1994 INTERNATIONAL HARVESTER 3800 Recalls (4)
- Campaign:
- 94V144000 on 08/16/1994
- Component:
- Engine and engine cooling:engine:gasoline:turbo-charger
- Manufactured:
- 12/31/1993 - 02/28/1994
- Affected:
- 373
- Defect:
- Four compression backplate retaining fasteners on the turbo-charger were torqued only hand tight. this allows the fasteners to loosen, and causes oil to leak into the compressor air side of the turbo-charger which, when coupled with the heat precipitated by the compressor and the mixing action of the compressor wheel, can result in an air/oil mixture that fuels the engine.
- Consequence:
- When this occurs, engine run-on and subsequent loss of operator control via the normal throttle mechanism can occur, which could result in a vehicle accident.
- Correction:
- Replace the suspect turbo-charger with a new turbo-charger.
- Notes:
- System: engine; turbo-charger.vehicle description: trucks and buses equipped with navistar i-6 engines.note: if your vehicle is presented to an authorized dealer on an agreed upon service date and the remedy is not provided within a reasonable time free of charge or the remedy does not correct the defect, please contact navistar at 1-800-448-7825. also, contact the national highway traffic safety administration's auto safety hotline at 1-800-424-9393.
- Campaign:
- 96V041000 on 03/11/1996
- Component:
- Wheels:center section
- Manufactured:
- 02/28/1993 - 01/31/1996
- Affected:
- 206
- Defect:
- The front wheel hub can develop cracks at the wheel mounting studs. when mounted to the hub, the hydraulic brake disc rotor does not properly support the hub at the wheel studs causing excessive stress and fatigue cracks in the hub.
- Consequence:
- Should sufficient cracks occur, the mounting flange portion of the hub along with the wheel could separate from the vehicle without warning. should this occur while the vehicle is driven, the driver could lose control of the vehicle and/or the separated wheel and hub could strike another vehicle, pedestrian or property.
- Correction:
- Dealers will install new, redesigned hubs on these vehicles.
- Notes:
- System: wheels; hub. vehicle description: school and transit buses and medium duty trucks built with 9,000, 10,000, 11,000 or 12,000 pound front axle, hydraulic disc brakes, and hub mounted disc wheels. note: owners who take their vehicles to an authorized dealer on an agreedupon service date and do not receive the free remedy within a reasonable time, should contact navistar at 1-800-448-7825. also contact the national highway traffic safety administration's auto safety hotline at 1-800-424-9393.
- Campaign:
- 96V174000 on 09/24/1996
- Component:
- Service brakes, hydraulic:antilock
- Manufactured:
- 01/29/1992 - 09/02/1996
- Affected:
- 580
- Defect:
- The wiring from the electronic control unit was connected to the wrong wheel sensor or to the wrong brake modulator valve. it is possible that either or both wiring may have occurred at either the front or rear axle or both axles.
- Consequence:
- Should the anti-lock braking system (abs) wiring be crossed, it would result in a significant degradation in vehicle stopping distance. a signal would be sent to the wrong brake chamber when a brake imbalance is detected. this condition increases the risk of a vehicle accident.
- Correction:
- Dealers will inspect the abs wiring and, if necessary, properly connect.
- Notes:
- Owner notification:owner notification is expected to begin october 8, 1996.note:owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact navistar at 1-800-448-7825.also contact the national highway traffic safety administration's auto safety hotline at 1-800-424-9393.
- Campaign:
- 96V192000 on 11/13/1996
- Component:
- Exterior lighting:turn signal:switch
- Manufactured:
- 12/31/1980 - 07/31/1994
- Affected:
- 171,638
- Defect:
- These buses have a turn signal lever that will not operate consistently in the lane change mode if the lever is not moved to the position where resistance to movement is felt.
- Consequence:
- Should the rear signal lamps not flash when a lane change was being made, it could result in a vehicle following the bus to collide with the bus increasing the risk of personal injury and/or property damage.
- Correction:
- Operators will be mailed information concerning the proper method of using turn signals. a decal will also be provided to be placed on the instrument panel of each bus.
- Notes:
- Owner notification:information and decals will be mailed to owner beginning december 10, 1996.note:owners not receiving this information free of charge within a reasonable time should contact navistar at 1-800-448-7825.also contact the national highway traffic safety administration's auto safety hotline at 1-800-424-9393.
1994 INTERNATIONAL HARVESTER 3800 TSB
- Bulletin:
- IK-0400107
- Component:
- 030000 brakes (pws)
- Summary:
- International: after lining condition and wear, fastener torque, component lubrication have been verified on the brakes because of the chatter or squealing on the trucks, a procedure will be performed. no model or model years are liste
Home | Privacy