1993 FORD F-450 SD Recalls (4)

Campaign:
01X001000 on 05/21/2001
Component:
Tires:tread/belt
Affected:
13,000,000
Defect:
This is not a safety recall in accordance with the safety act. however, it is deemed a safety improvement campaign by the agency. equipment description: ford is replacing all firestone wilderness at 15, 16, and 17 inch tires mounted on ford trucks and suvs. ford reports tread separation can occur due to a combination of the sensitivity of the tire design to stress, aging, and manufacturing differences between plants. ford is replacing these tires to prevent possible premature tire failure. vehicle description: the vehicles listed below may have been originally equipped with firestone wilderness at tires or may have had wilderness at tires installed during the firestone recall launched in august 2000. certain 1991 throught 2002 ford explorer certain 2001 throught 2002 explorer sport, and sport trac certain 1997 through 2002 mercury mountaineer certain 1991 through 2001 ranger certain 1999 through 2001 expedition certain 1991 through 1994, and 1997 model year f-series certain 1991 through 1994 bronco note: both original equipment and replacement tires are affected.
Consequence:
Should the tread separate at highway speeds, a vehicle crash could occur, possibly resulting in personal injury or death.
Correction:
The replacement/reimbursement program for this campaign expired on march 31, 2002. however, customers can contact ford at 1-877-917-3673 or go on-line to www.ford.com for possible assistance.
Campaign:
07V336000 on 08/02/2007
Component:
Vehicle speed control
Manufactured:
05/27/1992 - 08/23/1993
Affected:
3,600,000
Defect:
On certain pickup trucks, passenger vehicles, sport utility vehicles, and motor homes chassis, the speed control deactivation switch may, under certain conditions, leak internally and then overheat, smoke, or burn.
Consequence:
This could result in an underhood fire.
Correction:
Dealers will install a fused wiring harness. owners of the passenger cars included in this campaign will be instructed to return their vehicles to their dealers to have the speed control deactivation switch disconnected as an interim repair. as soon as repair parts are available (expected october 2007), owners will be instructed to return to the dealers for installation of a fused wiring harness. the recall began on august 13, 2007, and mailing completed by september 19, 2007. owners may contact ford at 1-888-222-2751.
Notes:
Ford recall no. 05s28.customers may also contact the national highway traffic safety administration;s vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov.
Campaign:
08V051000 on 02/03/2008
Component:
Vehicle speed control:cruise control
Manufactured:
07/17/1992 - 08/23/1993
Affected:
225,000
Defect:
Ford is recalling 225,000 my 1992-2003 econoline, my 1993-1995 taurus sho, my 1992-1998 crown victoria, my 1993 bronco, f-series, my 1995-1997 f-series super duty stripped chassis, my 1992-1998 mercury grand marquis, and my 1992-1995 lincoln town car vehicles. the affected vehicles were previously repaired using a wiring harness that is not compatible with the vehicle circuit polarity.
Consequence:
As a result, the fuse is located in the output circuit rather than in the intended input power feed circuit, and may not offer the intended protection in the event of an electrical short to ground.
Correction:
Dealers will install a new wiring harness, or replace the mating electrical component. the recall began on february 18, 2008. owners may contact ford at 1-800-392-3673.
Notes:
Ford recall no. 08s01.customers may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov.
Campaign:
09V399000 on 10/12/2009
Component:
Vehicle speed control
Affected:
4,500,000
Defect:
Ford is recalling model years 1995-2003 windstar, 2000-2003 excursion diesel, 1993-1997 and 1999-2003 f-250 sd through f-550 sd diesel, 1992-2003 e-150 through e-550, 1995-2002 explorer, 1997 and 2002 mercury mountaineer, 1995-1997 and 2001-2003 ranger, and 1994 f53 vehicles equipped with the texas instruments speed control deactivation switch (scds). the scds may leak internally and then overheat, smoke, or burn.
Consequence:
A vehicle fire could occur with or without the engine running.
Correction:
Ford will notify owners that dealers will install a fused wiring harness in line with the scds. on 1999-2003 windstar vehicles with a leaking scds, dealers will also inspect the abs control module connector and repair as necessary. repairs will be completed free of charge. the safety recall began on october 27, 2009. owners may contact ford at 1-888-222-2751.
Notes:
Ford's recall campaign number is 09s09.owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to <a href=http://www.safercar.gov>http://www.safercar.gov</a> .

1993 FORD F-450 SD TSB

Bulletin:
002310
Component:
103600 power train:automatic transmission:cooling unit and lines
Summary:
Subject regarding contamination from prior transmission concerns or excess wear may be trapped in the transmission fluid cooling system. *tt

Home | Privacy