1983 FORD F250 Recalls (6)

Campaign:
82V105000 on 10/27/1982
Component:
Structure:body:hood:hinge and attachments
Manufactured:
07/31/1982 - 09/30/1982
Affected:
600
Defect:
The springs that assist in raising the hood may detach from the hood without warning. the hood can be in any position when this occurs.
Correction:
The dealer will replace the hood lift assist spring assemblies with revised parts.
Notes:
Vehicle description: light trucks over 8,500 gvwr equipped with 6.9 literdiesel engines.system: hood assembly; hinge attachments.consequences of defect: spring detachment may cause the spring to strikepersons nearby. it is also possible for the hood to fall unexpectedly causingpersonal injury.note: the owner is advised to avoid opening and closing the hood until thevehicle can be repaired.
Campaign:
82V104000 on 10/27/1982
Component:
Power train:axle assembly
Manufactured:
09/30/1981 - 08/31/1982
Affected:
74,985
Defect:
On certain vehicles, the lock wedges used to secure the axle bearing nuts to the axle housing may fall out of position, allowing the nut to loosen. the nut on the left side may fall off, allowing movement of the axle shaft.
Correction:
The dealer will replace defective lock wedges with an improved version. wheel bearings will be inspected and adjusted or replaced, if necessary.
Notes:
Vehicle description: light trucks with dana full-floating rear axles.system: power train; rear axle assembly.consequences of defect: this could result in partial loss of braking action orpartial or total separation of the left rear wheel and brake assembly. ineither case, loss of vehicle control and an accident could follow.
Campaign:
82V124000 on 12/16/1982
Component:
Fuel system, gasoline:delivery:fuel pump
Manufactured:
08/31/1982 - 09/30/1982
Affected:
650
Defect:
Some of the involved vehicles may have a diode in the electrical fuel pump circuit that may short during engine starting due to inadequate capacity to withstand current draw. a short circuit would result in normal engine starting, but the pump will not continue to supply the engine with fuel.
Correction:
The dealer will replace defective element in the electrical fuel pump circuit with a new relay feed wiring assembly which contains a larger capacity diode, free of charge.
Notes:
Vehicle description: light trucks and multipurpose passenger vehicles.system: fuel; fuel pump.consequences of defect: under such circumstances, a vehicle may stall withoutprior warning, creating the potential for a vehicle accident. (vehicle willrestart but will stall again in 5 to 10 seconds).
Campaign:
83V028000 on 03/10/1983
Component:
Power train:automatic transmission
Manufactured:
11/30/1982 - 01/31/1983
Affected:
98,162
Defect:
The parking gear may not engage, even though the gear shift lever is placed in the "park" position. this occurs if the linkage inside the transmission that actuates the park gear was improperly manufactured. a pin that retains components on a linkage (actuating) rod could break and the linkage may not engage the parking gear.
Correction:
Dealer will inspect and, if necessary, replace the parking pawl actuating rod assembly.
Notes:
Vehicle description: passenger vehicles equipped with automatic overdrivetransmissions.system: power train; transmission, parking pawl actuating assembly.consequences of defect: if the parking brake is not applied and the parkinggear does not engage, unexpected vehicle movement could cause an accident andpersonal injury.note: drivers should always apply the parking brake whenever leaving thevehicle.
Campaign:
83V047000 on 05/12/1983
Component:
Fuel system, gasoline:delivery:hoses, lines/piping, and fittings
Manufactured:
12/31/1982 - 02/28/1983
Affected:
1,800
Defect:
In a collision, bolts may damage or pierce a fuel line, causing fuel spillage. affected vehicles may not be capable of meeting the minimum fuel leakage requirements of federal motor vehicle safety standard 301, "fuel system integrity".
Correction:
The dealer will replace the existing 2.18 inch bolts in the left front fender apron with one inch long bolts at no charge.
Notes:
Vehicle description: light trucks equipped with 6.9 liter diesel engines.system: structure; fender apron attaching bolts.consequences of defect: excessive length bolts have the potential to contactand damage the fuel line during vehicle impacts. fuel leakage in the presenceof a source of ignition could result in a fire.
Campaign:
84V065000 on 06/04/1984
Component:
Fuel system, diesel:storage:tank assembly
Manufactured:
07/31/1982 - 03/31/1984
Affected:
36,400
Defect:
Water separator canister may be punctured in a collision. crash tests in a 30 mph frontal collision revealed fuel leakage exceeding the maximum permitted by federal motor vehicle safety standard no. 301, "fuel system integrity".
Correction:
A protective shield for the canister will be installed without charge.
Notes:
Vehicle description: trucks; 4x4 chassis cabs equipped with 6.9 liter dieselengines. vehicles equipped with a pickup box that was removed after delivery(to install other aftermarket bodies).system: fuel system: fuel water separator canister.consequences of defect: if the fuel water separator canister is punctured, fuelleakage could cause a fire resulting in personal injury to vehicle occupants.

1983 FORD F250 TSBs (9)

Bulletin:
95524
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
there may be a concern of poor performance, coolant in the oil and engine knocking and/or hydraulic lock on some vehicles. *tw
Bulletin:
9597
Component:
021000 suspension:front
Summary:
Unknown
Bulletin:
83-16-23
Component:
105300 power train:driveline:driveshaft
Summary:
Unknown
Bulletin:
BC4225
Component:
061000 engine and engine cooling:engine
Summary:
Unknown
Bulletin:
97310
Component:
021242 suspension:front:springs:leaf spring assembly:hanger,bracket
Summary:
Noise- "popping/creaking"- front frame or suspension brackets- frame- "popping/creaking"- fastener replacement. *jd
Bulletin:
9747
Component:
160000 structure
Summary:
Frame- rivet replacement with bolts- service tips. *jd
Bulletin:
97511
Component:
103000 power train:automatic transmission
Summary:
Fluid- transmission fluid usage charts. *jd
Bulletin:
985A29
Component:
034000 service brakes, hydraulic:foundation components
Summary:
Some vehicles may exhibit excessive brake pedal travel, irregular front lining wear, and brake pull. *yc
Bulletin:
98030298420
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
A no start or hard start condition may occur on some vehicles due to the glow plug control system. *yc

Home | Privacy