1993 FORD ESCORT Recalls (3)

Campaign:
94V055000 on 03/31/1994
Component:
Seats
Manufactured:
04/30/1993 - 05/31/1993
Affected:
3,500
Defect:
The lock plate of the driver side inboard seat track adjusters were manufactured with an unauthorized modification to the fabrication process which causes the seat not to fully engage in certain seating positions near the mid-point of the seat track travel.
Consequence:
In the event of a crash the seat can move, which would result in reduced occupant protection.
Correction:
Dealers will replace the driver side inboard seat track.
Notes:
System: interior systems; seat tracks and anchors.vehicle description: passenger vehicles.note: if your vehicle is presented to an authorized dealer on an agreed upon service date and the remedy is not provided within a reasonable time and freeof charge or the remedy does not correct the defect or noncompliance, please contact ford service center at 1-800-392-3673. also, contact the national highway traffic safety administration's auto safety hotline at 1-800-424-9393.
Campaign:
94E019000 on 06/22/1994
Component:
Suspension:front
Manufactured:
11/30/1992 - 04/30/1994
Affected:
919
Defect:
The offset toe adjusting pin can fracture under conditions such as torsional loads, flexing motion, impact loads, and overtorquing.
Consequence:
This can result in loss of vehicle steering control andan accident.
Correction:
Dana will pay for replacement and labor costs of the adjustment pin without charge to the installing facility and the vehicle owner. these pins should be replaced by a ford original equipment pin assembly. owner or installer inquiries concerning this recall campaign should contact dana service center at 1-800-248-9606.
Notes:
System: suspension; independent front.equipment description: offset rear toe adjusting pin.note: if you have any problems with the pin replacement reimbursement program,please contact dana service center at 1-800-248-9606. also, contact thenational highway traffic safety administration's auto safety hotline at1-800-424-9393.
Campaign:
06E026000 on 03/22/2006
Component:
Exterior lighting
Affected:
61,944
Defect:
Certain pro-a motors corner lamps, turn signals, and headlights sold as replacement lamps for use on certain passenger vehicles listed above. some combination lamps that are not equipped with amber side reflectors fail to conform to federal motor vehicle safety standard no. 108, lamps, reflective devices, and associated equipment.
Consequence:
Without the amber reflectors, the vehicle will be poorly illuminated, possibly resulting in a vehicle crash without warning.
Correction:
Pro-a motors will notify owners and offer to repurchase the lamps. the recall began on april 3, 2006. owners may contact pro-a motors at 323-838-2988.
Notes:
This recall only pertains to pro-a motors aftermarket lamps and has no relation to any original equipment installed on the listed passenger vehicles.for more information on the lamp model numbers, click on document search and view document titled "lamp model numbers."customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov.

1993 FORD ESCORT TSBs (82)

Bulletin:
94236
Component:
034500 service brakes, hydraulic:foundation components:disc
Summary:
front and rear brake noise. *tw
Bulletin:
94237
Component:
034000 service brakes, hydraulic:foundation components
Summary:
revised master cylinder and brake booster for non-abs vehicles. *tw
Bulletin:
942312
Component:
103000 power train:automatic transmission
Summary:
vehicles may have a harsh 1-2 or 2-3 shift. *tw
Bulletin:
BC8777941201
Component:
102000 power train:manual transmission
Summary:
vehicles may exhibit a 5th gear jump out condition. *tw
Bulletin:
BC8778941201
Component:
102000 power train:manual transmission
Summary:
transmission may stick in reverse. *tw
Bulletin:
94253
Component:
090000 fuel system, other
Summary:
fuel gauge always reads full. *tw
Bulletin:
9546
Component:
136200 visibility:windshield wiper/washer:motor
Summary:
wiper motor replacement - upgraded service kits. *tw
Bulletin:
94L01
Component:
355100 equipment:other:labels
Summary:
ford motor company has discovered that the vehicle emission control information label may not be correct. the information label is important to the servicing and possibly registration renewal. a label with the correct information is enc
Bulletin:
SFA/94L01
Component:
355200 equipment:other:owners/service/other manual
Summary:
special field action - 94l01 - vehcile emission control information labels may not be correct. owners of the affected cars will be mailed new labels with instructions on how to attatch new labels to their cars. *tw
Bulletin:
BC2910950401
Component:
011000 steering:wheel and handle bar
Summary:
steering wheel shake/vibration at idle with transmission in gear. *tw
Bulletin:
9551
Component:
116000 electrical system:ignition
Summary:
ignition lock cylinder may stck or bind when the driver tries to rotate the key. *tw
Bulletin:
95511
Component:
138110 visibility:defroster/defogger system:windshield:blower
Summary:
chirp or squeak from blower motor. *tw
Bulletin:
9562
Component:
034500 service brakes, hydraulic:foundation components:disc
Summary:
roughness concern during brake application. *tw
Bulletin:
9565
Component:
138110 visibility:defroster/defogger system:windshield:blower
Summary:
blower motor - low speed ticking noise. *tw
Bulletin:
9566
Component:
138110 visibility:defroster/defogger system:windshield:blower
Summary:
chirp or squeak noise from blower motor at low speeds. *tw
Bulletin:
9582
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
a revised service windshield wiper motor is now available. *tw
Bulletin:
BC2210950601
Component:
103000 power train:automatic transmission
Summary:
Unknown
Bulletin:
9592
Component:
138110 visibility:defroster/defogger system:windshield:blower
Summary:
Unknown
Bulletin:
95102
Component:
116000 electrical system:ignition
Summary:
vehicles may have a disconnect of the ignition control module (icm) connector or moisture buildup within the connector. *tw
Bulletin:
95124
Component:
011000 steering:wheel and handle bar
Summary:
steering wheel shake at idle. *tw
Bulletin:
SFA/94L01
Component:
011000 steering:wheel and handle bar
Summary:
Unknown
Bulletin:
95153
Component:
062100 engine and engine cooling:cooling system:radiator assembly
Summary:
temperature gauge - fluctuating and /or inaccurate high readings. *sd
Bulletin:
95174
Component:
162000 structure:body
Summary:
door-glove compartment-improved lock assembly available-probes through 7/1/94 and escort/tracers built through 9/6/94 *sd
Bulletin:
95212
Component:
036000 service brakes, hydraulic:antilock
Summary:
the use of petroleum-based grease as a lubricant in servicing disc brakes is no longer acceptable because it may be incompatible with the rubber material used in the disc brake system. if petroleum-based grease is used to lubricate any par
Bulletin:
BC0678961025
Component:
102000 power train:manual transmission
Summary:
Information on aode/4r7w transmission main control & case replacement. *tt
Bulletin:
96246
Component:
114000 electrical system:wiring
Summary:
Wiring - electrical diode identification and service replacements. *tw
Bulletin:
96249
Component:
103700 power train:automatic transmission:torque converter
Summary:
Torque converter - leak test procedure - service tip. *tw
Bulletin:
96221
Component:
131000 visibility:windshield
Summary:
Windshield and interior glass - fog/film. *tw
Bulletin:
96222
Component:
034000 service brakes, hydraulic:foundation components
Summary:
Brakes - elimination of sanding rotors and drums - service tip. *tw
Bulletin:
96225
Component:
075000 fuel system, gasoline:carburetor system
Summary:
Mass air flow sensor - replacement as an assembly - service tip. *tw
Bulletin:
962612
Component:
103700 power train:automatic transmission:torque converter
Summary:
Transaxle - torque converter replacement guidelines and torque converter/transaxle cooling system cleaning procedures - service tip. *tw
Bulletin:
BC3550972301
Component:
034520 service brakes, hydraulic:foundation components:disc:pads
Summary:
Front brake squeal/noise during light brake applications below 35 mph, replace the pads/shims kit. *jd
Bulletin:
BC1016797230
Component:
034520 service brakes, hydraulic:foundation components:disc:pads
Summary:
Front brake squeal/noise during light brakie applications below 35 mph, replace the pads/shims kit. *jd
Bulletin:
9732
Component:
034520 service brakes, hydraulic:foundation components:disc:pads
Summary:
Brakes- front brake "squeal" below 56 km/h (35 mph)- vehicle with 14 inch wheels. *jd
Bulletin:
9743
Component:
061000 engine and engine cooling:engine
Summary:
Blower motor- "chirp" or "squeak" from blower motor at low speeds. *jd
Bulletin:
97511
Component:
103000 power train:automatic transmission
Summary:
Fluid- transmission fluid usage charts. *jd
Bulletin:
9768
Component:
980000 unknown or other
Summary:
Fuel economy- customer expectations versus vehicle usage. *jd
Bulletin:
97610
Component:
061000 engine and engine cooling:engine
Summary:
Blower motor- "chirping" or "squeaking" from blower motor at low speeds. *jd
Bulletin:
BC2361970501
Component:
980000 unknown or other
Summary:
Authorized warranty part replacement of brake pads to correct excessive brake noise. *tw
Bulletin:
97111097234
Component:
113000 electrical system:starter assembly
Summary:
Vehicles exhibiting a "squeaking" or "chirping" from the blower motor at low blower motor speeds. *yc
Bulletin:
985A5
Component:
034530 service brakes, hydraulic:foundation components:disc:rotor
Summary:
Hub-mount brake rotor machining equipment from rotunda is now approved for warranty and service use. *yc
Bulletin:
985A11
Component:
034000 service brakes, hydraulic:foundation components
Summary:
Service tip information regarding elimination of sanding rotors and drums. *yc
Bulletin:
985A13
Component:
034500 service brakes, hydraulic:foundation components:disc
Summary:
The use of petroleum-based grease as a lubricant in servicing disc brakes is no longer acceptable. *yc
Bulletin:
985A15
Component:
034100 service brakes, hydraulic:foundation components:master cylinder
Summary:
A revised master cylinder and brake booster is available for service on non-abs vehicles to further improve brake pedal feel and travel. *yc
Bulletin:
985A19
Component:
034500 service brakes, hydraulic:foundation components:disc
Summary:
The front brakes may have a persistent squeal during braking at speeds below 56 km/h (35 mph). *tt
Bulletin:
9888
Component:
103000 power train:automatic transmission
Summary:
Information on a new transmission fluid usage chart. *yc
Bulletin:
9845
Component:
045300 service brakes, air:disc:rotor
Summary:
Availability of hub-mount brake rotor machining equipment. *yc
Bulletin:
9848
Component:
353600 equipment:air conditioner
Summary:
Announcing the ford oem air conditioning retrofit kit availability. *yc
Bulletin:
9852
Component:
190000 tires
Summary:
Information on tire company telephone numbers for customer assistance. *yc
Bulletin:
9873
Component:
353400 equipment:electrical:radio/tape deck/cd etc.
Summary:
Experiencing a whining / buzzing noise in the speakers of the entertainment radio or two-way radio. *tt
Bulletin:
9874
Component:
061000 engine and engine cooling:engine
Summary:
A new silicone gasket and sealant. *yc
Bulletin:
982010
Component:
063000 engine and engine cooling:exhaust system
Summary:
Experiencing a " buzzing " or " rattling " noise from the exhaust system. *yc
Bulletin:
982310
Component:
063100 engine and engine cooling:exhaust system:emission control
Summary:
Mass air flow (maf)- sensor contamination- service tip. *ak
Bulletin:
98246
Component:
110000 electrical system
Summary:
Ford motor company has released a new electrical grease ( f8az - 19g208-aa ) to reduce the possibility of moisture corrosion at the terminals. *yc
Bulletin:
9814
Component:
034530 service brakes, hydraulic:foundation components:disc:rotor
Summary:
Subject regarding the availability of hub-mount brake rotor machining equipment. *tt
Bulletin:
99816
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Ford motor company now recommends sae 5w-30 viscosity grade for servicing any ford gasoline-powered vehicle regardless of model year. *tt
Bulletin:
99129
Component:
353400 equipment:electrical:radio/tape deck/cd etc.
Summary:
Experiencing a whine / buzz type noise in the speakers of the entertainment radio or two-way radio on vehicles with an in-tank electric fuel pump. *tt
Bulletin:
99139
Component:
125000 exterior lighting:brake lights
Summary:
Conditions with the brake lamps inadvertently disabling the brake shift interlock. *tt
Bulletin:
99222
Component:
114000 electrical system:wiring
Summary:
Subject on a wire harness terminal repair kit available for repairing electrical wiring harnesses. *tt
Bulletin:
99194
Component:
034000 service brakes, hydraulic:foundation components
Summary:
Information for servicing and diagnosing brake vibration, brake inspection, and brake friction material replacement. *tt
Bulletin:
99196
Component:
353600 equipment:air conditioner
Summary:
Information on identifying non-approved / alternate refrigerants which could cause safety, and performance concerns if installed in ford a/c systems. *tt
Bulletin:
13421
Component:
034000 service brakes, hydraulic:foundation components
Summary:
Some vehicles may exhibit grinding noises, or greater than normal brake roughness when applying the brakes immediately after installing motorcraft br-18 front brake pad. *tt
Bulletin:
6562
Component:
151100 seat belts:front:anchorage
Summary:
Brief information on passive restraint (motorized seatbelt) systems. *tt
Bulletin:
7369
Component:
034000 service brakes, hydraulic:foundation components
Summary:
Some vehicles may exhibit grinding noise, or greater than normal brake roughness, when applying the brakes immediately after installing motorcraft front brake pad part number br-18 (xu2z-2v001-ra). *t
Bulletin:
0015
Component:
103000 power train:automatic transmission
Summary:
Information regarding the new transmission cooler flusher- service tip. *mjs
Bulletin:
985A12
Component:
354600 equipment:mechanical:wrecker and wheel lift devices
Summary:
Recommended guidelines for towing behind recreational vehicles. *tt
Bulletin:
00124
Component:
150000 seat belts
Summary:
This bulletin provides revised passive restraint system information contained in the workshop manual and the electrical and vaccum troubleshooting manual (evtm). *tt
Bulletin:
001204
Component:
150000 seat belts
Summary:
Subject regarding passive restraint system service information. *tt
Bulletin:
985A14
Component:
034000 service brakes, hydraulic:foundation components
Summary:
A knocking noise proportional to wheel rotation may be heard from the front brakes during gentle braking. *tt
Bulletin:
12925
Component:
150000 seat belts
Summary:
Engineering is reviewing passive restraint (motorized seatbelt) systems in certain vehicles. *tt
Bulletin:
99152
Component:
103000 power train:automatic transmission
Summary:
Information on the new flush and fill tool available through rotunda. *tt
Bulletin:
11769
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Some vehicles may exhibit brief spark knock on acceleration during hot weather once the engine has thoroughly warmed up. *tt
Bulletin:
00187
Component:
171100 latches/locks/linkages:doors:latch
Summary:
Subject pertaining to revised door latch switch service procedure. *jb
Bulletin:
00188
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Concerns with premature failure occuring on the 1.9l motorcraft remanufactured longblock assembly and shortblock assembly due to ingestion of foreign objects remaining in the transferred intake system from the original failed engine.
Bulletin:
14993
Component:
022000 suspension:rear
Summary:
Some vehicles produced through july 1999 may exhibit rear suspension spring failure with no resulting operational concern. *tt
Bulletin:
01156
Component:
138120 visibility:defroster/defogger system:windshield:heater core
Summary:
Some vehicles may exhibit heater core leaks. *slc
Bulletin:
01157
Component:
980000 unknown or other
Summary:
Information regarding transmission fluid usage charts. *slc
Bulletin:
01181
Component:
103800 power train:automatic transmission:park/neutral start switch
Summary:
Brake shift interlock.*jb
Bulletin:
01194
Component:
110000 electrical system
Summary:
This aritlce is to provide information on replacement of old style hood lamp switch to the rvised mechanical hood lamp switch. *tt
Bulletin:
0214
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Some engine assemblies with aluminum cylinder heads repaired in-vehile have been found to leak coolant and/or oil from the cylinder head gasket area. *tt
Bulletin:
02176
Component:
032100 service brakes, hydraulic:switches:brake light
Summary:
Lamp-brake-invadvertent disabling of brake shift interlock. *mj
Bulletin:
02208
Component:
353600 equipment:air conditioner
Summary:
Climate control a/c service tech tips. *eh

Home | Privacy