1990 NISSAN VAN Recalls (5)

Campaign:
90V136000 on 10/25/1990
Component:
Steering:hydraulic power assist:hose, piping, and connections
Manufactured:
08/31/1986 - 02/28/1990
Affected:
33,000
Defect:
Power steering hoses may leak fluid that can spread to the exhaust manifold.
Consequence:
Under certain conditions, the manifold may become hotenough to ignite the power steering fluid and result in an engine compartmentfire.
Correction:
Install new heat resistant power steering hoses. also, install new fan coupling to increase air flow volume through engine compartment and replace any other damaged components.
Notes:
System: power steering hose.vehicle description: truck van.
Campaign:
91V211000 on 04/07/1992
Component:
Engine and engine cooling:cooling system:hose
Manufactured:
08/31/1986 - 02/28/1990
Affected:
33,000
Defect:
The cooling system hoses deteriorate and fail because of inadequate heat resistance. failure first occurs at the clamp connections, causing coolant fluid to be leaked or sprayed onto the engine compartment components.
Consequence:
If the vehicle is operated with a low coolant level, thecooling system temperature and pressure would rise very quickly. coolantreaching the hot exhaust manifold can ignite and cause an engine compartmentfire.
Correction:
Replace the defective cooling system hoses with improved heat resistant hoses, modify the coolant recovery system to prevent sudden increases in cooling system temperature and pressure, and replace engine compartment components which may have been damaged or would deteriorate with time.
Notes:
System: cooling system.vehicle description: passenger vans.note: included in the campaign service will be an engine oil and filter changeas well as a complete cooling system service. also, your dealer is authorized toprovide a loaner car, at no charge, while van is being serviced. the warranty onall powertrain components is extended to six years or 100,000 miles. previouslyextended powertrain warranty costs will be reimbursed, if requested.
Campaign:
93V036000 on 03/28/1993
Component:
Engine and engine cooling:cooling system:hose
Manufactured:
08/31/1986 - 02/28/1990
Affected:
33,000
Defect:
Nissan has made a preliminary determination that a defect exists in engine compartment component(s) that may fail due to the engine compartment heat.
Consequence:
The undetermined engine compartment component(s) cancause an engine compartment fire, resulting in possible injury to vehicleoccupants.
Correction:
Dealers will install a new design cooling system including the fan belts, radiator, water pump, alternator, freeze plug shields, and associated hoses. the remedy will also include a new auxiliary electric fan and power steering fluid cooler. to complete the remedy, a warning system to monitor cooling system performance will be installed to detect potential engine overheating.
Notes:
System: engine compartment.vehicle description: passenger vans.note: see nhtsa campaign 94v031000 for further recall information on these vans.
Campaign:
94V031000 on 02/28/1994
Component:
Engine and engine cooling:cooling system:hose
Manufactured:
08/31/1986 - 02/28/1990
Affected:
33,000
Defect:
Engine compartment fires and other thermal incidents have occurred on vehicles which had received all of the remedies provided by a previous safety-related recall (nhtsa campaign no. 93v036000). the fires are attributed to errors in installing the remedy specified in the recall.
Consequence:
If the remedy specified for recall 93v036000 was not performed correctly or the vehicle has not received the remedy, a fire could occur.
Correction:
Nissan will offer to repurchase these vehicles from the owners. the vehicles will then be destroyed. for owners that decline the repurchase offer nissan will provide a reinspection of their vehicle, free of charge, to confirm the prior recall was completed properly. also, nissan will perform any recall-related repairs that may be needed at no charge to the owner.
Notes:
System: engine cooling system; hoses.vehicle description: passenger, c22 vans.note: please contact nissan service center at 1-800-677-7822 for more information concerning this recall. consumers can also contact the national highway traffic safety administration's auto safety hotline at 1-800-424-9393.
Campaign:
95V103002 on 05/23/1995
Component:
Seat belts:front:buckle assembly
Manufactured:
07/31/1986 - 06/30/1991
Affected:
2,730,462
Defect:
The front safety belt buckle release buttons can break. these red plastic release buttons are marked "press." if a button breaks, pieces can fall into the buckle assembly causing the buckle to operate improperly.
Consequence:
The safety belts would not provide adequate protection to an occupant in a vehicle crash.
Correction:
Owners should promptly check the condition and operation of both front safety belt buckles and carefully inspect the red release button for any breaks or cracks. they should ensure that both buckles are operating properly by inserting each latch plate into its buckle, tugging on the belt to make sure the latch is securely locked, and then pressing the release button. the latch plate should pop out of the buckle when the button is pressed. if either release button shows a sign of breaking or cracking or if either buckle fails to operate properly, owners should promptly contact their authorized dealer to schedule an appointment to have the buckle replaced or repaired free of charge.
Notes:
System: interior; seat belts; belt buckles.vehicle description: passenger, multi-purpose vehicles and light duty trucks equipped with safety belts made by takata corporation.note: if your vehicle is presented to an authorized dealer on an agreed uponservice date and the remedy is not provided free of charge within a reasonable time, please contact nissan at 1-800-647-7261.also contact the nationalhighway traffic safety administration's auto safety hotline at 1-800-424-9393.

1990 NISSAN VAN TSBs (4)

Bulletin:
FC0008834
Component:
112000 electrical system:alternator/generator/regulator
Summary:
unable to maintain 160 lbs tension on alternator belt after recall rc-006. *tw
Bulletin:
NTB-09-030
Component:
110000 electrical system
Summary:
Nissan: the 12 volt battery is an important part of the vehicle electrical system and is required to stay connected when the engine is running. to prevent damage to vehicle electronic components follow the instructions/cautions. no mod
Bulletin:
NTB-09-101
Component:
199000 tires:pressure monitoring and regulating systems
Summary:
Nissan: tire pressure monitoring system (tpms) warning light on/flashing. no models or model years listed. *pe updated on 08-11-2011. *kb
Bulletin:
NTB-09-129
Component:
355200 equipment:other:owners/service/other manual
Summary:
Nissan: vent control valve replacement. when replacing the evap canister vent control valve for reason: use the one listed on page 2; for vent control valve replacement procedure, refer to the appropriate section of the electronic service

Home | Privacy