1986 FLXIBLE METRO Recalls (8)
- Campaign:
- 86V158000 on 12/04/1986
- Component:
- Equipment:other:labels
- Manufactured:
- 10/31/1983 - 09/30/1986
- Affected:
- 125
- Defect:
- Only two emergency window exists were identified on the left side of the bus, instead of three required by fmvss 217. consequence of defect: buses do not comply with fmvss 217.
- Correction:
- Emergency exit instructions will be added to the third window on the left side to identify this window position as an emergency exit.
- Notes:
- System: emergency window identification/fmvss 217.vehicle description: 40 passenger, 35 foot transit buses with sliding sidewindow option.
- Campaign:
- 86V171000 on 12/29/1986
- Component:
- Steering:column
- Manufactured:
- 01/31/1985 - 11/30/1986
- Affected:
- 1,102
- Defect:
- Incorrect lock washers may have been installed on the tilt steering column pivot bushing bolts and the column housing pivot may be misaligned. consequence of defect: pivot bolt could loosen and result in loss of steering control.
- Correction:
- Install proper lock washer and correct misalignment of column housing pivot.
- Notes:
- System: tilt steering column. vehicle description: metro transit buses with tilt steering column.
- Campaign:
- 87V068000 on 05/17/1987
- Component:
- Steering:column
- Manufactured:
- 04/30/1985 - 03/31/1987
- Affected:
- 3,122
- Defect:
- Steering column lower shaft may be too long allowing excessive thrust load to be applied to upper housing bearings and steering transfer box bearings.
- Consequence:
- Bearings could fail or seize, resulting in loss ofsteering control.
- Correction:
- Replace steering column assembly with one of proper length.
- Notes:
- System: tilt steering column.vehicle description: metro transit buses with tilt steering columns.
- Campaign:
- 87V066000 on 05/18/1987
- Component:
- Steering:column
- Manufactured:
- 01/31/1985 - 03/31/1987
- Affected:
- 3,075
- Defect:
- An incorrect bolt may have been installed to retain the tilt steering column pivot bushings.
- Consequence:
- Bolt may not maintain specified torque and could breakor work loose and fall out, resulting in loss of steering control.
- Correction:
- Install proper sae grade 5 bolt.
- Notes:
- System: tilt steering column.vehicle description: transit buses with tilt steering columns.
- Campaign:
- 87V067000 on 05/18/1987
- Component:
- Exterior lighting
- Manufactured:
- 05/31/1983 - 06/30/1986
- Affected:
- 290
- Defect:
- The flashing mode of the deceleration light system is not in compliance with fmvss 108.
- Consequence:
- Flashing deceleration lights may be confusing to otherdrivers; buses do not comply with fmvss 108.
- Correction:
- Modify deceleration lights to remove the flashing mode.
- Notes:
- System: lighting/fmvss 108.vehicle description: metro transit buses with deceleration light system option.
- Campaign:
- 88V079000 on 05/12/1988
- Component:
- Exterior lighting:hazard flashing warning lights
- Manufactured:
- 11/30/1983 - 08/31/1987
- Affected:
- 726
- Defect:
- Due to increased bulb load on the flasher, when operated in hazard mode, flasher did not meet performance requirements of fmvss 108.
- Consequence:
- Buses do not comply with fmvss 108.
- Correction:
- Install a combination turn hazard flasher that complies with standard.
- Notes:
- System: turn hazard flashers fmvss 108.vehicle description: metro transit buses equipped with swiss controls no. 4242vcombination turn hazard flashers.
- Campaign:
- 89V040000 on 04/04/1989
- Component:
- Structure:body:door
- Manufactured:
- 05/31/1983 - 02/28/1989
- Affected:
- 4,758
- Defect:
- The entrance door emergency release mechanism may exceed the 20 lb. force allowed by fmvss 217.
- Consequence:
- Buses would not comply with standard.
- Correction:
- Repair release cable mechanism to comply with standard.
- Notes:
- System: entrance door emergency release/ fmvss 217.vehicle description: metro transit buses.
- Campaign:
- 95V235000 on 12/21/1995
- Component:
- Visibility:windshield wiper/washer
- Manufactured:
- 02/28/1986 - 10/31/1994
- Affected:
- 741
- Defect:
- These buses have the headlights automatically activated whenever the windshield wipers are activated. no other exterior lights are activated by windshield wiper activation. this does not comply with the requirements of fmvss no. 108, "lamps, reflective devices, and associated equipment."
- Consequence:
- Consequence of non-compliance: this could cause a visibility problem increasing the potential for a vehicle accident.
- Correction:
- Dealers will modify the electrical wiring to activate all exterior lights whenever the windshield wipers are activated.
- Notes:
- System: visual; windshield wiper and washer; fmvss no. 108.vehicle description: city transit buses.note: owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time, should contact flxible at 1-614-362-2600. also contact the national highway traffic safety administration's auto safety hotline at 1-800-424-9393.
Home | Privacy