1978 VOLKSWAGEN SCIROCCO Recalls (8)

Campaign:
79V120000 on 10/11/1979
Component:
Electrical system:starter assembly:relay
Affected:
540,000
Defect:
Due to an improperly sealed antenna mounting hole, water could seap into the fuse relay board. the water entering the fuse relay board acts as a conductor of current, thereby charging the starter.
Correction:
The dealer will seal all radio antenna cable holes. in addition, electrical parts of the relay/fuse board will be checked and replaced in the case of corrosion.
Notes:
Vehicle description: passenger vehicles equipped with standard transmissions.system: electrical; starter relay.consequences of defect: the starter could be activated and the vehicle couldmove if the transmission is in gear and the emergency brake is not applied.this could cause injury to persons standing in the path of the moving vehicle.
Campaign:
77V182000 on 10/11/1979
Component:
Service brakes, hydraulic:power assist:vacuum:hoses, lines/piping, and fittings
Affected:
18,500
Defect:
On the involved vehicles, the two rubber elbows, located at each end of the plastic pipe leading from the throttle valve body housing to the brake booster vacuum pump, may be damaged as a result of improper clamp installation.
Correction:
The dealer will replace the rubber elbow connections and install new type clamps, without charge to owner.
Notes:
Vehicle description: passenger vehicles.system: service brakes; brake vacuum line connection elbows.consequences of defect: as a result, the driver may experience engine stallingand insufficient brake booster vacuum which may lead to a vehicle accident.
Campaign:
78V118000 on 02/14/1980
Component:
Parking brake:conventional:mechanical:linkage and cable
Manufactured:
03/31/1978 - 03/31/1978
Affected:
53
Defect:
The rear axle brake cable bracket is attached to the outside of a flange bolt of the rear axle. this bracket was not correctly installed during assembly.
Correction:
The dealer will relocate the bracket and install a new flange, if necessary, without charge.
Notes:
Vehicle description: passenger vehicles.system: emergency brakes; cable bracket.consequences of defect: this could deform the flange and allow the bolts tobecome loose. loss of vehicle control and an accident may occur.
Campaign:
80V035000 on 04/01/1980
Component:
Structure:body
Manufactured:
08/31/1974 - 05/31/1979
Affected:
140,000
Defect:
On some vehicles, the fender opening through which the antenna cable is routed may not be properly sealed. as a result, splashed water from the tires could enter passenger compartment through the opening, enter the fuse relay board and cause corrosion of the terminals. also, because water is a good conductor of electricity, the starter can be activated accidentally; the high flow of electricity may exhaust the battery within a short period of time. thus restarting the engine would become impossible and parking lights and emergency flashers would become inoperative.
Correction:
Dealer will inspect and, if necessary, seal the radio antenna holes and replace corroded components without charge to owner..
Notes:
Vehicle description: passenger vehicles equipped with automatic transmissions.system: structure; antenna cable opening.consequences of defect: vehicle would become disabled and a vehicle accidentcould occur if traffic is present.
Campaign:
81V012000 on 02/11/1981
Component:
Vehicle speed control:cables
Manufactured:
02/29/1976 - 12/31/1979
Affected:
110,000
Defect:
The accelerator cable which leads from the transmission lever to the throttle housing may malfunction. accelerator cable may have been bent during installation or during servicing of engine components. this could cause the steel band cable to bind and can result in delayed response during deceleration, high engine idle and hesitation during acceleration.
Correction:
The accelerator cable will be replaced with a newly designed one. in addition, other components of the acceleration system will be checked, lubricated, and if necessary, replaced. this will be done without charge.
Notes:
Vehicle description: passenger vehicles equipped with fuel-injected gasolineengines and automatic transmissions.system: fuel system; accelerator cable.consequences of defect: the ability to control engine speed could becomeimpaired with little or no warning. loss of vehicle control and an accident mayresult.note: any abnormal throttle control operation or irregular pedal operationshould be reported to dealer.
Campaign:
81V113000 on 09/30/1981
Component:
Structure:body
Manufactured:
08/31/1975 - 07/31/1979
Affected:
448,167
Defect:
Corrosive damage and increased electrical resistance may cause the fuel pump relay to stop functioning. the fuel pump relay is one of several relays on a relay board located near the firewall. corrosion caused by rain entering an improperly sealed antenna hole has been the subject of previous campaigns, but additional measures are required to ensure that the problem is corrected.
Correction:
Vehicles will be inspected to determine whether the modification has been performed. if not, a bypass will be installed to locate the fuel pump relay away from the relay board. any corroded relay boards or connectors will also be replaced.
Notes:
Vehicle description: passenger vehicles with electric fuel pumps.system: electrical; relay panel; fuel pump bypass modification.consequences of defect: corrosion, electrical failure at the fuel pump relay,and resulting failure of the fuel pump would cause engine stalling. a stalledvehicle could present a traffic hazard and an accident could result.
Campaign:
83V116000 on 11/21/1983
Component:
Service brakes, hydraulic:foundation components:hoses, lines/piping, and fittings
Manufactured:
03/31/1974 - 06/30/1979
Affected:
661,585
Defect:
Brake lines installed underneath the carpeting in the passenger compartment may rust due to the entry of water and road salt. if rusting remains unchecked, it produces leaks in the lines and brake fluid may be lost.
Correction:
The dealer will inspect and, if necessary, replace the interior brake lines at no cost to owner. owners are also advised that all brake lines should be inspected at two-year intervals.
Notes:
Vehicle description: passenger vehicles.system: service brakes; brake lines.consequences of defect: failure of one braking circuit of the dual systemincreases the vehicle stopping distance and may result in a vehicle accident.failure of both may cause total loss of brakes.note: owners are cautioned to have vehicles with failed brakes towed to thedealer. indication of failure is evidenced by soft resistance of the pedal ortravel of the pedal almost to the floor.
Campaign:
83V117000 on 11/22/1983
Component:
Fuel system, gasoline:fuel injection system
Manufactured:
08/31/1975 - 07/31/1982
Affected:
930,000
Defect:
The fuel pump may stop functioning without warning. this can occur because an electrical connector in the fuse panel may overheat and interrupt the electrical circuit.
Correction:
Dealer will inspect the fuse box and its connectors for corrosion, and correct where necessary. a bypass adapter to the fuel pump electrical circuit will be installed.
Notes:
Vehicle description: passenger vehicles equipped with fuel injection.system: fuel system; electric fuel pump.consequences of defect: if the fuel pump stops functioning, the engine willstall or fail to start. a stalled vehicle could cause an accident on thehighway.

Home | Privacy