1993 FORD ECONOLINE Recalls (5)

Campaign:
93V100000 on 06/14/1993
Component:
Fuel system, gasoline
Manufactured:
10/31/1991 - 01/31/1993
Affected:
1,235
Defect:
The fuel filler hose or fuel filler vent hose was damaged by a drill bit used to install the dso package attaching hardware onto the floor pan.
Consequence:
If either of the hoses was penetrated by the drill bit,fuel leakage could result, particularly during fueling of the vehicle. in thepresence of an ignition source, this could result in fire.
Correction:
Replace the fuel filler and vent hoses and relocate the mounting hardware in the floor pan.
Notes:
System: fuel system.vehicle description: cargo vans with sears fleet dso package.
Campaign:
94V128000 on 07/24/1994
Component:
Interior lighting
Manufactured:
10/31/1993 - 04/30/1994
Affected:
6,088
Defect:
The transformer used to power the neon center lightbeam can overheat and catch on fire.
Consequence:
The overheating and fires caused by the neon transformer can result in damage to the lightbeam assembly, the roof of the vehicle, and could result in a vehicle fire.
Correction:
Mark iii dealers will modify the assemblies to eliminate the neon lighting fixture in the vehicle and replace it with incandescent lights operating directly from the vehicle 12-volt battery.
Notes:
System: lighting; lamp or socket; courtesy lights.vehicle description: long wheel base conversion vans with a neon center lightbeam.note: if your vehicle is presented to an authorized dealer on an agreed upon service date and the remedy is not provided within a reasonable time and free of charge or the remedy does not correct the defect or noncompliance, please contact mark iii service center at 1-800-903-8267. also, contact the national highway traffic safety administration's auto safety hotline at 1-800-424-9393.
Campaign:
08V051000 on 02/03/2008
Component:
Vehicle speed control:cruise control
Manufactured:
09/02/1991 - 09/14/2003
Affected:
225,000
Defect:
Ford is recalling 225,000 my 1992-2003 econoline, my 1993-1995 taurus sho, my 1992-1998 crown victoria, my 1993 bronco, f-series, my 1995-1997 f-series super duty stripped chassis, my 1992-1998 mercury grand marquis, and my 1992-1995 lincoln town car vehicles. the affected vehicles were previously repaired using a wiring harness that is not compatible with the vehicle circuit polarity.
Consequence:
As a result, the fuse is located in the output circuit rather than in the intended input power feed circuit, and may not offer the intended protection in the event of an electrical short to ground.
Correction:
Dealers will install a new wiring harness, or replace the mating electrical component. the recall began on february 18, 2008. owners may contact ford at 1-800-392-3673.
Notes:
Ford recall no. 08s01.customers may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov.
Campaign:
09E012000 on 04/06/2009
Component:
Exterior lighting
Affected:
16,270
Defect:
Sabersport is recalling 16,270 combination corner and bumper lamp assemblies of various part numbers sold for use as aftermarket equipment for various passenger vehicles. these headlamps fail to conform to the requirements of federal motor vehicle safety standard no. 108, "lamps, reflective devices, and associated equipment." these lamps do not contain the required amber side reflectors.
Consequence:
Decreased lighting visibility may result in a vehicle crash.
Correction:
Sabersport will notify owners and offer a full refund for the noncompliant combination lamps. the safety recall began on may 11, 2009. owners may contact sabersport at 1-909-598-7589.
Notes:
This recall only pertains to aftermarket replacement equipment and has no relation to any original equipment installed on vehicles produced by the vehicle manufacturer.in order to determine if your aftermarket lamp assembly is affected by this noncompliance, please review the list of model numbers provided to us by sabersport.the list can be found under "document search" located at the bottom of your screen.owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to <a href=http://www.safercar.gov>http://www.safercar.gov</a> .
Campaign:
09E025000 on 05/10/2009
Component:
Exterior lighting:headlights
Affected:
42,540
Defect:
Dope, inc. is recalling 42,540 combination corner and bumper lamp assemblies of various part numbers sold for use as aftermarket equipment for various passenger vehicles. these headlamps fail to conform to the requirements of federal motor vehicle safety standard no. 108, "lamps, reflective devices, and associated equipment." these lamps do not contain the required amber side reflectors.
Consequence:
Decreased lighting visibility may result in a vehicle crash.
Correction:
Dope, inc. will notify owners and offer a full refund for the noncompliant combination lamps. the safety recall began on july 28, 2009. owners may contact dope, inc. at 1-626-272-1798.
Notes:
This recall only pertains to aftermarket replacement equipment and has no relation to any original equipment installed on vehicles produced by the vehicle manufacturer.in order to determine if your aftermarket lamp assembly is affected by this noncompliance, please review the list of model numbers provided to us by dope, inc.the list can be found under "document search" located at the bottom of your screen. owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to <a href=http://www.safercar.gov>http://www.safercar.gov</a> .

1993 FORD ECONOLINE TSBs (78)

Bulletin:
942318
Component:
103000 power train:automatic transmission
Summary:
transmission overheating, converter cover discoloration, clutches burned and burnt fluid *tw
Bulletin:
942415
Component:
103000 power train:automatic transmission
Summary:
upgrade kit for the e40d transmission. *tw
Bulletin:
BC0502941201
Component:
116200 electrical system:ignition:module
Summary:
harsh reverse engagement concerns. *tw
Bulletin:
BC4040941201
Component:
103000 power train:automatic transmission
Summary:
Severe driveline vibration or transmission extention housing bushing spinout. *tw
Bulletin:
ONP/94B56
Component:
116000 electrical system:ignition
Summary:
corrosion between the tamper sensor and the ignition switch casting may cause false activation of the anti-theft alarm system. *tw
Bulletin:
942610
Component:
022141 suspension:rear:springs:leaf spring assembly:leaf
Summary:
vehicles may exhibit more body roll due to reduction in the amount of leaf springs in the assembly. *tw
Bulletin:
942611
Component:
185000 vehicle speed control:cruise control
Summary:
hooting noise from the engine compartment. *tw
Bulletin:
95210
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
engine hesitation/surge during light acceleration. *tw
Bulletin:
95212
Component:
103000 power train:automatic transmission
Summary:
vehicles may exhibit a shift concern. *tw
Bulletin:
BC3103950301
Component:
061000 engine and engine cooling:engine
Summary:
improved parts for service of drive belt tracking. *tw
Bulletin:
BC3131950301
Component:
063140 engine and engine cooling:exhaust system:emission control:catalytic convertor
Summary:
service procedure for catalytic converter restriction issues - procedure requires the use of new ecm, iac valve and expansion chamber. *tw
Bulletin:
BC4157950301
Component:
063140 engine and engine cooling:exhaust system:emission control:catalytic convertor
Summary:
no start condition caused by plugged catalytic converter. *tw
Bulletin:
95310
Component:
061000 engine and engine cooling:engine
Summary:
new torque-to-yield cylinder head bolt kit. *tw
Bulletin:
95522
Component:
061000 engine and engine cooling:engine
Summary:
some diesel powered vehicles are experiencing drive belt tracking concerns due to front end accessory drive pulleys (fead) misalignment. *tw
Bulletin:
9568
Component:
061000 engine and engine cooling:engine
Summary:
revised oil pan gasket. *tw
Bulletin:
95617
Component:
061000 engine and engine cooling:engine
Summary:
early wear of fead tensioner pulley on vehicles with 5.0l/5.8l engines. *tw
Bulletin:
95619
Component:
103000 power train:automatic transmission
Summary:
new design transmission range sensor. *tw
Bulletin:
95711
Component:
063000 engine and engine cooling:exhaust system
Summary:
some vehicles may exhibit a lack of power or a no start condition due to an exhaust restriction. *tw
Bulletin:
95712
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
during highway deceleration or engine start-up, there may be a hooting noise coming from the engine compartment. *tw
Bulletin:
9588
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
knocking noise on initial start-up. *tw
Bulletin:
95522
Component:
061000 engine and engine cooling:engine
Summary:
accessory drive belts - all 7.3 idi diesels come off accessory drive pulleys - vehicles built after 2/15/92. *tw
Bulletin:
951112
Component:
103000 power train:automatic transmission
Summary:
revised design transmission rear case bushing. *tw
Bulletin:
9568
Component:
061000 engine and engine cooling:engine
Summary:
Unknown
Bulletin:
95206
Component:
021500 suspension:front:control arm
Summary:
upper ball joints may have early wear on some vehicles. this may be due to entry of moisture and contamination into the ball joints. replace the worn ball joint(s) w/ a new integral seal-type ball joint which has improved sealing to reduce
Bulletin:
95212
Component:
036000 service brakes, hydraulic:antilock
Summary:
the use of petroleum-based grease as a lubricant in servicing disc brakes is no longer acceptable because it may be incompatible with the rubber material used in the disc brake system. if petroleum-based grease is used to lubricate any par
Bulletin:
BC0678961025
Component:
102000 power train:manual transmission
Summary:
Information on aode/4r7w transmission main control & case replacement. *tt
Bulletin:
BC0883961004
Component:
063200 engine and engine cooling:exhaust system:manifold/header/muffler/tail pipe
Summary:
Vehicles may exhibit an exhaust leak &/or noise due to warped exhaust manifolds. *tt
Bulletin:
96246
Component:
114000 electrical system:wiring
Summary:
Wiring - electrical diode identification and service replacements. *tw
Bulletin:
96249
Component:
103700 power train:automatic transmission:torque converter
Summary:
Torque converter - leak test procedure - service tip. *tw
Bulletin:
96221
Component:
131000 visibility:windshield
Summary:
Windshield and interior glass - fog/film. *tw
Bulletin:
96222
Component:
034000 service brakes, hydraulic:foundation components
Summary:
Brakes - elimination of sanding rotors and drums - service tip. *tw
Bulletin:
962612
Component:
103700 power train:automatic transmission:torque converter
Summary:
Transaxle - torque converter replacement guidelines and torque converter/transaxle cooling system cleaning procedures - service tip. *tw
Bulletin:
9747
Component:
160000 structure
Summary:
Frame- rivet replacement with bolts- service tips. *jd
Bulletin:
9748
Component:
061110 engine and engine cooling:engine:gasoline:belts and associated pulleys
Summary:
Accessory drive belts- fead belt comes off- vehicles with 4.9l engine. *jd
Bulletin:
9777
Component:
061200 engine and engine cooling:engine:diesel
Summary:
Hard start- extreme cold ambient temperature- vehicles with 7.3l diesel engine. *jd
Bulletin:
97511
Component:
103000 power train:automatic transmission
Summary:
Fluid- transmission fluid usage charts. *jd
Bulletin:
9768
Component:
980000 unknown or other
Summary:
Fuel economy- customer expectations versus vehicle usage. *jd
Bulletin:
985A5
Component:
034530 service brakes, hydraulic:foundation components:disc:rotor
Summary:
Hub-mount brake rotor machining equipment from rotunda is now approved for warranty and service use. *yc
Bulletin:
985A11
Component:
034000 service brakes, hydraulic:foundation components
Summary:
Service tip information regarding elimination of sanding rotors and drums. *yc
Bulletin:
985A13
Component:
034500 service brakes, hydraulic:foundation components:disc
Summary:
The use of petroleum-based grease as a lubricant in servicing disc brakes is no longer acceptable. *yc
Bulletin:
9888
Component:
103000 power train:automatic transmission
Summary:
Information on a new transmission fluid usage chart. *yc
Bulletin:
9845
Component:
045300 service brakes, air:disc:rotor
Summary:
Availability of hub-mount brake rotor machining equipment. *yc
Bulletin:
9848
Component:
353600 equipment:air conditioner
Summary:
Announcing the ford oem air conditioning retrofit kit availability. *yc
Bulletin:
98419
Component:
980000 unknown or other
Summary:
Some vehicles may exhibit a flashing transmission control indicator lamp (tcil) and diagnostic trouble codes (dtcs) 62,628, and/or 1728. *yc
Bulletin:
9852
Component:
190000 tires
Summary:
Information on tire company telephone numbers for customer assistance. *yc
Bulletin:
9859
Component:
116100 electrical system:ignition:switch
Summary:
A hard to turn ignition key, and/or a hard to remove key from ignition cylinder may occur on some vehicles. *yc
Bulletin:
9864
Component:
063000 engine and engine cooling:exhaust system
Summary:
Information on a buzzing or rattle noise from the exhaust system. *tt
Bulletin:
9873
Component:
353400 equipment:electrical:radio/tape deck/cd etc.
Summary:
Experiencing a whining / buzzing noise in the speakers of the entertainment radio or two-way radio. *tt
Bulletin:
982010
Component:
063000 engine and engine cooling:exhaust system
Summary:
Experiencing a " buzzing " or " rattling " noise from the exhaust system. *yc
Bulletin:
9814
Component:
034530 service brakes, hydraulic:foundation components:disc:rotor
Summary:
Subject regarding the availability of hub-mount brake rotor machining equipment. *tt
Bulletin:
98123
Component:
103000 power train:automatic transmission
Summary:
Some vehicles may exhibit a flashing transmission control indicator lamp (tcil) and diagnostic trouble codes (dtcs) 62, 628, and / or 1728 may be stored in memory. *tt
Bulletin:
010198
Component:
061000 engine and engine cooling:engine
Summary:
Some vehicles may develop "cavitation" erosion in the cylinder wall of the engine. *tt
Bulletin:
99816
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Ford motor company now recommends sae 5w-30 viscosity grade for servicing any ford gasoline-powered vehicle regardless of model year. *tt
Bulletin:
9997
Component:
011000 steering:wheel and handle bar
Summary:
Some vehicles may exhibit a "squeaking" or "moaning" noise from the steering column while turning. *tt
Bulletin:
99129
Component:
353400 equipment:electrical:radio/tape deck/cd etc.
Summary:
Experiencing a whine / buzz type noise in the speakers of the entertainment radio or two-way radio on vehicles with an in-tank electric fuel pump. *tt
Bulletin:
6417
Component:
020000 suspension
Summary:
Addressing tire balance hints. *tt
Bulletin:
99164
Component:
116000 electrical system:ignition
Summary:
Concerns with a hard to turn ignition key and / or a hard to remove key from ignition cylinder. *tt
Bulletin:
99141
Component:
021500 suspension:front:control arm
Summary:
Subject regarding a high number of ball joints being replaced as the result of routine inspections or of complaints of tire wear and loose feelings in the steering system. *tt
Bulletin:
99141
Component:
010000 steering
Summary:
Complaints of tire wear and loose feelings in the steering system. *tt
Bulletin:
99222
Component:
114000 electrical system:wiring
Summary:
Subject on a wire harness terminal repair kit available for repairing electrical wiring harnesses. *tt
Bulletin:
99194
Component:
034000 service brakes, hydraulic:foundation components
Summary:
Information for servicing and diagnosing brake vibration, brake inspection, and brake friction material replacement. *tt
Bulletin:
99196
Component:
353600 equipment:air conditioner
Summary:
Information on identifying non-approved / alternate refrigerants which could cause safety, and performance concerns if installed in ford a/c systems. *tt
Bulletin:
98167
Component:
103000 power train:automatic transmission
Summary:
Transmission-e40d-no 2-3 upshift. some vehicles may exhibit a no 2-3 upshift condition. *ak
Bulletin:
98168
Component:
103000 power train:automatic transmission
Summary:
Transmission- e40d/4r100-1989-99-main controls, separator plates and separator plate gaskets usage chart. yd
Bulletin:
0015
Component:
103000 power train:automatic transmission
Summary:
Information regarding the new transmission cooler flusher- service tip. *mjs
Bulletin:
0038
Component:
103600 power train:automatic transmission:cooling unit and lines
Summary:
Vehicles may experience solid particle contaminants from prior transmission concerns or excess wear, may be trapped in the transmission fluid cooling system is not properly flushed, fluid in-line filter kit. *mjs
Bulletin:
00510
Component:
020000 suspension
Summary:
Customers may be concerned that vehicle looks like it dogtracks, due to a unique feature of the vehicle that combine to create an optical illusion of dogtracking, a condition which the rear axle is not square to the chassis. *mjs
Bulletin:
12070
Component:
021000 suspension:front
Summary:
Vehicles that are loaded to the upper end of fvw, with the majority of the load between the axles, may exhibit inner edge tire wear due to incorrect alignment. *mjs
Bulletin:
12123
Component:
021000 suspension:front
Summary:
Vehicles may exhibit a steering pull to the right or left, due to incorrect front end alignment settings. *mjs
Bulletin:
985102
Component:
021000 suspension:front
Summary:
Some vehicles that are loaded to the upper end of gvw, with the majority of the load between the axles, may exhibit inner edge tire wear due to incorrect alignment. *tt
Bulletin:
985153
Component:
020000 suspension
Summary:
Some vehicles may exhibit a steering pull to the right or left. *tt
Bulletin:
96728
Component:
101000 power train:clutch assembly
Summary:
Service tip information regarding the reverse clutch piston and piston seal usage. *tt
Bulletin:
12835
Component:
190000 tires
Summary:
Subject regarding tire balance hint. *tt
Bulletin:
99152
Component:
103000 power train:automatic transmission
Summary:
Information on the new flush and fill tool available through rotunda. *tt
Bulletin:
002310
Component:
103600 power train:automatic transmission:cooling unit and lines
Summary:
Subject regarding contamination from prior transmission concerns or excess wear may be trapped in the transmission fluid cooling system. *tt
Bulletin:
01156
Component:
138120 visibility:defroster/defogger system:windshield:heater core
Summary:
Some vehicles may exhibit heater core leaks. *slc
Bulletin:
03148
Component:
103600 power train:automatic transmission:cooling unit and lines
Summary:
New transmission cooler flusher - service tips. 2003 escort and super duty f series included. *tt
Bulletin:
032124
Component:
061000 engine and engine cooling:engine
Summary:
A hard start or no start condition in extreme cold weather. *tt

Home | Privacy