1994 GMC YUKON Recalls (4)
- Campaign:
- 95I005000 on 02/13/1996
- Component:
- Engine and engine cooling:engine:diesel
- Manufactured:
- 07/31/1993 - 06/30/1994
- Affected:
- 60,000
- Defect:
- Vehicle description: light duty pickup trucks, vans and motorhomes equipped with electronically fuel injected 6.5l diesel engine. this is not a safety recall in accordance with federal regulation part 573. however, it is deemed a safety improvement campaign by the agency. the campaign will improve the overall driveability of these vehicles.
- Consequence:
- Certain vehicles can exhibit some driveability concerns such as poor throttle response, stalling, misfire, poor hot or cold starting, extended cranking of a hot engine, or stalling after start. trucks with manualtransmissions can exhibit poor acceleration from start or could stall during deceleration.
- Correction:
- Dealers will install some recently developed enhancements which will improve the overall driveability of these vehicles.
- Notes:
- General motors has decided to conduct a safety improvement service campaign to improve the driveability of these vehicles. owners can contact chevrolet at 1-800-222-1020 or gmc at 1-800-462-8782.
- Campaign:
- 98V150001 on 02/10/1999
- Component:
- Visibility:windshield wiper/washer
- Manufactured:
- 07/31/1994 - 05/30/1996
- Affected:
- 1,557,585
- Defect:
- Vehicle description: light duty pickup trucks and sport utility vehicles, 2 and 4-wheel drive. solder joints near the wiring harness connector can crack causing the windshield wipers to work intermittently.
- Consequence:
- This condition can result in inoperative wipers, reducing a driver's visibility, and increasing the risk of a vehicle crash.
- Correction:
- Dealers will replace the wiper motor circuit board and cover.
- Notes:
- Owner notification began december 15, 1998.owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact chevrolet at 1-800-222-1020 or gmc at 1-800-462-8782.also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
- Campaign:
- 03V159000 on 04/29/2003
- Component:
- Visibility:windshield wiper/washer
- Manufactured:
- 07/31/1994 - 09/29/1994
- Affected:
- 1,755,876
- Defect:
- On certain minivans, pickup trucks, and sport utility vehicles with certain model-engine combinations, the windshield wiper motor may fail due to cracked solder joints on the controller circuit board. the windshield wipers could work intermittently or not at all.
- Consequence:
- If this were to occur during bad weather, driver visibility would be reduced, which could result in a crash.
- Correction:
- Dealers will replace the wiper motor circuit board and cover. owner notification began on june 19, 2003. owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact chevrolet at 1-800-222-1020, gmc at 1-800-462-8782, or oldsmobile at 1-800-442-6537.
- Notes:
- Gm recall no. 03023.customers can also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
- Campaign:
- 06E043000 on 05/21/2006
- Component:
- Fuel system, gasoline
- Affected:
- 88,303
- Defect:
- Certain replacement fuel filters, fram brand name p/n g3727, with date codes x52911 through x60801 sequentially or x600141 and a mexico country or origin marking on the fuel filter housing manufactured from october 18, 2005, through march 21, 2006, sold for use on the vehicles listed above and on certain school buses. (to see the school bus engine sizes, click on "document search" and then "bus applications"). the connector on the fuel filter was not manufactured to honeywell's specification. as a result, the o-ring may not seat correctly on the fuel line.
- Consequence:
- This condition may cause an inadequate seal at the connection, potentially leading to a fuel leak. in the presence of an ignition source, a fire could occur.
- Correction:
- Honeywell will notify owners and replace the fuel filters free of charge. the recall began on october 18, 2006. owners may contact fram customer service at 1-800-890-2075 (option 1).
- Notes:
- This recall only pertains to aftermarket fram fuel filters and has no relation to any original equipment installed on the vehicles listed.customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov.
1994 GMC YUKON TSBs (9)
- Bulletin:
- 566304
- Component:
- 071110 fuel system, gasoline:storage:tank assembly:filler pipe and cap
- Summary:
- fuel tank noise, fuel gage inaccurate, reduced fuel capacity.*sd
- Bulletin:
- 568204
- Component:
- 136000 visibility:windshield wiper/washer
- Summary:
- windshield wiper blade chatter(replace wiper arm and blade). *sd
- Bulletin:
- 667406
- Component:
- 102000 power train:manual transmission
- Summary:
- Transfer case hops out of 4-high, or no drive in 2 or 4-high ranges and/or grinding noise (install mainshaft/range hub kit) *tw
- Bulletin:
- 667202A
- Component:
- 102000 power train:manual transmission
- Summary:
- Manual transmission rattle noise at idle (install conventional flywheel). *tw
- Bulletin:
- 98043
- Component:
- 136200 visibility:windshield wiper/washer:motor
- Summary:
- Product recall campaign involving windshield wiper motor replacement. *tt
- Bulletin:
- 020730024A
- Component:
- 103400 power train:automatic transmission:lever and linkage:column shift
- Summary:
- Diagnosis of cracked or broken transmission case. *tt 2006 and prior cars and light duty trucks. *tt
- Bulletin:
- 02054
- Component:
- 136200 visibility:windshield wiper/washer:motor
- Summary:
- Special policy adjustment - windshield wiper motor failures. *tt
- Bulletin:
- 02054
- Component:
- 136000 visibility:windshield wiper/washer
- Summary:
- Windshield wiper failure due to cracked boulder joints on the controller circuit board. this special policy covers the condition for a period of seven years or 70,000 miles, whichever occurs first from the date the vehicle was originally p
- Bulletin:
- 01349A
- Component:
- 093000 fuel system, other:fuel injection system
- Summary:
- 6.5l l49 l56 l57 l65 diesel engine requiring fuel injection pump replacement. models p32/p42 1994-1999 included. *tt
Home | Privacy