1994 FORD MUSTANG Recalls (13)

Campaign:
95V062000 on 03/30/1995
Component:
Seats
Manufactured:
04/30/1993 - 05/31/1994
Affected:
54,000
Defect:
The wire harness on these seats is banded to the front seat cushion supports. the end of one of the supports can puncture the harness, resulting in a high resistance electrical short.
Consequence:
Overheating can result, and melting, smoke and possible ignition of the surrounding materials can occur.
Correction:
Dealers will remove the tie strap from each of the front seats.
Notes:
System: interior; seat; material.vehicle description: gt model passenger vehicles equipped with the power lumbar feature on the front seats.note: if your vehicle is presented to an authorized dealer on an agreed upon service date and the remedy is not provided free of charge within a reasonable time, please contact ford at 1-800-392-3673. also contact the national highway traffic safety administration's auto safety hotline at 1-800-424-9393.
Campaign:
97V180000 on 10/20/1997
Component:
Structure:body:hood
Manufactured:
10/03/1993 - 12/30/1995
Affected:
769,000
Defect:
Vehicle description: passenger vehicles and mini vans. tearing of the bond between the inner and outer hood panels during minor front end collisions can result in a gap at the leading edge of the hood. air forced between the inner and outer panels can produce enough pressure to force the outer panel upward.
Consequence:
This condition can result in total separation of the outer hood panel.
Correction:
Dealers will inspect the hood area for any damage along the leading edge of the hood. if there is any evidence of bond separation, the hood will be replaced. if there is no evidence of bond separation, additional adhesive will be applied between the inner and outer hood panels.
Notes:
Owner notification began november 10, 1997. owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact ford at 1-800-392-3673.also contact the national highway traffic safety administration's auto safety hotline at 1-800-424-9393.
Campaign:
00V349000 on 10/30/2000
Component:
Parking brake:conventional
Manufactured:
10/03/1993 - 10/09/2000
Affected:
434,000
Defect:
Vehicle description: passenger vehicles equipped with manual transmissions. if a vehicle is parked with the parking brake not fully applied and not in first gear, as directed in the owner guide, and the self adjustment pawl subsequently skips one or two teeth, the vehicle could move on some grades.
Consequence:
This could result in unintended vehicle movement and a vehicle crash without prior warning.
Correction:
Dealers will modify the parking brake control and install a plate or over-bracket to the control to lock the self adjust mechanism in position following adjustment.
Notes:
Owner notification began november 28, 2000.owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact ford at 1-800-392-3673.also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
Campaign:
01V318000 on 10/09/2001
Component:
Air bags:frontal:driver side inflator module
Affected:
911
Defect:
Equipment description: passenger vehicles that have had the driver's air bag module replaced after april 5, 2000. the replacement driver's air bag module inflator may have insufficient welds that could prevent proper inflation of the air bag.
Consequence:
in the event of a crash, the driver's air bag may not properly deploy which could potentially result in less than the intended level of occupant protection.
Correction:
Dealers will inspect and, if necessary, replace the driver's air bag module. owner notification began october 5, 2001. owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact ford at 1-866-436-7332.
Notes:
Also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
Campaign:
06E023000 on 03/13/2006
Component:
Exterior lighting:headlights
Affected:
292,000
Defect:
Certain anzo combination headlamp assemblies sold as replacement lamps for use on certain passenger vehicles. some combination lamps are not equipped with amber side reflectors which fail to conform to federal motor vehicle safety standard no. 108, "lamps, reflective devices, and associated equipment."
Consequence:
Without the amber reflectors, the vehicle will be poorly illuminated, possibly resulting in a vehicle crash.
Correction:
Anzo will notify owners and replace the headlamps free of charge. the recall began may 9, 2006. owners may contact anzo usa at 909-468-3688.
Notes:
This recall only pertains to aftermarket headlamp assemblies manufactured by anzo and has no relation to any original equipment installed on the listed passenger vehicles.customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov.
Campaign:
06E025000 on 03/20/2006
Component:
Exterior lighting:headlights
Affected:
1,450
Defect:
Certain poli-auto combination headlamp assemblies, p/nos. 11-728, 11-728d, 11-710, 11-419, 11-713, 11-703, 11-704, 11-708p, 11-735, 11-725, 11-726, 11-716 (p&c), 11-721-1, 11-733, 11-729, 11-730, and 11-732, sold as replacement lamps for use on certain passenger vehicles. some combination lamps that are not equipped with amber side reflectors fail to conform to federal motor vehicle safety standard no. 108, "lamps, reflective devices, and associated equipment."
Consequence:
Without the amber reflectors, the vehicle will be poorly illuminated, possibly resulting in a vehicle crash without warning.
Correction:
Poli-auto will notify owners and offer to repurchase the headlamps at its original purchase price. the recall is expected to begin during april 2006. owners may contact poli-auto at 305-477-1356.
Notes:
Customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov.
Campaign:
06E026000 on 03/22/2006
Component:
Exterior lighting
Affected:
61,944
Defect:
Certain pro-a motors corner lamps, turn signals, and headlights sold as replacement lamps for use on certain passenger vehicles listed above. some combination lamps that are not equipped with amber side reflectors fail to conform to federal motor vehicle safety standard no. 108, lamps, reflective devices, and associated equipment.
Consequence:
Without the amber reflectors, the vehicle will be poorly illuminated, possibly resulting in a vehicle crash without warning.
Correction:
Pro-a motors will notify owners and offer to repurchase the lamps. the recall began on april 3, 2006. owners may contact pro-a motors at 323-838-2988.
Notes:
This recall only pertains to pro-a motors aftermarket lamps and has no relation to any original equipment installed on the listed passenger vehicles.for more information on the lamp model numbers, click on document search and view document titled "lamp model numbers."customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov.
Campaign:
06E049000 on 06/04/2006
Component:
Exterior lighting
Affected:
27,176
Defect:
Certain ck motorsports combination headlights, clear corner, bumper, and side marker lights sold as replacement lamps for use on the passenger vehicles listed above. some combination lamps that are not equipped with amber side reflectors fail to conform to federal motor vehicle safety standard no. 108, lamps, reflective devices, and associated equipment.
Consequence:
Without the amber reflectors, the vehicle will be poorly illuminated, possibly resulting in a vehicle crash without warning.
Correction:
Ck motorsport will notify owners and replace the noncompliant lamps free of charge. the recall began on july 1, 2006. owners may contact ck motorsport at 1-909-610-7211.
Notes:
This recall only pertains to aftermarket replacement equipment and has no relation to any original equipment installed on vehicles manufactured by the vehicle manufacturers.for more information on the lamp model numbers, click on document search and view document titled "lamp model numbers."customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov.
Campaign:
06E060000 on 06/28/2006
Component:
Exterior lighting
Affected:
87,745
Defect:
Certain aai motorsports combination lamps sold as replacement lamps for use on the above list passenger vehicles. combination lamps not equipped with amber side reflectors fail to conform with the requirements of federal motor vehicle safety standard no. 108, "lamps, reflective devices, and associated equipment."
Consequence:
Lack of amber side reflectors in the lamps will decrease lighting visibility to other drivers and may possibly result in a vehicle crash
Correction:
Aai motorsports will notify owners and replace the lamps free of charge. the recall began on august 1, 2006. owners may contact aai motorsports at 909-923-9188.
Notes:
This recall only pertains to aai motorsports aftermarket lamps and has no relation to any original equipment installed on the listed passenger vehicles.for more information on the lamp model numbers, click on document search and view document titled "lamp model numbers."customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov.
Campaign:
06E064000 on 07/16/2006
Component:
Exterior lighting
Affected:
4,029
Defect:
Certain tradesonic combination lamps sold as replacement lamps for use on the above listed passenger vehicles. combination lamps not equipped with amber side reflectors fail to conform with the requirements of federal motor vehicle safety standard no. 108, lamps, reflective devices, and associated equipment.
Consequence:
Lack of amber side reflectors in the lamps will decrease lighting visibility to other drivers and may possibly result in a vehicle crash.
Correction:
Tradesonic will notify owners and replace the lamps free of charge. the recall is expected to begin during july 2006. owners may contact tradesonic at 626-934-8884.
Notes:
This recall only pertains to tradesonic aftermarket lamps and has no relation to any original equipment installed on the listed passenger vehicles.for more information on the lamp model numbers, click on document search and view document titled "lamp model numbers."customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov.
Campaign:
08E050000 on 08/13/2008
Component:
Exterior lighting:headlights
Affected:
1,921
Defect:
K2 motor is recalling 1,921 aftermarket headlamps of various models sold for use on the above listed vehicles. these headlamps are missing the amber side reflex reflector which fails to conform with the requirements of federal motor vehicle safety standard no. 108, "lamps, reflective devices, and associated equipment."
Consequence:
Without the amber side reflex reflectors, the lighting visibility may be affected, possibly resulting in a vehicle crash.
Correction:
K2 motor will notify owners and offer a full refund. the recall began on decemeber 17, 2008. owners may contact k2 motor at 1-909-839-2992.
Notes:
This recall only pertains to aftermarket replacement equipment and has no relation to any original equipment installed on vehicles manufactured by honda, ford, or chrysler llc. customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov.
Campaign:
09E012000 on 04/06/2009
Component:
Exterior lighting
Affected:
16,270
Defect:
Sabersport is recalling 16,270 combination corner and bumper lamp assemblies of various part numbers sold for use as aftermarket equipment for various passenger vehicles. these headlamps fail to conform to the requirements of federal motor vehicle safety standard no. 108, "lamps, reflective devices, and associated equipment." these lamps do not contain the required amber side reflectors.
Consequence:
Decreased lighting visibility may result in a vehicle crash.
Correction:
Sabersport will notify owners and offer a full refund for the noncompliant combination lamps. the safety recall began on may 11, 2009. owners may contact sabersport at 1-909-598-7589.
Notes:
This recall only pertains to aftermarket replacement equipment and has no relation to any original equipment installed on vehicles produced by the vehicle manufacturer.in order to determine if your aftermarket lamp assembly is affected by this noncompliance, please review the list of model numbers provided to us by sabersport.the list can be found under "document search" located at the bottom of your screen.owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to <a href=http://www.safercar.gov>http://www.safercar.gov</a> .
Campaign:
09E025000 on 05/10/2009
Component:
Exterior lighting:headlights
Affected:
42,540
Defect:
Dope, inc. is recalling 42,540 combination corner and bumper lamp assemblies of various part numbers sold for use as aftermarket equipment for various passenger vehicles. these headlamps fail to conform to the requirements of federal motor vehicle safety standard no. 108, "lamps, reflective devices, and associated equipment." these lamps do not contain the required amber side reflectors.
Consequence:
Decreased lighting visibility may result in a vehicle crash.
Correction:
Dope, inc. will notify owners and offer a full refund for the noncompliant combination lamps. the safety recall began on july 28, 2009. owners may contact dope, inc. at 1-626-272-1798.
Notes:
This recall only pertains to aftermarket replacement equipment and has no relation to any original equipment installed on vehicles produced by the vehicle manufacturer.in order to determine if your aftermarket lamp assembly is affected by this noncompliance, please review the list of model numbers provided to us by dope, inc.the list can be found under "document search" located at the bottom of your screen. owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to <a href=http://www.safercar.gov>http://www.safercar.gov</a> .

1994 FORD MUSTANG TSBs (125)

Bulletin:
94235
Component:
034530 service brakes, hydraulic:foundation components:disc:rotor
Summary:
front disc brake noise while braking. *tw
Bulletin:
942311
Component:
133000 visibility:power window devices and controls
Summary:
manfacturer request for return of front door outside electric mirror. *tw
Bulletin:
94222
Component:
162000 structure:body
Summary:
mouldings - rocker panel loose. *tw
Bulletin:
94269
Component:
103000 power train:automatic transmission
Summary:
delayed or no forward engagement of transmission. *tw
Bulletin:
BC8795950103
Component:
162000 structure:body
Summary:
a slight engine vibration may be felt in the vehicle, steering column, floor or seat. *tw
Bulletin:
BC8807950103
Component:
114000 electrical system:wiring
Summary:
inoperable power seats, lighter and auxiliary power point due to a shorted wire. *tw
Bulletin:
9524
Component:
062100 engine and engine cooling:cooling system:radiator assembly
Summary:
new radiator manufacturing process/modification. *tw
Bulletin:
95310
Component:
061000 engine and engine cooling:engine
Summary:
new torque-to-yield cylinder head bolt kit. *tw
Bulletin:
95313
Component:
103000 power train:automatic transmission
Summary:
possible water intrusion in the mlp/tr sensor causing shift concern. *tw
Bulletin:
BC2850950401
Component:
103700 power train:automatic transmission:torque converter
Summary:
torque converter clutch shudder/vibration. *tw
Bulletin:
95511
Component:
138110 visibility:defroster/defogger system:windshield:blower
Summary:
chirp or squeak from blower motor. *tw
Bulletin:
95514
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
revised oil fill procedures. *tw
Bulletin:
95515
Component:
103000 power train:automatic transmission
Summary:
there may be an intermittent loss of torque during or just after the 3-4 upshift or in 4th gear on some vehicles. *tw
Bulletin:
9562
Component:
034500 service brakes, hydraulic:foundation components:disc
Summary:
roughness concern during brake application. *tw
Bulletin:
9563
Component:
034520 service brakes, hydraulic:foundation components:disc:pads
Summary:
rear brake squeak. *tw
Bulletin:
9566
Component:
138110 visibility:defroster/defogger system:windshield:blower
Summary:
chirp or squeak noise from blower motor at low speeds. *tw
Bulletin:
9568
Component:
061000 engine and engine cooling:engine
Summary:
revised oil pan gasket. *tw
Bulletin:
BC2630950503
Component:
103000 power train:automatic transmission
Summary:
vehicles may exhibit a whine noisewhen driving at a steady speed around 38-44 mph. *tw
Bulletin:
BC2631950503
Component:
162000 structure:body
Summary:
vehicles may exhibit a rumble/clunk when going over bumps. *tw
Bulletin:
BC8934950503
Component:
103000 power train:automatic transmission
Summary:
vehicles equipped with an automatic transmission may exhibit a whine noise. *tw
Bulletin:
9571
Component:
162000 structure:body
Summary:
the cowl top vent grille assembly may crack at the washer jet. *tw
Bulletin:
9592
Component:
138110 visibility:defroster/defogger system:windshield:blower
Summary:
Unknown
Bulletin:
95102
Component:
116000 electrical system:ignition
Summary:
vehicles may have a disconnect of the ignition control module (icm) connector or moisture buildup within the connector. *tw
Bulletin:
95112
Component:
034000 service brakes, hydraulic:foundation components
Summary:
cobra vehicles only - a rattle noise may be heard from the fron wheels when going over bumps and/or a clunk noise may be heard when stopping from reverse. *tw
Bulletin:
BC2850950401
Component:
034500 service brakes, hydraulic:foundation components:disc
Summary:
Unknown
Bulletin:
BC1292950906
Component:
980000 unknown or other
Summary:
vehicles may exhibit a condition where the center console finish panel may not seat properly or may pop out. this may be due to improper adjustment of instrument panel to floor mounting.
Bulletin:
95173
Component:
162000 structure:body
Summary:
interior trim-console-interference between parking brake handle and console gap hider. *sd
Bulletin:
95175
Component:
051120 parking brake:conventional:mechanical:linkage and cable
Summary:
brakes-rubbing noise from underneath vehicles-parking brake cable conduit contacting driveshaft. noise-rubbing noisefrom underneath vehicle-parking brake cable conduit contacting driveshaft. *sd
Bulletin:
BC0112960102
Component:
162000 structure:body
Summary:
convertibles built after 12/4/95 will incorporate revised inside visor mounting brackets. the brackets were revised to allow for longer convertible top alignment pins. the mating holes for the convertible top alignment pins now go all the
Bulletin:
BC0114960102
Component:
021000 suspension:front
Summary:
mustang does not provide a simple means of caster adjustment when performing a front end alignment. engineering is developing a service procedure to allow easier caster adjustment. a tsb will be issued.
Bulletin:
BC0232960102
Component:
122000 exterior lighting:fog lights
Summary:
if mustang w/ inoperative fog lamp, check fog lamp for any signs of water intrusion. replace the fog lamp w/ current service parts if water intrusion is evident.
Bulletin:
95212
Component:
036000 service brakes, hydraulic:antilock
Summary:
the use of petroleum-based grease as a lubricant in servicing disc brakes is no longer acceptable because it may be incompatible with the rubber material used in the disc brake system. if petroleum-based grease is used to lubricate any par
Bulletin:
BC0678961025
Component:
102000 power train:manual transmission
Summary:
Information on aode/4r7w transmission main control & case replacement. *tt
Bulletin:
BC0810961011
Component:
103700 power train:automatic transmission:torque converter
Summary:
Vehicles equipped w/ an aode or 4r70w trans has a concern of shudder from the transmission torque converter clutch in 3rd or 4th gear or during 3-4 shift. *tt
Bulletin:
BC0351961126
Component:
061000 engine and engine cooling:engine
Summary:
Ford improvement program request for information on oil leak at the rear crankshaft oil seal. *tw
Bulletin:
96246
Component:
114000 electrical system:wiring
Summary:
Wiring - electrical diode identification and service replacements. *tw
Bulletin:
96249
Component:
103700 power train:automatic transmission:torque converter
Summary:
Torque converter - leak test procedure - service tip. *tw
Bulletin:
96221
Component:
131000 visibility:windshield
Summary:
Windshield and interior glass - fog/film. *tw
Bulletin:
96222
Component:
034000 service brakes, hydraulic:foundation components
Summary:
Brakes - elimination of sanding rotors and drums - service tip. *tw
Bulletin:
96225
Component:
075000 fuel system, gasoline:carburetor system
Summary:
Mass air flow sensor - replacement as an assembly - service tip. *tw
Bulletin:
96226
Component:
353600 equipment:air conditioner
Summary:
Air conditioning - compressor failure - insufficient amount of refrigerant oil. *tw
Bulletin:
962511
Component:
116200 electrical system:ignition:module
Summary:
Powertrain control module -reprogram powertrain control module (pcm) - service procedures - service tip. *tw
Bulletin:
962517
Component:
103700 power train:automatic transmission:torque converter
Summary:
Transmission - aode - 4r70w - shudder or vibration under light to moderate acceleration above 56 km/h (35 mph) while in 3rd or 4th gear. *tw
Bulletin:
96264
Component:
034520 service brakes, hydraulic:foundation components:disc:pads
Summary:
Brakes - rear brakes squeak - vehicles built through 11/20/94. *tw
Bulletin:
96268
Component:
138110 visibility:defroster/defogger system:windshield:blower
Summary:
Blower motor - intermittent or inoperative - temperatures at or below 0 degrees c (32 degrees f). *tw
Bulletin:
962612
Component:
103700 power train:automatic transmission:torque converter
Summary:
Transaxle - torque converter replacement guidelines and torque converter/transaxle cooling system cleaning procedures - service tip. *tw
Bulletin:
BC0351970201
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Engine oil leak at the rear crankshaft oil seal. *jd
Bulletin:
BC0351972301
Component:
061000 engine and engine cooling:engine
Summary:
An engine oil leak at the rear crankshaft oil seal. *jd
Bulletin:
9743
Component:
061000 engine and engine cooling:engine
Summary:
Blower motor- "chirp" or "squeak" from blower motor at low speeds. *jd
Bulletin:
BC3221970212
Component:
102000 power train:manual transmission
Summary:
Vibration/noise from the clutch pedal. *tw
Bulletin:
9751
Component:
220000 seats
Summary:
Interior- leather seat cleaning procedure- service tip. *jd
Bulletin:
97511
Component:
103000 power train:automatic transmission
Summary:
Fluid- transmission fluid usage charts. *jd
Bulletin:
9768
Component:
980000 unknown or other
Summary:
Fuel economy- customer expectations versus vehicle usage. *jd
Bulletin:
97610
Component:
061000 engine and engine cooling:engine
Summary:
Blower motor- "chirping" or "squeaking" from blower motor at low speeds. *jd
Bulletin:
BC2292970501
Component:
021400 suspension:front:macpherson strut
Summary:
Instructions on how to adjust the caster when performing a front end alignment. *tw
Bulletin:
BC2299970501
Component:
102000 power train:manual transmission
Summary:
Vehicles built prior to 3/1/97 may encounter difficulty getting the shift lever into gear when the clutch disc is hot. *tw
Bulletin:
BC2361970501
Component:
980000 unknown or other
Summary:
Authorized warranty part replacement of brake pads to correct excessive brake noise. *tw
Bulletin:
BC105879705
Component:
021000 suspension:front
Summary:
Instructions for adjusting the caster when performing a front end alignment. *tw
Bulletin:
BC105949705
Component:
102000 power train:manual transmission
Summary:
Vehicles may encounter difficulty getting the shift lever into gear when the clutch disc is hot. *tw
Bulletin:
97111097234
Component:
113000 electrical system:starter assembly
Summary:
Vehicles exhibiting a "squeaking" or "chirping" from the blower motor at low blower motor speeds. *yc
Bulletin:
985A5
Component:
034530 service brakes, hydraulic:foundation components:disc:rotor
Summary:
Hub-mount brake rotor machining equipment from rotunda is now approved for warranty and service use. *yc
Bulletin:
985A8
Component:
051120 parking brake:conventional:mechanical:linkage and cable
Summary:
Some vehicles may have a rubbing noise coming from underneath the vehicle-parking brake cable conduit contacting driveshaft. *ak
Bulletin:
985A9
Component:
034000 service brakes, hydraulic:foundation components
Summary:
On cobra vehicles only, a rattling noise may be heard from the front wheels when going over bumps and / or a clunking noise may be heard when stopping from reverse. *tt
Bulletin:
985A10
Component:
034400 service brakes, hydraulic:foundation components:drum
Summary:
Experiencing a squeaking noise coming from the rear brakes on some vehicles. *tt
Bulletin:
985A11
Component:
034000 service brakes, hydraulic:foundation components
Summary:
Service tip information regarding elimination of sanding rotors and drums. *yc
Bulletin:
985A13
Component:
034500 service brakes, hydraulic:foundation components:disc
Summary:
The use of petroleum-based grease as a lubricant in servicing disc brakes is no longer acceptable. *yc
Bulletin:
9887
Component:
103700 power train:automatic transmission:torque converter
Summary:
Experiencing a torque converter clutch shudder or vibration. *yc
Bulletin:
9888
Component:
103000 power train:automatic transmission
Summary:
Information on a new transmission fluid usage chart. *yc
Bulletin:
9845
Component:
045300 service brakes, air:disc:rotor
Summary:
Availability of hub-mount brake rotor machining equipment. *yc
Bulletin:
9852
Component:
190000 tires
Summary:
Information on tire company telephone numbers for customer assistance. *yc
Bulletin:
9864
Component:
063000 engine and engine cooling:exhaust system
Summary:
Information on a buzzing or rattle noise from the exhaust system. *tt
Bulletin:
9873
Component:
353400 equipment:electrical:radio/tape deck/cd etc.
Summary:
Experiencing a whining / buzzing noise in the speakers of the entertainment radio or two-way radio. *tt
Bulletin:
9874
Component:
061000 engine and engine cooling:engine
Summary:
A new silicone gasket and sealant. *yc
Bulletin:
98253
Component:
132000 visibility:glass, side/rear
Summary:
Concerns with the front window may travel beyond the upstop and exit the glass run on some vehicles. *yc
Bulletin:
982010
Component:
063000 engine and engine cooling:exhaust system
Summary:
Experiencing a " buzzing " or " rattling " noise from the exhaust system. *yc
Bulletin:
98222
Component:
101000 power train:clutch assembly
Summary:
Experiencing vibration/ noise felt in clutch pedal when lightly touching clutch pedal. *yc
Bulletin:
982310
Component:
063100 engine and engine cooling:exhaust system:emission control
Summary:
Mass air flow (maf)- sensor contamination- service tip. *ak
Bulletin:
98246
Component:
110000 electrical system
Summary:
Ford motor company has released a new electrical grease ( f8az - 19g208-aa ) to reduce the possibility of moisture corrosion at the terminals. *yc
Bulletin:
9943
Component:
100000 power train
Summary:
Information regarding reprogramming powertrain control modules (pcms). *tt
Bulletin:
9814
Component:
034530 service brakes, hydraulic:foundation components:disc:rotor
Summary:
Subject regarding the availability of hub-mount brake rotor machining equipment. *tt
Bulletin:
99816
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Ford motor company now recommends sae 5w-30 viscosity grade for servicing any ford gasoline-powered vehicle regardless of model year. *tt
Bulletin:
99129
Component:
353400 equipment:electrical:radio/tape deck/cd etc.
Summary:
Experiencing a whine / buzz type noise in the speakers of the entertainment radio or two-way radio on vehicles with an in-tank electric fuel pump. *tt
Bulletin:
99139
Component:
125000 exterior lighting:brake lights
Summary:
Conditions with the brake lamps inadvertently disabling the brake shift interlock. *tt
Bulletin:
12899
Component:
221600 seats:front assembly:power adjust
Summary:
Information on power seat switch replacement. *tt
Bulletin:
99222
Component:
114000 electrical system:wiring
Summary:
Subject on a wire harness terminal repair kit available for repairing electrical wiring harnesses. *tt
Bulletin:
99225
Component:
162900 structure:body:roof and pillars
Summary:
Concerns with the convertible top boot may fit improperly or be difficult to install on some vehicles due to the top not folding down all the way into the well. *tt
Bulletin:
99194
Component:
034000 service brakes, hydraulic:foundation components
Summary:
Information for servicing and diagnosing brake vibration, brake inspection, and brake friction material replacement. *tt
Bulletin:
99195
Component:
353600 equipment:air conditioner
Summary:
Service information for musty and mildew type odors coming from the air conditioning / heating system. *tt
Bulletin:
99196
Component:
353600 equipment:air conditioner
Summary:
Information on identifying non-approved / alternate refrigerants which could cause safety, and performance concerns if installed in ford a/c systems. *tt
Bulletin:
6997
Component:
061000 engine and engine cooling:engine
Summary:
Some service manuals may list the incorrect camshaft position sensor alignment tool for vehicles with various engine sizes. *tt
Bulletin:
13180
Component:
061000 engine and engine cooling:engine
Summary:
Information regarding camshaft position (cmp) sensor alignment tool chart. *mjs
Bulletin:
13428
Component:
162300 structure:body:door
Summary:
Some convertibles may exhibit a rattle noise fromthe door wedge when driving on rough roads. *tt
Bulletin:
6512
Component:
221600 seats:front assembly:power adjust
Summary:
Some vehicles may exhibit some normal service concerns with power seat operation. *tt
Bulletin:
0015
Component:
103000 power train:automatic transmission
Summary:
Information regarding the new transmission cooler flusher- service tip. *mjs
Bulletin:
7854
Component:
036000 service brakes, hydraulic:antilock
Summary:
Abs diagnostic trouble codes(dtcs) can only be retrieved using super starii tester or the flash out procedure by grounding out diagnostic circuit at test connector.
Bulletin:
12073
Component:
063000 engine and engine cooling:exhaust system
Summary:
Vehicles with federal emission equipped 1998, may exhibit a fuel smell in the passenger compartment at times. *mjs
Bulletin:
5031
Component:
063100 engine and engine cooling:exhaust system:emission control
Summary:
Some vehicles and certain federal emission equipped vehicles may exhibit a fuel smell in the passenger compartment at times. *tt
Bulletin:
12178
Component:
100000 power train
Summary:
Information regarding tsb 98-5a-12 (transaxle/transmission/transfer case-vehicles towed behind recreational vehicles-recommended guidelines) does not list towing information for certain model vehicles. *mjs
Bulletin:
9677
Component:
980000 unknown or other
Summary:
Illumination of the malfunction indicator lamp (mil) and / or the o/d light flashing. *tt
Bulletin:
96714
Component:
100000 power train
Summary:
Subject regarding a new transmission case and main control released for service on aode / 4r70w transmissions. *tt
Bulletin:
8485
Component:
980000 unknown or other
Summary:
Information regarding free floor mat exchange. **mr
Bulletin:
00M10
Component:
061000 engine and engine cooling:engine
Summary:
Subject regarding owner notification program supplement #1 3.8l engine head gaskets. *tt
Bulletin:
99152
Component:
103000 power train:automatic transmission
Summary:
Information on the new flush and fill tool available through rotunda. *tt
Bulletin:
4696
Component:
353400 equipment:electrical:radio/tape deck/cd etc.
Summary:
Subject regarding the subwoofer enclosure on coupes with the mach 460 audio system. *tt
Bulletin:
11804
Component:
353400 equipment:electrical:radio/tape deck/cd etc.
Summary:
Subject regarding the subwoofer enclosure on coupes with the mach 460 audio system. *tt
Bulletin:
00M10S2
Component:
061000 engine and engine cooling:engine
Summary:
Some vehicles may exhibit premature failure of the head gasket(s). this condition may result in engine coolant leakage, which, if not detected, can cause engine overheating. *tt
Bulletin:
00241
Component:
101100 power train:clutch assembly:pedal/linkage
Summary:
Some vehicles may exhibit a vibration that may be heard of felt at the clutch pedal between idle and 2300 rpm, and goes away when depressing the clutch at least 25mm. *tt
Bulletin:
002310
Component:
103600 power train:automatic transmission:cooling unit and lines
Summary:
Subject regarding contamination from prior transmission concerns or excess wear may be trapped in the transmission fluid cooling system. *tt
Bulletin:
00S37S1
Component:
050000 parking brake
Summary:
Subject regarding parking brake control assembly modification. *tt
Bulletin:
00212
Component:
162800 structure:body:hood
Summary:
Some vehicles may exhibit a hood that is hard to close. *jb
Bulletin:
14149
Component:
021000 suspension:front
Summary:
Information on caster adjustment when performing a front end alignment. *tt
Bulletin:
15067
Component:
100000 power train
Summary:
Some vehicles equipped with a manual transmission may exhibit a powertrain noise described as a brief roar, hoot or groan betwen 2500 - 3500 rpm when the clutch pedal is half way down, during shifting or when depressing and releasing the cl
Bulletin:
01156
Component:
138120 visibility:defroster/defogger system:windshield:heater core
Summary:
Some vehicles may exhibit heater core leaks. *slc
Bulletin:
01157
Component:
980000 unknown or other
Summary:
Information regarding transmission fluid usage charts. *slc
Bulletin:
15178
Component:
132000 visibility:glass, side/rear
Summary:
Some vehicles exhibit the door glass popping off track. *yh
Bulletin:
01181
Component:
103800 power train:automatic transmission:park/neutral start switch
Summary:
Brake shift interlock.*jb
Bulletin:
15205
Component:
131000 visibility:windshield
Summary:
Some vehicles may exhibit the door glass coming off of the window track. *tt
Bulletin:
00M09
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Information regarding engine replacements warranty extension program. *yh
Bulletin:
00M10
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Information regarding engine replacements warranty extension program. *yh
Bulletin:
0214
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Some engine assemblies with aluminum cylinder heads repaired in-vehile have been found to leak coolant and/or oil from the cylinder head gasket area. *tt
Bulletin:
15702
Component:
180000 vehicle speed control
Summary:
Subject regarding speed control lamp. *tt
Bulletin:
03181
Component:
110000 electrical system
Summary:
Remote keyless entry (rke) - service tips. *tt
Bulletin:
03261
Component:
103000 power train:automatic transmission
Summary:
New service part - number 5 needle bearing and race kit - 4r70w transmission - service tip. *tt
Bulletin:
02176
Component:
032100 service brakes, hydraulic:switches:brake light
Summary:
Lamp-brake-invadvertent disabling of brake shift interlock. *mj
Bulletin:
02208
Component:
353600 equipment:air conditioner
Summary:
Climate control a/c service tech tips. *eh

Home | Privacy