1990 LINCOLN CONTINENTAL Recalls (5)

Campaign:
90E043001 on 10/30/1990
Component:
Air bags:frontal
Manufactured:
07/31/1989 - 04/30/1990
Affected:
172,000
Defect:
Threaded inflator components may have been damaged during assembly which may allow components to separate when inflator receives a signal to deploy the air bag.
Consequence:
Inflator component separation allows hot combustion gases to escape into the passenger compartment which could result in injuries to vehicle occupants.
Correction:
Replace air bag modules containing potentially defective inflators.
Notes:
Note:this campaign was initiated by trw, inc., manufacturer of the air bag module system:air bag modules.vehicle description:passenger cars equipped with driver side supplemental airbag modules.
Campaign:
91V134000 on 08/06/1991
Component:
Service brakes, hydraulic:foundation components:disc:rotor
Affected:
325,000
Defect:
Front disc brake rotors of the subject vehicles may experience severe corrosion if operated in areas where calcium chloride and sodium chloride are used extensively.
Consequence:
Severely corroded rotors may fracture or separate nearthe inner edges of the brake discs resulting in reduced braking effectiveness,higher than normal pedal efforts, loud grinding noises, and moderate pulls whenthe brakes are applied. reduced braking effectiveness may increase minimumstopping distances, possibly resulting in an accident.
Correction:
Replace front brake rotors with full cast front brake rotors.
Notes:
System: brakes.vehicle description: passenger vehicles sold or registered in the following states: ct, il, in, me, ma, mi, nh, nj, ny, oh, pa, ri, vt, and wi.
Campaign:
97V174000 on 10/20/1997
Component:
Seat belts:front:buckle assembly
Manufactured:
02/28/1989 - 03/30/1990
Affected:
63,400
Defect:
Vehicle description: passenger vehicles. the front outboard seating position seat belt buckles may not latch or unlatch.
Consequence:
These conditions could reduce seat belt usage increasing the risk of personal injury in the event of a vehicle crash.
Correction:
Dealers will replace the front outboard seat belt buckle assemblies.
Notes:
Owner notification began april 15, 1998. owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact ford at 1-800-392-3673.also contact the national highway traffic safety administration's auto safety hotline at 1-800-424-9393.
Campaign:
97I003000 on 10/21/1997
Component:
Seat belts:front:buckle assembly
Manufactured:
06/30/1988 - 03/30/1990
Affected:
299,600
Defect:
This is not a safety recall in accordance with federal regulation 573. however, it is deemed a safety improvement campaign by the agency. ford is initiating an owner notification program that will provide an extended warranty, 12 years and unlimited mileage, for all seat belt buckles with functional concerns.
Consequence:
In the event of a collision, the occupant of the seat may not be properly restrained and personal injury could occur.
Correction:
Dealers will replace the seat belt buckle assembly, for 12 years and unlimited mileage.
Notes:
Note:ford has decided to conduct a safety improvement service campaign to replace the seat belt buckle assembly without charge.owners can contact ford at 1-800-392-3673.
Campaign:
98V323000 on 12/17/1998
Component:
Structure:frame and members
Manufactured:
11/03/1987 - 11/17/1994
Affected:
2,697,000
Defect:
Vehicle description: passenger vehicles originally sold or currently registered in connecticut, delaware, district of columbia, illinois, indiana, iowa, kansas, kentucky, maine, maryland, massachusetts, michigan, minnesota, missouri, nebraska, new hampshire, new jersey, new york, ohio, pennsylvania, rhode island, vermont, virginia, west virgnia, and wisconsin. the rear lower subframe mount plate nut can experience stress corrosion cracking if subjected to long term exposure to road salts. this can result in fracture and loss of the structural integrity of the subframe mount attachment. detachment of the body mounts at the rear corners of the subframe, which supports the engine and transmission, allows the rear corners of the subframe to drop.
Consequence:
If both rear corners drop, steering would become suddenly very difficult, affecting vehicle control and increasing the risk of a crash.
Correction:
Dealers will install subframe rear mount bolts, reinforcement plates, and plate nuts.
Notes:
Note:this recall campaign supercedes recall campaign 93v-106.owner notification is expected to begin january 18, 1999.owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact ford at 1-800-392-3673.also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).

1990 LINCOLN CONTINENTAL TSBs (48)

Bulletin:
94247
Component:
103000 power train:automatic transmission
Summary:
the forward clutch piston may crack on its outside diameter. *tw
Bulletin:
BC0270950103
Component:
103000 power train:automatic transmission
Summary:
some axod chain covers were overdrilled in the overdrive servo apply circuit, causing the overdrive band to be applied at all times. *tw
Bulletin:
9523
Component:
070000 fuel system, gasoline
Summary:
erratic distance-to-empty and fuel gauge readings. *tw
Bulletin:
9534
Component:
021000 suspension:front
Summary:
rattling or clunking noise from the fron suspension. *tw
Bulletin:
9546
Component:
136200 visibility:windshield wiper/washer:motor
Summary:
revised wiper motor. *tw
Bulletin:
9546
Component:
136200 visibility:windshield wiper/washer:motor
Summary:
wiper motor replacement - upgraded service kits. *tw
Bulletin:
95511
Component:
138110 visibility:defroster/defogger system:windshield:blower
Summary:
chirp or squeak from blower motor. *tw
Bulletin:
9562
Component:
034500 service brakes, hydraulic:foundation components:disc
Summary:
roughness concern during brake application. *tw
Bulletin:
9566
Component:
138110 visibility:defroster/defogger system:windshield:blower
Summary:
chirp or squeak noise from blower motor at low speeds. *tw
Bulletin:
9582
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
a revised service windshield wiper motor is now available. *tw
Bulletin:
9592
Component:
138110 visibility:defroster/defogger system:windshield:blower
Summary:
Unknown
Bulletin:
9566
Component:
034500 service brakes, hydraulic:foundation components:disc
Summary:
Unknown
Bulletin:
95157
Component:
103700 power train:automatic transmission:torque converter
Summary:
the torque converter identification codes have been revised as of 3/1/95. *sd
Bulletin:
95165
Component:
022000 suspension:rear
Summary:
suspension-rear-availability of camber kit to improve inner edge wear on rear rear tires. tires-rear-inner edge wear-availability of camber kit to improve wear. *sd
Bulletin:
95191
Component:
015000 steering:hydraulic power assist system
Summary:
the power steering system may have a 'grunt' and/or 'groan' noise. this may be caused by hydraulic fluid movement within the power steering rack.
Bulletin:
95212
Component:
036000 service brakes, hydraulic:antilock
Summary:
the use of petroleum-based grease as a lubricant in servicing disc brakes is no longer acceptable because it may be incompatible with the rubber material used in the disc brake system. if petroleum-based grease is used to lubricate any par
Bulletin:
96246
Component:
114000 electrical system:wiring
Summary:
Wiring - electrical diode identification and service replacements. *tw
Bulletin:
96249
Component:
103700 power train:automatic transmission:torque converter
Summary:
Torque converter - leak test procedure - service tip. *tw
Bulletin:
96221
Component:
131000 visibility:windshield
Summary:
Windshield and interior glass - fog/film. *tw
Bulletin:
962612
Component:
103700 power train:automatic transmission:torque converter
Summary:
Transaxle - torque converter replacement guidelines and torque converter/transaxle cooling system cleaning procedures - service tip. *tw
Bulletin:
BC101209702
Component:
103000 power train:automatic transmission
Summary:
Verify the transaxle installed in the vehicle is the correct model and model year for the vehicle. *jd
Bulletin:
9716
Component:
015200 steering:hydraulic power assist:hose, piping, and connections
Summary:
Some power steering hoses have been replaced with a revised design and should no longer be used for service. *jd
Bulletin:
9743
Component:
061000 engine and engine cooling:engine
Summary:
Blower motor- "chirp" or "squeak" from blower motor at low speeds. *jd
Bulletin:
97511
Component:
103000 power train:automatic transmission
Summary:
Fluid- transmission fluid usage charts. *jd
Bulletin:
9768
Component:
980000 unknown or other
Summary:
Fuel economy- customer expectations versus vehicle usage. *jd
Bulletin:
97610
Component:
061000 engine and engine cooling:engine
Summary:
Blower motor- "chirping" or "squeaking" from blower motor at low speeds. *jd
Bulletin:
97111097234
Component:
113000 electrical system:starter assembly
Summary:
Vehicles exhibiting a "squeaking" or "chirping" from the blower motor at low blower motor speeds. *yc
Bulletin:
9888
Component:
103000 power train:automatic transmission
Summary:
Information on a new transmission fluid usage chart. *yc
Bulletin:
9848
Component:
353600 equipment:air conditioner
Summary:
Announcing the ford oem air conditioning retrofit kit availability. *yc
Bulletin:
9849
Component:
062000 engine and engine cooling:cooling system
Summary:
Concerns with coolant may leak from the head gaskets and / or the vehicle may overheat. *yc
Bulletin:
9864
Component:
063000 engine and engine cooling:exhaust system
Summary:
Information on a buzzing or rattle noise from the exhaust system. *tt
Bulletin:
9873
Component:
353400 equipment:electrical:radio/tape deck/cd etc.
Summary:
Experiencing a whining / buzzing noise in the speakers of the entertainment radio or two-way radio. *tt
Bulletin:
982675
Component:
106220 power train:axle assembly:axle shaft:seal
Summary:
A revised forward clutch inner seal for the axod, axode, ax4s & ax4n transaxle is available with improved sealing and reduced chance of the seal rolling during installation. *yc
Bulletin:
98246
Component:
110000 electrical system
Summary:
Ford motor company has released a new electrical grease ( f8az - 19g208-aa ) to reduce the possibility of moisture corrosion at the terminals. *yc
Bulletin:
12559
Component:
101100 power train:clutch assembly:pedal/linkage
Summary:
Concerns with reverse clutch that could become sheared or torn in extremely cold temperatures. *tt
Bulletin:
99816
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Ford motor company now recommends sae 5w-30 viscosity grade for servicing any ford gasoline-powered vehicle regardless of model year. *tt
Bulletin:
99129
Component:
353400 equipment:electrical:radio/tape deck/cd etc.
Summary:
Experiencing a whine / buzz type noise in the speakers of the entertainment radio or two-way radio on vehicles with an in-tank electric fuel pump. *tt
Bulletin:
9811329
Component:
061000 engine and engine cooling:engine
Summary:
Information regarding the the availability of the revised headgasket for coolant loss conditions on some engines. *tt
Bulletin:
99222
Component:
114000 electrical system:wiring
Summary:
Subject on a wire harness terminal repair kit available for repairing electrical wiring harnesses. *tt
Bulletin:
99196
Component:
353600 equipment:air conditioner
Summary:
Information on identifying non-approved / alternate refrigerants which could cause safety, and performance concerns if installed in ford a/c systems. *tt
Bulletin:
0015
Component:
103000 power train:automatic transmission
Summary:
Information regarding the new transmission cooler flusher- service tip. *mjs
Bulletin:
12178
Component:
100000 power train
Summary:
Information regarding tsb 98-5a-12 (transaxle/transmission/transfer case-vehicles towed behind recreational vehicles-recommended guidelines) does not list towing information for certain model vehicles. *mjs
Bulletin:
985A6
Component:
036000 service brakes, hydraulic:antilock
Summary:
Some vehicles may cycle when brakes are applied on rough roads or on an incline while making a sharp turn. *yc
Bulletin:
99152
Component:
103000 power train:automatic transmission
Summary:
Information on the new flush and fill tool available through rotunda. *tt
Bulletin:
011201
Component:
136000 visibility:windshield wiper/washer
Summary:
This information is a supplement to the wiper system service information provided in the workshop manuals. this service information is intended as an aid to assist in diagnosis and repair of erratic wiper system conditions.
Bulletin:
01156
Component:
138120 visibility:defroster/defogger system:windshield:heater core
Summary:
Some vehicles may exhibit heater core leaks. *slc
Bulletin:
01157
Component:
980000 unknown or other
Summary:
Information regarding transmission fluid usage charts. *slc
Bulletin:
02107
Component:
136200 visibility:windshield wiper/washer:motor
Summary:
Transfer service tips for the front wiper motor mount bracket and depressed park output arm. *tt

Home | Privacy