1992 LINCOLN TOWN CAR Recalls (4)

Campaign:
95V151000 on 08/20/1995
Component:
Latches/locks/linkages:hood:latch
Manufactured:
03/31/1991 - 09/30/1991
Affected:
73,837
Defect:
The secondary hood latch may not engage when the hood is closed.
Consequence:
In the event the primary hood latch releases or is not properly latched when the vehicle is in motion, the hood could fly up obstructing the operator's vision, and increasing the potential for a vehicle accident.
Correction:
Dealers will replace the hood latch assembly.
Notes:
System: structure; hood; latches. vehicle description: passenger vehicles.note: owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time, should contact ford at 1-800-392-3673. also contact the national highway traffic safety administration's auto safety hotline at 1-800-424-9393.
Campaign:
98V322000 on 12/17/1998
Component:
Suspension:front:control arm:lower ball joint
Affected:
175,000
Defect:
Vehicle description: certain 1996-1999 ford crown victoria police, fleet, natural gas, and 1996-1999 lincoln town car limousine vehicles that were produced with a lower control arm ball joint containing a one piece bearing; and 1990-1996 ford crown victoria police, fleet, and ngv vehicles and 1990-1996 lincoln town car limousine vehicles that have been serviced with either a ball joint containing the one-piece bearing or a front lower control arm containing a ball joint with a one-piece bearing. the one-piece bearing within the lower control arm ball joint can weaken slowly during use and eventually crack. this could result in separation of the ball and cap of the joint, allowing the control arm to drop to the ground.
Consequence:
If this occurs while the vehicle is moving, reduced steering control could occur, increasing the risk of a crash.
Correction:
Dealers will replace the lower control arm ball joints (2).
Notes:
Owner notification is expected to begin january 18, 1999.owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact ford at 1-800-392-3673.also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
Campaign:
99V124000 on 05/19/1999
Component:
Electrical system
Manufactured:
11/03/1991 - 11/29/1992
Affected:
262,695
Defect:
Vehicle description: passenger vehicles. the speed control deactivation switch can develop a resistive short in the electrical circuit that could potentially result in an underhood fire. a fire is possible both when the vehicle is running and when the vehicle engine is off. also, the short could disable the speed control system or cause the brake light fuse to open.
Consequence:
A fire can originate in the left front underhood area.
Correction:
Dealers will install a new speed control deactivation switch and connector shell. owner notification began may 20, 1999.
Notes:
Ford recall no. 99s15.this recall has been supersedes by ford recall no. 05s28 (please see 05v017, 05v388, 06v286 and 07v336). owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact ford at 1-800-392-3673. also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
Campaign:
07V336000 on 08/02/2007
Component:
Vehicle speed control
Manufactured:
11/04/1991 - 02/27/1998
Affected:
3,600,000
Defect:
On certain pickup trucks, passenger vehicles, sport utility vehicles, and motor homes chassis, the speed control deactivation switch may, under certain conditions, leak internally and then overheat, smoke, or burn.
Consequence:
This could result in an underhood fire.
Correction:
Dealers will install a fused wiring harness. owners of the passenger cars included in this campaign will be instructed to return their vehicles to their dealers to have the speed control deactivation switch disconnected as an interim repair. as soon as repair parts are available (expected october 2007), owners will be instructed to return to the dealers for installation of a fused wiring harness. the recall began on august 13, 2007, and mailing completed by september 19, 2007. owners may contact ford at 1-888-222-2751.
Notes:
Ford recall no. 05s28.customers may also contact the national highway traffic safety administration;s vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov.

1992 LINCOLN TOWN CAR TSBs (61)

Bulletin:
94224
Component:
073000 fuel system, gasoline:fuel injection system
Summary:
moaning or hooting noise coming from the engine compartment may be coming from the idle air bypass valve. *tw
Bulletin:
ONP/94B56
Component:
116000 electrical system:ignition
Summary:
corrosion between the tamper sensor and the ignition switch casting may cause false activation of the anti-theft alarm system. *tw
Bulletin:
94269
Component:
103000 power train:automatic transmission
Summary:
delayed or no forward engagement of transmission. *tw
Bulletin:
BC8794950103
Component:
185000 vehicle speed control:cruise control
Summary:
vehicles may exhibit a moan or hoot noise from the idle air bypass valve. *tw
Bulletin:
9523
Component:
070000 fuel system, gasoline
Summary:
erratic distance-to-empty and fuel gauge readings. *tw
Bulletin:
9536
Component:
103000 power train:automatic transmission
Summary:
intermittent transmission operation. *tw
Bulletin:
95313
Component:
103000 power train:automatic transmission
Summary:
possible water intrusion in the mlp/tr sensor causing shift concern. *tw
Bulletin:
BC2850950401
Component:
103700 power train:automatic transmission:torque converter
Summary:
torque converter clutch shudder/vibration. *tw
Bulletin:
95515
Component:
103000 power train:automatic transmission
Summary:
there may be an intermittent loss of torque during or just after the 3-4 upshift or in 4th gear on some vehicles. *tw
Bulletin:
9562
Component:
034500 service brakes, hydraulic:foundation components:disc
Summary:
roughness concern during brake application. *tw
Bulletin:
9568
Component:
061000 engine and engine cooling:engine
Summary:
revised oil pan gasket. *tw
Bulletin:
95102
Component:
116000 electrical system:ignition
Summary:
vehicles may have a disconnect of the ignition control module (icm) connector or moisture buildup within the connector. *tw
Bulletin:
BC2850950401
Component:
034500 service brakes, hydraulic:foundation components:disc
Summary:
Unknown
Bulletin:
95212
Component:
036000 service brakes, hydraulic:antilock
Summary:
the use of petroleum-based grease as a lubricant in servicing disc brakes is no longer acceptable because it may be incompatible with the rubber material used in the disc brake system. if petroleum-based grease is used to lubricate any par
Bulletin:
BC0678961025
Component:
102000 power train:manual transmission
Summary:
Information on aode/4r7w transmission main control & case replacement. *tt
Bulletin:
BC0810961011
Component:
103700 power train:automatic transmission:torque converter
Summary:
Vehicles equipped w/ an aode or 4r70w trans has a concern of shudder from the transmission torque converter clutch in 3rd or 4th gear or during 3-4 shift. *tt
Bulletin:
96246
Component:
114000 electrical system:wiring
Summary:
Wiring - electrical diode identification and service replacements. *tw
Bulletin:
96249
Component:
103700 power train:automatic transmission:torque converter
Summary:
Torque converter - leak test procedure - service tip. *tw
Bulletin:
96221
Component:
131000 visibility:windshield
Summary:
Windshield and interior glass - fog/film. *tw
Bulletin:
96225
Component:
075000 fuel system, gasoline:carburetor system
Summary:
Mass air flow sensor - replacement as an assembly - service tip. *tw
Bulletin:
962517
Component:
103700 power train:automatic transmission:torque converter
Summary:
Transmission - aode - 4r70w - shudder or vibration under light to moderate acceleration above 56 km/h (35 mph) while in 3rd or 4th gear. *tw
Bulletin:
962612
Component:
103700 power train:automatic transmission:torque converter
Summary:
Transaxle - torque converter replacement guidelines and torque converter/transaxle cooling system cleaning procedures - service tip. *tw
Bulletin:
97511
Component:
103000 power train:automatic transmission
Summary:
Fluid- transmission fluid usage charts. *jd
Bulletin:
9768
Component:
980000 unknown or other
Summary:
Fuel economy- customer expectations versus vehicle usage. *jd
Bulletin:
985A13
Component:
034500 service brakes, hydraulic:foundation components:disc
Summary:
The use of petroleum-based grease as a lubricant in servicing disc brakes is no longer acceptable. *yc
Bulletin:
9887
Component:
103700 power train:automatic transmission:torque converter
Summary:
Experiencing a torque converter clutch shudder or vibration. *yc
Bulletin:
9888
Component:
103000 power train:automatic transmission
Summary:
Information on a new transmission fluid usage chart. *yc
Bulletin:
9848
Component:
353600 equipment:air conditioner
Summary:
Announcing the ford oem air conditioning retrofit kit availability. *yc
Bulletin:
98410
Component:
101000 power train:clutch assembly
Summary:
Vehicles may experience torque converter clutch shudder or vibration. *yc
Bulletin:
9864
Component:
063000 engine and engine cooling:exhaust system
Summary:
Information on a buzzing or rattle noise from the exhaust system. *tt
Bulletin:
9873
Component:
353400 equipment:electrical:radio/tape deck/cd etc.
Summary:
Experiencing a whining / buzzing noise in the speakers of the entertainment radio or two-way radio. *tt
Bulletin:
9874
Component:
061000 engine and engine cooling:engine
Summary:
A new silicone gasket and sealant. *yc
Bulletin:
982310
Component:
063100 engine and engine cooling:exhaust system:emission control
Summary:
Mass air flow (maf)- sensor contamination- service tip. *ak
Bulletin:
99816
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Ford motor company now recommends sae 5w-30 viscosity grade for servicing any ford gasoline-powered vehicle regardless of model year. *tt
Bulletin:
99129
Component:
353400 equipment:electrical:radio/tape deck/cd etc.
Summary:
Experiencing a whine / buzz type noise in the speakers of the entertainment radio or two-way radio on vehicles with an in-tank electric fuel pump. *tt
Bulletin:
99139
Component:
125000 exterior lighting:brake lights
Summary:
Conditions with the brake lamps inadvertently disabling the brake shift interlock. *tt
Bulletin:
983115
Component:
103700 power train:automatic transmission:torque converter
Summary:
Concerns with vehicles exhibiting a torque converter shudder. *tt
Bulletin:
99222
Component:
114000 electrical system:wiring
Summary:
Subject on a wire harness terminal repair kit available for repairing electrical wiring harnesses. *tt
Bulletin:
9836
Component:
103000 power train:automatic transmission
Summary:
Information concerning vibration-shudder under light to moderate acceleration above 56 km/h (35mph) in 3rd or 4rd gear- vehicles equipped with aode or 4r70w transmission.
Bulletin:
99196
Component:
353600 equipment:air conditioner
Summary:
Information on identifying non-approved / alternate refrigerants which could cause safety, and performance concerns if installed in ford a/c systems. *tt
Bulletin:
7312
Component:
134000 visibility:sun roof assembly
Summary:
Some vehicles equipped with factory installed moonroof may exhibit a booming or buffeting noise while traveling at speeds greater than 40 mph when the moonroof is open. *tt
Bulletin:
0015
Component:
103000 power train:automatic transmission
Summary:
Information regarding the new transmission cooler flusher- service tip. *mjs
Bulletin:
12178
Component:
100000 power train
Summary:
Information regarding tsb 98-5a-12 (transaxle/transmission/transfer case-vehicles towed behind recreational vehicles-recommended guidelines) does not list towing information for certain model vehicles. *mjs
Bulletin:
96714
Component:
100000 power train
Summary:
Subject regarding a new transmission case and main control released for service on aode / 4r70w transmissions. *tt
Bulletin:
13400
Component:
134000 visibility:sun roof assembly
Summary:
Some cars equipped with factory installed moonroof may exhibit a booming or buffeting noise while traveling at speeds greater than 40 mph when the moonroof is open. *tt
Bulletin:
985A6
Component:
036000 service brakes, hydraulic:antilock
Summary:
Some vehicles may cycle when brakes are applied on rough roads or on an incline while making a sharp turn. *yc
Bulletin:
99152
Component:
103000 power train:automatic transmission
Summary:
Information on the new flush and fill tool available through rotunda. *tt
Bulletin:
002310
Component:
103600 power train:automatic transmission:cooling unit and lines
Summary:
Subject regarding contamination from prior transmission concerns or excess wear may be trapped in the transmission fluid cooling system. *tt
Bulletin:
00213
Component:
353600 equipment:air conditioner
Summary:
Subject regarding climate control - eatc - blower motor control service tips. *jb
Bulletin:
14862
Component:
071100 fuel system, gasoline:storage:tank assembly
Summary:
Information on replacing fuel tank strap bolts. *tt
Bulletin:
0147
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Subject regarding engine oil recommendations for use in 2001 vehicles - sae 5w-20 motor oil. *tt
Bulletin:
011201
Component:
136000 visibility:windshield wiper/washer
Summary:
This information is a supplement to the wiper system service information provided in the workshop manuals. this service information is intended as an aid to assist in diagnosis and repair of erratic wiper system conditions.
Bulletin:
01156
Component:
138120 visibility:defroster/defogger system:windshield:heater core
Summary:
Some vehicles may exhibit heater core leaks. *slc
Bulletin:
01157
Component:
980000 unknown or other
Summary:
Information regarding transmission fluid usage charts. *slc
Bulletin:
01181
Component:
103800 power train:automatic transmission:park/neutral start switch
Summary:
Brake shift interlock.*jb
Bulletin:
012114
Component:
071100 fuel system, gasoline:storage:tank assembly
Summary:
Parts and procedure to reduce the potential of fuel tank punctures during rare and extremely high-speed rear impacts. *tt
Bulletin:
0214
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Some engine assemblies with aluminum cylinder heads repaired in-vehile have been found to leak coolant and/or oil from the cylinder head gasket area. *tt
Bulletin:
02107
Component:
136200 visibility:windshield wiper/washer:motor
Summary:
Transfer service tips for the front wiper motor mount bracket and depressed park output arm. *tt
Bulletin:
03148
Component:
103600 power train:automatic transmission:cooling unit and lines
Summary:
New transmission cooler flusher - service tips. 2003 escort and super duty f series included. *tt
Bulletin:
02208
Component:
353600 equipment:air conditioner
Summary:
Climate control a/c service tech tips. *eh
Bulletin:
CSP 08B04
Component:
071100 fuel system, gasoline:storage:tank assembly
Summary:
Ford/lincoln mercury: certain 1992-2001 model year crown victoria, grand marquis, and town car vehicles registered in the states of wisconsin and connecticut upgrade modifications for high speed rear impacts. *pe

Home | Privacy