1994 INTERNATIONAL HARVESTER 4000 Recalls (4)
- Campaign:
- 95E003003 on 09/26/1995
- Component:
- Service brakes, air:supply:hoses, lines/piping, and fittings
- Manufactured:
- 02/28/1993 - 02/28/1995
- Affected:
- 4,947
- Defect:
- Air system blockage in the air dryer occurs degrading the moisture removing capabilities of the dryer when the vehicle is operated in a cold environment and moisture accumulates and freezes in the air dryer or in the line between the dryer and the air system reservoir. the air dryer can become over pressurized causing the air dryer cartridge to separate from the mounting base.
- Consequence:
- If the air dryer separates from the base, the cartridgecan separate sufficiently enough to cause personal injury or property damage.
- Correction:
- Dealers will equip air systems with a pressure relief valve to be located between the compressor and the air dryer. this pressure relief valve is intended to vent if excessive pressure develops in the air dryer.
- Notes:
- System: brakes;air dryer. vehicle description: medium and heavy duty trucks and buses equipped with rockwell wabco system saver "1000" or system saver "twin" air dryers.note: if your vehicle is presented to an authorized dealer on an agreed upon service date and the remedy is not provided free of charge with in a reasonable time, contact navistar international at 1-800-448-7825.also contact the national highway traffic safety administration's auto safety hotline at 1-800-424-9393.
- Campaign:
- 96V041000 on 03/11/1996
- Component:
- Wheels:center section
- Manufactured:
- 02/28/1993 - 01/31/1996
- Affected:
- 206
- Defect:
- The front wheel hub can develop cracks at the wheel mounting studs. when mounted to the hub, the hydraulic brake disc rotor does not properly support the hub at the wheel studs causing excessive stress and fatigue cracks in the hub.
- Consequence:
- Should sufficient cracks occur, the mounting flange portion of the hub along with the wheel could separate from the vehicle without warning. should this occur while the vehicle is driven, the driver could lose control of the vehicle and/or the separated wheel and hub could strike another vehicle, pedestrian or property.
- Correction:
- Dealers will install new, redesigned hubs on these vehicles.
- Notes:
- System: wheels; hub. vehicle description: school and transit buses and medium duty trucks built with 9,000, 10,000, 11,000 or 12,000 pound front axle, hydraulic disc brakes, and hub mounted disc wheels. note: owners who take their vehicles to an authorized dealer on an agreedupon service date and do not receive the free remedy within a reasonable time, should contact navistar at 1-800-448-7825. also contact the national highway traffic safety administration's auto safety hotline at 1-800-424-9393.
- Campaign:
- 02V137000 on 05/19/2002
- Component:
- Tires
- Manufactured:
- 12/31/1985 - 01/15/2001
- Affected:
- 801
- Defect:
- Certain heavy duty trucks, truck tractors, and buses equipped with 195/75r22.5 tires mounted on 7.5 inch wide wheels fail to comply with requirements of federal motor vehicle safety standard no. 120, "tire selection and rims for motor vehicles other than passenger cars." these tires and rims do not match.
- Consequence:
- Tires mounted on rims that are too narrow could experience a decrease in sidewall durability, and could also experience higher treadwear for tires mounted on the steering axle.
- Correction:
- Dealers will install new rims of an acceptable width (8.25 - 9 9inches) for the 295/75r22.5 tire size. owner notification began august 23, 2002. owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact international at 1-800-448-7825.
- Notes:
- Customers can also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
- Campaign:
- 02V137000 on 05/19/2002
- Component:
- Wheels
- Manufactured:
- 12/31/1985 - 01/15/2001
- Affected:
- 801
- Defect:
- Certain heavy duty trucks, truck tractors, and buses equipped with 195/75r22.5 tires mounted on 7.5 inch wide wheels fail to comply with requirements of federal motor vehicle safety standard no. 120, "tire selection and rims for motor vehicles other than passenger cars." these tires and rims do not match.
- Consequence:
- Tires mounted on rims that are too narrow could experience a decrease in sidewall durability, and could also experience higher treadwear for tires mounted on the steering axle.
- Correction:
- Dealers will install new rims of an acceptable width (8.25 - 9 9inches) for the 295/75r22.5 tire size. owner notification began august 23, 2002. owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact international at 1-800-448-7825.
- Notes:
- Customers can also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
1994 INTERNATIONAL HARVESTER 4000 TSBs (2)
- Bulletin:
- G94907
- Component:
- 063200 engine and engine cooling:exhaust system:manifold/header/muffler/tail pipe
- Summary:
- install a vertical tail pipe mounting bracket cab reinforcement. *sd
- Bulletin:
- BCM9500042
- Component:
- 353600 equipment:air conditioner
- Summary:
- there have been reports of 2000, 4000, and 8000 series vehicles that were built since december 5, 1994 that during ambient temperatures of 70 to 80 degrees fahrenheit that the air conditioning is shutting off. once the ignition switch, or
Home | Privacy