1982 FORD EXP Recalls (4)
- Campaign:
- 81V047000 on 05/11/1981
- Component:
- Fuel system, gasoline:storage:tank assembly:filler pipe and cap
- Manufactured:
- 01/31/1981 - 02/28/1981
- Affected:
- 5,200
- Defect:
- Certain vehicles may not meet applicable minimum fuel spillage requirements of federal motor vehicle safety standard no. 301, "fuel system integrity". during a 30 mph rear impact test, fuel spillage limits were exceeded by vehicle.
- Correction:
- Revised fuel filler and vent pipe assemblies will be installed on affected vehicles, without charge.
- Notes:
- Vehicle description: passenger vehicles.system: fuel; fuel filler and vent pipe assembly.consequences of defect: excessive fuel spillage resulting from a rear impactcould cause a fire and personal injury if an ignition source is present.
- Campaign:
- 81V084000 on 07/13/1981
- Component:
- Service brakes, hydraulic:power assist:vacuum
- Manufactured:
- 05/31/1981 - 05/31/1981
- Affected:
- 4,338
- Defect:
- Some vehicles equipped with power brake boosters have front and rear shells that may have been improperly joined. improperly joined booster shells may separate either partially or completely during brake application.
- Correction:
- All defective boosters will be replaced at no charge to owner.
- Notes:
- Vehicle description: passenger vehicles equipped with power brake boosters.system: service brakes; power brake booster.consequences of defect: this separation may result in total loss of the servicebrakes without prior warning, loss of vehicle control, and possibly, anaccident.note: owner is advised to contact dealer immediately to find out whether thedefect was corrected prior to vehicle purchase. the vehicle should not bedriven until the problem is corrected.
- Campaign:
- 82V045000 on 05/16/1982
- Component:
- Equipment:air conditioner
- Manufactured:
- 07/31/1981 - 02/28/1982
- Affected:
- 113,000
- Defect:
- On the involved vehicles, a thermal limiter in the blower motor resistor circuit of the air conditioner/heater assembly may not function as intended. if the blower motor becomes jammed when the system is operating in the medium-low blower speed, the resistor coils can overheat causing melting and possible ignition.
- Correction:
- Dealer will replace the resistor assembly with an improved version without charge to owner.
- Notes:
- Vehicle description: passengers vehicles equipped with optional airconditioning.system: air conditioner; motor, fan.consequences of defect: a vehicle fire could result, possibly causing loss ofvehicle control, accident, and passenger injury.note: until the vehicle is serviced, the blower should be operated only in thehigh or low speeds. the a/c mode lever should be turned to the "off" positionif the blower becomes noisy or if a burning odor or smoke is noticed.
- Campaign:
- 83V063000 on 07/07/1983
- Component:
- Latches/locks/linkages:doors:latch
- Manufactured:
- 06/30/1980 - 02/28/1983
- Affected:
- 610,000
- Defect:
- Door lock pillars could develop fatigue cracks from normal usage of door, at the point where door latch striker reinforcements are attached.
- Correction:
- Any damaged lock pillars will be repaired and reinforcements will be installed between the door latch striker and lock pillars.
- Notes:
- Vehicle description: passenger vehicles; two door.system: structure; door lock pillars.consequences of defect: door may not latch properly. in driving over roughroads the door could open, allowing passenger to fall from vehicle and becomeinjured.
1982 FORD EXP TSBs (4)
- Bulletin:
- RC INDEX
- Component:
- 980000 unknown or other
- Summary:
- Unknown
- Bulletin:
- 97511
- Component:
- 103000 power train:automatic transmission
- Summary:
- Fluid- transmission fluid usage charts. *jd
- Bulletin:
- 9888
- Component:
- 103000 power train:automatic transmission
- Summary:
- Information on a new transmission fluid usage chart. *yc
- Bulletin:
- 01157
- Component:
- 980000 unknown or other
- Summary:
- Information regarding transmission fluid usage charts. *slc
Home | Privacy