1992 FORD AEROSTAR Recalls (5)

Campaign:
97V204000 on 11/19/1997
Component:
Power train:transfer case (4-wheel drive)
Manufactured:
01/30/1992 - 01/19/1997
Affected:
75,000
Defect:
Vehicle description: all wheel drive passenger minivans. these vehicles can develop powertrain bending resonance or transfer case output shaft bushing displacement. the powertrain bending resonance or the output shaft bushing displacement can result in structural failure of the transmission and/or transfer case. fluid explusion, driveshaft separation or loss of vehicle drive can result.
Consequence:
This condition can cause a loss of vehicle control, and, if the expelled fluid contacts the exhaust system, a vehicle fire could occur.
Correction:
Dealers will install a new transfer case rear output shaft bushing and an aluminum driveshaft will be installed.
Notes:
Owner notification is expected to begin february 16,1998.owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact ford at 1-800-392-3673.also contact the national highway traffic safety administration's auto safety hotline at 1-800-424-9393.
Campaign:
98E010000 on 04/08/1998
Component:
Service brakes, air:disc:rotor
Affected:
23,500
Defect:
Equipment description: aftermarket brake rotors for use on certain ford and mazda trucks. cracked castings caused cracks to appear on the outer diameter of the rotor hat or around the stud hole.
Consequence:
Loss of braking can result.
Correction:
Aimco will reimburse consumers/installers for the cost of replacement rotors and installation. consumers are requested to return to the location where the rotors were originally purchased/installed for replacement.
Notes:
Owner notification is expected to begin during april 1998.owners who do not receive the free rotors within a reasonable time should contact aimco at 815-759-7935.also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
Campaign:
99V029000 on 02/15/1999
Component:
Electrical system:ignition:switch
Manufactured:
08/11/1991 - 08/21/1997
Affected:
762,201
Defect:
Vehicle description: mini vans. these vehicles were produced with a higher than specified electrical load through the accessory power feed circuit. the potential for contact between the b2 (battery), a2 (accessory), and p1 (proof) circuits can occur, creating a short circuit, allowing current to flow through the ground wire.
Consequence:
This can cause over heating and the potential for a vehicle fire.
Correction:
Dealers will install a jumper harness with a relay which will re-route and activate all a2 accessories through the relay.
Notes:
Owner notification began march 19, 1999.owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contactford at 1-800-392-3673.also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
Campaign:
99V094000 on 04/28/1999
Component:
Power train:transfer case (4-wheel drive)
Manufactured:
08/01/1991 - 12/30/1991
Affected:
10,951
Defect:
Vehicle description: all wheel drive passenger minivans. (this includes all 1992 awd aerostars not previously included in safety recall 97v-204/97s83). these vehicles can develop powertrain bending resonance or transfer case output shaft bushing displacement. the powertrain bending resonance or the output shaft bushing displacement can result in structural failure of the transmission and/or transfer case. fluid explusion, driveshaft separation or loss of vehicle drive can result.
Consequence:
This condition can cause a loss of vehicle control, and, if the expelled fluid contacts the exhaust system, a vehicle fire could occur.
Correction:
Dealers will install a new transfer case rear output shaft bushing and an aluminum driveshaft will be installed.
Notes:
Owner notification began june 17, 1999. owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact ford at 1-800-392-3673.also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
Campaign:
06E022000 on 03/12/2006
Component:
Service brakes, hydraulic
Affected:
7,440
Defect:
Certain aftermarket brake hydraulic master cylinders sold as replacement brake cylinders for certain ford, daimlerchrysler, and jeep passenger vehicles. these brake cylinders were sold under the brand names of napa, raybestos, aimco, ac delco, carquest, bendix, and wagner. only products that were manufactured from july 27, 2005 through january 17, 2006 (date codes 0529 through 0602) are subject to this recall. when subject to very cold temperatures, an internal seal in the master cylinder could lose flexibility and may cause brake fluid to leak.
Consequence:
Loss of brake fluid can lead to a decrease in brake line pressure and an increase in stopping distance, which can result in a vehicle crash.
Correction:
Affinia (brake parts, inc.) will replace the subject brake hydraulic master cylinders free of charge. the recall began on march 20, 2006. owners can contact affina group customer service at 1-800-323-0354.
Notes:
This recall only pertains to aftermarket napa, raybestos, ac delco, aimco, carquest, and bendix brake hydraulic master cylinders and has no relation to any original equipment installed on daimlerchrysler or ford vehicles.customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov.

1992 FORD AEROSTAR TSBs (62)

Bulletin:
94249
Component:
133000 visibility:power window devices and controls
Summary:
front door glass tipping and binding during downward travel. *tw
Bulletin:
94256
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
knocking noise from lower end #1 main bearing during acceleration. *tw
Bulletin:
95320
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
knocking noise from lower front of engine compartment. *tw
Bulletin:
95910
Component:
061000 engine and engine cooling:engine
Summary:
Unknown
Bulletin:
95102
Component:
116000 electrical system:ignition
Summary:
vehicles may have a disconnect of the ignition control module (icm) connector or moisture buildup within the connector. *tw
Bulletin:
951012
Component:
103000 power train:automatic transmission
Summary:
transfer case may leak fluid from the case vent tube. *tw
Bulletin:
BC1383950906
Component:
015200 steering:hydraulic power assist:hose, piping, and connections
Summary:
vehicle may exhibit a moan when turning - to correct this condition, replace the high pressure hose with a tuned hose. *tw
Bulletin:
BC1350950906
Component:
103000 power train:automatic transmission
Summary:
high altitude transmission available. *tw
Bulletin:
95161
Component:
162000 structure:body
Summary:
sheet metal-roof panel and drip rail replacement- seam sealer application procedure.*sd
Bulletin:
951612
Component:
162300 structure:body:door
Summary:
door-replacement sliding - service tip. *sd
Bulletin:
951614
Component:
353600 equipment:air conditioner
Summary:
air conditioning-poor performance even though a/c system is functioning properly service tips. *sd
Bulletin:
95212
Component:
036000 service brakes, hydraulic:antilock
Summary:
the use of petroleum-based grease as a lubricant in servicing disc brakes is no longer acceptable because it may be incompatible with the rubber material used in the disc brake system. if petroleum-based grease is used to lubricate any par
Bulletin:
BC0678961025
Component:
102000 power train:manual transmission
Summary:
Information on aode/4r7w transmission main control & case replacement. *tt
Bulletin:
BC0822961010
Component:
162620 structure:body:hatchback/liftgate:support device
Summary:
Concerns w/ liftgate opening efforts &/or the liftgate not staying open, especially in cold ambient temps. *tt
Bulletin:
96246
Component:
114000 electrical system:wiring
Summary:
Wiring - electrical diode identification and service replacements. *tw
Bulletin:
96249
Component:
103700 power train:automatic transmission:torque converter
Summary:
Torque converter - leak test procedure - service tip. *tw
Bulletin:
96221
Component:
131000 visibility:windshield
Summary:
Windshield and interior glass - fog/film. *tw
Bulletin:
96225
Component:
075000 fuel system, gasoline:carburetor system
Summary:
Mass air flow sensor - replacement as an assembly - service tip. *tw
Bulletin:
962612
Component:
103700 power train:automatic transmission:torque converter
Summary:
Transaxle - torque converter replacement guidelines and torque converter/transaxle cooling system cleaning procedures - service tip. *tw
Bulletin:
962616
Component:
171100 latches/locks/linkages:doors:latch
Summary:
Sliding door - damaged or misadjusted latch mechanism. *tw
Bulletin:
962617
Component:
034000 service brakes, hydraulic:foundation components
Summary:
Brakes - brake service - service tips. *tw
Bulletin:
BC3485972301
Component:
062300 engine and engine cooling:cooling system:hose
Summary:
4.0l equipped vehicles may experience temperature gauge fluctuation that may be accompanied with a thumping noise or feel in the coolant hose with the engine at normal operating temperature. *jd
Bulletin:
BC1019997230
Component:
062300 engine and engine cooling:cooling system:hose
Summary:
4.0l equipped vehicles may experience temperature gauge fluctuation that may be accompnied with a thumping noise or feel in the coolant hoses with the engine at normal operating temperature. *jd
Bulletin:
9747
Component:
160000 structure
Summary:
Frame- rivet replacement with bolts- service tips. *jd
Bulletin:
97511
Component:
103000 power train:automatic transmission
Summary:
Fluid- transmission fluid usage charts. *jd
Bulletin:
9768
Component:
980000 unknown or other
Summary:
Fuel economy- customer expectations versus vehicle usage. *jd
Bulletin:
97610
Component:
061000 engine and engine cooling:engine
Summary:
Blower motor- "chirping" or "squeaking" from blower motor at low speeds. *jd
Bulletin:
97111097234
Component:
113000 electrical system:starter assembly
Summary:
Vehicles exhibiting a "squeaking" or "chirping" from the blower motor at low blower motor speeds. *yc
Bulletin:
9832
Component:
162200 structure:body:bumpers
Summary:
Front and rear bumpers made of xenoy plastic have had the conductive primer removed from service parts. *yc
Bulletin:
985A13
Component:
034500 service brakes, hydraulic:foundation components:disc
Summary:
The use of petroleum-based grease as a lubricant in servicing disc brakes is no longer acceptable. *yc
Bulletin:
9888
Component:
103000 power train:automatic transmission
Summary:
Information on a new transmission fluid usage chart. *yc
Bulletin:
9848
Component:
353600 equipment:air conditioner
Summary:
Announcing the ford oem air conditioning retrofit kit availability. *yc
Bulletin:
9852
Component:
190000 tires
Summary:
Information on tire company telephone numbers for customer assistance. *yc
Bulletin:
9864
Component:
063000 engine and engine cooling:exhaust system
Summary:
Information on a buzzing or rattle noise from the exhaust system. *tt
Bulletin:
9873
Component:
353400 equipment:electrical:radio/tape deck/cd etc.
Summary:
Experiencing a whining / buzzing noise in the speakers of the entertainment radio or two-way radio. *tt
Bulletin:
98233
Component:
106000 power train:axle assembly
Summary:
Concerns with front drive axle fluid may leak out of the vent under some driving modes on some vehicles. *yc
Bulletin:
982310
Component:
063100 engine and engine cooling:exhaust system:emission control
Summary:
Mass air flow (maf)- sensor contamination- service tip. *ak
Bulletin:
98246
Component:
110000 electrical system
Summary:
Ford motor company has released a new electrical grease ( f8az - 19g208-aa ) to reduce the possibility of moisture corrosion at the terminals. *yc
Bulletin:
98112
Component:
103000 power train:automatic transmission
Summary:
Subject regarding a new service center support that uses a thrust bearing (#3 and #4) in place of thrust washers has been released. *tt
Bulletin:
99816
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Ford motor company now recommends sae 5w-30 viscosity grade for servicing any ford gasoline-powered vehicle regardless of model year. *tt
Bulletin:
99129
Component:
353400 equipment:electrical:radio/tape deck/cd etc.
Summary:
Experiencing a whine / buzz type noise in the speakers of the entertainment radio or two-way radio on vehicles with an in-tank electric fuel pump. *tt
Bulletin:
99139
Component:
125000 exterior lighting:brake lights
Summary:
Conditions with the brake lamps inadvertently disabling the brake shift interlock. *tt
Bulletin:
983080
Component:
103000 power train:automatic transmission
Summary:
Information regarding transfer case rear housing and driveshaft replacement. *tt
Bulletin:
99222
Component:
114000 electrical system:wiring
Summary:
Subject on a wire harness terminal repair kit available for repairing electrical wiring harnesses. *tt
Bulletin:
99183
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Service tip information on revised oil pan gasket replacement procedure. *tt
Bulletin:
99196
Component:
353600 equipment:air conditioner
Summary:
Information on identifying non-approved / alternate refrigerants which could cause safety, and performance concerns if installed in ford a/c systems. *tt
Bulletin:
0015
Component:
103000 power train:automatic transmission
Summary:
Information regarding the new transmission cooler flusher- service tip. *mjs
Bulletin:
985A52
Component:
034000 service brakes, hydraulic:foundation components
Summary:
This bulletin contains service tips when servicing any brake related roughness / pull concerns. *tt
Bulletin:
96719
Component:
010000 steering
Summary:
Experiencing a rapping or clanging noise when the steering wheel is turned rapidly or when turning on a bumpy road surface. *tt
Bulletin:
985A12
Component:
354600 equipment:mechanical:wrecker and wheel lift devices
Summary:
Recommended guidelines for towing behind recreational vehicles. *tt
Bulletin:
6896
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Some vehicles may exhibit an engine noise which may be perceived by the customer as a piston / connecting rod bearing knock. *tt
Bulletin:
13118
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Some vehicles may exhibit an engine noise which may be perceived by the customer as a piston / connecting rod bearing knock. *tt
Bulletin:
99152
Component:
103000 power train:automatic transmission
Summary:
Information on the new flush and fill tool available through rotunda. *tt
Bulletin:
002310
Component:
103600 power train:automatic transmission:cooling unit and lines
Summary:
Subject regarding contamination from prior transmission concerns or excess wear may be trapped in the transmission fluid cooling system. *tt
Bulletin:
01124
Component:
061000 engine and engine cooling:engine
Summary:
On some vehicles, engine oil may continue to leak from the engine oil pan gasket area after an engine oil pan gasket repair has been performed. *tt
Bulletin:
01156
Component:
138120 visibility:defroster/defogger system:windshield:heater core
Summary:
Some vehicles may exhibit heater core leaks. *slc
Bulletin:
01157
Component:
980000 unknown or other
Summary:
Information regarding transmission fluid usage charts. *slc
Bulletin:
01181
Component:
103800 power train:automatic transmission:park/neutral start switch
Summary:
Brake shift interlock.*jb
Bulletin:
01197
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Some vehicles equipped with the 4.0l ohv engine may exhibit an engine noise which may be perceived by the customer as a piston / onnecting rod bearing knock. *tt
Bulletin:
02142
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Some vehicles equipped with an automatic transmission and a 4.0l ohv engine may exhibit a noise / vibration, no drive, unusual noise during cranking or a no crank condition. *tt
Bulletin:
03148
Component:
103600 power train:automatic transmission:cooling unit and lines
Summary:
New transmission cooler flusher - service tips. 2003 escort and super duty f series included. *tt
Bulletin:
02176
Component:
032100 service brakes, hydraulic:switches:brake light
Summary:
Lamp-brake-invadvertent disabling of brake shift interlock. *mj

Home | Privacy