1980 FREIGHTLINER FREIGHTLINER Recalls (6)
- Campaign:
- 80V031000 on 03/30/1980
- Component:
- Trailer hitches
- Manufactured:
- 05/31/1979 - 01/31/1980
- Affected:
- 1,500
- Defect:
- Cracks may develop in the truck"s rear towing crossmember which supports the trailer hitch and to which the safety cables are attached. should these cracks progress to the point of complete separation, the crossmember and the trailer could become detached from the truck.
- Correction:
- Dealer will replace the "a" frames and any other damaged parts at no charge to owner.
- Notes:
- Vehicle description: trucks equipped with a rear towing crossmember and "a"frame assembly.system: structure; rear towing crossmember.consequences of defect: trailer detachment can occur without prior warning,resulting in a vehicle accident.
- Campaign:
- 81V020000 on 03/10/1981
- Component:
- Steering:linkages
- Manufactured:
- 08/31/1980 - 11/30/1980
- Affected:
- 1,333
- Defect:
- On certain vehicles, some cotter pins may be missing at the ball joint connections of the drag link ends and tie rod ends in the lower front axle steering system. steering joint could separate if the ball stud retaining nut loosens and falls off due to absence of cotter pin.
- Correction:
- Steering linkage from the frame down to and including the front axle will be inspected. cotter pins will be installed, if necessary.
- Notes:
- Vehicle description: heavy trucks.system: steering; drag link and tie rod ball joint ends; cotter pins.consequences of defect: driver could experience loss of steering controlwithout warning and an accident could result.note: if any nuts on the front axle linkage are missing, the vehicle should notbe moved.
- Campaign:
- 81V099000 on 08/26/1981
- Component:
- Trailer hitches
- Manufactured:
- 08/31/1979 - 04/30/1981
- Affected:
- 70
- Defect:
- The safety chain bale portion of the towing attachment may have a defective weld in a critical area. if the trailer hitch should become unlatched or in the event of an accident causing the truck and trailer to become separated, the resulting forces could cause a failure of the safety chain bale. a failure of this part would allow complete separation of the truck and trailer without prior warning.
- Correction:
- Upon separation, the trailer would travel out of control until the emergency braking system could bring it to a stop. a vehicle accident could result. corrective action: the safety chain bale will be inspected and, if necessary, replaced with a new one.
- Notes:
- Vehicle description: trucks with tow hitch.system: structure; safety chain bale.
- Campaign:
- 82V114000 on 12/05/1982
- Component:
- Service brakes, air:slack adjusters
- Manufactured:
- 03/31/1978 - 10/31/1982
- Affected:
- 249
- Defect:
- Brakes may fail to conform to federal motor vehicle safety standard no. 121, "air brake systems". the air brakes on the front axle may not actuate and release within the time required for safe braking. the brakes may exceed the .55 second limits.
- Correction:
- The dealer will modify the brake system by adding an air brake relay valve and necessary piping to the front axle air brake system free of charge.
- Notes:
- Vehicle description: heavy trucks equipped with 14,000 lb. gawr front steeringaxle.system: service brakes; air brakes.consequences of defect: the time that it takes for the brakes to react could beunsafe. degraded brake control could cause loss of vehicle control and mayresult in an accident.
- Campaign:
- 84V021000 on 04/03/1984
- Component:
- Steering:linkages
- Manufactured:
- 12/31/1978 - 01/31/1984
- Affected:
- 4,773
- Defect:
- A bolt may not have been fully tightened on the pitman arm and retaining screws may not have been installed or may not have been fully tightened. the pitman arm could separate from the steering shaft.
- Correction:
- A retainer will be installed, or the pitman arm will be replaced, if loose.
- Notes:
- Vehicle description: heavy trucks equipped with sheppard model 392 steeringgear systems.system: steering; pitman arm.consequences of defect: loss of steering would result, possibly causing anaccident.
- Campaign:
- 86V084000 on 07/08/1986
- Component:
- Wheels:center section
- Manufactured:
- 04/30/1980 - 09/30/1980
- Affected:
- 478
- Defect:
- The aluminum wheel hubs develop cracks near the inner wheel bearing, allowing loss of bearing lubricant. consequence of defect: the hub failure and/or loss of bearing lubricant resulting in bearing freeze up could result in steering control problems, which may lead to an accident.
- Correction:
- Replace the hubs from the suspect batch.
- Notes:
- System: wheel hub of front steering axle. vehicle description: high c.o.e. model series and long conventional model trucks equipped with model ff-971 front steering axle.
1980 FREIGHTLINER FREIGHTLINER TSB
- Bulletin:
- 954-12
- Component:
- 073200 fuel system, gasoline:fuel injection system:injectors
- Summary:
- 954-12 installation of the fuel injector.pdf
Home | Privacy