
102000 power train:manual transmission
Summary:
E4od trans may emit a tick/rattle noise when driving at light loads in 1st gear at 1100 to 1800 rpm rpm. *tt
Bulletin:
BC0883961004
Component:
063200 engine and engine cooling:exhaust system:manifold/header/muffler/tail pipe
Summary:
Vehicles may exhibit an exhaust leak &/or noise due to warped exhaust manifolds. *tt
Bulletin:
BC0321961101
Component:
021000 suspension:front
Summary:
Pop/clunk from steering linkage over bumps. *tw
Bulletin:
96246
Component:
114000 electrical system:wiring
Summary:
Wiring - electrical diode identification and service replacements. *tw
Bulletin:
96249
Component:
103700 power train:automatic transmission:torque converter
Summary:
Torque converter - leak test procedure - service tip. *tw
Bulletin:
962412
Component:
051120 parking brake:conventional:mechanical:linkage and cable
Summary:
Brakes - rear parking brake cable binds - vehicles built before 8/20/96 - all chassis cab vehicles are excluded. *tw
Bulletin:
96221
Component:
131000 visibility:windshield
Summary:
Windshield and interior glass - fog/film. *tw
Bulletin:
96222
Component:
034000 service brakes, hydraulic:foundation components
Summary:
Brakes - elimination of sanding rotors and drums - service tip. *tw
Bulletin:
96223
Component:
185000 vehicle speed control:cruise control
Summary:
Long crank - sticking idle air control (iac) valve - vehicles built from 11/1/94 through 3/30/96 -stall - after starting when engine allowed to soak from 1-4 hours - sticking idle air control (iac) valve. *tw
Bulletin:
96226
Component:
353600 equipment:air conditioner
Summary:
Air conditioning - compressor failure - insufficient amount of refrigerant oil. *tw
Bulletin:
962211
Component:
075000 fuel system, gasoline:carburetor system
Summary:
Air cleaner - damaged air filter in severe dusty conditions - vehicles with 7.3l dit diesel engine built through 5/8/96 - service tip. *tw
Bulletin:
962212
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Engine compartment noise - buzzing or knocking - right front of engine - after starting - 4.9l engines - f series built from 8/1/94 through 10/15/95 - econolines built from 8/15/94 through 10/15/95. *tw
Bulletin:
962213
Component:
063200 engine and engine cooling:exhaust system:manifold/header/muffler/tail pipe
Summary:
Exhaust - exhaust leak at exhaust manifolds - vehicles equipped with 7.0l or 7.5l engine. *tw
Bulletin:
962511
Component:
116200 electrical system:ignition:module
Summary:
Powertrain control module -reprogram powertrain control module (pcm) - service procedures - service tip. *tw
Bulletin:
962519
Component:
034100 service brakes, hydraulic:foundation components:master cylinder
Summary:
Brakes - high brake pedal travel or low brake pedal feel. *tw
Bulletin:
962612
Component:
103700 power train:automatic transmission:torque converter
Summary:
Transaxle - torque converter replacement guidelines and torque converter/transaxle cooling system cleaning procedures - service tip. *tw
Bulletin:
962620
Component:
107000 power train:axle hubs
Summary:
Noise - ratcheting - front axle - 4x4 - self engagement of automatic hub locks. *tw
Bulletin:
962621
Component:
103700 power train:automatic transmission:torque converter
Summary:
Vibration- driveline resonance/vibration between 1400 and 2000 rpm with converter clutch engaged during medium to heavy throttle conditions- vehicles with 7.3l di turbo engine and transmission built prior to 11/13/95 (5l13) transmission- e4
Bulletin:
BC0053970201
Component:
103000 power train:automatic transmission
Summary:
Some 1995 and all 1996 and 1997 vehicles with e40d transmissions have been built with a reusable elastomeric transmission fluid pan gasket. *jd
Bulletin:
BC0321970201
Component:
017500 steering:linkages:tie rod assembly
Summary:
Pop/clunk from steering linkage over bumps. *jd
Bulletin:
BC1015397020
Component:
103000 power train:automatic transmission
Summary:
Vehicles with e4od transmissions have been built with a reusable elastomeric transmission fluid pan gasket. *jd
Bulletin:
97114
Component:
061000 engine and engine cooling:engine
Summary:
Engine compartment noise-"buzzing or knocking"- right front of engine-after starting. *jd
Bulletin:
97215
Component:
980000 unknown or other
Summary:
Diagnostic guides for out-of-warranty vehicles to be used as a master copy - diagnostic guides no longer available from adistra. *tw
Bulletin:
97216
Component:
061000 engine and engine cooling:engine
Summary:
Leak - oil leakat engine valley pan and/or high pressure oil pump - vehicles equipped with 7.3l diesel engine. *tw
Bulletin:
BC0053972301
Component:
104000 power train:transfer case (4-wheel drive)
Summary:
Some 1995 and all 1996 and 1997 vehicles with e4od transmissions have been built with a reusable elastomeric transmission fluid pan gasket. *jd
Bulletin:
BC0321972301
Component:
017100 steering:linkages:link:drag:connection
Summary:
Pop/clunk from steering linkage over bumps. *jd
Bulletin:
BC3363972301
Component:
116200 electrical system:ignition:module
Summary:
The ngs displays incorrect date for the ing gem pid on the vehicles. *jd
Bulletin:
BC3520972301
Component:
102000 power train:manual transmission
Summary:
High shift efforts on manual transmission. *jd
Bulletin:
BC1017297230
Component:
102000 power train:manual transmission
Summary:
High shift efforts on manual transmission. *jd
Bulletin:
BC1022797230
Component:
116200 electrical system:ignition:module
Summary:
The ngs displays incorrect data for the ign gem pid on the vehicles. *jd
Bulletin:
97310
Component:
021242 suspension:front:springs:leaf spring assembly:hanger,bracket
Summary:
Noise- "popping/creaking"- front frame or suspension brackets- frame- "popping/creaking"- fastener replacement. *jd
Bulletin:
9747
Component:
160000 structure
Summary:
Frame- rivet replacement with bolts- service tips. *jd
Bulletin:
9748
Component:
061110 engine and engine cooling:engine:gasoline:belts and associated pulleys
Summary:
Accessory drive belts- fead belt comes off- vehicles with 4.9l engine. *jd
Bulletin:
BC3130970221
Component:
061200 engine and engine cooling:engine:diesel
Summary:
Diesel exhaust smell in passenger cabin may be due to poor connection at the inlet or outlet to/from the turbo. *tw
Bulletin:
BC3241970210
Component:
063200 engine and engine cooling:exhaust system:manifold/header/muffler/tail pipe
Summary:
Exhaust leaks or noise at the joint between the y-pipe and the exhaust manifold. *tw
Bulletin:
BC3287970206
Component:
101100 power train:clutch assembly:pedal/linkage
Summary:
The clutch may be hard to depress due to dust/contamination entering the slave cylinder. *tw
Bulletin:
9778
Component:
121000 exterior lighting:headlights
Summary:
Headlamp- headlamp housing melts- ambulance and emergency vehicles only. *jd
Bulletin:
9779
Component:
114100 electrical system:wiring:front underhood
Summary:
Wiring- aftermarket wiring alterations- service tip. *jd
Bulletin:
97511
Component:
103000 power train:automatic transmission
Summary:
Fluid- transmission fluid usage charts. *jd
Bulletin:
9768
Component:
980000 unknown or other
Summary:
Fuel economy- customer expectations versus vehicle usage. *jd
Bulletin:
97618
Component:
061000 engine and engine cooling:engine
Summary:
Low rpm- 7.3l dit engine fails to start- code 340 stored in memory and/or engine fails to achieve rated speed for 2-3 minutes after extended cold soak- f-series built through 2/9/96 and all econolines. *jd
Bulletin:
97627
Component:
021700 suspension:front:hub
Summary:
Noise- "ratcheting"- front axle- 4x4- self-engagement of automatic hub locks- f-250 and f-350 over 8500# gvw. *jd
Bulletin:
97628
Component:
021700 suspension:front:hub
Summary:
Noise- "ratcheting"- front axle- 4x4- self-engagement of automatic hub locks- bronco, f-150 and f-250 under 8500# gvw. *jd
Bulletin:
BC2297970501
Component:
075000 fuel system, gasoline:carburetor system
Summary:
When the air cleaner is being replaced, the drain mechanism on the bottom of the air cleaner case is to be cleaned of obstructions. *tw
Bulletin:
BC2301970501
Component:
102000 power train:manual transmission
Summary:
New clutch slave cylinder with a redesigned lip seal. *tw
Bulletin:
97050110621
Component:
500000 child seat
Summary:
Part number information for the use of a child seat tether. *tw
Bulletin:
97111097238
Component:
030000 service brakes, hydraulic
Summary:
Subject on rear vibration/shudder when applying brakes. *yc
Bulletin:
985A5
Component:
034530 service brakes, hydraulic:foundation components:disc:rotor
Summary:
Hub-mount brake rotor machining equipment from rotunda is now approved for warranty and service use. *yc
Bulletin:
985A11
Component:
034000 service brakes, hydraulic:foundation components
Summary:
Service tip information regarding elimination of sanding rotors and drums. *yc
Bulletin:
985A13
Component:
034500 service brakes, hydraulic:foundation components:disc
Summary:
The use of petroleum-based grease as a lubricant in servicing disc brakes is no longer acceptable. *yc
Bulletin:
985A25
Component:
034000 service brakes, hydraulic:foundation components
Summary:
A vibration or shudder may be felt during braking on some vehicles. *yc
Bulletin:
985A34
Component:
031000 service brakes, hydraulic:pedals and linkages
Summary:
Some vehicles brake pedal may feel low or there may be long brake pedal travel. *yc
Bulletin:
985A35
Component:
051120 parking brake:conventional:mechanical:linkage and cable
Summary:
The rear parking brake cables may bind and not allow the rear brake shoes to return fully to the anchor pins after the parking brake is applied. *yc
Bulletin:
9888
Component:
103000 power train:automatic transmission
Summary:
Information on a new transmission fluid usage chart. *yc
Bulletin:
9845
Component:
045300 service brakes, air:disc:rotor
Summary:
Availability of hub-mount brake rotor machining equipment. *yc
Bulletin:
98413
Component:
034000 service brakes, hydraulic:foundation components
Summary:
A grabbing condition and / or squeal noise from the rear brakes during first few brake applications after rainfall and / or while brakes are cold. *tt
Bulletin:
98419
Component:
980000 unknown or other
Summary:
Some vehicles may exhibit a flashing transmission control indicator lamp (tcil) and diagnostic trouble codes (dtcs) 62,628, and/or 1728. *yc
Bulletin:
9852
Component:
190000 tires
Summary:
Information on tire company telephone numbers for customer assistance. *yc
Bulletin:
9864
Component:
063000 engine and engine cooling:exhaust system
Summary:
Information on a buzzing or rattle noise from the exhaust system. *tt
Bulletin:
980298
Component:
980000 unknown or other
Summary:
Information regarding the hotline survey. *yc
Bulletin:
980323
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Concerns with external oil leaks. *yc
Bulletin:
982740
Component:
061000 engine and engine cooling:engine
Summary:
Concerns with high pressure oil pumps are not serviceable. *yc
Bulletin:
982010
Component:
063000 engine and engine cooling:exhaust system
Summary:
Experiencing a " buzzing " or " rattling " noise from the exhaust system. *yc
Bulletin:
982310
Component:
063100 engine and engine cooling:exhaust system:emission control
Summary:
Mass air flow (maf)- sensor contamination- service tip. *ak
Bulletin:
982313
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Some vehicles with a 7.3l direct injection (di) turbo diesel engine, one or more of the following concerns may be present: rough idle, stalling, hesitation/ stumble, loss / lack of power, poor fuel economy, and excessive oil consumption.
Bulletin:
982314
Component:
061110 engine and engine cooling:engine:gasoline:belts and associated pulleys
Summary:
Premature wear of the belt tensioner may occur on some vehicles. *yc
Bulletin:
98246
Component:
110000 electrical system
Summary:
Ford motor company has released a new electrical grease ( f8az - 19g208-aa ) to reduce the possibility of moisture corrosion at the terminals. *yc
Bulletin:
9943
Component:
100000 power train
Summary:
Information regarding reprogramming powertrain control modules (pcms). *tt
Bulletin:
98122
Component:
138000 visibility:defroster/defogger system
Summary:
Performance enhancement for defroster. *tt
Bulletin:
99816
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Ford motor company now recommends sae 5w-30 viscosity grade for servicing any ford gasoline-powered vehicle regardless of model year. *tt
Bulletin:
99129
Component:
353400 equipment:electrical:radio/tape deck/cd etc.
Summary:
Experiencing a whine / buzz type noise in the speakers of the entertainment radio or two-way radio on vehicles with an in-tank electric fuel pump. *tt
Bulletin:
99139
Component:
125000 exterior lighting:brake lights
Summary:
Conditions with the brake lamps inadvertently disabling the brake shift interlock. *tt
Bulletin:
12905
Component:
106000 power train:axle assembly
Summary:
Some vehicles may experience axle wind up and / or clunking, popping, ratcheting type noises when making cornering maneuvers on vehicles equipped with a four wheel drive hi or low range mode. *tt
Bulletin:
983074
Component:
106000 power train:axle assembly
Summary:
Concerns with axle wind-up and / or clunking, popping, ratcheting type noises when making cornering maneuvers. *tt
Bulletin:
9811335
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Exhibiting a vibration, noise or ground out condition when turning or under load. *tt
Bulletin:
983564
Component:
030000 service brakes, hydraulic
Summary:
Experiencing a squealing noise from the front brakes when applying the brakes on some vehicles. *tt
Bulletin:
99222
Component:
114000 electrical system:wiring
Summary:
Subject on a wire harness terminal repair kit available for repairing electrical wiring harnesses. *tt
Bulletin:
99194
Component:
034000 service brakes, hydraulic:foundation components
Summary:
Information for servicing and diagnosing brake vibration, brake inspection, and brake friction material replacement. *tt
Bulletin:
99196
Component:
353600 equipment:air conditioner
Summary:
Information on identifying non-approved / alternate refrigerants which could cause safety, and performance concerns if installed in ford a/c systems. *tt
Bulletin:
98122
Component:
138000 visibility:defroster/defogger system
Summary:
Information on the defroster performance enhancement.
Bulletin:
98158
Component:
021000 suspension:front
Summary:
Front end shimmy may occur at various driving speeds and is usually induced when hitting bumps, such as large potholes or rough railroad crossings. shimmy is not always verified during road test. *ak
Bulletin:
13412
Component:
103000 power train:automatic transmission
Summary:
Some vehicles may exhibit a condition of no 4x4 low range engagement or a stuck in 4x4 low range, with no (dtc) diagnostic trouble code stored in the gem. *tt
Bulletin:
98168
Component:
103000 power train:automatic transmission
Summary:
Transmission- e40d/4r100-1989-99-main controls, separator plates and separator plate gaskets usage chart. yd
Bulletin:
7353
Component:
103000 power train:automatic transmission
Summary:
Some vehicles may exhibit a condition of no 4x4 low range engagement or a stuck in 4x4 low range, with no diagnostic trouble codes stored in the gem module. *tt
Bulletin:
0015
Component:
103000 power train:automatic transmission
Summary:
Information regarding the new transmission cooler flusher- service tip. *mjs
Bulletin:
0038
Component:
103600 power train:automatic transmission:cooling unit and lines
Summary:
Vehicles may experience solid particle contaminants from prior transmission concerns or excess wear, may be trapped in the transmission fluid cooling system is not properly flushed, fluid in-line filter kit. *mjs
Bulletin:
13745
Component:
100000 power train
Summary:
Some vehicles may experience a condition of no 4 x 4 low range engagement or a stuck in 4 x 4 low range. *mjs
Bulletin:
985042
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Repeat message regarding vehicles exhibiting rough idle / miss condition. *tt
Bulletin:
5046
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Repeat message regarding vehicles exhibiting a lack of power. *tt
Bulletin:
5047
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Repeat message regarding a hard start / no start condition. *tt
Bulletin:
985058
Component:
061000 engine and engine cooling:engine
Summary:
Subject regarding external oil leaks - repeat message. *tt
Bulletin:
96718
Component:
034000 service brakes, hydraulic:foundation components
Summary:
Subject regarding on-vehicle caliper-mounted brake rotor machining accessories from rotunda, for certain vehicles, are now available for service use. *tt
Bulletin:
96727
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Experiencing a knocking noise when the engine is cold and under acceleration. *tt
Bulletin:
96728
Component:
101000 power train:clutch assembly
Summary:
Service tip information regarding the reverse clutch piston and piston seal usage. *tt
Bulletin:
985A12
Component:
354600 equipment:mechanical:wrecker and wheel lift devices
Summary:
Recommended guidelines for towing behind recreational vehicles. *tt
Bulletin:
9803000
Component:
980000 unknown or other
Summary:
Hotline contact id number on oasis. a nine digit contact number is attached to the oasis information when a vin and symptom code is entered into oasis. *yc
Bulletin:
980312
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Excessive white smoke. verify glow plug operation by performing glow plug system operation check on the hard start/no start diagnostic sheet. *tt
Bulletin:
980325
Component:
061000 engine and engine cooling:engine
Summary:
Cold engine upper knock/tick. *yc
Bulletin:
98-4722
Component:
185000 vehicle speed control:cruise control
Summary:
Repeat message, no change- rough idle/miss. *ak
Bulletin:
98-4726
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Repeat message, no change: hard start/ no start. *ak
Bulletin:
98-4734
Component:
061120 engine and engine cooling:engine:gasoline:turbo-charger
Summary:
Lack of power due to failure of engine turbo boost
Bulletin:
98-4742
Component:
116000 electrical system:ignition
Summary:
Vehicle stalls upon acceleration. *ak
Bulletin:
13505
Component:
103400 power train:automatic transmission:lever and linkage:column shift
Summary:
All 4x4 vehicles with electronic shift onthe fly transfer cases will display contact plate pids opposite of the 1999 or earlier workshop manual indicates when using ngs with 15.0 level or later software. *tt
Bulletin:
985A23
Component:
034000 service brakes, hydraulic:foundation components
Summary:
A comprehensive pull and drift diagnostic procedure has been developed to assist technicians in helping to resolve pull or drift conditions. *tt
Bulletin:
985A32
Component:
034510 service brakes, hydraulic:foundation components:disc:caliper
Summary:
Procedures on caliper-mount lathe machining setup. *yc
Bulletin:
4614
Component:
185000 vehicle speed control:cruise control
Summary:
Information on vehicles exhibiting rough idle / miss. *tt
Bulletin:
4616
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Brief information vehicles exhibiting hard start / no start condition. *tt
Bulletin:
4617
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Brief information on vehicles exhibiting lack of power condition. *tt
Bulletin:
4625
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Brief information on vehicles exhibiting a stall on deceleration condition. *tt
Bulletin:
4629
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Brief information concern vehicles exhbiting external oil leaks. *tt
Bulletin:
4633
Component:
034000 service brakes, hydraulic:foundation components
Summary:
Rear brake drag or excessive wear on rear brakes. *tt
Bulletin:
99-8-15
Component:
162300 structure:body:door
Summary:
Subject regarding door trim panel replacement - service tip. *tt
Bulletin:
99111
Component:
980000 unknown or other
Summary:
Information designed to aid in the diagnosis, testing and repair of noise, vibration and harshness (nvh) concerns. *tt
Bulletin:
99152
Component:
103000 power train:automatic transmission
Summary:
Information on the new flush and fill tool available through rotunda. *tt
Bulletin:
5250
Component:
185000 vehicle speed control:cruise control
Summary:
Information on super duty models with 7.3l diesel engines exhibiting rough idle / miss condition. *tt
Bulletin:
5251
Component:
103400 power train:automatic transmission:lever and linkage:column shift
Summary:
Some super duty vehicles with 7.3l dit diesel engines may exhibit 4x4 lights on, 4x4 inoperative and / or multiple gem codes. *tt
Bulletin:
5254
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Information on super duty 7.3 dit diesel engine vehicles exhibiti lack of power. *tt
Bulletin:
5262
Component:
180000 vehicle speed control
Summary:
Service information for vehicles exhibiting stall on deceleration condition. *tt
Bulletin:
980307
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Vehicle stalls/quits while driving. *ak
Bulletin:
980323
Component:
073000 fuel system, gasoline:fuel injection system
Summary:
Dtc's p1211/1212 icp pressure higher/lower than expected.
Bulletin:
00239
Component:
110000 electrical system
Summary:
A condition may exist with possible electronc damage occuring to the compuvalve from voltage spikes between the compuvalve connections when connecting or disconnecting the main compuvalve harness c4025. *tt
Bulletin:
14455
Component:
061000 engine and engine cooling:engine
Summary:
Oil leak from the front or rear cylinder head oil supply rail end plugs. *tt
Bulletin:
002310
Component:
103600 power train:automatic transmission:cooling unit and lines
Summary:
Subject regarding contamination from prior transmission concerns or excess wear may be trapped in the transmission fluid cooling system. *tt
Bulletin:
01181
Component:
103800 power train:automatic transmission:park/neutral start switch
Summary:
Brake shift interlock.*jb
Bulletin:
01246
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Engine oil system priming procedures, service tips for reports of premature engine failure. *tt
Bulletin:
03148
Component:
103600 power train:automatic transmission:cooling unit and lines
Summary:
New transmission cooler flusher - service tips. 2003 escort and super duty f series included. *tt
Bulletin:
03213
Component:
061120 engine and engine cooling:engine:gasoline:turbo-charger
Summary:
A no-start or reduced power condition may occur intermittently. *tt
Bulletin:
03214
Component:
061000 engine and engine cooling:engine
Summary:
Poor idle quality and/or low output after the engine returns to idle speed. *tt
Bulletin:
03215
Component:
061000 engine and engine cooling:engine
Summary:
Hard starting after the fuel injectors have been replaced. *tt
Bulletin:
03216
Component:
181000 vehicle speed control:accelerator pedal
Summary:
A lack of accelerator control when moving off of the idle position. *tt
Bulletin:
03217
Component:
061000 engine and engine cooling:engine
Summary:
Rear of engine oil pan, near the crankshaft, may leak oil. *tt
Bulletin:
03218
Component:
090000 fuel system, other
Summary:
The water-in-fuel lamp may stay on and the fuel may be slow to drain or not drain at all when the fuel drain valve is opened. *tt
Bulletin:
03219
Component:
061000 engine and engine cooling:engine
Summary:
Availability of new sealant for servicing 7.3l di turbo engine. *tt
Bulletin:
032110
Component:
061000 engine and engine cooling:engine
Summary:
Hard or no start, hesitation, idle rough, low power, misses, stalls. *tt
Bulletin:
032111
Component:
061000 engine and engine cooling:engine
Summary:
No start/hard start and/or long crank time for vehicles with 7.3l di turbo diesel. *tt
Bulletin:
032112
Component:
100000 power train
Summary:
On vehicles with transmission build dates prior to 9/20/95, the overdrive cancel lamp may be illuminating and diagnostic trouble code (dtc) p1728 present and/or engine stall when reverse and/or manual low is selected. *tt
Bulletin:
032114
Component:
061110 engine and engine cooling:engine:gasoline:belts and associated pulleys
Summary:
The front end accessory drive (fead) belt may wear, shred and/or come off during deceleration. *tt
Bulletin:
032117
Component:
061000 engine and engine cooling:engine
Summary:
The air cleaner element may allow dust to bypass due to the air cleaner element collapsing/distorting under severe dust conditions. *tt
Bulletin:
032118
Component:
100000 power train
Summary:
Driveline resonance/vibration between 1400 and 2000 rpm with the torque converter clutch engaged on vehicles with transmissions built prior to 11/13/95 (5l13). *tt
Bulletin:
032121
Component:
061000 engine and engine cooling:engine
Summary:
A high number of high pressure rexroth pumps and injection pressure regulators (ipr) are being replaced due to oil leaking, when all that is required is a new gasket or seal on either the pump or ipr. *tt
Bulletin:
032123
Component:
061000 engine and engine cooling:engine
Summary:
Low rpm, no start, runs poorly, stall. 7.3l dit engine. *tt
Bulletin:
032125
Component:
114000 electrical system:wiring
Summary:
Aftermarket wiring alterations - service tip. *tt
Bulletin:
032127
Component:
090000 fuel system, other
Summary:
Lack of power and/or low performance condition caused by no return fuel flow to the fuel tank. *tt
Bulletin:
16515
Component:
010000 steering
Summary:
Oil leak at high pressure pump fittings and/or plug. this includes super duty f-series. oasis. *tt
Bulletin:
17571
Component:
110000 electrical system
Summary:
Malfunction indicator lamp (mil) on with diagnostic trouble codes p0603 (powertrain control module keep alive memory error) or p0605 ( powertrain control module read only memory error). *tt
Bulletin:
02176
Component:
032100 service brakes, hydraulic:switches:brake light
Summary:
Lamp-brake-invadvertent disabling of brake shift interlock. *mj

Home | Privacy