1994 CHEVROLET CAVALIER Recalls (2)

Campaign:: 94V115000 on 06/27/1994
Component:: Steering:linkages:knuckle:spindle:arm
Manufactured:: 02/28/1994 - 02/28/1994
Affected:: 65
Defect:: These vehicles were built with overtorqued drive axle spindle nuts. this condition can cause excessive loads on the spindle nut and drive axle resulting in failure of the drive axle or the spindle nut. failure of either of these components can result in separation of the steering knuckle tire-wheel assembly from the drive axle.
Consequence:: This can result in loss of vehicle control and a vehicle accident.
Correction:: Dealers will replace the left-hand and right-hand drive axles, bearing-hub assemblies, spindle nuts, and washers on all involved vehicles. corrective action: dealers will replace left-hand and right-hand drive axles, bearing-hub assemblies, spindle nuts, and washers on all involved vehicles.
Notes:: System: suspension; independent front spindle; knuckle; steering.vehicle description: passenger cars.note: if your vehicle is presented to an authorized dealer on an agreed upon service date and the remedy is not provided within a reasonable time and free of charge or the remedy does not correct the defect or noncompliance, please contact chevrolet service center at 1-800-222-1020 or pontiac service center at 1-800-762-2737. also, contact the national highway traffic safety administration's auto safety hotline at 1-800-424-9393.
Campaign:: 96I001000 on 03/26/1996
Component:: Communications:horn assembly
Manufactured:: 03/31/1993 - 06/30/1994
Affected:: 417,000
Defect:: This is not a safety recall in accordance with federal regulation 573. however, it is deemed a safety improvement campaign by the agency. these vehicles were built with insufficient retention of the horn pad.
Consequence:: The horn pad can separate from the steering wheel falling between the steering wheel spokes. the horn pad could become jammed between the steering wheel spokes and the turn signal lever, resulting in damage to the turn signal lever, horn pad, and horn wiring.
Correction:: Dealers will modify the horn pad retention clips, install horn pad retention brackets to the steering wheel, reinstall the horn pad and assure that the horn pad is properly retained.
Notes:: Note:general motors has decided to conduct a safety improvement campaign to modify the horn pad on these vehicles.owners can contact chevrolet at 1-800-222-1020.

1994 CHEVROLET CAVALIER TSBs (18)

Bulletin:: 433211
Component:: 010000 steering
Summary:: crunch noise from right side dash area when turning steering wheel. *tw
Bulletin:: 435006A
Component:: 034510 service brakes, hydraulic:foundation components:disc:caliper
Summary:: Unknown
Bulletin:: 535010
Component:: 036000 service brakes, hydraulic:antilock
Summary:: Unknown
Bulletin:: 438101A
Component:: 162300 structure:body:door
Summary:: Unknown
Bulletin:: 9573T4001
Component:: 105000 power train:driveline
Summary:: grinding and/or growling noise in park on incline.*sd
Bulletin:: 776001
Component:: 061000 engine and engine cooling:engine
Summary:: Knock, rattle or tap noise from the engine before the engine has reached operating temperature or under light load conditions at operating temperature knock, rattle or tap noise from the engine before the engine has reached operating
Bulletin:: 733301
Component:: 021000 suspension:front
Summary:: Squawk noise coming from front suspension or engine compartment area (install ultra high molecular tape). *tw
Bulletin:: 776001
Component:: 061000 engine and engine cooling:engine
Summary:: Information concerning engine knock/rattle or tap noise before engine has reached operating temperature or under light load conditions at operating temperature (replace piston and/or rod assemblies). ak
Bulletin:: 9709015015A
Component:: 036000 service brakes, hydraulic:antilock
Summary:: Complaints that the abs indicator lamp is "on". *yc
Bulletin:: 970801735026
Component:: 036000 service brakes, hydraulic:antilock
Summary:: Comment that the abs light is on with diagnostic trouble codes (dtc's) 46 and 86 set as current or history. *yc
Bulletin:: 98876121A
Component:: 061000 engine and engine cooling:engine
Summary:: Vehicles may exhibit a clattering noise at idle speed originating from the timing chain and front cover area. *yc
Bulletin:: 990730030
Component:: 106000 power train:axle assembly
Summary:: Some vehicles equipped with hydra-matic 3t40, 4t60 or 4t60-e transxales may comment on a grinding and / or growling noise that is noticeable when in park on incline. *tt
Bulletin:: 000524001
Component:: 034000 service brakes, hydraulic:foundation components
Summary:: Information regarding snow intrusion into rear drum brake assemblies. **mr
Bulletin:: 876002A
Component:: 061100 engine and engine cooling:engine:gasoline
Summary:: Some v6 engines may, on a very infrequent basis, have an oil odor condition that is generally encountered after the engine's oil has been changed.typically the odor lasts approximately 1000 miles after the change of oil and then does not re
Bulletin:: 990730030A
Component:: 106000 power train:axle assembly
Summary:: Owners of some vehicles equipped with hydra-matic 3t40, 4t60, 4t60-e or 4t65-e transaxles may comment on a grinding and / or growling noise that is noticeable when standing in park on a hill or slope with the engine running and the parking
Bulletin:: 00966B
Component:: 046300 service brakes, air:antilock:wheel speed sensor
Summary:: Abs front wheel speed codes - jumper harness. *tt
Bulletin:: 00966
Component:: 046300 service brakes, air:antilock:wheel speed sensor
Summary:: Anti-lock braking system (abs) front wheel speed codes - jumper harness. *tt
Bulletin:: PIC4696C
Component:: 150000 seat belts
Summary:: This preliminary information communication provides information to the technician on how to unlock radios that are delco theftlock. technician will use the radio to get the scrambled code. technician will need to contact the radio unlock ce

Home | Privacy