1995 AM GENERAL HUMMER Recalls (5)
- Campaign:
- 95V023000 on 02/21/1995
- Component:
- Vehicle speed control
- Manufactured:
- 06/30/1994 - 12/31/1994
- Affected:
- 150
- Defect:
- Water can accumulate in the cruise control cable and if the outside temperature is below freezing and the cruise control is engaged, the water can freeze causing the cable to bind and not release as intended when the brake pedal is applied or the system is turned off at the master cruise control switch.
- Consequence:
- The engine throttle can stick open resulting in loss of throttle control with the increased potential for a vehicle accident.
- Correction:
- Dealers will remove the current cruise control actuator and cable assembly and install a new assembly. additionally, dealers will change the routing of the cable.
- Notes:
- System: fuel; throttle linkages and control. vehicle description: multi-purpose vehicles equipped with diesel engines and cruise control. note: if your vehicle is presented to an authorized dealer on an agreed upon service date and the remedy is not provided free of charge within a reasonable time, contact am general at 1-800-638-8303.also contact the national highway traffic safety administration's auto safety hotline at 1-800-424-9393.
- Campaign:
- 95V161000 on 08/31/1995
- Component:
- Fuel system, gasoline:storage:tank assembly
- Manufactured:
- 10/31/1994 - 07/31/1995
- Affected:
- 463
- Defect:
- Under high ambient temperatures (greater than 95 degrees fahrenheit) and the fuel tank level between 1/4 and 1/2 full, the fuel tank internal pressure can increase causing the tank to expand. tank expansion causes an interference between the fuel tank protective shield and the propeller shaft resulting a hole in the fuel tank at the point of shield-to-shaft contact.
- Consequence:
- This condition can cause fuel leakage, and if an ignition source is present, could result in a fire.
- Correction:
- Dealers will install a supplemental fuel tank venting system on these vehicles.
- Notes:
- System: fuel; fuel tank assembly; tank.vehicle description: gasoline powered multi-purpose passenger vehicles.note: owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time, should contact am general at 1-800-638-8303. also contact the national highway traffic safety administration's auto safety hotline at 1-800-424-9393.
- Campaign:
- 96V049000 on 03/11/1996
- Component:
- Vehicle speed control:accelerator pedal
- Manufactured:
- 07/31/1992 - 02/29/1996
- Affected:
- 3,000
- Defect:
- The coating used to protect the accelerator pedal shaft is incompatible with the bronze bushing through which the shaft passes. over time, and in the presence of a corrosive environment (water, road salt), the shaft can corrode inside the bushing increasing the amount of friction between the rotating shaft and the stationary bushing.
- Consequence:
- A corroded accelerator pedal shaft can cause the engine throttle to bind and not fully return to idle when the operator's foot is removed from the accelerator pedal increasing the potential for a vehicle accident.
- Correction:
- Dealers will install a revised accelerator pedal and shaft assembly.
- Notes:
- System: fuel; throttle linkages and controls. vehicle description: multi-purpose passenger vehicles equipped with diesel or gasoline engines. turbo-charged diesel vehicles are not included. note: owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time, should contact am general at 1-219-258-6615. also contact the national highway traffic safety administration's auto safety hotline at 1-800-424-9393.
- Campaign:
- 06E043000 on 05/21/2006
- Component:
- Fuel system, gasoline
- Affected:
- 88,303
- Defect:
- Certain replacement fuel filters, fram brand name p/n g3727, with date codes x52911 through x60801 sequentially or x600141 and a mexico country or origin marking on the fuel filter housing manufactured from october 18, 2005, through march 21, 2006, sold for use on the vehicles listed above and on certain school buses. (to see the school bus engine sizes, click on "document search" and then "bus applications"). the connector on the fuel filter was not manufactured to honeywell's specification. as a result, the o-ring may not seat correctly on the fuel line.
- Consequence:
- This condition may cause an inadequate seal at the connection, potentially leading to a fuel leak. in the presence of an ignition source, a fire could occur.
- Correction:
- Honeywell will notify owners and replace the fuel filters free of charge. the recall began on october 18, 2006. owners may contact fram customer service at 1-800-890-2075 (option 1).
- Notes:
- This recall only pertains to aftermarket fram fuel filters and has no relation to any original equipment installed on the vehicles listed.customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov.
- Campaign:
- 07E088000 on 10/29/2007
- Component:
- Equipment
- Affected:
- 121,680
- Defect:
- Certain honeywell fram racing brand hp4 and hp8 oil filters that were manufactured from may 25, 2006, through september 14, 2007, and sold for use as replacement equipment for vehicles list above. the affected filters are marked with a date code a61451 through a72571 sequentially. the date code and part number appear on the filter housing. fram racing hp4 and hp8 oil filters not bearing a date code in this range are not affected by this recall. the gasket of the oil filter becomes more pliable under high temperatures and pressures.
- Consequence:
- This condition may cause inadequate sealing and loss of engine oil, possibly resulting in a fire.
- Correction:
- Honeywell will replace the affected oil filters free of charge. the recall began during november 2007. owners can contact fram customer service toll-free at 1-800-890-2075.
- Notes:
- Customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov.
1995 AM GENERAL HUMMER TSBs (17)
- Bulletin:
- AG95102
- Component:
- 162300 structure:body:door
- Summary:
- replacement seals for doors and door opening to provide a tighter seal. *tw
- Bulletin:
- AG95022
- Component:
- 180000 vehicle speed control
- Summary:
- hummer may experience poor performance driveability symptoms due to improper accelerator cable adjustment. *tw
- Bulletin:
- AG951013
- Component:
- 162300 structure:body:door
- Summary:
- Unknown
- Bulletin:
- AG95105
- Component:
- 220000 seats
- Summary:
- Unknown
- Bulletin:
- AG95021
- Component:
- 980000 unknown or other
- Summary:
- Unknown
- Bulletin:
- AG95121
- Component:
- 136200 visibility:windshield wiper/washer:motor
- Summary:
- Unknown
- Bulletin:
- AG95105
- Component:
- 220000 seats
- Summary:
- auxiiliary rear seats and mounting kits. *tw
- Bulletin:
- AG950603
- Component:
- 103000 power train:automatic transmission
- Summary:
- ctis line chafing. *tw
- Bulletin:
- 970401971301
- Component:
- 198000 tires:temporary/emergency spare tire
- Summary:
- Instructions on installation of the swing-away sprare tire carrier kit p/n 05744642. *yc
- Bulletin:
- 980101980501
- Component:
- 103400 power train:automatic transmission:lever and linkage:column shift
- Summary:
- Exhibiting resonant frequencies causing the transfer case shift lever to vibrate or rattle. *yc
- Bulletin:
- 980101981002
- Component:
- 138000 visibility:defroster/defogger system
- Summary:
- Installation instructions for ventilation kits. *yc
- Bulletin:
- 981104
- Component:
- 138000 visibility:defroster/defogger system
- Summary:
- Subject on main hvac unit servicing. *yc
- Bulletin:
- 971003
- Component:
- 131000 visibility:windshield
- Summary:
- A heated windshield kit has been designed to accelerate windshield defrosting in cold ambient temperatures. *ak
- Bulletin:
- 971003
- Component:
- 131000 visibility:windshield
- Summary:
- A heated windshield wiper has been designated to accelerate windshield defrosting in cold ambient temperatures.
- Bulletin:
- 000102
- Component:
- 350000 equipment
- Summary:
- This bulletin mentions that starting with the september general motors tis update, hummer diagnostic information is included for the tech 2 scanner. the software will include diagnostic trouble code (dtc) retrieval, data stream access, sn
- Bulletin:
- 011001
- Component:
- 162300 structure:body:door
- Summary:
- Subject regarding revised front door armrest. *tt
- Bulletin:
- 041322
- Component:
- 354500 equipment:mechanical:winch
- Summary:
- Winch control pack. *mj
Home | Privacy