1994 FORD E-350 Recalls (5)

Campaign:: 93V194000 on 11/30/1993
Component:: Parking brake:conventional
Affected:: 106
Defect:: These vehicles do not comply with fmvss 105, "hydraulic brake systems." the parking brake application force for a foot operated control system should not exceed 125 pounds to hold the vehicle on a 30% grade. interference between the parking brake pedal and a wire harness may increase the needed pedal force to greater than 125 pounds to set the parking brake to hold the vehicle on the 30% grade.
Consequence:: The interference between the foot pedal and the wireharness may not allow the parking brake to fully set. if this occurs when thevehicle is parked on an incline, it may roll, causing a crash.
Correction:: Final stage manufacturers will be informed of this condition and provided with parts and instructions necessary to correct this situation.
Notes:: System: emergency parking brake; mechanical; fmvss 105.vehicle description: full-size vans, 9600 lb. gvw, equipped with single rearwheels and school bus preparation packages.note: if your vehicle is presented to an authorized dealer on an agreed uponservice date and the remedy is not provided within an reasonable time and freeof charge or the remedy does not correct the defect or noncompliance, pleasecontact ford service center at 1-800-392-3673. also, contact the nationalhighway traffic safety administration's auto safety hotline at 1-800-424-9393.
Campaign:: 06V286000 on 08/01/2006
Component:: Vehicle speed control
Affected:: 1,200,000
Defect:: On certain trucks equipped with speed control, gasoline or natural gas engines, the speed control deactivation switch may overheat.
Consequence:: Overheating could result in smoke or burn and an underhood fire.
Correction:: Dealers will install a fused wiring harness into the speed control system free of charge. the recall began on august 7, 2006. owners may contact ford at 1-866-436-7332. (note: also see recalls 05v017 and 05v388)
Notes:: Ford recall no. 05s28.customers may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov.
Campaign:: 08V051000 on 02/03/2008
Component:: Vehicle speed control:cruise control
Manufactured:: 09/02/1991 - 09/14/2003
Affected:: 225,000
Defect:: Ford is recalling 225,000 my 1992-2003 econoline, my 1993-1995 taurus sho, my 1992-1998 crown victoria, my 1993 bronco, f-series, my 1995-1997 f-series super duty stripped chassis, my 1992-1998 mercury grand marquis, and my 1992-1995 lincoln town car vehicles. the affected vehicles were previously repaired using a wiring harness that is not compatible with the vehicle circuit polarity.
Consequence:: As a result, the fuse is located in the output circuit rather than in the intended input power feed circuit, and may not offer the intended protection in the event of an electrical short to ground.
Correction:: Dealers will install a new wiring harness, or replace the mating electrical component. the recall began on february 18, 2008. owners may contact ford at 1-800-392-3673.
Notes:: Ford recall no. 08s01.customers may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov.
Campaign:: 09V399000 on 10/12/2009
Component:: Vehicle speed control
Affected:: 4,500,000
Defect:: Ford is recalling model years 1995-2003 windstar, 2000-2003 excursion diesel, 1993-1997 and 1999-2003 f-250 sd through f-550 sd diesel, 1992-2003 e-150 through e-550, 1995-2002 explorer, 1997 and 2002 mercury mountaineer, 1995-1997 and 2001-2003 ranger, and 1994 f53 vehicles equipped with the texas instruments speed control deactivation switch (scds). the scds may leak internally and then overheat, smoke, or burn.
Consequence:: A vehicle fire could occur with or without the engine running.
Correction:: Ford will notify owners that dealers will install a fused wiring harness in line with the scds. on 1999-2003 windstar vehicles with a leaking scds, dealers will also inspect the abs control module connector and repair as necessary. repairs will be completed free of charge. the safety recall began on october 27, 2009. owners may contact ford at 1-888-222-2751.
Notes:: Ford's recall campaign number is 09s09.owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to <a href=http://www.safercar.gov>http://www.safercar.gov</a> .
Campaign:: 14V197000 on 04/20/2014
Component:: Equipment adaptive
Manufactured:: 11/19/2006 - 09/09/2010
Affected:: 66
Defect:: Cummings mobility conversion & supply, inc. (cummings) is recalling various model year 1994-2011 ford and chevrolet vans equipped with braun ncl-2, and nvl-2 wheel chair lifts manufactured november 20, 2006, through september 10, 2010. over time, and with frequent use, the roll stop latches on the outer barrier of the lifts in these vans may become bent or misaligned.
Consequence:: A wheelchair occupant may defeat or ride over the insufficiently latched roll stop. if this occurs when the lift platform is in an elevated position, the wheelchair's occupant could fall and sustain injury.
Correction:: Braun corporation notified all the vehicle owners, and cummings mobility replaced the recalled parts with new parts, free of charge. the recall was completed as of april 10, 2014. owners may contact cummings customer service at 1-800-639-5438.
Notes:: Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.

1994 FORD E-350 TSBs (42)

Bulletin:: 95524
Component:: 061100 engine and engine cooling:engine:gasoline
Summary:: there may be a concern of poor performance, coolant in the oil and engine knocking and/or hydraulic lock on some vehicles. *tw
Bulletin:: 9596
Component:: 022140 suspension:rear:springs:leaf spring assembly
Summary:: Unknown
Bulletin:: 9599
Component:: 061100 engine and engine cooling:engine:gasoline
Summary:: Unknown
Bulletin:: 951111
Component:: 103000 power train:automatic transmission
Summary:: Vibration - driveline vibration at highway speeds - extention housing seal leakage. *tw
Bulletin:: 951113
Component:: 103000 power train:automatic transmission
Summary:: delayed forward engagement and/or heat stained forward clutch plates after installing center support service. *tw
Bulletin:: BC2893950401
Component:: 061100 engine and engine cooling:engine:gasoline
Summary:: Unknown
Bulletin:: BC1351950906
Component:: 073200 fuel system, gasoline:fuel injection system:injectors
Summary:: rough idle or miss may be due to loose injector hold down bolt. *tw
Bulletin:: BC0678961025
Component:: 102000 power train:manual transmission
Summary:: Information on aode/4r7w transmission main control & case replacement. *tt
Bulletin:: BC0820961010
Component:: 103000 power train:automatic transmission
Summary:: Revised eec calibration has been incorporated in pcm calibrations for vehicles which display lack of power due to torque converter engagement scheduling, catalytic converter failures, rough idle or hard start on hot restart. *tt
Bulletin:: BC0883961004
Component:: 063200 engine and engine cooling:exhaust system:manifold/header/muffler/tail pipe
Summary:: Vehicles may exhibit an exhaust leak &/or noise due to warped exhaust manifolds. *tt
Bulletin:: 962213
Component:: 063200 engine and engine cooling:exhaust system:manifold/header/muffler/tail pipe
Summary:: Exhaust - exhaust leak at exhaust manifolds - vehicles equipped with 7.0l or 7.5l engine. *tw
Bulletin:: 97215
Component:: 980000 unknown or other
Summary:: Diagnostic guides for out-of-warranty vehicles to be used as a master copy - diagnostic guides no longer available from adistra. *tw
Bulletin:: BC2297970501
Component:: 075000 fuel system, gasoline:carburetor system
Summary:: When the air cleaner is being replaced, the drain mechanism on the bottom of the air cleaner case is to be cleaned of obstructions. *tw
Bulletin:: 980323
Component:: 061100 engine and engine cooling:engine:gasoline
Summary:: Concerns with external oil leaks. *yc
Bulletin:: 6417
Component:: 020000 suspension
Summary:: Addressing tire balance hints. *tt
Bulletin:: 985042
Component:: 061100 engine and engine cooling:engine:gasoline
Summary:: Repeat message regarding vehicles exhibiting rough idle / miss condition. *tt
Bulletin:: 5046
Component:: 061100 engine and engine cooling:engine:gasoline
Summary:: Repeat message regarding vehicles exhibiting a lack of power. *tt
Bulletin:: 5047
Component:: 061100 engine and engine cooling:engine:gasoline
Summary:: Repeat message regarding a hard start / no start condition. *tt
Bulletin:: 5050
Component:: 061000 engine and engine cooling:engine
Summary:: Repeat message regarding a stall on decel condition. *tt
Bulletin:: 985058
Component:: 061000 engine and engine cooling:engine
Summary:: Subject regarding external oil leaks - repeat message. *tt
Bulletin:: 985A12
Component:: 354600 equipment:mechanical:wrecker and wheel lift devices
Summary:: Recommended guidelines for towing behind recreational vehicles. *tt
Bulletin:: 980312
Component:: 061100 engine and engine cooling:engine:gasoline
Summary:: Excessive white smoke. verify glow plug operation by performing glow plug system operation check on the hard start/no start diagnostic sheet. *tt
Bulletin:: 980325
Component:: 061000 engine and engine cooling:engine
Summary:: Cold engine upper knock/tick. *yc
Bulletin:: 98-4722
Component:: 185000 vehicle speed control:cruise control
Summary:: Repeat message, no change- rough idle/miss. *ak
Bulletin:: 98-4726
Component:: 061100 engine and engine cooling:engine:gasoline
Summary:: Repeat message, no change: hard start/ no start. *ak
Bulletin:: 98-4734
Component:: 061120 engine and engine cooling:engine:gasoline:turbo-charger
Summary:: Lack of power due to failure of engine turbo boost
Bulletin:: 98-4742
Component:: 116000 electrical system:ignition
Summary:: Vehicle stalls upon acceleration. *ak
Bulletin:: 12835
Component:: 190000 tires
Summary:: Subject regarding tire balance hint. *tt
Bulletin:: 4614
Component:: 185000 vehicle speed control:cruise control
Summary:: Information on vehicles exhibiting rough idle / miss. *tt
Bulletin:: 4616
Component:: 061100 engine and engine cooling:engine:gasoline
Summary:: Brief information vehicles exhibiting hard start / no start condition. *tt
Bulletin:: 4617
Component:: 061100 engine and engine cooling:engine:gasoline
Summary:: Brief information on vehicles exhibiting lack of power condition. *tt
Bulletin:: 4625
Component:: 061100 engine and engine cooling:engine:gasoline
Summary:: Brief information on vehicles exhibiting a stall on deceleration condition. *tt
Bulletin:: 4629
Component:: 061100 engine and engine cooling:engine:gasoline
Summary:: Brief information concern vehicles exhbiting external oil leaks. *tt
Bulletin:: 5250
Component:: 185000 vehicle speed control:cruise control
Summary:: Information on super duty models with 7.3l diesel engines exhibiting rough idle / miss condition. *tt
Bulletin:: 5251
Component:: 103400 power train:automatic transmission:lever and linkage:column shift
Summary:: Some super duty vehicles with 7.3l dit diesel engines may exhibit 4x4 lights on, 4x4 inoperative and / or multiple gem codes. *tt
Bulletin:: 5254
Component:: 061100 engine and engine cooling:engine:gasoline
Summary:: Information on super duty 7.3 dit diesel engine vehicles exhibiti lack of power. *tt
Bulletin:: 5262
Component:: 180000 vehicle speed control
Summary:: Service information for vehicles exhibiting stall on deceleration condition. *tt
Bulletin:: 5343
Component:: 980000 unknown or other
Summary:: This bulletin states that replacement under warranty of certain specified components on any 7.3l dit diesel vehicle, requires that the replaced component be returned with the appropriate year diesel engine diagnostic guide for warranty reim
Bulletin:: 12261
Component:: 980000 unknown or other
Summary:: Subject regarding engine diagnostic guide for warranty reimbursement. *tt
Bulletin:: 98156
Component:: 063200 engine and engine cooling:exhaust system:manifold/header/muffler/tail pipe
Summary:: Exhaust leak at exhaust manifolds--vehicle equipped with 7.0l 0r 7.5l engine. *ak
Bulletin:: 980307
Component:: 061100 engine and engine cooling:engine:gasoline
Summary:: Vehicle stalls/quits while driving. *ak
Bulletin:: 980323
Component:: 073000 fuel system, gasoline:fuel injection system
Summary:: Dtc's p1211/1212 icp pressure higher/lower than expected.

Home | Privacy