1993 DODGE GRAND CARAVAN Recalls (9)
- Campaign:
- 95I001005 on 05/08/1996
- Component:
- Latches/locks/linkages:hatchback/liftgate:lock
- Manufactured:
- 07/31/1992 - 06/30/1995
- Affected:
- 1,342,202
- Defect:
- Vehicle description: light duty passenger minivans with remote release. this is not a safety recall. there has been no determination that a safety defect exists with the minivan latches. chrysler is conducting a service campaign to replace the liftgate latch assembly of the affected minivans. in a collision, the rear liftgate latch assembly could open.
- Consequence:
- If the liftgate latch opens, occupants can be ejected resulting in significantly increased risk of injury or death.
- Correction:
- Chrysler will replace the liftgate latch with a new stronger latch assembly without charge. chrysler began notifying owners during december 1995.
- Notes:
- This is not a safety recall.there has been no determination that a safety defect exists with the minivan latches.however, chrysler has decided to provide a stronger latch without charge.owners can contact chrysler at1-800-minivan (1-800-646-4826).
- Campaign:
- 95I001001 on 05/08/1996
- Component:
- Latches/locks/linkages:hatchback/liftgate:lock
- Manufactured:
- 07/31/1992 - 06/30/1995
- Affected:
- 66,407
- Defect:
- Vehicle description: light duty passenger minivans without remote release. this is not a safety recall. there has been no determination that a safety defect exists with the minivan latches. chrysler is conducting a service campaign to replace the liftgate latch assembly of the affected minivans. in a collision, the rear liftgate latch assembly could open.
- Consequence:
- If the liftgate latch opens, occupants can be ejected resulting in significantly increased risk of injury or death.
- Correction:
- Chrysler dealers will replace the liftgate latch with a new stronger latch assembly without charge. chrysler began notifying owners of these vehicles beginning september 1995.
- Notes:
- This is not a safety recall. there has been no determination that a safety defect exists with the minivan latches.however, chrysler has decided to provide a stronger latch without charge.owners can contact chrysler at 1-800-minivan (1-800-646-4826).
- Campaign:
- 96V099000 on 06/17/1996
- Component:
- Service brakes, hydraulic:antilock
- Manufactured:
- 06/30/1990 - 05/31/1993
- Affected:
- 321,000
- Defect:
- The abs hydraulic control unit can experience excessive brake actuator piston seal wear causing pump-motor deterioration.
- Consequence:
- If this condition occurs, the abs function could be lost and reduced power assist would be experienced during vehicle braking increasing the potential for a vehicle accident.
- Correction:
- Dealers will test the vehicle's anti-lock brake system and repair the vehicles if necessary. also the warranty on all abs components will be extended to 10 years or 100,000 miles (except for the brake actuator piston assembly and the pump-motor assembly which will have a lifetime coverage). owners will also be reimbursed for previous abs component repair costs.
- Notes:
- System: brakes; hydraulic; anti-skid system. vehicle description: passenger vehicles and mini-vans equipped with anti-lock brake systems (abs). note: owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact chrysler at 1-800-853-1403. also contact the national highway traffic safety administration's auto safety hotline at 1-800-424-9393.
- Campaign:
- 97V148000 on 09/15/1997
- Component:
- Seat belts:front:buckle assembly
- Manufactured:
- 07/31/1990 - 03/29/1993
- Affected:
- 1,100,000
- Defect:
- Vehicle description: passenger mini-vans. covers on the solid stalk mounted seat belt buckles can become dislodged causing the release button to stick inside the cover. the buckle would then be only partially latched.
- Consequence:
- In the event of a vehicle crash, the occupant may not be properly restrained increasing the risk of personal injury.
- Correction:
- Dealers will install a cover retaining clip to the stalk mounted buckle cover to prevent dislocation of the buckle cover.
- Notes:
- Owner notification began december 8, 1997.owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact chrysler at 1-800-853-1403. also contact the national highway traffic safety administration's auto safety hotline at 1-800-424-9393.
- Campaign:
- 97V149000 on 09/15/1997
- Component:
- Seat belts:front:anchorage
- Manufactured:
- 07/31/1990 - 03/29/1993
- Affected:
- 1,100,000
- Defect:
- Vehicle description: passenger mini-vans. the center rear seat, right outboard side, safety belt anchor hook can become unattached from the body anchor position.
- Consequence:
- In the event of a vehicle crash, the occupant may not be properly restrained increasing the risk of personal injury.
- Correction:
- Dealers will replace the anchor hook retaining clip with a revised profile clip and a cover plate.
- Notes:
- Owner notification began december 8, 1997. owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact chrysler at 1-800-853-1403. also contact the national highway traffic safety administration's auto safety hotline at 1-800-424-9393.
- Campaign:
- 99V113000 on 05/11/1999
- Component:
- Air bags
- Manufactured:
- 02/28/1993 - 03/30/1995
- Affected:
- 736,824
- Defect:
- Vehicle description: mini vans. the wiring that initiates the driver and/or passenger air bag could electrically short circuit to ground. a short circuit to ground that exists immediately after turning the ignition key to the "on" or "start" position can cause the air bag(s) to inadvertently deploy.
- Consequence:
- Inadvertent air bag deployment can injure a front seat occupant.
- Correction:
- Dealers will perform an electronic diagnostic check. any short circuits identified in either the driver's or passenger side air bag initiator wire circuit will be repaired.
- Notes:
- Owner notification began august 2, 1999.owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact chrysler at 1-800-992-1997. also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
- Campaign:
- 99V189000 on 07/18/1999
- Component:
- Visibility:windshield wiper/washer:linkages
- Manufactured:
- 06/30/1990 - 05/14/1993
- Affected:
- 828,559
- Defect:
- Vehicle description: minivans. the left hand windshield wiper pivot drive arm was not mechanically staked to the pivot shaft.
- Consequence:
- This could allow the drive arm to disengage from the shaft leading to a loss of wiper function. the driver's visibility would be impaired, increasing the risk of a crash.
- Correction:
- Dealers will replace the left hand side windshield wiper pivot assembly.
- Notes:
- Owner notification began march 27, 2000. owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact chrysler at 1-800-992-1997.also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
- Campaign:
- 99V213000 on 10/14/1999
- Component:
- Structure:body:hatchback/liftgate:hinge and attachments
- Manufactured:
- 07/31/1990 - 06/29/1994
- Affected:
- 1,318,189
- Defect:
- Vehicle description: mini vans. the bolts used to attach the strut to the body and the rear liftgate can accumulate fatigue damage if three factors combine. if the bolt is loose, the gas strut is over-pressurized, and the frequency of opening and closing cycles is higher than for the average customer, the bolt can fail.
- Consequence:
- Personal injury could occur if the bolts break allowing the liftgate to fall suddenly.
- Correction:
- Dealers will inspect for loose fasteners, if the fasteners are loose, the strut (and integral bolts) will be replaced. if the bolt shows evidence of torque, the bolt will be removed, larger washers will replace the existing washer and the bolt will be reinstalled and hand tightened to the target torqued.
- Notes:
- Owner notification began during august 1999. owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact chrysler at 1-800-992-1997. also contact the national highway traffic safety administration's auto safety hotline at 1-888-327-4236.
- Campaign:
- 00V305000 on 10/23/2000
- Component:
- Steering:wheel and handle bar
- Manufactured:
- 06/30/1992 - 09/29/1993
- Affected:
- 679,000
- Defect:
- Vehicle description: mini vans equipped with 2-spoke luxury wheels manufactured july 1992 through june 1993; or equipped with 4-spoke sport wheels manufactured from july 1992 through september 1993. the steering wheel armature stamping can crack and separate from the center hub attachment to the steering column.
- Consequence:
- If the steering wheel separates from the center hub attachment to the steering column, loss of control can occur increasing the risk of an accident.
- Correction:
- Dealers will inspect the steering wheel for cracks and any wheels with cracks will be replaced. all other vehicles will have a reinforcement plate installed to prevent steering wheel separation in the event cracking occurs.
- Notes:
- Owner notification began november 6, 2000.owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact daimlerchrysler at 1-800-992-1997. also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
Home | Privacy