1983 FORD ECONOLINE Recalls (6)
- Campaign:
- 82V124000 on 12/16/1982
- Component:
- Fuel system, gasoline:delivery:fuel pump
- Manufactured:
- 08/31/1982 - 09/30/1982
- Affected:
- 650
- Defect:
- Some of the involved vehicles may have a diode in the electrical fuel pump circuit that may short during engine starting due to inadequate capacity to withstand current draw. a short circuit would result in normal engine starting, but the pump will not continue to supply the engine with fuel.
- Correction:
- The dealer will replace defective element in the electrical fuel pump circuit with a new relay feed wiring assembly which contains a larger capacity diode, free of charge.
- Notes:
- Vehicle description: light trucks and multipurpose passenger vehicles.system: fuel; fuel pump.consequences of defect: under such circumstances, a vehicle may stall withoutprior warning, creating the potential for a vehicle accident. (vehicle willrestart but will stall again in 5 to 10 seconds).
- Campaign:
- 83V028000 on 03/10/1983
- Component:
- Power train:automatic transmission
- Manufactured:
- 11/30/1982 - 01/31/1983
- Affected:
- 98,162
- Defect:
- The parking gear may not engage, even though the gear shift lever is placed in the "park" position. this occurs if the linkage inside the transmission that actuates the park gear was improperly manufactured. a pin that retains components on a linkage (actuating) rod could break and the linkage may not engage the parking gear.
- Correction:
- Dealer will inspect and, if necessary, replace the parking pawl actuating rod assembly.
- Notes:
- Vehicle description: passenger vehicles equipped with automatic overdrivetransmissions.system: power train; transmission, parking pawl actuating assembly.consequences of defect: if the parking brake is not applied and the parkinggear does not engage, unexpected vehicle movement could cause an accident andpersonal injury.note: drivers should always apply the parking brake whenever leaving thevehicle.
- Campaign:
- 85V061000 on 05/20/1985
- Component:
- Fuel system, diesel
- Manufactured:
- 02/28/1983 - 03/31/1985
- Affected:
- 8,500
- Defect:
- When frontally impacted into a fixed barrier at 30 mph, as specified in federal motor vehicle safety standard (fmvss) no. 301, the left frame rails of such vehicles may displace inboard, pinching the fuel/water separator canister between the frame rail and engine sufficiently to displace the fuel/water separator drain rod, allowing the contents of the canister to drain. consequence of defect: fuel leak during or after a crash increases the possibility of a fire.
- Correction:
- Install a canister shield, a revised design drain rod shield, and modify fuel/water separator mounting bracket.
- Notes:
- Vehicle description: vans, super vans, super wagons and club wagons equippedwith 6.9 liter diesel engines. system: fuel/fmvss 301.
- Campaign:
- 87V113000 on 07/21/1987
- Component:
- Engine and engine cooling:exhaust system:emission control
- Manufactured:
- 07/31/1983 - 07/31/1987
- Affected:
- 16,000
- Defect:
- Expulsion of fuel due to overpressurization.
- Consequence:
- Fuel or fuel vapors in the presence of an ignitionsource can cause a fire.
- Correction:
- Modification of the base fuel venting and emission control system to reduce operating temperatures and fuel system pressures.
- Notes:
- System: fuel.vehicle description: ambulance, ford econoline e350 cutaway chassis and vans,equipped with 7.5 liter engines.
- Campaign:
- 87V144000 on 09/08/1987
- Component:
- Engine and engine cooling:exhaust system:emission control
- Manufactured:
- 07/31/1983 - 07/31/1987
- Affected:
- 188,000
- Defect:
- Vehicles are subject to excessive underhood temperatures and fuel system pressures in severe duty applications.
- Consequence:
- This creates potential for fuel expulsion from the fuelfiller pipe which in the presence of an ignition source, could result in afire.
- Correction:
- Install modification kits to minimize possibility of fuel expulsion and to shield underbody components from exhaust system heat.
- Notes:
- System: fuelvehicle description: 1983 through 1987 e250, e350, club wagons and econolinevans and chassis equipped with 7.5 and 1985 through 1987 e250, e350, club wagonsand econoline vans equipped with 5.8 liter engines.
- Campaign:
- 07E064000 on 08/23/2007
- Component:
- Fuel system, gasoline:delivery:fuel pump
- Affected:
- 34,000
- Defect:
- Certain federal-mogul aftermarket fuel pumps sold under the brand names of carter, accuflow, napa, truflow, parts depo, and parts master, shipped between august 2006 and july 2007 for use on the vehicles listed above. the fuel pump diaphragm in certain production runs may have been improperly installed or inadequately tested which may cause the fuel pump to leak.
- Consequence:
- A leaking fuel pump could create a vehicle fire hazard.
- Correction:
- Federal-mogul will notify owners and replace the defective fuel pumps free of charge. the recall began on october 15, 2007. owners can contact federal-mogul at 248-354-7700.
- Notes:
- This recall only pertains to aftermarket carter, napa, accuflow, tru flow, parts master, and parts depot brand fuel pumps and has no relation to any original equipment installed on the listed motor vehicles.customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov.
1983 FORD ECONOLINE TSBs (4)
- Bulletin:
- 9747
- Component:
- 160000 structure
- Summary:
- Frame- rivet replacement with bolts- service tips. *jd
- Bulletin:
- 97511
- Component:
- 103000 power train:automatic transmission
- Summary:
- Fluid- transmission fluid usage charts. *jd
- Bulletin:
- 9888
- Component:
- 103000 power train:automatic transmission
- Summary:
- Information on a new transmission fluid usage chart. *yc
- Bulletin:
- 98246
- Component:
- 110000 electrical system
- Summary:
- Ford motor company has released a new electrical grease ( f8az - 19g208-aa ) to reduce the possibility of moisture corrosion at the terminals. *yc
Home | Privacy