1995 FORD CROWN VICTORIA Recalls (12)

Campaign:
95E006002 on 02/27/1995
Component:
Air bags:frontal
Manufactured:
12/31/1994 - 01/31/1995
Affected:
8,600
Defect:
The passenger side air bag has an inflator body that cracked during forming of the curl that retains the igniter plug in the end of the inflator. also the igniter end cap can separate from the inflator.
Consequence:
The passenger side air bag may not inflate properly resulting in reduced occupant protection in a vehicle accident. if the igniter end cap separates in a frontal collision, hot gases can be released and ignite flammable material or cause burn injuries.
Correction:
Dealers will remove and replace the passenger side air bag module.
Notes:
System: interior; passive restraints; air bag; passenger. vehicle description: passenger side air bag in passenger cars, vans andmulti-purpose vehicles. note: if your vehicle is presented to an authorized dealer on an agreed upon service date and the remedy is not provided free of charge within a reasonable time, contact ford at 1-800-392-3673. also contact the national highway traffic safety administration's auto safety hotline at 1-800-424-9393.
Campaign:
95V063000 on 03/30/1995
Component:
Fuel system, gasoline:storage:tank assembly:filler pipe and cap
Manufactured:
05/31/1994 - 11/30/1994
Affected:
100,000
Defect:
The seal material between the fuel filler pipe and fuel tank may not have been fully cured during the molding process which could allow for fuel leakage.
Consequence:
Fuel leakage could result in a vehicle fire if an ignition source were present.
Correction:
Dealers will replace the fuel filler pipe-to-fuel tank seal with a new seal of different material.
Notes:
System: fuel; fuel tank assembly; pipe; filler; neck.vehicle description: passenger vehicles.note: if your vehicle is presented to an authorized dealer on an agreed upon service date and the remedy is not provided free of charge within a reasonable time, please contact ford at 1-800-392-3673. also contact the national highway traffic safety administration's auto safety hotline at 1-800-424-9393.
Campaign:
95V189000 on 10/03/1995
Component:
Electrical system:fuses and circuit breakers
Manufactured:
07/31/1994 - 10/31/1994
Affected:
45,000
Defect:
These vehicles were built with the non-cycling power window circuit breaker and the cycling headlamp circuit breaker interchanged.
Consequence:
In the event of a short or overload in the headlampcircuit, both headlamps can go out without warning, rather than flashing as intended with the cycling circuit breaker. this could lead to reduced night time driver visibility, increasing the potential for a vehicle accident.
Correction:
Dealers will inspect these vehicles, remove the circuit breaker and reinstall the breaker in the correct locations.
Notes:
System: electrical; fuse and recepticle; circuit breaker.vehicle description: passenger vehicles.note: owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact ford at 1-800-392-3673. also contact the national highway traffic safety administration's auto safety hotline at 1-800-424-9393.
Campaign:
96V045000 on 03/11/1996
Component:
Seat belts:front:anchorage
Manufactured:
07/31/1994 - 09/30/1994
Affected:
49,000
Defect:
The rivets holding the rear outboard belt d-rings were not heat treated properly causing the heads of the rivets to fracture under load and fail to hold the d-rings to the straps. this does not conform to the requirements of fmvss no. 210, "seat belt assembly anchorages."
Consequence:
Consequence of non-compliance: this condition can reduce the restraining capabilities of the safety belt in the event of an accident.
Correction:
Dealers will install a reinforcement plate on the rear outboard seat belt assembly anchorages involved in this campaign.
Notes:
System: interior; restraint; belt anchor and attachment; fmvss no. 210.vehicle description: passenger vehicles.note: owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time, should contact ford at 1-800-392-3673. also contact the national highway traffic safety administration's auto safety hotline at 1-800-424-9393.
Campaign:
96V135000 on 07/17/1996
Component:
Steering:linkages
Manufactured:
07/31/1994 - 03/31/1996
Affected:
72,000
Defect:
The pitman arms were not fully lubricated at the assembly plant. the "ball joint" at the outer end of the pitman arm can become contaminated and corrode.
Consequence:
Such corrosion can result in abnormal wear of the joint, resulting in separation of the joint. loss of steering control can occur increasing the risk of a vehicle accident.
Correction:
Dealers will inspect the vehicles and if the joint is found to have significant wear, the arm will be replaced. those pitman arms not replaced will have the "ball joint" fully greased.
Notes:
System: steering; linkages; arm; pitman. vehicle description: police interceptors, commercial fleet, taxi, limousines, or livery/trailer tow packages. owner notification: owner notification is expected to begin august 19, 1996. note: owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact ford at 1-800-392-3673. also contact the national highway traffic safety administration's auto safety hotline at 1-800-424-9393.
Campaign:
97V024000 on 03/24/1997
Component:
Latches/locks/linkages:hood:latch
Manufactured:
02/28/1991 - 10/06/1996
Affected:
125,000
Defect:
Vehicle description: police and taxi vehicles. the hood latch striker can wear or become detached from the hood.
Consequence:
Either of these conditions can result in the hood opening without warning while the vehicle is being operated impairing the driver's visibility.
Correction:
Dealers will install an improved hood latch striker (vehicles with 1992 model hoods) or revised striker plate attaching fasteners (vehicles with 1993-1997 model hoods).
Notes:
Owner notification:owner notification is expected to begin april 14, 1997. note:owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact ford at 1-800-392-3673.also contact the national highway traffic safety administration's auto safety hotline at 1-800-424-9393.
Campaign:
98I001000 on 06/04/1998
Component:
Service brakes, hydraulic:foundation components:hoses, lines/piping, and fittings
Affected:
167,742
Defect:
This is not a safety recall in accordance with federal regulation 573. however, it is deemed a safety improvement campaign by the agency. ford is initiating an owner notification program for owners of certain 1995-1997 crown victoria model vehicles with police, taxi, and commercial fleet packages and town car vehicles with the livery package. these vehicles may have insufficient clearance between the brake line and the underbody front floor pan assembly which could cause wear of the brake lines.
Consequence:
This could lead to brake fluid loss for the rear brakes and, potentially, increased stopping distances.
Correction:
Dealers will inspect the brake lines for wear, install two new tube bundle clips, and check the brake lines for proper clearances. if the brake lines are worn, the damaged section of the brake line will be replaced.
Notes:
Note:ford has decided to conduct a safety improvement service campaign to inspect the brake lines without charge.owners can contact ford at 1-800-392-3673.
Campaign:
98V322000 on 12/17/1998
Component:
Suspension:front:control arm:lower ball joint
Affected:
175,000
Defect:
Vehicle description: certain 1996-1999 ford crown victoria police, fleet, natural gas, and 1996-1999 lincoln town car limousine vehicles that were produced with a lower control arm ball joint containing a one piece bearing; and 1990-1996 ford crown victoria police, fleet, and ngv vehicles and 1990-1996 lincoln town car limousine vehicles that have been serviced with either a ball joint containing the one-piece bearing or a front lower control arm containing a ball joint with a one-piece bearing. the one-piece bearing within the lower control arm ball joint can weaken slowly during use and eventually crack. this could result in separation of the ball and cap of the joint, allowing the control arm to drop to the ground.
Consequence:
If this occurs while the vehicle is moving, reduced steering control could occur, increasing the risk of a crash.
Correction:
Dealers will replace the lower control arm ball joints (2).
Notes:
Owner notification is expected to begin january 18, 1999.owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact ford at 1-800-392-3673.also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
Campaign:
02I003000 on 11/20/2002
Component:
Fuel system, gasoline:storage:tank assembly
Manufactured:
06/30/1992 - 10/20/2002
Affected:
350,000
Defect:
In order to enhance police office safety, model year 1992-2003 crown victoria police interceptor (cvpi) vehicles will be equipped with shields designed to help protect the fuel tank in high-speed rear-impact crashes. ford also will be offering an optional trunk package designed to improve the safe transport of sharp-edged, heavy equipment in these vehicles.
Consequence:
Some high-speed rear-impact crashes have resulted in fuel tank punctures and fires in cvpi vehicles.
Correction:
Ford has advised us that shield kits have been available since late october and will be installed on police interceptor vehicles at no cost. the optional trank package will be available by the end of 2002. ford has established a new web site at www.cvpi.com to answer additional questions about the safe use of cpvi vehicles.
Notes:
Customers can also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
Campaign:
07V336000 on 08/02/2007
Component:
Vehicle speed control
Manufactured:
02/04/1992 - 02/27/1998
Affected:
3,600,000
Defect:
On certain pickup trucks, passenger vehicles, sport utility vehicles, and motor homes chassis, the speed control deactivation switch may, under certain conditions, leak internally and then overheat, smoke, or burn.
Consequence:
This could result in an underhood fire.
Correction:
Dealers will install a fused wiring harness. owners of the passenger cars included in this campaign will be instructed to return their vehicles to their dealers to have the speed control deactivation switch disconnected as an interim repair. as soon as repair parts are available (expected october 2007), owners will be instructed to return to the dealers for installation of a fused wiring harness. the recall began on august 13, 2007, and mailing completed by september 19, 2007. owners may contact ford at 1-888-222-2751.
Notes:
Ford recall no. 05s28.customers may also contact the national highway traffic safety administration;s vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov.
Campaign:
08V051000 on 02/03/2008
Component:
Vehicle speed control:cruise control
Manufactured:
02/04/1992 - 10/30/1997
Affected:
225,000
Defect:
Ford is recalling 225,000 my 1992-2003 econoline, my 1993-1995 taurus sho, my 1992-1998 crown victoria, my 1993 bronco, f-series, my 1995-1997 f-series super duty stripped chassis, my 1992-1998 mercury grand marquis, and my 1992-1995 lincoln town car vehicles. the affected vehicles were previously repaired using a wiring harness that is not compatible with the vehicle circuit polarity.
Consequence:
As a result, the fuse is located in the output circuit rather than in the intended input power feed circuit, and may not offer the intended protection in the event of an electrical short to ground.
Correction:
Dealers will install a new wiring harness, or replace the mating electrical component. the recall began on february 18, 2008. owners may contact ford at 1-800-392-3673.
Notes:
Ford recall no. 08s01.customers may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov.
Campaign:
15E082000 on 10/05/2015
Component:
Steering
Affected:
1,767
Defect:
Dorman products, inc. (dorman) is recalling certain model dorman steering shafts, part number 425-359, solutions steering shafts, part number 7-0359, and oe solutions steering shafts, part number 425-359, manufactured april 17, 2014, to september 28, 2015. these aftermarket replacement steering shafts are sold for use in 1995-2002 ford crown victoria, mercury grand marquis, and lincoln town car vehicles. these steering shafts may separate during operation if the integral fastener is loose or missing and if the interfacing vehicle shaft is compressed in length.
Consequence:
If the shafts separate during vehicle operation, a loss of steering control would result, increasing the risk of a vehicle crash.
Correction:
Dorman will notify owners, and dealers will replace the steering shaft, free of charge. the recall began on october 28, 2015. owners may contact dorman customer service at 1-800-523-2492, option 5.
Notes:
Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.

1995 FORD CROWN VICTORIA TSBs (118)

Bulletin:
94239
Component:
353600 equipment:air conditioner
Summary:
excessive clutch air gap on fs-10 a/c compressors can allow the clutch disc to move away from the pulley. *tw
Bulletin:
BC0393941201
Component:
162000 structure:body
Summary:
taxi and police fleet vehicles may experience a crack on the left hand "a" pillar area. *tw
Bulletin:
BC0404941201
Component:
071110 fuel system, gasoline:storage:tank assembly:filler pipe and cap
Summary:
engine rolling idle concerns due to loose fuel tank filler cap. *tw
Bulletin:
BC8746941201
Component:
176100 latches/locks/linkages:hood:latch
Summary:
vehicle may exhibit a hood clunk or rattle due to installation of prior model year latch. *tw
Bulletin:
BC0100950103
Component:
116000 electrical system:ignition
Summary:
vehicle may exhibit an inoperable system after the ignition is cycled. *tw
Bulletin:
BC8792950103
Component:
138000 visibility:defroster/defogger system
Summary:
poor heater performance. *tw
Bulletin:
BC3412950201
Component:
036000 service brakes, hydraulic:antilock
Summary:
incorrect cycling of abs or hear/feel abs cycling in light decel. *tw
Bulletin:
BC3621950201
Component:
021000 suspension:front
Summary:
suspension compressor running hours after ignition is turned off. *tw
Bulletin:
BC3061950301
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
vehicles exhibit a high pitched whistle/whine noise coming from the engine compartment. *tw
Bulletin:
BC3133950301
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
vehicles may experience a misfire followed by a rough running engine. *tw
Bulletin:
9536
Component:
103000 power train:automatic transmission
Summary:
intermittent transmission operation. *tw
Bulletin:
95311
Component:
103700 power train:automatic transmission:torque converter
Summary:
irregular or no torque converter clutch operation. *tw
Bulletin:
95313
Component:
103000 power train:automatic transmission
Summary:
possible water intrusion in the mlp/tr sensor causing shift concern. *tw
Bulletin:
BC2850950401
Component:
103700 power train:automatic transmission:torque converter
Summary:
torque converter clutch shudder/vibration. *tw
Bulletin:
BC2851950401
Component:
162300 structure:body:door
Summary:
keyless entry key fobs are sensitive and could cause the inadvertant activation of the trunk release or panic functions. *tw
Bulletin:
BC3032950401
Component:
116200 electrical system:ignition:module
Summary:
under some driving conditions, vehicles may have engine misfire. *tw
Bulletin:
95515
Component:
103000 power train:automatic transmission
Summary:
there may be an intermittent loss of torque during or just after the 3-4 upshift or in 4th gear on some vehicles. *tw
Bulletin:
9562
Component:
034500 service brakes, hydraulic:foundation components:disc
Summary:
roughness concern during brake application. *tw
Bulletin:
BC2490950503
Component:
034500 service brakes, hydraulic:foundation components:disc
Summary:
brake squeal from rear brakes and squeal may appear to come from front brakes. *tw
Bulletin:
BC2562950503
Component:
116200 electrical system:ignition:module
Summary:
vehicles with certain calibrations may experience a misfire event. *tw
Bulletin:
BC8943950503
Component:
034500 service brakes, hydraulic:foundation components:disc
Summary:
vehicles may exhibit brake squeal from the rear brakes and may appear to be from the front brakes. *tw
Bulletin:
BC3032950401
Component:
034500 service brakes, hydraulic:foundation components:disc
Summary:
Unknown
Bulletin:
BC0248960102
Component:
221600 seats:front assembly:power adjust
Summary:
temp. loss of memory seat settings, memory mirror settings or intermittent operation of easy entry/exit system may be from regulator reset issue in drivers seat module (dsm). replace dsm w/ service parts date coded 11/13/95 or later on tow
Bulletin:
95212
Component:
036000 service brakes, hydraulic:antilock
Summary:
the use of petroleum-based grease as a lubricant in servicing disc brakes is no longer acceptable because it may be incompatible with the rubber material used in the disc brake system. if petroleum-based grease is used to lubricate any par
Bulletin:
BC0678961025
Component:
102000 power train:manual transmission
Summary:
Information on aode/4r7w transmission main control & case replacement. *tt
Bulletin:
BC0706961022
Component:
020000 suspension
Summary:
Light to moderate axle noise (axle whine) at 50 to 65 mph (80 to 105 kph) during accels, decels or cruise. *tt
Bulletin:
BC0810961011
Component:
103700 power train:automatic transmission:torque converter
Summary:
Vehicles equipped w/ an aode or 4r70w trans has a concern of shudder from the transmission torque converter clutch in 3rd or 4th gear or during 3-4 shift. *tt
Bulletin:
BC0311961101
Component:
103600 power train:automatic transmission:cooling unit and lines
Summary:
Owner notification 96b97 oil cooler line replacement clarification. *tw
Bulletin:
BC0536961108
Component:
980000 unknown or other
Summary:
12v power point, on right hand side of instrument panel, restricting hot air from the floor duct - new closure panel available. *tw
Bulletin:
96246
Component:
114000 electrical system:wiring
Summary:
Wiring - electrical diode identification and service replacements. *tw
Bulletin:
96249
Component:
103700 power train:automatic transmission:torque converter
Summary:
Torque converter - leak test procedure - service tip. *tw
Bulletin:
96221
Component:
131000 visibility:windshield
Summary:
Windshield and interior glass - fog/film. *tw
Bulletin:
96222
Component:
034000 service brakes, hydraulic:foundation components
Summary:
Brakes - elimination of sanding rotors and drums - service tip. *tw
Bulletin:
96223
Component:
185000 vehicle speed control:cruise control
Summary:
Long crank - sticking idle air control (iac) valve - vehicles built from 11/1/94 through 3/30/96 -stall - after starting when engine allowed to soak from 1-4 hours - sticking idle air control (iac) valve. *tw
Bulletin:
96225
Component:
075000 fuel system, gasoline:carburetor system
Summary:
Mass air flow sensor - replacement as an assembly - service tip. *tw
Bulletin:
962511
Component:
116200 electrical system:ignition:module
Summary:
Powertrain control module -reprogram powertrain control module (pcm) - service procedures - service tip. *tw
Bulletin:
962517
Component:
103700 power train:automatic transmission:torque converter
Summary:
Transmission - aode - 4r70w - shudder or vibration under light to moderate acceleration above 56 km/h (35 mph) while in 3rd or 4th gear. *tw
Bulletin:
962612
Component:
103700 power train:automatic transmission:torque converter
Summary:
Transaxle - torque converter replacement guidelines and torque converter/transaxle cooling system cleaning procedures - service tip. *tw
Bulletin:
BC0311970201
Component:
022000 suspension:rear
Summary:
Whine/noise from rear axle between 50-65 mph. driveshaft and #4 crossmember frame dracket kit. *jd
Bulletin:
BC0314970201
Component:
036000 service brakes, hydraulic:antilock
Summary:
Inadvertent abs activation on smooth dry pavement. *jd
Bulletin:
9722
Component:
220000 seats
Summary:
Seat - front - driver's side seat cushion pad support spring may sag and/or seat may become uncomfortable - fleet usage. *tw
Bulletin:
BC0314972301
Component:
036000 service brakes, hydraulic:antilock
Summary:
Inadvertent abs activation on smooth dry pavement. *jd
Bulletin:
BC3511972301
Component:
162300 structure:body:door
Summary:
Wind noise from the front door area on affected vehicles. *jd
Bulletin:
BC3512972301
Component:
162300 structure:body:door
Summary:
Wind noise from the front door area at varying speeds and conditions on affected vehicles. *jd
Bulletin:
BC3552972301
Component:
162300 structure:body:door
Summary:
A white stress mark in the door scuff plate. *jd
Bulletin:
BC1017097230
Component:
162300 structure:body:door
Summary:
White stress mark in the door scuff plate, replace with new level part. *jd
Bulletin:
BC1017797230
Component:
162300 structure:body:door
Summary:
Wind noise from the front door area on affected vehicles. *jd
Bulletin:
BC1017897230
Component:
162300 structure:body:door
Summary:
Wind noise from the front door area at varying speeds and conditions on affected vehicles. *jd
Bulletin:
BC031A497020
Component:
036000 service brakes, hydraulic:antilock
Summary:
Inadvertent abs activation on smooth dry pavement. *tw
Bulletin:
BC9125970201
Component:
205000 wheels:multi piece
Summary:
Center locking wheel covers, a clicking noise heard at low speeds check the torque on the locking bolt. *jd
Bulletin:
BC3273970207
Component:
353400 equipment:electrical:radio/tape deck/cd etc.
Summary:
List of prefixes or radio units to return for repair. *tw
Bulletin:
9751
Component:
220000 seats
Summary:
Interior- leather seat cleaning procedure- service tip. *jd
Bulletin:
97511
Component:
103000 power train:automatic transmission
Summary:
Fluid- transmission fluid usage charts. *jd
Bulletin:
9768
Component:
980000 unknown or other
Summary:
Fuel economy- customer expectations versus vehicle usage. *jd
Bulletin:
97010510637
Component:
162300 structure:body:door
Summary:
Concerns were door latch will not open or close. *yc
Bulletin:
97090297182
Component:
020000 suspension
Summary:
Some vehicles may experience a lean right condition. *yc
Bulletin:
985A2
Component:
030000 service brakes, hydraulic
Summary:
A squealing and / or moaning noise may be heard from the rear brakes during light to medium brake applications. *tt
Bulletin:
985A3
Component:
036000 service brakes, hydraulic:antilock
Summary:
The anti-lock brake system ( abs ) may activate under false abs conditions. *yc
Bulletin:
985A5
Component:
034530 service brakes, hydraulic:foundation components:disc:rotor
Summary:
Hub-mount brake rotor machining equipment from rotunda is now approved for warranty and service use. *yc
Bulletin:
985A11
Component:
034000 service brakes, hydraulic:foundation components
Summary:
Service tip information regarding elimination of sanding rotors and drums. *yc
Bulletin:
985A13
Component:
034500 service brakes, hydraulic:foundation components:disc
Summary:
The use of petroleum-based grease as a lubricant in servicing disc brakes is no longer acceptable. *yc
Bulletin:
9887
Component:
103700 power train:automatic transmission:torque converter
Summary:
Experiencing a torque converter clutch shudder or vibration. *yc
Bulletin:
9888
Component:
103000 power train:automatic transmission
Summary:
Information on a new transmission fluid usage chart. *yc
Bulletin:
9845
Component:
045300 service brakes, air:disc:rotor
Summary:
Availability of hub-mount brake rotor machining equipment. *yc
Bulletin:
9847
Component:
980000 unknown or other
Summary:
Subject regarding revised remote keyless entry (rke) system. *tt
Bulletin:
98410
Component:
101000 power train:clutch assembly
Summary:
Vehicles may experience torque converter clutch shudder or vibration. *yc
Bulletin:
9852
Component:
190000 tires
Summary:
Information on tire company telephone numbers for customer assistance. *yc
Bulletin:
9864
Component:
063000 engine and engine cooling:exhaust system
Summary:
Information on a buzzing or rattle noise from the exhaust system. *tt
Bulletin:
9873
Component:
353400 equipment:electrical:radio/tape deck/cd etc.
Summary:
Experiencing a whining / buzzing noise in the speakers of the entertainment radio or two-way radio. *tt
Bulletin:
9874
Component:
061000 engine and engine cooling:engine
Summary:
A new silicone gasket and sealant. *yc
Bulletin:
982010
Component:
063000 engine and engine cooling:exhaust system
Summary:
Experiencing a " buzzing " or " rattling " noise from the exhaust system. *yc
Bulletin:
982310
Component:
063100 engine and engine cooling:exhaust system:emission control
Summary:
Mass air flow (maf)- sensor contamination- service tip. *ak
Bulletin:
98245
Component:
220000 seats
Summary:
Concerns regarding the front seat feeling loose on some vehicle. *yc
Bulletin:
98246
Component:
110000 electrical system
Summary:
Ford motor company has released a new electrical grease ( f8az - 19g208-aa ) to reduce the possibility of moisture corrosion at the terminals. *yc
Bulletin:
9943
Component:
100000 power train
Summary:
Information regarding reprogramming powertrain control modules (pcms). *tt
Bulletin:
9812
Component:
030000 service brakes, hydraulic
Summary:
Experiencing squealing and / or moaning noise from the rear brakes during light to medium brake applications. *tt
Bulletin:
9814
Component:
034530 service brakes, hydraulic:foundation components:disc:rotor
Summary:
Subject regarding the availability of hub-mount brake rotor machining equipment. *tt
Bulletin:
986001
Component:
063130 engine and engine cooling:exhaust system:emission control:gas recirculation valve (egr valve)
Summary:
Concerns with malfunction indicator lamp (mil) on and diagnostic trouble code (dtc) p0401 (insufficient exhaust gas recirculation (egr) flow). *tt
Bulletin:
99816
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Ford motor company now recommends sae 5w-30 viscosity grade for servicing any ford gasoline-powered vehicle regardless of model year. *tt
Bulletin:
9996
Component:
103000 power train:automatic transmission
Summary:
Experiencing a delayed or no 2-3 upshift, primarily when the transmission is cold on vehicles with ford qality remanufactured (fqr) 4r70w transmission exchange units with julian build between 062-97 and 040-99. *tt
Bulletin:
99910
Component:
036400 service brakes, hydraulic:antilock:abs warning light
Summary:
Addressing concerns with the brake lamp inadvertently disabling the brake shift interlock on police vehicles. *tt
Bulletin:
99129
Component:
353400 equipment:electrical:radio/tape deck/cd etc.
Summary:
Experiencing a whine / buzz type noise in the speakers of the entertainment radio or two-way radio on vehicles with an in-tank electric fuel pump. *tt
Bulletin:
99139
Component:
125000 exterior lighting:brake lights
Summary:
Conditions with the brake lamps inadvertently disabling the brake shift interlock. *tt
Bulletin:
99222
Component:
114000 electrical system:wiring
Summary:
Subject on a wire harness terminal repair kit available for repairing electrical wiring harnesses. *tt
Bulletin:
9836
Component:
103000 power train:automatic transmission
Summary:
Information concerning vibration-shudder under light to moderate acceleration above 56 km/h (35mph) in 3rd or 4rd gear- vehicles equipped with aode or 4r70w transmission.
Bulletin:
99194
Component:
034000 service brakes, hydraulic:foundation components
Summary:
Information for servicing and diagnosing brake vibration, brake inspection, and brake friction material replacement. *tt
Bulletin:
99195
Component:
353600 equipment:air conditioner
Summary:
Service information for musty and mildew type odors coming from the air conditioning / heating system. *tt
Bulletin:
99196
Component:
353600 equipment:air conditioner
Summary:
Information on identifying non-approved / alternate refrigerants which could cause safety, and performance concerns if installed in ford a/c systems. *tt
Bulletin:
98B19S1
Component:
033110 service brakes, hydraulic:power assist:vacuum:hoses, lines/piping, and fittings
Summary:
Owner notification program 98b19-s1 - brake line wear on certain vehicles. correction to original technical instructions regarding diameter of replacement brake lines. yd
Bulletin:
0015
Component:
103000 power train:automatic transmission
Summary:
Information regarding the new transmission cooler flusher- service tip. *mjs
Bulletin:
8257
Component:
121000 exterior lighting:headlights
Summary:
Brief information regarding vehicles that exhibit yellowing of the headlamps. *tt
Bulletin:
13933
Component:
121000 exterior lighting:headlights
Summary:
Some vehicles may exhibit yellowing of the headlamps. *tt
Bulletin:
12178
Component:
100000 power train
Summary:
Information regarding tsb 98-5a-12 (transaxle/transmission/transfer case-vehicles towed behind recreational vehicles-recommended guidelines) does not list towing information for certain model vehicles. *mjs
Bulletin:
96714
Component:
100000 power train
Summary:
Subject regarding a new transmission case and main control released for service on aode / 4r70w transmissions. *tt
Bulletin:
985A6
Component:
036000 service brakes, hydraulic:antilock
Summary:
Some vehicles may cycle when brakes are applied on rough roads or on an incline while making a sharp turn. *yc
Bulletin:
99-8-15
Component:
162300 structure:body:door
Summary:
Subject regarding door trim panel replacement - service tip. *tt
Bulletin:
99111
Component:
980000 unknown or other
Summary:
Information designed to aid in the diagnosis, testing and repair of noise, vibration and harshness (nvh) concerns. *tt
Bulletin:
99152
Component:
103000 power train:automatic transmission
Summary:
Information on the new flush and fill tool available through rotunda. *tt
Bulletin:
002310
Component:
103600 power train:automatic transmission:cooling unit and lines
Summary:
Subject regarding contamination from prior transmission concerns or excess wear may be trapped in the transmission fluid cooling system. *tt
Bulletin:
00213
Component:
353600 equipment:air conditioner
Summary:
Subject regarding climate control - eatc - blower motor control service tips. *jb
Bulletin:
14370
Component:
980000 unknown or other
Summary:
Information on programming remotes after driver door module replacement. *jb
Bulletin:
14862
Component:
071100 fuel system, gasoline:storage:tank assembly
Summary:
Information on replacing fuel tank strap bolts. *tt
Bulletin:
0147
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Subject regarding engine oil recommendations for use in 2001 vehicles - sae 5w-20 motor oil. *tt
Bulletin:
01156
Component:
138120 visibility:defroster/defogger system:windshield:heater core
Summary:
Some vehicles may exhibit heater core leaks. *slc
Bulletin:
01157
Component:
980000 unknown or other
Summary:
Information regarding transmission fluid usage charts. *slc
Bulletin:
15171
Component:
131000 visibility:windshield
Summary:
Information regarding police option-rear window disable-tamper resistance. *yd
Bulletin:
01181
Component:
103800 power train:automatic transmission:park/neutral start switch
Summary:
Brake shift interlock.*jb
Bulletin:
01194
Component:
110000 electrical system
Summary:
This aritlce is to provide information on replacement of old style hood lamp switch to the rvised mechanical hood lamp switch. *tt
Bulletin:
012114
Component:
071100 fuel system, gasoline:storage:tank assembly
Summary:
Parts and procedure to reduce the potential of fuel tank punctures during rare and extremely high-speed rear impacts. *tt
Bulletin:
0214
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Some engine assemblies with aluminum cylinder heads repaired in-vehile have been found to leak coolant and/or oil from the cylinder head gasket area. *tt
Bulletin:
01246
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Engine oil system priming procedures, service tips for reports of premature engine failure. *tt
Bulletin:
02107
Component:
136200 visibility:windshield wiper/washer:motor
Summary:
Transfer service tips for the front wiper motor mount bracket and depressed park output arm. *tt
Bulletin:
02B02
Component:
350000 equipment
Summary:
Installation of optional police interceptor package upgrade kit. *tt update part 2. expiration date removed. *tt
Bulletin:
03181
Component:
110000 electrical system
Summary:
Remote keyless entry (rke) - service tips. *tt
Bulletin:
03261
Component:
103000 power train:automatic transmission
Summary:
New service part - number 5 needle bearing and race kit - 4r70w transmission - service tip. *tt
Bulletin:
02176
Component:
032100 service brakes, hydraulic:switches:brake light
Summary:
Lamp-brake-invadvertent disabling of brake shift interlock. *mj
Bulletin:
02208
Component:
353600 equipment:air conditioner
Summary:
Climate control a/c service tech tips. *eh
Bulletin:
CSP 08B04
Component:
071100 fuel system, gasoline:storage:tank assembly
Summary:
Ford/lincoln mercury: certain 1992-2001 model year crown victoria, grand marquis, and town car vehicles registered in the states of wisconsin and connecticut upgrade modifications for high speed rear impacts. *pe

Home | Privacy