1995 CHRYSLER SEBRING Recalls (5)
- Campaign:
- 97V201000 on 11/19/1997
- Component:
- Suspension:front:control arm:lower ball joint
- Manufactured:
- 07/30/1994 - 07/09/1997
- Affected:
- 599,000
- Defect:
- Vehicle description: passenger vehicles. the lower control arm ball joint can separate due to loss of lubrication.
- Consequence:
- Separation of the ball joint could cause a loss of steering control increasing the risk of a vehicle crash.
- Correction:
- Dealers will inspect the ball joint end housing cover seal for leakage with a high pressure air tester and the rubber boot will be visually inspected for damage. if the cover seal leaks or the boot is damaged, the lower control arm will be replaced.
- Notes:
- Owner notification began december 15, 1997.owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact chrysler at 1-800-992-1997.also contact the national highway traffic safety administration's auto safety hotline at 1-800-424-9393.
- Campaign:
- 99V066003 on 04/25/1999
- Component:
- Suspension:front:control arm:lower ball joint
- Manufactured:
- 06/15/1994 - 06/29/1996
- Affected:
- 165,857
- Defect:
- Vehicle description: passenger vehicles. if the rubber boots on the lower lateral arm ball joints of the front suspension were damaged during assembly, dirt and water can intrude.
- Consequence:
- This condition could cause the lower lateral arm ball joint to separate, increasing the risk of a vehicle crash.
- Correction:
- Dealers will inspect the rubber boots, and if the boot is damaged, they will replace the lower lateral arm and ball joint on the affected vehicles.
- Notes:
- Owner notification began august 2, 1999. owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact chrysler at 1-800-992-1997.also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
- Campaign:
- 00V421002 on 03/11/2001
- Component:
- Suspension:front:control arm:lower ball joint
- Manufactured:
- 06/30/1994 - 02/27/2000
- Affected:
- 393,796
- Defect:
- Vehicle description: passenger vehicles. if the rubber boots on the lower lateral arm ball joints of the front suspension were damaged during assembly, dirt and water can intrude. also, mmc has added the potential of leaking moisture, which can cause the ball stud to corrode.
- Consequence:
- This condition could cause the lower lateral arm ball joint to separate, increasing the risk of a vehicle crash. this campaign supercedes mmc's previous safety recall campaign, see 99v-066.
- Correction:
- Dealers will inspect the lower lateral arm ball joint for wear. ball joints that exhibit wear beyond the established tolerance will be replaced with newly designed lateral arm ball joints. ball joints that are within the established tolerance will be cleaned and a special sealant will be applied to prevent intrusion of moisture.
- Notes:
- Owner notification began may 21, 2001.owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact daimlerchrysler at 1-800-853-1403. also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
- Campaign:
- 06E088000 on 10/25/2006
- Component:
- Fuel system, gasoline:delivery:fuel pump
- Affected:
- 39,243
- Defect:
- Certain tigas fuel pump modules manufactured between june 1 and september 24, 2006, sold under various brand names and p/nos. these fuel pump modules are sold as aftermarket for use in certain daimlerchrysler vehicles listed above. silicone material used in manufacture of the flapper valve was out-of-specification, leading to excess swell of the flapper valve restricting the flow of fuel to the fuel pump module.
- Consequence:
- Fuel restriction could result in loss of power and/or engine stall, possibly resulting in a vehicle crash.
- Correction:
- Ti automotive will notify owners and replace the defective fuel pump modules free of charge. the recall began on october 6, 2006. owners may contact ti automotive toll-free at 1-877-461-1834.
- Notes:
- This recall only pertains to aftermarket fuel pump modules and has no relation to any original equipment installed on vehicles by daimlerchrysler.customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov.
- Campaign:
- 07E055000 on 07/25/2007
- Component:
- Fuel system, gasoline:delivery:fuel pump
- Affected:
- 222
- Defect:
- Certain airtex fuel pump module assemblies, p/n e7081h, sold for use as replacement equipment for the vehicles listed above. the wall of the flared fitting of the fuel pump is not thick enough to prevent the mating threaded fittings from bottoming out before an adequate seal is achieved. this condition may result in leakage of fuel at the connection of the vehicle fuel line and the fuel pump module assembly.
- Consequence:
- In the presence of an ignition source, a fuel leak could result in a fire.
- Correction:
- Airtex will notify owners and replace the fuel pumps free of charge. the recall is expected to begin during july 2007. owners can contact airtex automotive at 800-880-3056.
- Notes:
- Airtex recall no. fp072007-1.this recall only pertains to aftermarket replacement equipment and has no relation to any original equipment installed on vehicles manufactured by daimlerchrysler or mitsubishi.customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov.
1995 CHRYSLER SEBRING TSBs (71)
- Bulletin:
- 022294
- Component:
- 021000 suspension:front
- Summary:
- right steering drift or lead during normal straight-line driving. *tw
- Bulletin:
- 180295
- Component:
- 116200 electrical system:ignition:module
- Summary:
- check engine light on "evap purge flow monitor failure." *tw
- Bulletin:
- 090195
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- engine damage may occur by incorrect installation of camshaft sprocket after an engine repair. *tw
- Bulletin:
- CH181495
- Component:
- 116000 electrical system:ignition
- Summary:
- driveability improvements and/or check engine light on. *tw
- Bulletin:
- CH181395
- Component:
- 116200 electrical system:ignition:module
- Summary:
- whistle noise from pcm. *tw
- Bulletin:
- CH210695
- Component:
- 103000 power train:automatic transmission
- Summary:
- Unknown
- Bulletin:
- CH181795A
- Component:
- 061100 engine and engine cooling:engine:gasoline
- Summary:
- Unknown
- Bulletin:
- 183195
- Component:
- 116000 electrical system:ignition
- Summary:
- new in stock vehicles may exhibit hard starts, miss-fire, or rough idle due to spark plug fouling. this can be caused by infrequent engine operation during the transportation process. bulletin involves cleaning the spark plugs prior to del
- Bulletin:
- 236395
- Component:
- 162300 structure:body:door
- Summary:
- bulletin applies to vehicles built prior to may 10, 1995 (mdh 05-10-xx). some vehicles may exhibit a loose air dam or door cladding. the result is from loss of tape adhesion and/or poor clip retention. this bulletin involves the loose cla
- Bulletin:
- 084495
- Component:
- 012200 steering:column locking:anti-theft device
- Summary:
- bulletin applies to talon models built prior to jun 1, 1995 (mdh 06-01-xx) and avenger/sebring models built prior to august 2, 1995 (mdh 08-02-xx). some vehicles may exhibit an intermittent or random activation of the theft alarm when the
- Bulletin:
- 081695REVA
- Component:
- 180000 vehicle speed control
- Summary:
- bulletin supersedes technical service bulletin 08-16-95, dated apr. 14, 1995. if the vehicle operator **repeatedly** presses and releases the set button with their foot off of the accelerator (a 'lift foot set' to begin speed control oper
- Bulletin:
- 020197
- Component:
- 161000 structure:frame and members
- Summary:
- A light thump, chuckle, or creak noise may be heard form the rear of the vehicle while driving over small to medium bumps- this noise comes from the inside shock. *jd
- Bulletin:
- 230397
- Component:
- 161000 structure:frame and members
- Summary:
- Difficult to clean light colored "chalky" residue from plastic body components that are molded in black. *tw
- Bulletin:
- 180897
- Component:
- 116000 electrical system:ignition
- Summary:
- Sag/hesitation on acceleration, or engine miss. *tw
- Bulletin:
- 180997
- Component:
- 103700 power train:automatic transmission:torque converter
- Summary:
- Vehicle shudder during torque converter emcc (lock up) operation/diagnostic trouble code 38. *tw
- Bulletin:
- 181097
- Component:
- 116000 electrical system:ignition
- Summary:
- Intermittent single cylinder misfire and/or mil illuminated. *tw
- Bulletin:
- 230297
- Component:
- 134000 visibility:sun roof assembly
- Summary:
- Sunroof sunshade binding or coming out of track. *tw
- Bulletin:
- 182297
- Component:
- 116200 electrical system:ignition:module
- Summary:
- Mil illumination with hex code $3a. *tw
- Bulletin:
- 233897
- Component:
- 980000 unknown or other
- Summary:
- Keyless entry transmitter diagnostics. *tw
- Bulletin:
- 250297
- Component:
- 060000 engine and engine cooling
- Summary:
- Various noises coming from the engine compartment. *yc
- Bulletin:
- 070397
- Component:
- 062000 engine and engine cooling:cooling system
- Summary:
- Various car owner's have expressed interest in using engine coolants made with propylene glycol instead of ethylene glycol. *yc
- Bulletin:
- 970314210597
- Component:
- 102000 power train:manual transmission
- Summary:
- Condition with tranaxle shudder during a 3rd gear to 3rd gear partial emcc ( electronically modulated converter clutch) engagement, 3rd gear partial emcc to 4th gear partial emcc engagement, or 4th gear to 4th gear emcc engagement. *yc
- Bulletin:
- 020298
- Component:
- 020000 suspension
- Summary:
- A squeaking or hard rubbing noise may be heard from the rear of the vehicle when traveling over bumps. *yc
- Bulletin:
- 020798
- Component:
- 022400 suspension:rear:shock absorber
- Summary:
- Conditions with light knocking or tapping noise being heard from the rear shock rear while traveling over bumps. *yc
- Bulletin:
- 232398
- Component:
- 980000 unknown or other
- Summary:
- Information on remote keyless entry programming. *yc
- Bulletin:
- 182698
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Excessive cold crank time with a no start condition caused by no/low compression due to loose carbon holding valves opening/sags/stumbles/hesitates after cold start. *ak
- Bulletin:
- 7671/7672
- Component:
- 063000 engine and engine cooling:exhaust system
- Summary:
- Various information pertaining to fuel pressure regulator, aspirator system and reprogram pcm. emissions recalls. *ak
- Bulletin:
- 050898
- Component:
- 034500 service brakes, hydraulic:foundation components:disc
- Summary:
- Exhibitting a conditon where the steering wheel shakes or the brake pedal pulsates due to premature wear of front brake rotors and pads. *ak
- Bulletin:
- 081798
- Component:
- 145000 air bags:on-off switch assembly
- Summary:
- Subject regarding airbag on - off switches. *yc
- Bulletin:
- 190199
- Component:
- 015100 steering:hydraulic power assist:pump
- Summary:
- Procedures on aligning the power steering belt. *tt
- Bulletin:
- 210499
- Component:
- 103000 power train:automatic transmission
- Summary:
- Service and parts information on 1999 running changes to transmission range sensor (trs) *tt
- Bulletin:
- 210599
- Component:
- 103000 power train:automatic transmission
- Summary:
- Subject regarding reusable automatic transmission oil pan gasket. *tt
- Bulletin:
- 020299
- Component:
- 020000 suspension
- Summary:
- Vehicles exhibiting front coil spring creaking, popping, or squeaking. *tt
- Bulletin:
- 210699
- Component:
- 180000 vehicle speed control
- Summary:
- Conditions with intermittent loss of speed control. *tt
- Bulletin:
- 090799
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Information regarding 2.5l v-6 head gasket application. *tt
- Bulletin:
- 090899
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Technical service bulletin regarding multi-layer steel (mls) head gasket installation procedures. *tt
- Bulletin:
- 210599A
- Component:
- 103000 power train:automatic transmission
- Summary:
- This bulletin announces the availability and installation of a resuable automatic transmission oil pan gasket. *tt
- Bulletin:
- 233599
- Component:
- 220000 seats
- Summary:
- Information on child seat tether anchors. *tt
- Bulletin:
- 081698
- Component:
- 353400 equipment:electrical:radio/tape deck/cd etc.
- Summary:
- Information on installation of radio transmitting equipment. *ak
- Bulletin:
- 234998
- Component:
- 162000 structure:body
- Summary:
- Some vehicles exhibit a whistle ( windnoise) coming from the " a " pillar area. *yc
- Bulletin:
- 183298
- Component:
- 162000 structure:body
- Summary:
- Subject on flash programming failure recovery. *yc
- Bulletin:
- 070397
- Component:
- 060000 engine and engine cooling
- Summary:
- Concerns with engine coolant usage. *nlm
- Bulletin:
- 090997
- Component:
- 061100 engine and engine cooling:engine:gasoline
- Summary:
- Information on gasket surface preparation on aluminum engine components. *nlm
- Bulletin:
- 190597
- Component:
- 015100 steering:hydraulic power assist:pump
- Summary:
- Concerns with power steering belt alignment. *nlm
- Bulletin:
- 210597
- Component:
- 103000 power train:automatic transmission
- Summary:
- Concerns with 41te/42le transaxle shudder during an emcc (electronically modulated converter clutch) shift. *nlm
- Bulletin:
- 210997
- Component:
- 102000 power train:manual transmission
- Summary:
- Information on 41te/42le service information. *nlm
- Bulletin:
- 220197
- Component:
- 190000 tires
- Summary:
- Information on tire and wheel runout. *nlm
- Bulletin:
- 250297
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Customer may complain of popping/knocking noise in engine compartment. *nlm
- Bulletin:
- 083799
- Component:
- 145000 air bags:on-off switch assembly
- Summary:
- Daimlerchrysler corporation is now offerinb airbag on / off switches for selected vehicles. *tt
- Bulletin:
- 080600
- Component:
- 114000 electrical system:wiring
- Summary:
- This bulletin provides a revised wire splice procedure and related parts. *tt
- Bulletin:
- 084699
- Component:
- 120000 exterior lighting
- Summary:
- Some vehicles may exhibit a condition where the door ajar warning light and dome light may work intermittently or may become inoperative. *tt
- Bulletin:
- 230800
- Component:
- 220000 seats
- Summary:
- Subject regarding child seat tether anchors. *tt
- Bulletin:
- 233599REVA
- Component:
- 162000 structure:body
- Summary:
- Subject on the child seat tether anchors. *mjs
- Bulletin:
- 082700
- Component:
- 140000 air bags
- Summary:
- Subject regarding non-deployed airbag handling procedures. *tt
- Bulletin:
- 2300800B
- Component:
- 220000 seats
- Summary:
- Subject regarding child seat tether anchors. *tt
- Bulletin:
- 0804000
- Component:
- 221600 seats:front assembly:power adjust
- Summary:
- Information on new components and a repair procedure developed to replace failed seat slide motors. *tt
- Bulletin:
- 0800600REV
- Component:
- 110000 electrical system
- Summary:
- Subject regarding wire splice repairs. *sb
- Bulletin:
- 0801001
- Component:
- 110000 electrical system
- Summary:
- Subject regarding airbag / clock spring service for various models including 2002 model year jeep liberty. *tt
- Bulletin:
- 1801201
- Component:
- 350000 equipment
- Summary:
- Subject regarding generic scan tool (gst), publication no. 81-170-00008 provided with this technical service bulletin to provide reference information when using generic scan tool on obdii vehicles. *tt
- Bulletin:
- 2100601
- Component:
- 103000 power train:automatic transmission
- Summary:
- Automatic transmission fluid usage atf+4. *tt *mj
- Bulletin:
- 1802002
- Component:
- 980000 unknown or other
- Summary:
- Flash programming failure recovery. *slc
- Bulletin:
- 20616
- Component:
- 110000 electrical system
- Summary:
- P/n cbszr068aa: inspect & return: module kit - occupant restraint you have been identified as either having stock, or have stock in transit to your dealership. please return part number cbszr068aa as per the qir attached. replacement par
- Bulletin:
- 22892
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- Return: lamp assy - chmsl& cargo light you have been identified as either having stock, or have stock in transit to your dealership. please return all stock of follow ing part numbers:55372082ae, 55372082ad, 55372082ac, 55372082ab, 553720
- Bulletin:
- 22867
- Component:
- 110000 electrical system
- Summary:
- Inspect and return: solenoid module - transmission you have been identified as either having stock, or have stock in transit to your dealership. please return suspect stock of follow ing part numbers:52120000aa, 52119435af, 05078709ab. s
- Bulletin:
- 22958
- Component:
- 117000 digital instrument panel
- Summary:
- 1nt30xdvac - inspect and return: panel - instrument panel you have been identified as either having stock, or have stock in transit to your dealership. please return suspect stock of part number 1n t30xdvac. see attachments for identifyin
- Bulletin:
- 20244
- Component:
- 350000 equipment
- Summary:
- Cbxdp361aa return: spacer kit - visor you have been identified as either having stock, or have stock in transit to your dealership. please return stock of part number cbxdp361aa. replacement part number is cbxdp361ab w hich is in stock a
- Bulletin:
- Volume 2, Issue
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- Warranty operations newsletter updates from warranty operations
- Bulletin:
- Volume 2, Issue
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- Warranty operations newsletter updates from warranty operations
- Bulletin:
- 23137
- Component:
- 350000 equipment
- Summary:
- Inspect and return: trim cover assy - a-pillar rt/lt you have been identified as either having stock, or have stock in transit to your dealership. please return suspect stock of part numbers: 1za04dx9ae, 1za05dx9ae. see attachments for id
- Bulletin:
- 23104
- Component:
- 120000 lighting (pws)
- Summary:
- 05182535ad - lamp assy ?tail light lt you have been identified as either having stock, or have stock in transit to your dealership. please return suspect stock of part number 05182535ad . see attachments for identifying suspect stock. pl
- Bulletin:
- 23027
- Component:
- 114000 electrical system:wiring
- Summary:
- Return: wiring assy - engine you have been identified as either having stock, or have stock in transit to your dealership. please return stock packaged before 2016/07/31 (31 july, 2016)of follow ing part numbers:68176457af, 68176459af. p
Home | Privacy